sensor BMW Z4 ROADSTER 2008 E85 Service and warranty information
[x] Cancel search | Manufacturer: BMW, Model Year: 2008, Model line: Z4 ROADSTER, Model: BMW Z4 ROADSTER 2008 E85Pages: 54, PDF Size: 2.39 MB
Page 7 of 54
Special Note
Maintenance items and schedules stated herein
reflect the combined recommendations for all
2008 BMW Z4 models and are subject to
change. The most current maintenance recom-
mendations are available from your authorized
BMW center.
The performance of certain subsequent mainte-
nance elements, as required by the BMW New
Vehicle Limited Warranty, will be specified at
intervals computed by the BMW service interval
indicator as follows:
Oil Service: Engine oil should be changed
with the engine at operating temperature.
Note: change oil at least once a year.
Your BMW is factory-equipped with a newly-
developed synthetic engine oil. At the time of
the printing of this booklet BMW High-Perfor-
mance Synthetic 5W-30 Oil (Part Number
07 51 0 017 866) and Mobil 1 5W-30 and
5W-40 oils are strongly recommended and
approved by BMW for the BMW Z4 models.
BMW is evaluating various synthetic oils for
inclusion in our list of recommended motor
oils.
BMW recommends that you check engine oil
level whenever fuel is added to your vehicle.
Inspection I: Major vehicle maintenance as
specified in the following pages under Inspec-
tion I.
Inspection II: Additional major vehicle mainte-
nance as specified in the following pages
under Inspection II.
The following maintenance elements must be
performed at the mileage/time stated (time
intervals begin from the vehicle’s production
date):
Brake Fluid Service: Change brake fluid every
two years.
Oxygen Sensor Service: The oxygen sensor
deteriorates strictly on a mileage basis and
must therefore be replaced every
120,000 miles to maximize vehicle fuel econ-
omy and minimize exhaust pollution. The
replacement of the oxygen sensor is required
under the terms of the applicable BMW emis-
sion system warranties.
Spark Plug Service: Replace spark plugs
every 100,000 miles.
Automatic Transmission Service: Change ATF
every 100,000 miles.
The engine coolant has a lifetime rating and
does not need to be changed except for sys-
tem repairs.
For your convenience, you may also wish to
have your BMW center perform any necessary
operations to fulfill any state inspection require-
ments in your area concurrent with the mainte-
nance elements specified above during other
repairs. Should you request more frequent
maintenance service, the cost of these ser-
vices will not be covered by the Maintenance
Program.
Make sure that confirmation of maintenance
work is always entered in this Service and War-
ranty Information Statement. You may need this
for any warranty claims that become necessary,
and later on as evidence that your car has been
given the correct and regular maintenance that
justifies its resale or trade-in value.
BMW has applied the most modern technologi-
cal advances not only to the design and produc-
tion of your vehicle, but also to computing of the
optimum maintenance interval for your type of
operations and driving style. Your BMW center
has made a substantial investment in unique
BMW special service tools to enable his BMW
factory trained service technicians to perform
quality repairs on your BMW in minimal time.
Your service technician looks forward to serving
your every service need and to help maximize
your satisfaction with your BMW, its longevity,
and resale value.
3
Page 12 of 54
Inspection II
Includes all items listed under Inspection I, and the following checks and maintenance operations.
Engine Compartment Z4 Roadster
3.0i, 3.0si
Z4 Coupe 3.0si
Replace air cleaner element. (Note: Reduce replacement interval in dusty operating
conditions). •
Brake Fluid Service
Replace brake fluid every 2 years (time interval begins from the vehicle’s production
date). •
Oxygen Sensor Service
Replace Oxygen Sensor every 120,000 miles.
•
Spark Plug Service
Replace spark plugs every 100,000 miles. •
Automatic Transmission Service
Replace ATF every 100,000 miles. •
8
Page 13 of 54
Emission Control Maintenance Schedule: BMW Z4 Roadster 3.0i, 3.0si
and Z4 Coupe 3.0si
The maintenance schedule as shown is required
for the proper functioning of the emission con-
trol systems for optimum vehicle performance
and fuel economy.
Abbreviations:
I - Inspect
R - Replace part(s) and/or fluid listed
Basic Engine
Engine oil .........................
Engine oil filter .....................
Fuel System
Air filter ..........................
Ignition System
Spark plugs .......................
Emission Control Components
Oxygen sensor .....................
BMW Z4 Roadster
3.0i/3.0si
Z4 Coupe 3.0si
Oil Service
Inspection I
Oil Service
Inspection II
R
R R
R R
R R
R
R
Replace at intervals of 100,000 miles
Replace at intervals of 120,000 miles
Oxygen Sensor Service: The oxygen sensor deteriorates strictly on a mileage basis and must there-
fore be replaced to maximize vehicle fuel economy and minimize exhaust pollution.
The mileage interval varies according to individual driving conditions and is determined by the service
interval indicator.
9
Page 14 of 54
Speedometer
(Odometer Memory)
changed:
MileageDate
Record of Spark Plug
Replacement (Every 100,000 Mi. ) Record of Oxygen Sensor
replacement (Every 120,000 Miles) Record of
brake/clutch
fluid changes
(Every 2 years) Record of
ATF change (Every
100,000 Mi.)
Date Mileage Date Mileage Date Mileage
Speedometer
(Odometer Memory)
changed:
Mileage
Date
10
Page 39 of 54
The following systems are covered by the Fed-
eral Emission Performance Warranty for a period
of two years or 24,000 miles, whichever occurs
first. The specific systems may vary according to
model, therefore, all of the systems listed may
not be used on your vehicle. For assistance in
determining which systems and specific compo-
nents within these systems apply to your vehi-
cle, please contact your BMW center.
AIR INDUCTION SYSTEM
FUEL METERING SYSTEM
IGNITION SYSTEM
POSITIVE CRANKCASE VENTILATION SYS-
TEM (PCV)
FUEL EVAPORATIVE CONTROL SYSTEM
EXHAUST SYSTEM
ENGINE EMISSION CONTROL SYSTEM
SENSORS/DEVICES
ON BOARD DIAGNOSTIC SYSTEM (OBD)
RELATED PARTS ASSOCIATED WITH THE
ABOVE SYSTEMS
The following components and/or system are/is
covered under the Federal Emission Perfor-
mance Warranty for a period of 8 years or
80,000 miles, whichever occurs first.
CATALYTIC CONVERTER
ENGINE CONTROL MODULE (INCLUDING ON-
BOARD DIAGNOSTIC SYSTEM)
For assistance in determining coverage of the
specific components of the on-board diagnostic
system, please contact your BMW center.
35
Page 43 of 54
General
The warranty gives you specific legal rights, and
you may also have other rights which vary from
state to state.
THE DURATION OF ANY IMPLIED WARRAN-
TIES, INCLUDING THE IMPLIED WARRANTY
OF MERCHANTABILITY, IS LIMITED TO THE
DURATION OF THE EXPRESS WARRANTIES
HEREIN. BMW OF NORTH AMERICA, LLC
HEREBY EXCLUDES INCIDENTAL AND CON-
SEQUENTIAL DAMAGES, INCLUDING LOSS
OF TIME, INCONVENIENCE, OR LOSS OF USE
OF THE VEHICLE, FOR ANY BREACH OF ANY
EXPRESS OR IMPLIED WARRANTY, INCLUD-
ING THE IMPLIED WARRANTY OF MER-
CHANTABILITY, APPLICABLE TO THIS
PRODUCT.
For assistance in determining which parts are
covered by this warranty, please contact your
authorized BMW center or the BMW NA Cus-
tomer Relations and Services Department at
1 800 831-1117. You may obtain further infor-
mation concerning the emissions warranty or
report violations of warranty terms, by contact-
ing Air Resources Board (ARB), Mobile Source
Division, 9528 Telstar Avenue, El Monte, CA
91731. Please include the title of the BMW ser-
vice department head and telephone number.
California Emission Warranty Parts
List
The following components are covered for
defects by the California Emission Control Sys-
tem Limited Warranty for a period of 7 years or
70,000 miles, whichever comes first.
Component Z4
Roadster 3.0i,
3.0si Z4
Coupe 3.0si
Engine Control Module •
Exhaust Manifold Gasket •
Exhaust Manifold w/Catalyst •
Exhaust Pipe w/Catalyst •
Fuel Pump •
Fuel Tank •
Seal, Fuel Pump/Level Sensor •
Fuel Pressure Regulator w/Fuel Filter •
Intake Manifold •
Intake Manifold Adjuster Unit (Rear) •
Torque Converter •
Throttle Body •
Transmission Control Module •
Valvetronic Sensor •
VANOS (VVT) Camshaft Adjustment
Unit •
39