air filter BUICK ROADMASTER 1993 Owners Manual

Air Cleaner
The air cleaner is located behind the engine fan. To
access the filter, lift up on the latches and let the cover
down. Replace the filter and snap the latches.
Refer
to the Maintenance Schedule to determine when
to replace-the air filter and the
PCV filter.
See “Scheduled .Maintenance Services”
in the Index.
Operath e engine wltn tne air cleaner off can
cause you or others to be burned. The air
cleaner not only cleans the air,
it stops flame i
the engine backfires. If it isn’t there, and the
engine backfires, you could be burned. Don’t
drive
with it off, and be careful working on tT
engine with t‘ air cf - - -- -8r om-
_.
I
253

Cap.acities and, Specifications
CRANKCASE CAPACITY (With Filter) -
5.0 quarts/4.7 liters
TRANSMKSSIQN -
Drain and Refill - 1.0.0. pints/4.7 lifers
Overhaul
- 22.4 pints/f0.6.. liters
MAINTENANCE .ITEM PART NUMBERS3
Air Cleaner - A1.135C
Fuel Filtir
- GF580 ,
Oil Filter - PF2S
PCV Valve - C.V789C
’ PCV Filter - FB59
Radiator Cap - RC27
Spark Plug
- CR43TS, GAP 0.035”
1 8th Character of the Vehicle Identification Number.
2 Made in a GM plant in the United States,
3 Part: numbers are AC type.
4. Air Conditioning Refrigerant - Not all air conditioning refrigerants are the same. If the air conditioning system in your
vehicle needs refrigerant,
be- sure the proper refiigerant is used. If you’re not sure ask your Buick dealer;
295

TO BE SERVICED
(See Explanation of
Scheduled Maintenance
' Months, Whiche'ver Services Following:
Miles (kilometers) or
WHEN TO PERFORM
I
Schedules I and 11y
Item No.
~ Occurs First
7. Front Wheel bearing
~~
Repack See Explanation of Scheduled
Maintenance Service
,Following Schedules I and I1
9. Spark Plug
Replacement*
Inspection*?
I 11. EGR System Inspection*? I
I 12. Air Cleaner Filter
Replacement*
13. Air Cleaner Inspection*?
14.Fuel Tank, Cap
& Lines
Inspection*?
15. Engine Timing &
Distributor Check*
~~
Every 30 000 mi
(50 000 km)
MILES (000)
- KILOMETERS (000)
75 80
J
The services shown in. this schedule up to 48 000 miles (80 00.0 km) should be performed after
48 000 miles at the same intervals.
* An Emission Control Service.
-f- The U.S. Environmental F'rotection Agency has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of
vehicle useful life. General Motors, however, urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded in "Section EMaintenance Record".

..
TO BE ,SERVICED
(See explanation of
Scheduled Maintenance Services Following
Schedules I'and
11)
Item No. - .
8. Transmission Service
9. Spark Plug Replacement"
10. Spark Plug. Wire.Inspection*T
11. EGR System Inspection*?
12. Air Cleaner Filter Replacement"
13. ~ir cleaner Inspection*?
14. Fuel Tank, Cap & Lines'Inspectiori*f
15. En&e Timing & Distributor Check!
WHEN TO PERFORM
., Miles (kilometers) or
Months, Whichever
Occurs First
See Explanation of Scheduled Maintenance
Services Following Schedules
I and 11
Every 30!000 mi. (50 000 km)
t-
KILOMETERS (000)
..
The'services shown in this schedule up to 45.000 miles (75 000 km) should be performed after 45 000
miles at the'same inte-Wals.
I I ..
* An Emission Control Service.
f The U.S. Environmental Protection Agency has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of
vehicle useful life. Gerieml Motors, however; urges that all recommended maintenance services be performed at the indicated intervals and the maintenance be.recorded in "Section EMaintenance
Record".
305

7.
8.
To help ensure-proper operation, we recommena a
pressure test of both’the cooling system and the
pressure cap. If you do not use your vehicle under any of these
conditions, change both the fluid and filter every
100,000 miles (1 60 000 km).
Front Wheel Bearing Repack - When your 9. Spark Plug Replacement* - Replace spark plugs
vehicle is used in such service as police work, as a with the proper type. See “Specifications Chart.’’ in
taxi or
in door-to-door delivery, clean and repackthe the Index.
front wheel bearings at each brake relining or
15,000 Spark plug Wire Inspection*? - Inspect for
miles (25 000 km), whichever comes first. If you
don’t use your vehicle in such service, clean
and
repack the bearings at each brake relining or 30,000 -
miles (50 000 km) whichever comes first. burns, cracks .or other damage. Check the boot fit
at
the distributor and at the spark plugs. Replace wires
as. needed.
Transmission Service - Change both the fluid and
filter every
15,000 miles (25 000 km) if the vehicle
is mainly driven under one or ‘more
of these
conditions:
In heayy city traffic where the outside
temperature regularly reaches
‘90 OF (32 C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police car or delivery
service.
11. Exhaust Gas Recirculation (EGR) System
Inspection*?
- Conduct the EGR system service
as described in the service manual.
To purchase a
service manual, see “Service Publications” in the
Index.
12. Air Cleaner Filter Replacement* - Replace every
30,000 miles (50 000 km) or more ofkn under dusty
conditions. Ask your dealer for the proper
replacement intervals for your driving conditions.
307
I