fuel cap CADILLAC CATERA 1997 1.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine If the Light Is On Steady
You may be able to correct the emission system
malfunction by considering the following:
Did you just drive through a deep puddle of water?
If
so, your electrical system may be wet. The condition
will usually be corrected when the electrical system
dries out.
A few driving trips should turn the light off.
Are you low on fuel?
As your engine starts to run out of fuel, your engine may
not run as efficiently as designed since small amounts of
air are sucked into the fuel line causing a misfire. The
system can detect this. Adding fuel should correct this
condition. Make sure to install the fuel cap properly. It
will take
a few driving trips to turn the light off.
Have you recently changed brands of fuel?
If
so, be sure to fuel your vehicle with quality fuel (see
“Fuel” in the Index). Poor fuel quality will cause your
engine not to run as efficiently as designed. You may
notice this as stalling after start-up, stalling when you
put the vehicle into gear, misfiring, hesitation on
acceleration or stumbling on acceleration. (These
conditions may go away once the engine is warmed up.)
This will be detected by
the system and cause the light
to turn on.
If you experience one or more of these conditions,
change the fuel brand you use. It will require at least one
full tank of the proper fuel to
turn the light off.
If none of the above steps have made the light turn off,
have your dealer or qualified service center check the
vehicle. Your dealer has the proper test equipment and
diagnostic tools to
fix any mechanical or electrical
problems that may have developed.
2-71

Downloaded from www.Manualslib.com manuals search engine Loading Your Vehicle
(@I OCCUPANTS VEHICLE CAP. WT.
TIRE-LOADING
INFORMATION
I FRT. CTR. RR. TOTAL LBS. KG
MAX. LOADING & GVWR SAME AS VEHICLE
CAPACITY WEIGHT XXX COLD TIRE
TIRE SIZE SPEED PRESSURE
RTG PSUKPa
FRT.
RR.
SPA.
IF TIRES ARE HOT, ADD 4PS1/28KPa
SEE OWNER‘S MANUAL FOR ADDITIONAL
INFORMATION
Two labels on your vehicle show how much weight it
may properly carry. The Tire-Loading Information label
found on the rear edge of the driver’s door tells
you the
proper size, speed rating and recommended inflation
pressures for the tires on your vehicle. It also gives you
important information about the number
of people that
can be in your vehicle and
the total weight that you can
carry.
This weight is called the Vehicle Capacity Weight
and includes the weight of all occupants, cargo and all
options not installed at the factory.
f
MFD BY GENERAL MOTORS CORP
DATE
GVWR GAWR FRT GAWR RR
THIS VEHICLE CONFORMS TO ALL APPLI-
CABLE
U.S. FEDERAL MOTOR VEHICLE
SAFETY, BUMPER, AND THEFT PREVENTION
STANDARDS
IN EFFECT ON THE DATE OF
MANUFACTURE SHOWN ABOVE.
I
The other label is the certification label, found on the
rear edge of the driver’s door. It tells you the gross
weight capacity of your vehicle, called the GVWR
(Gross Vehicle Weight Rating). The GVWR includes
the weight of the vehicle, all occupants, fuel and cargo.
Never exceed the GVWR for your vehicle, or the
Gross Axle Weight Rating (GAWR)
for either the front
or rear axle.
If you do have a heavy load, you should spread it out.
Don’t carry more than
176 lbs. (80 kg) in the trunk.
4-30

Downloaded from www.Manualslib.com manuals search engine Electronic Level Control
This feature keeps the rear of your vehicle level as the
load changes. It’s automatic
-- you don’t need to
adjust anything.
Towing a Trailer
If you don’t use the correct equipment and drive
properly, you can lose control when you pull a
trailer. For example,
if the trailer is too heavy, the
brakes may not work well
-- or even at all. You
and your passengers could be seriously injured.
Pull a trailer only
if you have followed all the
steps
in this section. Ask your Catera dealer for
advice and information about towing
a trailer
with your vehicle.
I NOTICE:
Pulling a trailer improperly can damage your
vehicle and result in costly repairs not covered
by
your warranty. To pull a trailer correctly, follow
the advice in this part, and see your Catera
dealer for important information about towing a
trailer with your vehicle.
Your Catera can tow a trailer if it is equipped with the
proper trailer towing equipment. To identify what the
vehicle trailering capacity is for your vehicle, you
should read the information in “Weight
of the Trailer”
that appears later in this section. But trailering is
different than just driving your vehicle by itself.
Trailering means changes in handling, durability and fuel economy. Successful, safe trailering takes correct
equipment, and it has to be used properly.
4-32

Downloaded from www.Manualslib.com manuals search engine Here you will find information about the care of your Catera. This section begins with service and fuel information,
and then
it shows how to check important fluid and lubricant levels. There is also technical information about your
vehicle, and a part devoted to its appearance care.
6-2
6-3
6-5
6-5 6-7
6- 10
6- 15 6-18
6- 19
6-24
6-25
6-29
6-29
6-37
Service
Fuel
Fuels in Foreign Countries
Filling Your Tank
Checking Things Under the Hood
Engine Oil
Air Cleaner
Automatic Transmission Fluid
Engine Coolant
Windshield Washer Fluid
Brakes
Battery Bulb Replacement
Wiper Blade Replacement Tires
Cleaning the Inside of Your Catera
Care
of Safety Belts
Cleaning the Outside
of Your Catera
Cleaning Aluminum or Chrome Wheels
Underbody Maintenance
Appearance Care Materials Chart
Vehicle Identification Number (VIN)
Electrical System Replacement Bulbs Capacities and Specifications
Air Conditioning Refrigerants
Normal Maintenance Replacement Parts
6-38
6-46
6-49
6-50
6-5 1
6-53
6-54
6-55
6-55
6-62 6-62
6-63
6-63
6-1

Downloaded from www.Manualslib.com manuals search engine Fuels in Foreign Countries
If you plan on driving in another country outside the
United States or Canada, the proper fuel may be hard to
find. Never use leaded gasoline or any other fuel not
recommended in the previous text on fuel. Costly repairs
caused by use
of improper fuel wouldn’t be covered by
your warranty.
To check on fuel availability, ask an auto club, or
contact a major oil company that does business in the
country where you’ll be driving.
You can also write us at the following address for
advice. Just tell
us where you’re going and give your
Vehicle Identification Number (VIN).
General Motors International Product Center
1908 Colonel Sam Drive
Oshawa, Ontario
L1H 8P7
Filling Your Tank
The cap is behind a hinged door on the passenger’s side
of your vehicle.

Downloaded from www.Manualslib.com manuals search engine I
I A CAUTION:
1
Gasoline vapor is highly flammable. It burns
violently, and that can cause very bad injuries.
Don't smoke if you're near gasoline or refueling your vehicle. Keep sparks, flames and smoking materials away from gasoline.
To use this feature,
your vehicle must be in
PARK (P). Press the fuel
door unlock button located
on the.instrument panel
center console to unlock and
open the fuel door. You can
also press the fuel button on
the
RKE transmitter to
access the fuel cap. While
refueling, hang the tethered fuel cap inside the
fuel door as shown
by the arrow.
To take off the cap, turn it slowly to the left
(counterclockwise).

Downloaded from www.Manualslib.com manuals search engine If you get gasoline on yourself and then
something ignites
it, you could be badly burned.
Gasoline can spray out on you
if you open the
fuel filler cap too quickly. This spray can happen
if your tank is nearly full, and is more likely in
hot weather. Open the fuel filler cap slowly and
wait for any “hiss” noise to stop. Then unscrew
the cap all the
way.
Be careful not to spill gasoline. Clean gasoline from
painted surfaces as soon as possible. See “Cleaning the
Outside of Your Catera” in the Index.
When
you put the cap back on, turn it to the right
(clockwise) until you hear a clicking sound. Make sure
you fully install the cap.
Checking Things Under the Hood
A CAC-ION:
An electric fan under the hood can start up and
injure you even when the engine
is not running.
Keep hands, clothing and tools away from any
underhood electric fan.
Things that burn can get on hot engine parts and
start a fire. These include liquids like gasoline,
oil, coolant, brake fluid, windshield washer and
other fluids, and plastic or rubber. You or others
could be burned. Be careful not to drop or spill
things that will burn onto a hot engine.
6-7

Downloaded from www.Manualslib.com manuals search engine If you’ll be driving at speeds higher than 100 mph
(160 km/h) where it is legal, raise the cold inflation
pressure of each tire to
37 psi (250 ma). When you end
this very high-speed driving, reduce the cold inflation
pressures to those listed on the Tire-Loading
Information label.
I NOTICE:
Don’t let anyone tell you that underinflation or
overinflation
is all right. It’s not. If your tires
don’t have enough air (underinflation), you can
get the following:
1 Too muchflexing
’ 0 Toomuch heat
~ 0 Tire overloading
Bad wear
0 Bad handling
1 0 Bad fuel economy.
NOTICE: (Continued)
I
NOTICE: (Continued) -
If your tires have too much air (overinflation),
you can get the following:
0 Unusual wear
0 Bad handling
0 Rough ride
Needless damage from road hazar
~- . - .. ..~ ~
v
When to Check
Check your tires once a month or more.
How to Check
Use a good quality pocket-type gage to check tire
pressure.
You can’t tell if your tires are properly
inflated simply
by looking at them. Radial tires may
look properly inflated even when they’re underinflated.
Be sure to put the valve caps back on the valve
stems. They help prevent leaks by keeping
out dirt
and moisture.
6-39

Downloaded from www.Manualslib.com manuals search engine Fuse
5
6
7
8
9
10
12 15 16
17
18
19
20
27 28
29
39
Usage
A/C Compressor
A/C Blower-Radiator
A/C Blower-Radiator
A/C Blower-Radiator
Secondary Air Induct
Injection Valves
Blower-Radiator A/C Blower-Radiator
Plug Connection
A/C Blower-Radiator
A/C Blower-Radiator
Relay
Fuel Pump
Oxygen Exhaust Sensor
Control Unit
Blower
Box
Diagnostic Plug Connection
Replacement Bulbs
Front Turn Signal Lamp ............... 90487485
Inner High Beam
................... 905 12338
Outer Low Beam
................... 905 12338
Application Bulb Number
Headlamps Composite
Rear Turn Signal Lamp and Taillamp
.... 90002521
Capacities and Specifications
Displacement ......... 18 1 cubic inches (2 962 cc)
Type
......................... 3.0 L DOHC V6
VIN Engine Code ........................... R
Horsepower .............. 200 (bhp) @ 6000 rpm
Torque
.................. 192 (lb-ft) 0 3600 rpm
Firing Order ....................... 1-2-3-4-5-6
Thermostat
Starts To Open . .... 198"F(9Z°C)
Engine Specifications
149 (kW) @ 6000 rpm
260
(N-m) @ 3600 rpm
6-62

Downloaded from www.Manualslib.com manuals search engine Capacities
Engine Crankcase
Transmission
................. 7.0 quarts (6.6 L)
Oil Change With Filter* ...... 6.1 quarts (5.75 L)
Engine Cooling System ......... 10.6 quarts ( IO L)
Fuel Tank ................... 18 gallons (68. I L)
R- i 34a
Refrigerant,. ............. 2.9 lbs. (0.95 kg)
Wheel Base ............. 107.4 inches (272.8 cm)
Length ................... 194 inches (492.8 cm)
Height.. ................. 56.3 inches (143.1 cm)
Width ................... 70.3 inches (178.6 cm)
Front Tread
............... 59.3 inches ( 150.6 cm)
Rear Tread ................ .59.8 inches (152 cm)
Wheel Bolt Torque ............ 80 lb-ft (I 10 N-m)
Oil Change Without Filter* .... 5.8 quarts (5.5 L)
Vehicle Dimensions
* Recheck the oil level after filling. See “Engine Oil” in
the Index.
Air Conditioning Refrigerants
Normal Maintenance
Replacement Parts
Air Filter Element ................... 905093 18
Fuel Filter Element
.................. 90437575
Engine
Oil Filter .................... 93 156300
Passenger’s Compartment Air Filter
......................... 90510338
Thermostat
......................... 90502201
Windshield Wiper Blade
.......... 905 12807 (RH)
905 12808
(LH)
Spark Plugs ... 90541059 (Bosch Plug = FLR9LTE)
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant,
be sure the proper refrigerant is used.
If you’re not sure, ask your Catera dealer.
6-63