lock CADILLAC ELDORADO 1994 10.G Repair Manual

Downloaded from www.Manualslib.com manuals search engine Y
r
r I
i
r
!r:
i E
,r
i 'E
L HDLP LO R HDLP LO L HDLP HI R HDLP HI ION 3 COOL'FAN TRANS
I FUSE CENTER IDENTIFICATION I
ENGINE COMPARTMENT FUSE BLOCK
DlSTR 20A
SIR 20A - IGNITION CONTROL MODULE
- DIAGNOSTIC/ENERGY RESERVE
MODULE (DERM)
- DUAL POLE ARMING SENSOR PCM (ION 1OA
- PASS-Key@ DECODER MODULE INJ 10A
- POWERTRAIN CONTROL MODULE (PCM)
- 1,4,6, AND 7 FUEL INJECTORS
- 2.3.5. AND 8 FUEL INJECTORS INJ 1OA
ION
1 iOA - A/C REFRIGERANT PRESSURE SWITCH - TRANSAXLE RANGE SWITCH - STOP/BTSI/CRUISE BRAKE SWITCH - INSTRUMENT PANEL'CLUSTER - KEYLESS ENTRY MODULE - DIAGNOSTlCfENERGY RESERVE MODULE
- PERM2 ORN RING LIGHTS - TURN/HAZARD SWITCH ASSY. - CHIME MODULE - HEADLIGHT SWITCH - TWILIGHT SENTINEUDRL MODULE
- FUELPUMP - OIL PRESSURE SWITCH - POWERTRAIN CONTROL MODULE IPCMI
FUEL PUMP 20A
PCM (BAT) 1OA
RTD
, AT) 20A - RgAD SENSING SUSPENSION (RSS) MODUL A/C COMP 1OA
- POWERTRAIN CONTROL MODULE (PCM)
- A/C COMPRESSOR CLUTCH HDLPS 3OA
.~
- HEADLIGHT DIMMER SWITCH - HEADLIGHT RELAY "D (ENGINE COMF!
- DRL HEADLIGHT RELAY "E" (WITH DAYTIME
- POWERS C13 MICRO RELAY CENTER)
RUNNING LIGHTS)
E
STOP LP 2OA - STOP/BTSI/CRUISE SWITCH - STOPUGHT SWITCH CAPACITOR TURNIHAZ 20A - HAZARD FLASHER - TURN FLASHER RELAY - TURN FLASHER MODULE DRL 1 OA (CANADA) - DAV~ME RUNNI'NG LIGHTS (CANADA) ~ ~~
DRL 1 OA (CANADA)
HTD
W/S 1OA
L HDLP LO 1OA
- LEFT AND RIGHT LO BEAM HEADLAMP
- HEATED WINDSHIELD CONTROL MODULE
- LEFT LO BEAM HEADLAMP R HDLP LO 10A
L HDLP HI 1OA - RIGHT LO BEAM HEADLAMP
- LEFT HI BEAM HEADLAMP R HDLP HI 1OA
IGN
3 10A - RIGHT HI BEAM HEADLAMP
- REAR DEFOGGERRELAY - ELECTRONIC LEVEL CONTROL IELCI - HEATED WINDSHIELD - HEATER AND A/C PROGRAMMER - CRUISE CONTROL
..
COOLING FAN 1OA - MENDED TRAVEL BRAKE SWITCH - POWERTRAIN CONTROL MO'DULE (PCM) - COOLING FAN RELAYS 1,2, AND 3 - FRONT AND REAR HEATED OXYGEN SENSOR TRANSIECS 1 OA - OVERSPEED ALERT MODULE (=PORT) - POWER STEERING PRESSURE SWITCH - EXHAUST GAS REClRCULAilON (EGR) VALVE - TRANSAXLE SHIFT SOLENOIDS A & B - EVAPORATIVE EMISSION CONTROL
SOLENOID ~~
- POWERTRAIN CONTROL MODULE (PCM) - TORQUE CONVERTER CLUTCH SOLENOID - TCC BRAKESWlTCH
313

Downloaded from www.Manualslib.com manuals search engine I 30AC.B. I
A
I I 60A
E
I 60A I
I I 50A
4
I 40A 1
n
LH MAXI8 FUSE BLOCK
FUSE 1 (50 AMP) (STRG 1-2)
- RETAINED ACCESSORY POWER (RADIO/WIPERS)
- STARTER
- TRUNK COMF FUSES 81 1 AND 813
FUSE 2 (60 AMP) (BODY)
- ENGINE COMI? B11
- ROAD SENSING SUSPENSION
- FOG LIGHTS
- TRUNK COMF! FUSE C1, C3, C5, C7, C9, AND
c11
- TRUNK COMF! FUSE C13 (EXPORT)
- REAR FOG LIGHT (EXPORT)
CIRCUIT BREAKER 3 (30 AMP) (SEAT)
- LEFT AND RIGHT POWER SEAT SWITCHES
- LEFT AND RIGHT LUMBAR RELAYS
- POWER DOOR LOCKS
- KEYLESS ENTRY MODULE
- HORNS
- FUEL DOOR RELEASE SWITCH - TRUNK RELEASE SWITCH
FUSE 4 (30 AMP) (IPC)
- POWERTRAIN CONTROL MODULE (PCM)
- ELECTRONIC CLIMATE CONTROL
- RAP/ILLUMINATED ENTRY MODULE
- INSTRUMENT PANEL CLUSTER
- PASS-Key@ DECODER MODULE
- THEFT DETERRENT
FUSE 5 (SO AMP) (HVAC)
- LEFT AND RIGHT HEATED SEATS
- ELECTRONIC LEVEL CONTROL (ELC)
- TRUNK LID PULL DOWN
- POWER ANTENNA
- REAR DEFOGGER
- LEFT AND RIGHT MIRROR DEFOGGERS
FUSE 6 (60 AMP) (STRG 3)
- RETAINED ACCESSORY POWER
(SUNROOF/POWER WINDOWS)
- ENGINE COMF! FUSES Dl, D3, D5
- TRUNK COMF! FUSES Al, A3, A5, Ai', A9
RH MAXI8 FUSE BLOCK
CIRCUIT BREAKER 1 (30 AMP) (DAB)
- RETAINED ACCESSORY POWER (RAP)
(SUNROOF/POWER WINDOWS)
FUSE 2 (30 AMP) (RADIO)
- DELCO-BOSE@ SPEAKERS
- RADIO CONTROL HEAD
- REMOTE RADIO RECEIVER
FUSE 3 (50 AMP) (COOL)
FUSE
4 (40 AMP) HVAC BLOWER (BLOWER)
- COOLING FANS
- HVAC POWER MOTOR
- A/C COMPRESSOR
FUSE 5 (50 AMP) ABS (BRAKES)
FUSE
6 (50 AMP) (LAMPS)
- BRAKE PRESSURE MODULATOR VALVE
- TURN FLASHER MODULE
- HAZARD FLASHER
- STOP/BTSI/CRUISE BRAKE SWITCH
- PARKING LIGHTS
- DAY TIME RUNNING LIGHTS (CANADA)
- ENGINE COME FUSES B1,W AND B5
- TRUNK COMF! FUSES Dl 1, Dl3
314

Downloaded from www.Manualslib.com manuals search engine WIPER THEFT HVAC/DABIE
REAR FOG FOG LP CNSL FAN CIGAR BODY
2 BODY 1 READ LP
LPRKLP
R PRKLP RAD (BAT) ANTBRKPLD ELC R HTD SEAT L HTD SEAT
~
TRUNK COMPARTMENT FUSE BLOCK
- RAP/IUMINATED ENTRY MODULE CRANK (10 AMP)
- DIAGNOSTIC/ENERGY RESERVE
- TRANSAXLE RANGE SWITCH (NSSS) MODULE (DERM) ION 1 (10 AMP .,
- FUEL
LEV& SENSOR - ELECTROCHROMIC MIRROR - RAP/ILWMINATED ENTRY MODULE - THEFT DETERRENT MODULE - KEYLESS ENTRY MODULE - TURN FLASHER RELAY-~F" TRUNK cc MICRO RELAY CENTER )MF!
MODI
JLE
- PASS-Key@ DECODER MODULE - THEFT DETERRENT RELAY
"D" (TRUNK COME
- THEFT DETERRENT MODULE
- HEATER AND NC PROGRAMMER HVAC/DABIE (10 AMP)
- RAP/ILLUMINATED ENTRY MODULE RELAY CENTER) REAR FOG (10 AMP)
FOG
LP (10 AMP)
CNSL FAN (1OAMP)
~~ ~~~
- REAR FOG LIGHT RELAY A (EXPORT)
- FOG LIGHT RELAYS A AND F
- REAR BLOWER MOTOR - REAR BLOWER RELAY .MODULE
CIGAR (20 AMP) - LTAND
RT REAR CIGARETTE LIGHTERS (SNILLE ONLY) - FRONT CIGARETTE LIGHTER - CHIME MODULE
- POWER MdOR SWITCH BODY 2 (10 AMP
- RAPRELAY - LOCK-OUT INHIBIT RELAY "B" (TRUNK COMF! 1 MICRO
- PANEL LIGHTS INHIBIT RELAY "F" (TRUNK COMF! 3 MICRO
- COURTESY LIGHTS RELAY "C" (TRUNK COMF! 2 MICRO
- RAP RELAY "E" (TRUNK COMF! 2 MICRO RELAY CENTER) - KEYLESS ENTRY MODULE - TRUNKLAMP - SEAT BELT RETRACTOR SOLENOIDS (ELDORADO ONLY) RELAY CENTER)
RELAY CENTER) (EXPORT)
RELAY CENTER)
- FRONT Dook LOCK swmm BODY 1 (10 AMP
- GLOVE BOX LAMP - LT AND RT FOOTWELL COURTESY LAMPS - HEADLIGHT SWITCH
- LTAN- ___ L PRK LP (10 AMP - LT REAR TAIdToPnURN LAMPS - LT FRONT PARWURN LAMPS - FRONT AND REAR I .EFT SIDE MARKER LAMPS - RADIO CONTRC - HEADLlGl - INSTRUML ... . . R PRK LP (10 AMP - RT TAlusToP !URN LAMPS - AT FRONT AND REAR SIDE MARKER LAMPS - RT FRONT PARK AND TURN LAMPS
- RAE RAD (BA
ANT/TRl
- TRU - POWER7
~VlVl~ WM. : PLATE LAMPS
;% (10 AMP)
c PLD (20 AMP) NK LID PULL DOWN MOTOR WTENNA
{NIC LEVEL CONTROL (ELC)
% SEAT
316

Downloaded from www.Manualslib.com manuals search engine r
The.head1ightwiring is protected by,a circuit breaker in the light switch.
An electrical overload will cause the lights to .go on and off, or in.. some
cases: to -remain-
off. If this happens, have your headlight wiring checked
rightaway.
.Wiradshiekl Wipem
The windshield wiper motor is protected by a circuit breaker and a fuse.
If the..motor overheats due to heavy snow, .etc.,-.the wiper will stop imtil
the
motor mls. If the overload iscaused by some electrical problem and
not snow, etc., be sure to get it fixed.
Power Widbws andother Power Options
F I ! Circuit breakers in .the fuse panel protect the power windows and other power
accessories. .whensthe current load islm heavy, the circuit breaker
qens .and
closes, protecting the circuit until the, problem is. fixed or goes. away.
I r,
r
r
/r: I
r' LJ
DESCRIPTION BULB NO.
Ash ?i.ay.Illuninatio.n .................................... .1445
Backup Lights ......................................... 2057
Cornering Light ................................... 1156 ,DC7
CowtesyReading Light
.................................... 168
Glove. Compartment Light ................................ 194
Headlights'Composite -Inner High Beam
................................ 9005 HB3
.-Outer Low Beam
................................... ,9006 HB4
Illumination Entry~Lock~Lamp
............................. .192
Instrument. Panel Illuniinatian ............................ ' 194
. 1.nstrumeIlit Panel'T'llt&s ................................ 194
LicenseP1ate.Ligh.t ....................................... 194
Park and Tim Signal ................................ 2357.NA
. Fog Light ............................................... 886
-Errport.Bulb ............................................ H4
317
I

Downloaded from www.Manualslib.com manuals search engine The Northstar engine is designed to require less maintenance than many
other DOHC
V-8 engines. Engine systems are designed to remind the
driver when service is required.
An oil life index indicator monitors
ongoing operating conditions and reminds the driver when an oil change
is needed.
A low coolant warning message keeps track.of the level of this
vital fluid. Direct acting hydraulic tappets provide maintenance free zero
lash operation
of the 32 valves from idle to the 6500 rpm redline. The
camshafts are driven by
a two stage roller chain assembly which is
designed
to provide quiet maintenance free Operation. Platinum tipped
,spark plugs increase the replacement interval
to 100,000 miles.
The four valve per cylinder design provides more efficient engine
breathing which results in higher power than comparable
two valve
engines. The central location
of each spark plug ensures a fast and
complete burning of the fuel/air mixture. The induction system uses
smooth thermoplastic tubes to channel air into the cylinders. The
smoothness
of the tubes is equivalent to the elaborate port polishing
methods used for race car engines. Careful design using the shape and
length
of the tubes boosts horsepower by using sonic pressure waves
created by the motion
of the inlet valves to increase the amount of air
entering ,each cylinder.
The Northstar engine is also designed
to be very durable. The aluminum
block has cast-in-place iron cylinder liners for greater wear resistance.
High strength connecting rods support the free floating piston pins in
bronze bushings for superior high speed performance. The fillets
of the
nodular iron crankshaft undergo
a high pressure compression rolling
operation to improve their resistance to fatigue.
Quiet operation is enhanced by the use of special materials and designs.
The front cover of the engine is stamped from laminated steel which
damps out noise. Special cam cover gasket seals isolate valve train
operation.The fuel injectors are placed inside the induction system
housing
to eliminate- the clicking noise which is common to other fuel
injected engines.
The Northstar engine is designed to provide years of efficient. reliable.
satisfying operation.
7
320

Downloaded from www.Manualslib.com manuals search engine r
r
r
I
Ir
r
Iil
r
r
r!
The power rack and pinion..stee&g .gstem--h,w, a ,rotaq- spool valve which
directs hydraulic fluid coming from the power steering pump .to one side or
the other
side of the rack piston. The integral rack.piston is attached to the
rack. The rack piston converts hydraulic pressure to a linear force which
moves the rack4eft or right.
The force is then transmitted through the
inner and outer tie rods to the steering
.. knuckles, , which turn the wheels
If hydraulic assist is not available, manual conirol, is ‘maintained. However
under these, conditions. more steering effort is required.
4.6 LITER NORTHSTAR ENGINE
Displacement ............................... .4.6L (279 cu.in.)
No. of Cylinders
................ 32-valve DOHC 8 - 90 Degree V
Power (ACC. to
SAE 51349) ................ 270 (b,hp) @ 5600 rpm
Torque (ACC. to
SAE 51349) ............ 300 (lbs. ft.) @? 4000 rpm
ELDORADO
...................................... 204 (kW) @ 5600 rprn
...................................... 407(N*m) @ 4OOOrpm
ETC
Power (ACC. to SAE 51349) ................ 295’(bhp) @ 6000 rpm
Torque (ACC. to
SAE 51349) ............ 290 (lbs. ft.) @? 440.0 rpm
Bore
........................................ 93mm.(3.66.in.)
Stroke
...................................... .84mm (331in.)
Compression Ratio
.................................... 10.3: 1
Cylinder Block ...... Die Cast Aluminum with Iron Cylinder Bores
Cylinder Heads
................................. Cast Aluminum
Intake Manifold-
............ Die Cast Magnesium / Thermoplastic
.......................................... Air Induction Tubes
........................................ 220 (kW) @ 6000 rpm
...................................... 393 (Nom) @ 4400 rpm
Valve. System ................... Direct Acting Hydraulic Tappets
Intake Valve
.................................. 33mm (1.29 in.).
Fkhaust Valve,. ................................ 29mm (1.14.h.)
Pktons
...................................... Cast Aluminum
Firing Order
.................................. 1-2-7-3-4-5-6-8
Left Bank ........................................... 2-4-6-8
325

Downloaded from www.Manualslib.com manuals search engine r
r
c
r
r
r
c
Roadside Service represents the spirit of luxury leadership at Camqc
Motor Car Division.
We hope the need never arises, but if it does,
Roadside.Service
is there for you! ! Roadside Service covers you on the
road,
far from home, all day and night, weekends and holidays.
THERE mE'NO MEMBERSHIP OR ENROLLMENT CHARGES.
Any CadiUac is eligible under this program.
ROmSDE SER.WCE AVAILABILITY-
TYPE DAILY INCLUDING
OF ASSISTANCE HOLIDAYS
Phone Advisor 24 Hours
Dealer Technib, 8 a.m. - 12 midnight
Towing
Battery Jump Start
Lockout Assistance 24 hours
Fuel Delivery
Tire Change
.
Cadillac Roadside Service is just one of your Cadillac Owner
Privilegessm that leads to
peace of mind.
1

Downloaded from www.Manualslib.com manuals search engine - Cadillac Owner Privileges SM =
Roadside Service provides several Cadillac Owner PrivilegesSm at \
"no
charge", throughout your 1994 Cadillac Warranty Period - 48 Months
or 50,000 Miles/80,000 Kilometers.
0 EMERGENCY ROAD SERVICE - is performed on site for the .
following situations:
TOWING SERVICE
BATI'ERY
JUMP START
LOCK OUT ASSISTANCE
FUEL DELIVERY
FLAT TIRE CHANGE (8 Covers change only)
* Tire replacement/warranty coverage must be
determined by a Cadillac dealer or appropriate
tire manufacturer.
i.
8'
?
2

Downloaded from www.Manualslib.com manuals search engine What Will Roadbide Service Cost You ? ? ?
There is no cost to call the toll-free Roadside Service number. Many
times Roadside Advisors
can assist you over the phone.
There is
no cost for Roadside Service if the repair is under warranty or
the provided service
is one of the covered Emergency Road Services.
If a dealership Service Technician travels to your location, and the
reDair is not covered under warranty, there is a
nominal service fee to
cover the technician's travel to and from your location. Labor is
charged at one and half times the Cadillac dealership retail labor rate,
with a
30 minute minimum. There is also a charge for any parts used
and a mileage fee
if the technician travels beyond 30 miles.
How Do You Pay For Roadside Service 3 ? ?
Payment is due at the time services are performed if it is determined
they are non-warranty related. Payment may be made by cash, personal
check or any major credit
card honored by the participating Cadillac
dealership, tow service or locksmith.
In some instances where warranty determination cannot be made, \
the
charges must still be paid. Retain the
bill and submit it to an authorized
Cadillac dealership Service Department for review.
If the repair is
determined
to be covered by warranty the dealer will expedite
reimbursement directly to you.
c-
t-
L
4

Downloaded from www.Manualslib.com manuals search engine r .
r
r
'-r
. r
. r
I
11
" p
ELDORADO INDEX
A
Acc (Ignition Key Position) ........................... 84
Accessory Power. Retained .......................... 311
Adding Brake Fluid
..................................... 272
Electrical Equipment ............................. 311
Engine Coolant ............................. 224. 262
Engine Oil ...................................... 253
Power Steering Fluid ............................. 267
Transaxle Fluid .................................. 262
Additives. Engine Oil ............................... 257
Adjustment. Brake ................................. 273
Adult Safety Belt Usage .............................. 20
Air Bag ............................................ 30
Air Cleaner ........................................ 258
Air Cleaner Replace ..................... See Maint . Book
Air Conditioner .................................... 151
Air Outlets ........................................ 150
Air System ........................................ 150
Alarm. How To Turn Off Theft ........................ 80
Alcohol. Driving Under The Influence Of .............. 171
Alcohol in Gasoline ................................. 243
Aluminum Wheels. Cleaning ......................... 305
AM Radio Reception ............................... 157
AM Stereo Radio Reception ......................... 158
Antenna. Cleaning Radio ............................ 168
Antifreeze ........................................ 263
Anti-Lock Brakes .................................. 177
Anti-Lock Brake System Warning Light ............ 133. 177
Anti-Lockout Feature ................................ 71
Anti-Theft Tips ..................................... 79
Appearance Care .................................... 298
Arm. Wearing A Safety Belt Under Your ................ 28
Ashtrays .......................................... 126
Astroroof ......................................... 124
Automatic Air Conditioning System ................... 151
Automatic Door Lock ................................ 70
Air Cleaner Filter Replacement ...................... 285
AMAX@ ........... .- .............................. 158
1
li