power steering CADILLAC SEVILLE 1993 4.G Owners Manual
[x] Cancel search | Manufacturer: CADILLAC, Model Year: 1993, Model line: SEVILLE, Model: CADILLAC SEVILLE 1993 4.GPages: 407, PDF Size: 22.28 MB
Page 111 of 407
Downloaded from www.Manualslib.com manuals search engine POWER WINDOWS
The controls are near
each window. Here’s
how the master control
works.
Your vehicle has Retained Accessory Power
(RAP). When you stop your
vehicle and turn the ignition key to “Off”, you can still use your power
windows. The electrical power
to operate the windows will not shut off
until you open a door or 10 minutes has passed. If you want this power
for another
10 minutes, just turn the key to “Run” and back to “Off”.
Ekpress Down Window
The driver’s power window has this feature. Just press the switch once --
for half a second or more -- and then let go. The window will go all the
way down. If
you want to stop the window as it is going down, press the
switch again.
HORN
To sound the horn, just press the center of the steering wheel.
97
Page 198 of 407
Downloaded from www.Manualslib.com manuals search engine Some driving conditions or climates may cause a brake squeal when the
brakes are first applied or lightly applied. This does not mean something
is wrong with your brakes.
Brake linings should always be replaced as complete axle sets. \
Brake Pedal Travel
See your dealer if the brake pedal does not return to normal height, or if
there is a rapid increase in pedal travel. This could be a sign of brake
trouble.
Brake Agustment
Every time you make a moderate brake stop, your disc brakes adjust for
wear.
If you rarely make a moderate or heavier stop, then your brakes might
not adjust correctly. If you drive
in that way, then -- very carefully -- make
a few moderate brake stops about every
1000 miles (1600 km), so your
brakes will adjust properly.
Braking in Emergencies
Use your anti-lock braking system when you need to. With anti-lock, you
can steer and brake at
the same time. In many emergencies, steering can
help you more than even the
very best braking.
STEERING
Power Steering
If you lose power steering assist because the engine stops or the system
fails to function, you can steer but it
will take much more effort.
Steering Tips
Driving on Curves
It’s important to take curves at a reasonable speed.
184
c
c
u
Page 300 of 407
Downloaded from www.Manualslib.com manuals search engine MUTOR OR SURGE TANK
PRESSURE CAP
When you replace your radiator or surge tank pressure cap, an AC@ cap
is recommended.
THERMOSTAT
Engine coolant temperature is controlled by a thermostat in the engine
coolant system.
The thermostat stops the flow of coolant through the
radiator until the coolant reaches a preset temperature.
When you replace your thermostat, an
AC@ thermostat is recommended.
POWER STEERING FLUID
0
4.9 Liter
286
Page 301 of 407
Downloaded from www.Manualslib.com manuals search engine P
L
r
r
c
P
P
c
P
I.
How To Check Power Steering Fluid:
4.6 Liter (Northstar)
Unscrew the cap and wipe the dipstick with a clean rag. Replace the cap
and completely tighten it. Then remove the cap again and look at the
fluid level
on the dipstick.
0
0
When the engine
compartment is
hot, the level
should
be at the
“HOT” mark.
When the engine
compartment is
cool, the
level
should be at the
“FULL COLD”
mark.
287
I
Page 302 of 407
Downloaded from www.Manualslib.com manuals search engine What to Add:
Refer to the Maintenance Schedule to determine what kind of fluid to
use. See “Recommended Fluids and Lubricants” in the Index.
.~
NOTICE:
When adding power steering fluid or making a complete fluid
change, always use the proper fluid. Failure to use the proper
fluid can cause leaks and damage hoses and seals.
WNDSHIELD WASHER FLUID
To Add:
’L-
Open the cap labeled “WASHER FLUID ONLY.” Add washer fluid until
the bottle is full.
3
288
..
Page 338 of 407
Downloaded from www.Manualslib.com manuals search engine MPERACE CAREIMATERL4LS ClYART
NUMBER
I 1050017 I 32 OZ. 10.946 Ll
1052277 12 02. (0.354 L)
10501 72 16 02. (0.473 L)
1050173 16 02. (0.473 L)
10501 74
32
OZ. (0.946 L) 1050214 16
OZ. (0.473 L)
1050244
6
LB. (2.72 KG) 1050429 23
02. (0.660 L) 1050427 16
OZ. (0.473 L)
1052349
8 OZ. (0.237 L) 1050729 12
02. (0.354 L)
+
1052870 16 OZ. (0.473 L)
1051
398 8 OZ. (0.237 L)
1 105151 5 I 32 02. (0.946 L)
+
1052367 16 02. (0.473 L)
1052753 1 GAL. (3.785 L)
1052271 I 23 02. (0.680 L)
1052358 I 12 OZ. 10.354 LI
I 1052535 I 16 OZ. (0.473 L)
DESCRIPTION
WASHER SOLVENT AND GAS
LINE DE-ICER
POWER STEERING FLUID SPRAY-A-SQUEAK
TAR AND ROAD OIL REMOVER
USAGE
WINDSHIELD WASHING SYSTEM AND GASCINE
POWER STEERING
WEATHER STRIPS-STOPS SQUEAKS ON METAL-TO-METAL AND METAL-TO-RUBBER CONTACT
REMOVES OLD WAXES, POLISHES,
I TAR AND ROAD OIL
CHROME CLEANER AND
I REMOVES RUST AND CORROSION
POLISH ON CHROMEAND STAINLESS I STEEL
WHITE SIDEWALL TIRE CLEANS WHITE AND BLACK TIRES
CLEANER
VINYULEATHER CLEANER
SPOT AND STAIN REMOVAL
ON FABRIC CLEANER SPOT AND STAIN REMOVAL
ON
. ___
LEATHER OR VINYL
CLOTH AND FABRIC
I
GLASS CLEANER I GLASS CLEANING AND SPOT I CLEANING ON VINYLS
MULTI-PURPOSE POWDERED
I CLEANS VINYL AND CLOTH ON
CLEANER
I DOOR TRIM, SEATS, AND
CARPET-ALSO. TIRES AND MATS
DOOR HINGES AND LATCHES
WASH-WAX (CONC.) EXTERIOR WASH
I CLOTH AND FABRIC
GM OPTIKLEEN
f WINDSHIELD WASHER SOLVENT
MAGIC MIRROR CLEANER
POLISH AND ANTI~FREEZE
EXTERIOR CLEANER AND POLISH
I
DEXRONQ HE I AUTOMATIC TRANSMISSION
GM ENGINE OIL
(ETHYLENE GLYCOL BASE) ANTI-FREEZE
ANTI-FREEZE COOLANT
YEAR ROUND COOLANT AND PERMANENT TYPE
USAGE
SUPPLEMENT (E.O.S.) SEE YOUR DEALER
FOR SPECIFIC
GM GEAR LUBRICANT
REAR AXLE
LIMITEDSLIP ADDITIVE I REAR AXLE
DELCO-SUPREME II BRAKE I BRAKE FLUID
324
I
Page 343 of 407
Downloaded from www.Manualslib.com manuals search engine c
P
___.__ HDIP Lo HDLP HI R H'C HI IGN 3 COOL FAN TRANSECS
i I
I FUSE CENTER IDENTIFICATION J
ENGINE COMPARTMENT FUSE BLOCK
COIL 20A - 4.9L DISTRIBUTOR - 4.6L IGNtTION CONTROL MODULE SIR 2OA
- DIAGNOSTIC ENERGY RESERVE - - - - - - -
LF4 DERM) SIR (AIR BAG) - MlNG SENSOR
PCM (IO 1.OA - POWE Y TRAIN CONTROL MODUL
INJ IOA - PASSKeyS DECODER MODULE MODULE
.E (PCM)
--FUEL INJECTORS 1,4,6,7 INJ 1OA - FUEL INJECTORS 2,3,5,8 ION 1OA - A/C COMPRESSOR - ELECTROCHROMIC MIRROR - INSTRUMENT PANEL CLUSTER - DIAGNOSTIC ENERGY RESERVE MODULE
- KEYLE &Pi S E TRY MO b ULE - CORNERING LIGHTS - CHIME MODULE - TWILIGHT SENTINEUDRL MODULE - BACKUP LIGHTS - BRAKE TRANSMISSION SHIFT INTERLOCK
- FUEL PUMP
(DERM SIR AIR BAG
FUEL
20A
PCU(&A IOA
AC IOI
MID W 8 101
$TOP LP ;Ku
fURNiHA2 20A
FQWERTWN CONTROL MOWlE
MI&€ a 7RAIFI CONTRO( uOMKE (PCM)
AC CCEUYellS3uA
HfArtO &NISH&AO
STOP LIGHTS
- HAZARD LIGHTS - TURN SIGNAL LIGHTS
DRL 1OA (CANADA)
DRL
10A (CANADA)
SUSPENSION 1OA
- DAYTIME RUNNING LIGHTS
- DAYTIME RUNNING LIGHTS
- ROAD SENSING SUSPENSION
- LNORTHSTW PEED SENSITIVE SUSPENSION (4.9L)
- R 6 AD SENSING SUSPENSION
- LEFT HEADIAMP LOW BEAM
- RT HEADLAMP LOW BEAM
- LEFT HEADIAMP HIGH BEAM
- RIGHT HEADIAMP HIGH BEAM
- HEATED WINDSHIELD - HEATER AND A/C PROGRAMMER
- ELECT. LEVEL CONTROL (ELC) - DEFOGGER RELAY "D"
- CRUISE CONTROL
- POWERTRAIN CONTROL MODULE
- COOLING FANS
- POWERTRAIN CONTROL MODULE 4.6L)
- FRONT AND REAR HEATED OXYGE L
RTD BAT) 20A
L HDLP LO 1OA (EXPORT)
R HDLP LO 1OA (EXPORT)
L HDLP HI 1OA (EXPORT)
R HDLP HI (EXPORT)
ION 3 1OA
COOLING FAN 1OA
SENSOR (4.6L) TRANSIECS 1 OA
SOLENOID -- EXHAUST GAS RECIRCULATION (EGR)
- POWERTRAIN CONTROL MODULE (PCM) - AUTOMATIC TRANSAXLE - EVAPORATIVE EMISSION CONTROL
- OVERSPEED ALERT MODULE (EXPOR
- POWER STEERING PRESSURE SWITC 3
SOLENOID
329
I
F
Page 359 of 407
Downloaded from www.Manualslib.com manuals search engine The power rack and pinion steering system has a rotary spool valve which
directs hydraulic fluid coming from the power steering pump to one side
or the other side
of the rack piston. The integral rack piston is attached to
the rack. The rack piston converts hydraulic pressure to a linear force
which moves the rack left or right. The force is then transmitted through
the inner and outer tie rods to the steering knuckles, which turn the
wheels
If hydraulic assist
is not available, manual control is maintained. However
under these conditions more steering effort is required.
4.6 LITER NORTHSTAR ENGINE
Displacement ............................... .4.6L (279 cu.in.)
No. of Cylinders ................ 32-valve DOHC 8 - 90 Degree V
Power (Acc.
to SAE 51349) ............... 295 (bhp @ 6000 rpm
..................................... 220 (kW @ 6000rpm
Torque (ACC. to
SAE 51349) ............ 290 (lbs. ft. @ 4400 rpm
Bore ........................................ 93mm (3.66 in.)
Stroke
...................................... .84mm (3.31in.)
Compression Ratio
................................... 10.3:l
Cylinder Heads ............................... Cast Aluminum
Intake Manifold
........................ Die Cast Magnesium /
........................... Thermoplastic Air Induction nbes
Valve System
................... Direct Acting Hydraulic Tappets
Intake Valve
................................. 33mm (1.29 in.)
Exhaust Valve
................................ 29mm (1.14 in.)
Pistons
...................................... Cast Aluminum
Firing Order
.................................. 1-2-7-3-4-5-6-8
Left Bank
.......................................... 2-4-6-8
Right Bank
......................................... 1-3-5-7
Camshaft
................... Induction Hardened Cast Grey Iron
Drive Type
........ Single Row / Staged Drive 8 mm Roller Chain
Main Bearings
......................................... Five
1
1 .................................... 393 (Ndm @ 4400 rpm
Cylinder Block
...... Die Cast Aluminum with Iron Cylinder Bores
345
Page 363 of 407
Downloaded from www.Manualslib.com manuals search engine FLUID CAPACITIES
Transaxle (4T6OE) .............................. 20 pts. (9.5 L)
Transaxle (4T80E)
.............................. 30 pts. (14 L)
Engine Oil (4.9 L)
............................ 5 quarts (4.7 L)
With Filter Change ........................... 5.5 qts (5.2 L)
Engine Oil (4.6 L)
.............................. 6.5 qts (6.2 L)
With Filter Change ............................ 7 qts (6.6 L)
Engine Cooling System
........................ 12.3 qts (1 1.7 L)
Fuel Tank .................................. 20 gallons (76 L)
Power Steering .............................. 1.3 quarts (1.2 L)
Windshield Washer Reservoir .................. 4.2 quarts (4.1 L)
TIGHTEN TORQUE
Spark Plugs (4.9 L) ........................ .20 Nqm (15 lbs. ft.)
Spark Plugs (4.6
L) ......................... 15 Nom (11 lbs. ft.)
Oil Pan Drain Plug (4.9 L)
................... 30N-m (22 Ibs. ft.)
Oil Pan Drain Plug (4.6 L) ................... 20N.m (15 lbs. ft.)
KEHICLE DIMENSIONS
Seville/STS
Shipping Weight .......................... 3595 lbs. (1630.5 kg)
Shipping Weight
(STS) .................... 3807 lbs. (1726.8 kg)
Wheel Base
................................ 111 in. (2819 mm)
Length .................................. .203.9 in. (5179 mm)
Height ................................... .54.0 in. (1371 mm)
Width.. .................................. .74.3 in. (1887 mm)
Front Tread ............................... .60.9 in. (1547 mm)
Rear Tread ............................... .60.9 in. (1547 mm)
349
Page 390 of 407
Downloaded from www.Manualslib.com manuals search engine r
r
F
r
P
P
r
t
SUBJECT INDEX
A
Acc (Ignition Key Position) ............................ 80
Accessory Power. Retained .......................... 327
Adding
Brake Fluid
..................................... 293
Electrical Equipment ............................. 326
Engine Coolant ....................... 240.245.283. 285
EngineOil ...................................... 271
Power Steering Fluid ............................. 288
Transaxle Fluid .................................. 281
Additives. Engine Oil ............................... 275
Adjustment. Brake ................................. 184
Adult Safety Belt Usage .. 1 ........................... 18
-Air Bag ............................................ 30
Aircleaner ....................................... 277
Air Cleaner Replace ................ See Maint . Book. p.22
Air Cleaner Filter Replacement ...................... 301
Air Conditioner .................................... 147
Air Outlets .................................... ._. .. 146
Air System ........................................ 146
Alarm. How To Turn Off Theft ......................... 77
Alcohol. Driving Under The Influence Of .............. 175
Alcohol in Gasoline ................................. 263
Aluminum Wheels. Cleaning ......................... 322
AMAX@ .......................................... 154
AM Radio Reception ............................... 153
AM Stereo Radio Reception ......................... 154
Antifreeze ..................................... 237. 245
Anti-Lock Brakes .................................. 181
Anti-Lock Brake System Warning Light ............. 129. 181
Anti-Theft Tips ..................................... 75
Appearance Care ................................... 315
Arm. Wearing A Safety Belt Under Your ................ 28
Ashtrays .......................................... 121
Astroroof .......................................... 119
Automatic Air Conditioning System ................... 147
Automatic Door Lock ................................ 68
Automatic Overdrive ................................. 86
Antenna. Cleaning Radio .-. .. _ ........................ 164
r I I
1