radiator CHEVROLET ASTRO 1999 User Guide

yellowblue
6-28 What to Use
Use a mixture of one-half clean, drinkable water and
one
-half DEX-COOL
coolant which won't damage
aluminum parts. If you use this coolant mixture, you
don't need to add anything else.
CAUTION:
Adding only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid like alcohol, can boil before the proper
coolant mixture will. Your vehicle's coolant
warning system is set for the proper coolant
mixture. With plain water or the wrong mixture,
your engine could get too hot but you wouldn't
get the overheat warning. Your engine could
catch fire and you or others could be burned.
Use a 50/50 mixture of clean, drinkable water
and DEX
-COOL
coolant.
NOTICE:
If you use an improper coolant mixture, your
engine could overheat and be badly damaged.
The repair cost wouldn't be covered by your
warranty. Too much water in the mixture can
freeze and crack the engine, radiator, heater core
and other parts.
If you have to add coolant more than four times a year,
have your dealer check your cooling system.
NOTICE:
If you use the proper coolant, you don't have to
add extra inhibitors or additives which claim to
improve the system. These can be harmful.

yellowblue
6-29 Checking Coolant
The vehicle must be on a level surface. When your
engine is cold, the coolant level should be at ADD, or a
little higher. When your engine is warm, the level should
be up to FULL HOT, or a little higher.
Adding Coolant
If you need more coolant, add the proper DEX
-COOL

coolant mixture at the coolant recovery tank.
CAUTION:
Turning the radiator pressure cap when the
engine and radiator are hot can allow steam and
scalding liquids to blow out and burn you badly.
With the coolant recovery tank, you will almost
never have to add coolant at the radiator. Never
turn the radiator pressure cap
-- even a
little
-- when the engine and radiator are hot.
Add coolant mixture at the recovery tank, but be careful
not to spill it.
CAUTION:
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Don't spill coolant on a hot engine.

Short Trip/City Scheduled Maintenance
yellowblue
7-28
100,000 Miles (166 000 km) (Continued)

If you haven't used your vehicle under severe service conditions listed
previously and, therefore, haven't changed your automatic transmission fluid,
change both the fluid and filter.

Inspect Positive Crankcase Ventilation (PCV) valve.
An Emission Control Service.
150,000 Miles (240 000 km)

Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first). See ªEngine Coolantº in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test
cooling system and pressure cap.
An Emission Control Service.ACTUAL
SERVICED BY:MILEAGE
DATE

Long Trip/Highway Scheduled Maintenance
yellowblue
7-40
100,000 Miles (166 000 km)

Inspect spark plug wires.
An Emission Control Service.

Replace spark plugs.
An Emission Control Service.

If you haven't used your vehicle under severe service conditions listed
previously and, therefore, haven't changed your automatic transmission fluid,
change both the fluid and filter.

Inspect Positive Crankcase Ventilation (PCV) valve.
An Emission Control Service.
150,000 Miles (240 000 km)

Drain, flush and refill cooling system (or every 60 months since last service,
whichever occurs first). See ªEngine Coolantº in the Index for what to use.
Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test
the cooling system and pressure cap.
An Emission Control Service.
ACTUAL
SERVICED BY:MILEAGE
DATE
ACTUAL
SERVICED BY:MILEAGE
DATE

yellowblue
7-45
Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall). You should let your dealer's
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a service manual. See ªService and Owner
Publicationsº in the Index.
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook
-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out
-of-position parts as well as open seams,
holes, loose connections or other conditions which could
cause a heat build
-up in the floor pan or could let
exhaust fumes into the vehicle. See ªEngine Exhaustº in
the Index.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed. Clean the outside
of the radiator and air conditioning condenser. To help
ensure proper operation, a pressure test of the cooling
system and pressure cap is recommended at least once
a year.

yellowblue
9-8
Radiator 5-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator Pressure Cap 6-26 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radio Reception 3-28 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radios 3-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rain, Driving In 4-16 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ratchet, Wheel 5-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reading Lamps 2-39, 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear
Air Conditioning System 3
-5 . . . . . . . . . . . . . . . . . . . . . . . .
Axle 6-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Heating System 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside Seat Position 1-34 . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Comfort Guides 1-37 . . . . . . . . . . . . . . . . . . . . .
Seat Audio 3-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat Passengers 1-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storage 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Towing 5-7 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Window Defogger 3-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windshield Washer 2-34 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rearview Mirror 2-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reclining Front Seatbacks 1-4 . . . . . . . . . . . . . . . . . . . . . . . . .
Recommended Fluids and Lubricants 7-47 . . . . . . . . . . . . . . .
Recovery Tank, Coolant 5-12 . . . . . . . . . . . . . . . . . . . . . . . . . .
Recreational Vehicle Towing 4-27 . . . . . . . . . . . . . . . . . . . . . .
Refrigerants, Air Conditioning 6-68 . . . . . . . . . . . . . . . . . . . .
Regulator, Fuel 2-18 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Remote Compact Disc Player 3-23 . . . . . . . . . . . . . . . . . . . . .
Removable Rear Seats 1-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . Replacement
Bulbs 6
-66 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parts 6-69 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wheel 6-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Safety Belts 1-63 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reporting Safety Defects 8-10, 8-11 . . . . . . . . . . . . . . . . . . . .
Restraints
Checking 1
-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Child 1-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Head 1-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing Parts After a Crash 1-63 . . . . . . . . . . . . . . . . . . .
System Check 7-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Reverse 2-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Right Front Passenger Position 1-26 . . . . . . . . . . . . . . . . . . . .
Roadside Assistance 8-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Roadside Assistance, Canadian 8-7 . . . . . . . . . . . . . . . . . . . . .
Rocking Your Vehicle 5-33 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotation, Tires 6-45 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belt Extender 1-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Safety Belts 1-12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Adults 1-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Care 6-54 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Center Rear Passenger Position 1-40 . . . . . . . . . . . . . . . . . .
Children 1-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Driver Position 1-17 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Extender 1-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .