radio CHEVROLET ASTRO 2003 Owner's Manual

1. Check the other vehicle. It must have a 12-volt
battery with a negative ground system.
Notice: If the other system isn’t a 12-volt system
with a negative ground, both vehicles can be
damaged.
2. Get the vehicles close enough so the jumper cables
can reach, but be sure the vehicles aren’t touching
each other. If they are, it could cause a ground
connection you don’t want. You wouldn’t be able
to
start your vehicle, and the bad grounding could
damage the electrical systems.
To avoid the possibility
of the vehicles rolling, set
the parking brake firmly on both vehicles involved
in the jump start procedure. Put an automatic
transmission in PARK (P) and a manual
transmission in NEUTRAL.
3. Turn off the ignition on both vehicles. Unplug
unnecessary accessories plugged into the cigarette
lighter
or accessory power outlets. Turn off all lamps
that aren’t needed as well as radios. This will avoid
sparks and help save both batteries. In addition,
it could save your radio!
Nofice: If you leave your radio on, it could be badly
damaged. The repairs wouldn’t be covered by
your warranty.
4. Open the hoods and locate the batteries. Find the
positive
(+) and negative (-) terminals on each
battery.
Using a match near a battery can cause battery
gas to explode. People have been hurt doing
this, and some have been blinded. Use a
flashlight if you need more light.
Be sure the battery has enough water.
You don’t need to add water to the ACDelco@
battery installed in your new vehicle. But if
a battery has filler caps, be sure the right amount
of fluid is there. If it is low, add water
to take care
of that first. If you don’t, explosive
gas could be present.
Battery fluid contains acid that can burn you.
Don’t get
it on you. If you accidentally get it in
your eyes or on your skin, flush the place with
water and get medical help immediately.
5-48

Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected from
short circuits by a combination of fuses, circuit breakers
and fusible thermal links. This greatly reduces the
chance of fires caused by electrical problems.
Look at the silver-colored band inside the fuse.
If the
band is broken or melted, replace the fuse. Be sure you
replace a bad fuse with a new one of the identical
size and rating.
Spare fuses and a fuse puller are located in the
underhood fuse block. You can remove fuses with
the fuse puller. Remember to replace any of the spare
fuses you use,
so you will have some if you ever
need them again.
If you ever have a problem on the road and don’t have
a spare fuse, you can borrow one that has the same
amperage. Just pick some feature of your vehicle
that you can get along without
- like the radio or
cigarette lighter
- and use its fuse, if it is the correct
amperage. Replace it as soon as you can.
There are two fuse blocks in your vehicle: one
is inside
the vehicle and one is in the engine compartment.
Instrument Panel Fuse Block
The fuse block is located on the lower portion of the
instrument panel on the driver’s side.
5-93

FuseKircuit Usage
Breaker
1
2
Stop/Turn/Hazard Lamps,
Center High Mounted Stop Lamp,
Anti-Lock Brakes
Radio Accy, Rear Seat
Audio Controls
FuseKircuit
Breaker
3
4
5
6
8
9
Usage
Courtesy Lamps, Glove Box Lamp,
Dome Reading Lamps, Vanity Mirror
Lamps, Courtesy Lamps
Daytime Running Lamps Relay,
Instrument Panel Cluster
Rear Defogger
Cruise Module, Truck Body Control Module, Instrument Panel Cluster,
Cruise Control Switch,
Electrochromic Mirror
Power Outlets, DLC,
Subwoofer Amplifier
Crank Circuit Fuse, ParWNeutral
Switch, Starter Enabler Relay
License Plate Lamp, Tailamps,
Parking Lamps, Ashtray Lamp,
Panel Lights, Trailer Taillamps,
Front and Rear Sidemarker Lamps,
Door Switch Illumination, Headlamp
Switch Illumination, Rear Seat
Audio Illumination, Truck Body
Control Module
5-94

13
14
15
16
Fuse/Circuit Usage Breaker
10 Air Bag System
11 Not Used
12 L, MI, M2 Blower Motor, Rear Air
Conditioning Relay Coil, Front Cont.
Temp. Door Motor, HI Blower Relay.
Defogger Timer Coil
Cigarette Lighter, Door Lock
Switches, Dutch Door Release Module
Cluster Illum, Climate Controls,
Chime Module, Radio Illumination,
Rear Heat Switch Illumination, Rear
Wipermasher Switch Illumination,
Rear Liftgate Switch Illumination,
Remote Cassette Illumination,
Overhead Console, Truck Body
Control Illurnination
Truck Body Module, Headlamp Relay
Front Turn Signals, Rear Turn
Signals, Trailer Turn Signals,
Back-up Lamps, Brake Transmission
Shift Interlock Solenoid 21
22
23
24
A
19
20
FuseKircuit
Usage
Breaker
17 Front Wipers, Front Washer Pump
18 VCM-lgn
3, VCM-Brake, Cruise
Stepper Motor Signal, ATC Module
Instrument Panel Radio: ATC
(Main Feed),
2000 Series (Standby)
PRNDUOdometer, TCC Enable and
PWM Solenoid, Shift A and Shift B
Solenoids, 3-2 Downshift Solenoid, Instrument Panel Cluster, VCM
Module
Powr Adjust Mirrors
Not Used
Rear Wiper, Rear Washer Pump
Not Used
(Circuit Breaker) Power Door Lock
Relay, 6-Way Power Seats
(Circuit Breaker) Power Windows
B
5-95

Fuse/Circuit Usage
Breaker
DIODE-I Air Conditioning
Blank Not Used
Blank
Not Used
Blank Not Used
LIGHTING Courtesy Fuse, Power Adjust
Mirrors Fuse, Truck Body Control
Battery Fuse
Power Accessory Circuit Breaker,
Stop/Hazard Fuse, Auxiliary Power
Fuse, Cigarette Lighter Fuse, Radio
Battery Fuse
BATT
Fuse/Circuit
Breaker
IGN A
IGN
B
ABS
Blank RAP
HTD MIRI
RR DEFOG
Usage
Starter Relay, Ignition Switch
Ignition Switch
Electronic Brake Control Module
Not Used Radio Accessory, Power Windows
Rear Window Defogger,
Climate Control Head
5-98

Accessory Power Outlets ................................. 3-16
Activating the Theft-Deterrent Feature
................ 3-48
Adding Equipment to Your Air Bag-Equipped
Vehicle
....................................................... 1-70
Adding Washer Fluid
....................................... 5-41
Additional Program Information
......................... 7-1 0
Additives, Fuel ................................................. 5-6
Add-On Electrical Equipment
............................ 5-92
Add-on Equipment
.......................................... 4-31
Adjusting the Speakers (Balance/Fade)
........ 3-40, 3-43
Air Bag
Readiness Light
.......................................... 3-26
Air Bag System
.............................................. 1-62
Adding Equipment to Your
Air Bag-Equipped Vehicle
...................... 1-70
How Does an Air Bag Restrain?
.................... 1-67
Servicing Your Air Bag-Equipped Vehicle
......... 1-69
What Will You See After an Air Bag inflates?
...... 1-68
When Should an Air Bag Inflate?
................... 1-66
Where Are the Air Bags?
.............................. 1-64
All Overseas Locations
...................................... 7-5
All-Wheel Drive
............................................... 5-52
All-Wheel Drive (AWD) System
......................... 2-26
All-Wheel-Drive Service Light
............................ 3-35
Aluminum Wheels
........................................... 5-88
What
Makes an Air Bag Inflate?
.................... 1-67
Air CleanedFiIter, Engine
... ...................... 5-24
AM
............................................................... 3-50 AM-FM Radio
...................... ................ 3-39
Antenna, Fixed Mast
....................................... 3-50
Anti-lock Brake System
..................................... 4-7
Anti-Lock Brake, System Warning Light
.............. 3-29
Appearance Care
............................................ 5-83
Care of Safety Belts
.................................... 5-86
Chemical Paint Spotting
............................... 5-89
Cleaning the Inside of Your Vehicle
................ 5-83
Finish Damage
............................................ 5-88
Sheet Metal Damage
................................... 5-88
Underbody Maintenance
............................... 5-89
Weatherstrips
.............................................. 5-86
Ashtrays
........................................................ 3-17
Audio System(s)
............................................. 3-38
Audio Systems
AM-FM Radio
............................................. 3-39
Care of Your CD Player
............................... 3-50
Care of Your CDs
........................................ 3-50
Fixed Mast Antenna
..................................... 3-50
Radio with CQ
............................................ 3-41
Rear Seat Audio (RSA)
................................ 3-46
Setting the Time for Radios with HR and
MN Buttons
............................................. 3-38
Setting the Time for Radios with the
Set Button
.............................................. 3-38
Theft-Deterrent Feature
................................ 3-47
Understanding Radio Reception
..................... 3-50
Cleaning
the Outside of Your Vehicle
.............. 5-86
GM Vehicle Care/Appearance Materials
.......... 5-89
1

Matching Transmitter(s) to Your Vehicle ................. 2-5
Mexico, Central America and Caribbean
Islands/Countries (Except Puerto Rico and
U.S. Virgin Islands) ........................................ 7-5
MyGMLink.com
................................................ 7-4
New Vehicle Break-In
...................................... 2-19
Normal Maintenance Replacement Parts
........... 5-101
Odometer
............................................
Off-Road Recovery ................................
Oil
... 3-25
... 4-1 1
Engine ....................................................... 5-1 5
Pressure Gage
............................................ 3-34
Older Children, Restraints
................................ 1-35
Online Owner Center
........................................ 7-4
Operation Tips
................................................ 3-22
Other Warning Devices
...................................... 3-5
Outlet Adjustment
............................................ 3-22
Outside Convex Mirror
............................................. 2-33
Manual Mirrors
............................................ 2-32
Power Mirrors
............................................. 2-32
Overhead Console
.......................................... 2-39
Owners, Canadian
............................................... ii
Owner’s Information
........................................ 7-1 2
P
Park (P)
Shifting Into
............................. ........ 2-27
Shifting Out
of ......................... ............ 2-29
Brake
..................................................... 2-26
Parking
Over Things That Burn
................................. 2-30
Park (P) Mechanism Check
........................... 6-29
Parking Brake
and Automatic Transmission
Parking on Hills
........................................ 4-39 -39
Part A
- Scheduled Maintenance Services ............... 6-4
Part B
- Owner Checks and Services ................... 6-26
Part D
- Recommended Fluids and Lubricants ....... 6-32
Part
E - Maintenance Record ............................. 6-34
Passing
................................................. 4-12, 4-38
Passlock@
...................................................... 2-18
Payload
......................................................... 4-31
Plan Ahead When Possible
................................ 7-8
Playing the Radio
................................... 3-39, 3-41
Power
Accessory Outlets
........................................ 3-16
Door Locks
.................................................. 2-8
Electrical System
......................................... 5-92
Seat
............................................................ 1-3
Windows .................................................... 2-17
Part
C - Periodic
Maintenance Inspections ............ 6-30
Playing a Compact Disc
................................... 3-43
Steering Fluid
............................................. 5-40 9

Power Steering ................................................ 4-9
Programming the HomeLink Transmitter
............. 2-35
Programmable Automatic Door Locks
.................. 2-9
Q
Questions and Answers About
Safety Belts ......... 1-17
R
Radiator Pressure Cap ................. ............ 5-30
Radios
....................................... ............ 3-38
AM-FM
....................................... ........ 3-39
Care of Your CD Player
........................... 3-50
Care of Your CDs
.................................... 3-50
Radio with CD
............................................ 3-41
Rear Seat Audio
.......................................... 3-46
Setting the Time for Radios with HR and
MN Buttons
......................................... 3-38
Setting the Time for Radios with the
Set Buttons
............................. ........ 3-38
Theft-Deterrent
........................ ........ 3-47
Understanding Reception
.......................... 3-50
Reading Lamps
.............................................. 2-40
Rear Air Conditioning System
........................... 3-20
Rear Axle
...................................................... 5-53
Rear Climate Control System
............................ 3-21
Rear Doors
.................................................... 2-13
Rear Heating System
...................................... 3-19 Rear
Rear
Rear Rear
Rear
Rear Safety Belt
Comfort Guides
...................... 1-32
Seat Audio
............................................. 3-46
Seat Operation
......................................... 1-7
Seat Outside Passenger Positions
............. 1-29
Seat Passengers, Safety Belts
.................. 1-29
Window Defoqqer
.................................... 3-21
Rearview Mirrors 2-32 -- .............................................
Reclining Seatbacks .......................................... 1-4
Recreational Vehicle Towing
............................. 4-29
Reinstalling the Engine Cover
........................... 5-23
Remote Keyless Entry System
............................ 2-4
Remote Keyless Entry System, Operation
............ 2-5
Removing the Engine Cover
............................. 5-20
Removing the Flat Tire and Installing the
Spare Tire
.................................................. 5-76
Removing the Rear Seats
.................................. 1-7
Removing the Spare Tire and
Tools ................... 5-72
Removing the Wheel Covers
............................ 5-75
Replacement Bulbs
......................................... 5-61
Replacing Brake System Parts
.......................... 5-46
Replacing Restraint System Parts
After a Crash
.............................................. 1-71
Replacing the Rear Seats
.................................. 1-9
Reporting Safety Defects Canadian Government
.................................. 7-11
General Motors
........................................... 7-11
United States Government
............................ 7-10
Reprogramming a Single HomeLink@ Button
....... 2-37
Resetting Defaults
........................................... 2-37
10

Service (cont.)
Doing Your Own Work
................................... 5-3
Engine Soon Light
....................................... 3-30
Publications Ordering Information
................... 7-1 1
Sewice Bulletins ............................................. 7-1 2
Service Engine Soon Light in the United States
or Check Engine Light
in Canada
.................................................. 3-30
Service Manuals
............................................. 7-1 1
Servicing Your Air Bag-Equipped Vehicle ............ 1-69
Setting Preset Stations
............................ 3-39, 3-42
Setting the Temperature
................................... 3-20
Setting the Time
Radios with HR and MN Buttons
................... 3-38
Radios with the Set Button
........................... 3-38
Setting the Tone (Bassnreble)
.................. 3-40, 3-43
Shifting Into Park (P)
....................................... 2-27
Sheet
Metal Damage
....................................... 5-88
Shifting Out of Park (P)
................................... 2-29
Short Trip/City Definition
.................................... 6-5
Short TripKity Intervals
..................................... 6-5
Short Trip/City Scheduled Maintenance
...... ... 6-7
Shoulder Belt Height Adjuster
............... ..... 1-20
Skidding
........................................ ......... 4-13
Sliding Door Security Lock
............................... 2-1 1
Sliding Side Door
............................................ 2-10
Some Other Rainy Weather Tips
....................... 4-18
Spare Tire Check
............................................ 6-27 Special Fabric Cleaning
Problems
..................... 5-84
Specifications, Capacities
................................. 5-99
Speedometer
.................................................. 3-25
Steering
.......................................................... 4-9
Starter Switch
Check
....................................... 6-28
Starting Your Engine
....................................... 2-21
Steering in Emergencies
.................................. 4-10
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection .............................. 6-30
Steering Tips
................................................... 4-9
Storage Areas
................................................ 2-38
Convenience Net
......................................... 2-45
Luggage Carrier
.......................................... 2-44
Overhead Console
....................................... 2-39
Storing a Flat or Spare Tire and
Tools ............... 5-81
Stuck in Sand, Mud, Ice or Snow
...................... 4-28
Sun Visors
..................................................... 2-17
Sunglasses Storage Compartment
..................... 2-44
Taillamps
....................................................... 5-60
Theft.Deterrent. Radio
..................................... 3-47
Theft-Deterrent Systems
................................... 2-18
Passlock@
............................................... 2-18
Throttle System Inspection
........................... 6-31
Tilt Wheel
........................................................ 3-5
Tire Inflation Check
......................................... 6-26
12

Tires ..................................................... 5.63. 5-88
Buying New Tires
........................................ 5-66
Chains
....................................................... 5-70
Changing a Flat Tire
.................................... 5-71
Compact Spare Tire
..................................... 5-82
If a Tire Goes Flat
....................................... 5-70
Inflation
- Tire Pressure ............................... 5-64
Inspection and Rotation
................................ 5-64
Uniform Tire Quality Grading
......................... 5-67
Wheel Alignment and Tire Balance
................. 5-69
Wheel Replacement
..................................... 5-69
When It
Is Time for New Tires ...................... 5-66
To Use the Engine Coolant Heater
.................... 2-22
Top
of the Instrument Panel ............................. 5-85
Top Strap
...................................................... 1-48
Top Strap Anchor Location
............................... 1-50
Torque Lock
................................. ....... 2-29
Tow/Haul Mode Button
..................................... 2-25
Tow/Haul Mode Light
................................... 3-36
Towing Recreational Vehicle
..................................... 4-29
Towing a Trailer
.......................................... 4-31
Your Vehicle
............................................... 4-29
Trailer Brakes
................................................. 4-36
Trailer Wiring Harness
..................................... 4-41
Trailering Package
.......................................... 4-31
Transfer Case
................................................ 5-52
Transmission Fluid, Automatic
........................................... 5-25
Total Weight on Your Vehicle’s Tires
... ....... 4-35 Transmission
Operation. Automatic
.................... 2-23
Transmission. Transaxle. Transfer Case Unit
Repair Manual
............................................ 7-11
Trip Odometer
................................................ 3-25
Turn Signal/Multifunction Lever
........................... 3-6
Turn Signals When Towing a Trailer
.................. 4-38
Transportation Options
...................................... 7-9
Turn and Lane Change Signals
.......................... 3-6
U
Underbody Flushing Service ................. ..... 6-29
Underhood Fuse Block
.................... ..... 5-96
Understanding Radio Reception
.... ..... 3-50
Uniform Tire Quality Grading
......................... 5-67
United States
................................................... 7-4
Unlocking the Theft-Deterrent Feature
After a Power Loss
...................................... 3-49
Used Replacement Wheels
.............................. 5-70
Using Cleaner on Fabric
.................................. 5-84
Using HomeLink@
........................................... 2-37
v
Vehicle
Control
..................................................... 4-6
Loading
...................................................... 4-29
Symbols
......................................................... iv
Damage Warnings
........................................... iv
13