load capacity CHEVROLET ASTRO CARGO VAN 1995 2.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine The fuel gage tells you how much fuel you have remaining when the
ignition is on. When the gage first indicates empty you still have a little fuel
left, but you should get more fuel as soon as possible.
A box around the fuel gage symbol on the digital cluster will begin to flash
when
your tank is 1/8 full or less.
Here are things some owners ask about. None
of these indicate a problem
with your fuel gage:
0 At the gas station, the gas pump shuts off before the gage reads full.
The fuel tank will take either a little more or a little less fuel to fill up
The gage moves a little when you turn a comer or speed up.
The gage doesn’t go back to empty when you tum off the ignition.
than
the gage shows.
I
For your fuel tank capacity, see the Index under “Fluid Capacities.”
2-60

Downloaded from www.Manualslib.com manuals search engine Luggage Carrier (Option)
I If you have the
luggage carrier, you
can load things
on top
of your vehicle. The
luggage carrier has
slats attached to the
roof, side rails, and
tiedowns.
NOTICE:
Loading cargo that weighs more than 200 pounds (91 kg) on the
luggage carrier may damage your vehicle. When you carry large
things, never let them hang over the rear or the sides of your
vehicle. Load your cargo
so that it rests on the slats and does not
scratch or damage the vehicle. Put the cargo against the side
rails and fasten it securely to the luggage carrier. Put the main
weight as far forward as you can.
Don’t exceed the maximum vehicle capacity when loading your vehicle. For
more information
on vehicle capacity and loading, see “Loading Your
Vehicle” in the Index.
To prevent damage or loss of cargo as you’re driving, check now and then to
make sure the luggage carrier and cargo are still securely fastened.
2-62

Downloaded from www.Manualslib.com manuals search engine Loading Your Vehicle
PAYLOAD =-I
PSI/KPA (COLD)
-0
-0 < SEE OWNER'S MANUAL FOR ADDITIONAL INFORMATION
The Certificatioflire
label is found on the
rear edge
of the
driver's door. The
label shows the size
of
your original tires and
the inflation pressures
needed to obtain the
gross weight capacity
of your vehicle.
This is called the GVWR (Gross Vehicle Weight Rating). The GVWR
includes the weight of the vehicle, all occupants, fuel, cargo, and tongue
weight, if pulling a trailer.
The CertificatiodTire label also tells you the maximum weights for the
front and rear axles, called Gross Axle Weight Rating (GAWR).
To find out
the actual loads on your front and rear axles, you need to go to a weigh
station and weigh your vehicle. Your dealer
can help you with this. Be sure
to spread out your load equally on both sides of the centerline.
Never exceed the GVWR for your vehicle, or the Gross Axle Weight Rating
(GAWR) for either the front or rear axle.
And, if you do have a heavy load, you should spread it out.
Using heavier suspension components to get added durability might not
change your weight ratings. Ask your dealer
to help you load your vehicle
the right way.
4-23

Downloaded from www.Manualslib.com manuals search engine NOTICE:
Your warranty does not cover parts or components that fail
because of overloading.
If you put things inside your vehicle - like suitcases, tools, packages, or
anything else
- they will go as fast as the vehicle goes. If you have to stop
or turn quickly, or
if there is a crash, they’ll keep going.
Payload
The Payload Capacity is shown on the Certification/Tire label. This is the
maximum
load capacity that your vehicle can carry. Be sure to include the
weight
of the people inside as part of your load. If you added any
accessories
or equipment after your vehicle left the factory, remember to
subtract the weight
of these things from the payload. Your dealer can help
you with this.
4-24

Downloaded from www.Manualslib.com manuals search engine 0
0
0
Don’t tow a trailer at all during the first 500 miles (800 km) your new
vehicle is driven. Your engine, axle or other parts could be damaged.
Then, during the first
500 miles (800 km) that you tow a trailer, don’t
drive over
50 mph (80 kdh) and don’t make starts at full throttle. This
helps your engine and other parts
of your vehicle wear in at the heavier
loads.
You should use DRIVE (D) (or, as you need to, a lower gear) when
towing a trailer. Operating your vehicle in
DRIVE (D) when towing a
trailer will minimize heat build-up and extend the
life of your
transmission.
Three important considerations have to do with weight:
Weight of the Trailer
How heavy can a trailer safely be?
It depends
on how you plan to use your rig. For example, speed, altitude,
road grades, outside temperature and how much your vehicle is used to pull
a trailer are
all important. And, it can also depend on any special equipment
that you have on your vehicle.
You can ask your dealer for our trailering information or advice, or you can
write us
at the address listed in your Warranty and Owner Assistance
Information Booklet.
In Canada, write to:
General Motors of Canada Limited
Customer Assistance Center
1908 Colonel Sam Drive
Oshawa, Ontario
LlH 8P7
Weight of the Trailer Tongue
The tongue load (A) of any trailer is an important weight to measure
because it affects the total or gross weight
of your vehicle. The gross vehicle
weight (GVW) includes the curb weight
of the vehicle, any cargo you may
carry in it, and the people who will be riding in the vehicle. And if you will
tow
a trailer, you must add the tongue load to the GVW because your
vehicle will be carrying that weight, too. See “Loading Your Vehicle” in the
Index for more information about your vehicle’s maximum load capacity.
4-27

Downloaded from www.Manualslib.com manuals search engine To Check Engine Oil
Pull out the dipstick and clean it with a paper towel or cloth, then push it
back in all the way. Remove it again, keeping the tip down.
When to Add Oil
If the oil is at or below the ADD line, then you’ll need to add some oil. But
you must use the right kind. This part explains what kind
of oil to use. For
crankcase capacity,
see “Capacities and Specifications” in the Index.
NOTICE:
Don’t add too much oil. If your engine has so much oil that the
oil level gets above the cross-hatched area that shows the pro\
per
operating range, your engine could be damaged.
Just fill it enough to put the level somewhere in the proper operating range.
Push the dipstick all the way back in when you’re through.
6-9

Downloaded from www.Manualslib.com manuals search engine sudden tire failure. The grade C corresponds to a level of performance
which all passenger car tires must meet under the Federal Motor Vehicle
Safety Standard
No. 109. Grades B and A represent higher levels of
performance on the laboratory test wheel than the minimum required by
law.
Warning:
The temperature grade for this tire is established for a tire that is
properly inflated and not overloaded. Excessive speed, underinflation, or
excessive loading, either separately or in combination, can cause heat
buildup and possible tire failure.
These grades are molded on the sidewalls of passenger car tires.
While the tires available as standard or optional equipment
on General
Motors vehicles may vary with respect to these grades, all such tires meet
General Motors performance standards and have been approved for use on
General Motors vehicles. All passenger type
(P Metric) tires must conform
to Federal safety requirements in addition
to these grades.
Wheel Alignment and Tire Balance
The wheels on your vehicle were aligned and balanced carefully at the
factory
to give you the longest tire life and best overall performance.
In most cases, you will
not need to have your wheels aligned again.
However, if
you notice unusual tire wear or your vehicle pulling one way or
the other, the alignment may need to be reset.
If you notice your vehicle
vibrating when driving on a smooth road, your wheels may need
to be
rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked, or badly rusted or corroded. If
wheel nuts keep coming loose, the wheel, wheel bolts, and wheel nuts
should be replaced. If the wheel leaks air, replace it (except some aluminum
wheels, which can sometimes be repaired). See your GM dealer if any of
these conditions exist.
Your dealer will know the kind
of wheel you need.
Each new wheel should have the same load carrying capacity, diameter,
width, offset, and
be mounted the same way as the one it replaces.
6-46

Downloaded from www.Manualslib.com manuals search engine Engine identification
Engine Description
Type
VIN Code
Fuel System
Produced By
Emissions
**Central
Port Fuel Injection
Wheel Nut Torque
DESCRIPTION
Base or Optional Wheel
4.3L
V6
W
CPI* *
us.
L.D.
Cooling System Capacity
ENGINE VIN CODE
4.3L W
TORQUE
100 ft. lbs. (140 Nom)
QUANTITY* Without Rear
Heater
13.5 Quarts
(12.8 Liters)
QUANTITY*
With Rear
Heater
16.5 Quarts
( 15.5 Liters)
*All quantities are approximate. After refill, the level MUST be checked.
Crankcase Capacity
ENGINE
4.3L
VIN CODE
w
QUANTITY*
With Filter
4.5 Quarts (4.3 Liters)
*All quantities are approximate. After refill, the level MUST be checked.
Do not overfill.
Fuel Tank Capacity
TYPE
Standard Tank
QUANTITY*
27 Gallons ( 102 Liters)
*All quantities are approximate.
6-62

Downloaded from www.Manualslib.com manuals search engine Service Replacement Part and Filter
Recommendations
ENGINE (VIN)
OIL FILTER
AIR CLEANER FILTER
PCV VALVE
SPARK PLUGS* FUEL FILTER
RADIATOR CAP 4.3L (W)
PF52
A1163C
cv774c
CR43TSM
GF48
1
RC27
*Use copper-cored resistor type spark plugs.
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same. If the air conditioning
system in your vehicle needs refrigerant, be sure
the proper refrigerant is
used. If you’re not
sure, ask your GM dealer. For additional information, see
your “Warranty and Owner Assistance Information” booklet.
Refrigerant should be added only by a qualified
A/C technician.
Air Conditioning Refrigerant Capacity
TYPE
R-l34a
R-134a
SYSTEM
C-60* *
C-69***
QUANTITY*
2.00 lbs. (.91 kg)
3.00 lbs. (1.36 kg)
*All Quantities
Are Approximate
**Front A/C Only
***Front
& Rear A/C
NOTICE:
R-134a refrigerant is not compatible with R-12 refrigerant in
an air conditioning system. R-12 in an R-134a system
will cause
compressor failure, refrigerant oil sludge, or poor air
conditioning system performance.
6-68

Downloaded from www.Manualslib.com manuals search engine Braking ......................................................... 4-5
In Emergencies
................................................ 4-7
Break-In, New Vehicle ........................................... 2-13
Bulb Replacement
Center High Mounted Stop Lamp (CHMSL)
........................ 6-39
Composite Headlamps
......................................... 6-35
Front Park Turn Signal Lamps
................................... 6-37
Halogen Bulb
................................................ 6-34
RearLamps
.................................................. 6-38
Replacement Chart
............................................ 6-63
Sealed Beam Headlamps
........................................ 6-33
C
Capacities and Specifications ....................................... 6-61
CarbonMonoxide
........................................... 2-254-30
Care of Your Cassette Tape Player (See “Audio Systems”
)
Cassette Tape Player System (See “Audio Systems’’ )
Catalytic Converter .............................................. 6-40
Center High Mounted Stop Lamp (CHMSL) (See “Bulb Replacement”
)
Certificationmire Label ........................................... 4-23
ChangingaFlatTire
.............................................. 5-21
Child Restraints (See “Safety Belts”)
Circuit Breakers (See “Fuses and Circuit Breakers”)
Cleaning Chemical Paint Spotting
........................................... 6-55
Cigarette LightedAshtrays
......................................... 2-46
Fabric Protection
.............................................. 6-50
Finishcare .................................................. 6-53
Glass
....................................................... 6-52
Insideofvehicle
.............................................. 6-49
Instrumentpanel. Top
.......................................... 6-51
OutsideofVehicle ............................................. 6-53
Outside
of the Windshield. Backglass and Wiper Blades ............... 6-52
Vinyl
....................................................... 6-51
WheelsandTires
.............................................. 6-54
AMRadio
.................................................... 3-6
Audio Systems
with AM/FM Stereo ................................ 3-6
Comfort Controls
................................................. 3-1
Compact Disc (CD) System (See “Audio Systems”)
Console Center Overhead
.............................................. 2-48
Control
of a Vehicle ............................................... 4-4
Coolant (See “Engine”)
Special Problems
.............................................. 6-50
Weatherstrips
................................................. 6-52
Clock, Setting the
Cooling System Capacity
.......................................... 6-62
Crankcase Capacity
.............................................. 6-62
Cruise Control
(Option) ........................................... 2-35
Passing Another Vehicle
........................................ 2-38
OnHills
..................................................... 2-38
ToGetOutOf
................................................ 2-39
ToEraseSpeedMemory
........................................ 2-39
ToIncreaseSpeed
............................................. 2-37
2