check engine light CHEVROLET ASTRO PASSENGER 1993 1.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine 2. Get the vehicles close enough so the jumper cables can reach, but be
sure the vehicles aren’t touching each other.
If they are, it could cause a
ground .connection you don’t want. You wouldn’t be able
to start your
vehicle, and the bad grounding could damage the electrical syst\
ems.
1 CAUTION
I
A You could be injured if the vehicles roll. Set the parking brake firmly
b on each vehicle. Put an automatic transmission in P (Park) or a
I manual transmission in N (Neutral).
3. Turn off the ignition on both vehicles. Turn off all lights that aren’t
needed, and radios. This will avoid sparks and help save both \
batteries.
And
it could save your radio!
1’ NOTICE
Iv dar li 1. The Pairs f you leave your radio on, it could be t
Nouldn’t be covered bv vour warrallLv I
4. Open the hoods and locate the batteries. Find the positive (t) and the
negative
(-) terminals on each battery.
1 CAUTION
A Using a match near a battery can cause battery gas to explode.
People have been hurt doing this, and some have been blinded. \
Use
a flashlight
if you need more light.
You don’t need
to add water to the Delco Freedom@ battery installed
in every new
GM vehicle. But if a battery has filler caps, be sure the
right amount of fluid is there.
If it is low, add water to take care of
that first. If you don’t, explosive gas could be present.
Battery fluid contains acid that can burn you. Don’t get
it on you. If
you accidentally get it in your eyes or on your skin, flush the place
I with water and get medical help immediately.
5. Check that the jumper cables don’t have loose or missing in\
sulation. If
they do, you could get a shock. The vehicles could be damaged\
, too.
Before you connect the cables, here are some things you should\
know.
Positive
(t) will go to positive (+) and negative (-) will go to negative
(-) or a metal engine part. Don’t connect (t) to (-) or you’ll get a
short that would damage the battery and maybe other parts,
too.
5-4

Downloaded from www.Manualslib.com manuals search engine Senrice & Appearance Care
Hood Latches and Hood Hinge
The Maintenance Schedule will tell you how often to lubricate the hood latch
and hood hinge assembly. See “Recommended Fluids and Lubricants”\
in the
Index for the proper lubricant
to use.
Propeller Shaft Slip Splines/Universal Joints
The Maintenance Schedule will tell you how often the slip splines must be
lubricated. See “Recommended Fluids and Lubricants” in the \
Index for the
proper lubricant
to use.
Constant Velocity Joints (All- Wheel Drive Only)
The Maintenance Schedule will tell you how often to lubricate the the
constant velocity joints. See “Recommended Fluids and Lubrican\
ts” in the
Index for the proper lubricant
to use.
Sliding Door Tracks
Your vehicle’s sliding door has three tracks which need lubricatio\
n.
For the upper and lower tracks, open the door, wipe the track\
clean and then
lubricate with Lubriplate@ White Grease.
For the outside middle track, close the door after you finish \
the upper and
lower tracks. Then, wipe the track clean and lubricate with Lu\
briplateB White
Grease.
Body
Normal use of your vehicle will cause metal-to-metal wear at some points \
on
the cab and body
if they are not lubricated.
tor exposed surfaces, such as door checks, door lock bolts, lock s\
triker
plates, dovetail bumper wedges, etc., a thin film
of engine oil should be
applied.
Where oil holes are provided in the body or cab, a dripless \
oil can be used.
The seat adjusters and seat track should be lubricated with chassis grease.
Door weatherstrips and rubber hood bumpers should be lightly coated with
a
rubber lubricant.
Never use
too much of any lubricant and be sure to wipe up any extra
lubricant when you are finished.
Some parts that need lubricating are hard
to get at. Window regulators and
controls are inside the doors. You can get to these by removing the trim
panels.
6-40

Downloaded from www.Manualslib.com manuals search engine Headlights
The headlight wiring is protected by a circuit breaker in the light switch. An
electrical overload will cause the lights
to go on and off, or in some cases to
remain
off. If this happens, have your headlight wiring checked right away.
Windshield Wipers
The windshield wiper motor is protected by a circuit breaker and a fuse. If
the motor overheats due to heavy snow, etc., the wiper will s\
top until the
motor cools. If the overload is caused by some electrical prob\
lem and not
snow, etc., be sure to get it fixed.
Power Windows and Other Power Options
Circuit breakers in the fuse panel protect the power windows a\
nd other power
accessories. When the current load is too heavy, the circuit b\
reaker opens
and closes, protecting the circuit until the problem is fixed
or goes away.
Trailer Wiring Harness
The optional seven-wire trailer wiring harness is protected by \
an in-line fuse
in the battery feed wire. This fuse is near the junction bloc\
k. See “Trailer
Wiring Harness” in the Index.
Fuse Block
K3629
The fuse block is under the instrument panel on the driver’\
s side. You can
remove the cover with
a screwdriver and then remove fuses with a fuse
extractor. To remove fuses
if you don’t have one, hold the end of the fuse
between your thumb and index finger and pull straight out.
6-63

Downloaded from www.Manualslib.com manuals search engine Service & Appearance Cam
Be sure to use the correct fuse. If you ever have a problem on the road and
don’t have a spare fuse, you can “borrow” one of the correct value. Just pick
some feature of your
cigarette lighter-and
as soon
as you can.
information.
Capacities
vehicle that you can get along without-like the radio or
use its fuse,
if it is of the value you need.. Replace it
See “Fuses and Circuit Breakers” in the Index for more
and Specification Charts
Replacement Parfs
Replacement part numbers listed in this section are based on the latest
information available at the time of printing, and are subject to change.
If a
part listed in this manual is not the same as the part used in your vehicle
when
it was built, or if you have any questions, please contact your GM
dealer.
Engine Identification
IGINE IDENTIFICATION
Liter VIN
Fuel
Code
BY Displacement System
Engine
Type
Produced Emissions
4.3L
L.D. U.S. CPI** W V6 4.3L L.D.
us. TBI* Z V6
* Throttle Body Electronic Fuel Injection
** Central Port Electronic Fuel Injection
~0004
Wheel Nut Torque
I Base or Optional Wheel I 100 ft. Ibs. (140
N-m) I
I TO21 6 I
Cooling System
ENGINE With Rear Heater
Without Rear Heater
VIN CODE
QUANTITY
4.3L I Z
16.5 Quarts (1 5.5 Liters)
13.5 Quarts (1 2.8 Liters)
4.3L I w
16.5 Quarts (I 5.5 Liters) 13.5 Quarts (1 2.8 Liters)
All quantities are approximate.
After refill, the level
MUST be checked.
TO006
6-64

Downloaded from www.Manualslib.com manuals search engine Most bulletins apply to conditions affecting a small number of cars or trucks.
Your Chevrolet dealer or a qualified technician may have to determine
if a
specific bulletin applies to your vehicle.
You can subscribe to all Chevrolet bulletins by calling Helm, Inc. at
1-800-782-4356. This way you’ll get them as they come out.
lndividual PSP’s
If you don’t want to buy all the PSP’s issued by Chevrolet for all car and
truck models in the model year, you can buy individual PSP’s, such as those\

which may pertain to a particular model. To do this, you will first need to see
our index of PSP’s.
It provides a variety of information. Here’s what you’ll find
in the index and how you can get one:
What You’ll Find in the Index:
A list of all PSP’s published by Chevrolet in a model year (1989 or
later). PSP’s covering all models of Chevrolet cars or light trucks less
than 10,000 pounds (4536 kg)
GWVR are listed in the same index.
Ordering information so you can buy the specific PSP’s you may want.
Price information for the PSP’s you may want to buy.
How You Can Get an Index:
Indexes are published periodically. Most of the PSP’s which could potentially
apply to the most recent Chevrolet models will be listed in the most recent
publication for that model year. This means you may want to wait until the
end of the model year before ordering an index,
if you are interested in
buying PSP’s pertaining to a current model year truck.
Some PSP’s pertaining to a particular model year vehicle may be published in
later years, and these would be listed in the later year’s index. When you
order an index for a model year that is not over yet, we’ll sen\
d you the most
recently published issue. Check the ordering form for indexes f\
or earlier model
years.
Cut out the ordering form,
fill it out, and mail it in. We will then see to it that
an index is mailed to you. There is no charge for indexes for the 1989-1993
model years.
Toll-Free Telephone Number
If you want an additional ordering form for an index or a subscr\
iption, just
call toll-free and we’ll be happy to send you one. Automated recording
equipment will take your name and mailing address. The number
to call is
1-800-551 -4123.
8-7

Downloaded from www.Manualslib.com manuals search engine ..
.
E
Engine Block Heater
..................... 2.16. 3-9
Coolant
............................ 5.11. 6-26
Coolant Temperature Gage
...... 2-60
Cover
......................................... 6-1 5
Exhaust ............................ 2.24. 6-41
Fan Noise
.................................. 5-1 6
Identification
..................... 6.60. 6-64
Oil (See “Oil”) Overheating
................................. 5-8
Running While Parked
... 2.22. 2-25
Equipment. Add-on
...................... 6-44
Exhaust System
............................ 6-41
F
Finish Care
........................................... 6-56
Damage
..................................... 6-57
Automatic Transmission
............ 6-20
Brake
......................................... 6-32
Capacities
.................................. 6-64
Coolant
............................ 5.11. 6-26
Leak Check
............................... 6-34
Power Steering
......................... 6-30
Transfer Case
........................... 6-23
Windshield Washer
................... 6-31
Fog Lamps
.................................... 2-42
Four-wheel Antilock
..................... 4-1 5
Front Seats ..................................... 1-2
Fuel
................................................. 6-4
Gage
.......................................... 2-63
In Foreign Countries
................... 6-6
Regulator
................................... 2-1 5
Tank Capacity ........................... 6-65
Fuse Block
.................................... 6-63
Fuses and Circuit Breakers
......... 6-68
Fluid
Filling Your Tank
......................... 6-6
G
Gages
Fuel ............................................ 2-63 ....
Voltmeter .................................... 2-64
Gasolines for Cleaner Air
.............. 6-5
H
Hatch Release Switch .................. 2-27
Hazard Warning Flashers
.............. 5-2
Head Restraints
............................ 1-11
Headlights
...................................... 6-35
High Beams
..................... 2.66. 4-24
High-Low Beam
......................... 2-31
Reminder Light
.......................... 2-44
Heating System
.............................. 3-5
Fan Lever
.................................... 3-5
Rear
............................................. 3-7
Temperature Lever
...................... 3-5
Highway Hypnosis
........................ 4-34
Hitches Hood Block Heater.,
............................ 2-16
Function Lever
............................ 3-5
4-46
...........................................
Latches and Hinge ................... 6-40
Release
........................................ 6-8
Horn
............................................... 2-28
Hydroplaning
................................. 4-27
I
If You’re Stuck in Sand. Mud.
Ice or Snow
.............................. 5-32
Ignition Switch
............................... 2-13
Inflation-Tire Pressure
................... 6-45
Instrument Cluster
........................ 2-52
Standard
.................................... 2-55
Digital
......................................... 2-52
J
Jack Storage ................................. 5-18
Jump Starting
.................................. 5-3
9-3

Downloaded from www.Manualslib.com manuals search engine fNDEX
K
Keys ................................................ 2-3
L
Lights ............................................. 2-40
Dome
......................................... 2-44
Fog Lamps
................................ 2-42
Front Parking
............................ 6-36
Indicator
..................................... 2-64
Taillights
..................................... 6-37
Interior Override Switch
............ 2-45
Operation
................................... 2-31
Reading
..................................... 2-44
Turn Signal
................................ 6-36
Loading Your Vehicle
................... 6-42
Lubrication
..................................... 6.39
Accelerator Control System
..... 6-39
Body
........................................... 6-40
Front Suspension and Steering Linkage
................... 6-38
Front Wheel Bearings
(Two-Wheel Drive)
................. 6-38
Latches and Hinge
................... 6-40
Lock Cylinders
.......................... 6-41
Propeller Shaft Slip
SplinesAJniversal Joints
........ 6-40
Rear Axle
.................................. 6-23
Transfer Case
........................... 6-23
Luggage Carrier
............................ 2-49
M
Maintenance .................................... 7-2
Other Items
............................... 6-38
Periodic Inspections
.................. 7-13
Record
....................................... 7-1 6
Scheduled Maintenance
..... 7.3. 7-8
Underbody
................................. 6-58
Mirrors
........................................... 2-45
Inside
......................................... 2-45
Outside
............................ 2.46. 2-47
Vanity
......................................... 2-48
Model Reference
............................... iii
When Towing
a Trailer
............. 4-49
0
Odometer ....................................... 2-56
Trip
............................................. 2-57
Oil
.................................................... 6-9
Additives
.................................... 6-14
Disposal of Used
...................... 6-15
Pressure Gage
.......................... 2-62
To Check
................................... 6-10
What Kind
to Use ..................... 6-12
When
to Change ...................... 6-14
Owner Checks and Services
....... 7-11
P
Off -Road Recovery ....................... 4-20
Parking Brake
.......................................... 2-20
Downhill
..................................... 4-38
On Hills
............................ 4-37, 4-49
Uphill
.......................................... 4-38
Passing Other Vehicles
...... 4-21, 4-48
Pavement Markings
........................ 4-7
Payload Capacity
.......................... 6-43
Periodic Maintenance Inspections7-13
Power Mirrors
........................................ 2-47
Other Options
............................ 6-38
Seat
.............................................. 1-2
Visor Vanity
............................... 2-48
Windows
.................................... 2-26
Fluid
........................................... 6-30
Product Service Publications
......... 8-6
R
Radiator Pressure Cap ................ 6-29
Radio (See “Audio Systems”) Over Things That Burn
............ 2-23
Power Steering
............................. 4-18
Reading Lights
.............................. 2-44
Rear Defogger
................................ 3-8
Rear Hatch/Split-Panel Doors
........ 2-8
Rear WiperNVasher
...................... 2-34
Recommended Fluids/Lubricants
. 7-14
Reporting Safety Defects
............... 8-4
9-4

Downloaded from www.Manualslib.com manuals search engine Road Signs ..................................... 4-2
Roadside Assistance ...................... 8.5
Rocking Your Vehicle ................... 5-32
Roof Console ................................ 2-51
S
Safety Belts .................................. 1-12
Care Of ..................................... 6-55
Checking Restraint Systems .... 1-43
Driver Position ........................... 1-1 8
Extender .................................... 1-42
Lap-Shoulder Belt ..................... 1-19
Larger Children ......................... 1-40
Passenger Positions ....... 1-26, 1-30
Proper Wear .............................. 1-1 8
Questions and Answers ........... 1-16
Reminder Light .......................... 1-1 7
Replacing After a Crash .......... 1-43
Shoulder Belt Height Adjuster .... 1-21
Smaller Children and Babies ... 1-32
Use During Pregnancy ............. 1-25
Why They Work ........................ 1-13
Safety Chains ............................... 4-46
Safety Warnings ............................. 0-2
Scheduled Maintenance
Services
............................... 7-3, 7-8
Seats ............................................... 1-2
Bench ........................................... 1-5
Controls ....................................... 1-2
Head Restraints ........................ 1-1 1
Rear ............................................. 1-5
Power Driver’s ............................. 1-3
Reclining Bucket ......................... 1-3
Removable ................................... 1-8
Seatback Latches ....................... 1-7
Service ............................................ 6-3
Do-It-Yourself ............................... 6-3
Parts Identification Label .......... 6-62
Publications ......................... 8-6, 8-8
Replacement ParVFilter Recommendations
................. 6-70
Service Station Checks ................ 7-1 7
Adults ......................................... 1-18
Shifting IntolOut Of Park ... 2-21, 2-23
Single Belt Accessory Drive ........ 6-38
Spare Tire ..................................... 5-19
Specification Charts ...................... 6-64
Speedometer ................................. 2-56
Springs, Fiberglass ....................... 6-58
Starting Your Engine .................... 2-14
Steering
In Emergencies
......................... 4-19
Tips ............................................ 4-18
Storage Compartment .................. 2-51
Storing the JacWSpare Tire ......... 5-30
Sun Visors .................................... 2-48
T
Theft .............................................. 2-12
Thermostat .................................... 6-29
Tilt Wheel ...................................... 2-28
Tires ............................................... 6-44
Chains ........................................ 6-51
Changing A Flat ..A-16, 5.17, 5-21
Compact Spare ......................... 5-31
Inspection and Rotation ............ 6-47
Loading ...................................... 6-42
New ............................................ 6-48
Pressure ..................................... 6-45
Uniform Tire Quality Grading ... 6-49
Top Strap ...................................... 1-34
Towing Your Vehicle ....................... 5-7
Towing a Trailer ............................ 4-43
Backing Up ................................ 4-48
Following Distance .................... 4-48
Making Turns ............................. 4-48
Turn Signals .............................. 4-48
Traffic Lights ................................... 4-6
Trailer
Brakes
........................................ 4-46
Wiring Harness .......................... 2-67
Trailering Package ........................ 6-44
Transfer Case ............................... 6-23
Transmission, Automatic ............... 2-17
Add Fluid ................................... 6-22
Check Fluid ............................... 6-20
Torque Lock ............................... 4-39
9-5