oil temperature CHEVROLET ASTRO PASSENGER 1994 1.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine These symbols are on some of your controls:
Hood Release
Ventilating
Fan
Windshield Wiper
Q
Rear Window
Wiper
& Washer
w
Windshield
Washer
I I
Rear Window Defogger
w
These symbols are used on warning and indicator lights:
Engine Coolant
Temperature Battery Charging
System
Brake
(Standard Cluster
ANTI-
LOCK
4- Wheel
Anti-Lock
Windshield Defroster
Hatch
Release
II
Fuel Engine Oil
Pressure
ix

Downloaded from www.Manualslib.com manuals search engine Here are things some owners ask about. None of these indicate a problem
with your fuel gage:
0 At the gas station, the gas pump shuts off before the gage r\
eads full.
The fuel tank will take either a little more or a little less fuel to fill up
than the gage shows.
The gage moves a little when you turn a corner or speed up.
The gage doesn’t go back to empty when you turn off the ignition.
For your fuel tank capacity, see the Index under “Fluid Capacities.”
Oil Pressure Gage
Standard Cluster Digital Cluster
The oil pressure gage shows the engine oil pressure in psi (pounds pe\
r
square inch) when the engine is running. Canadian vehicles indicate
pressure in
kPa (kilopascals). Oil pressure may vary with engine speed,
outside temperature and oil viscosity, but readings above the low pressure
zone indicate the normal operating range.
A reading in the low pressure zone may be caused by a dangerous\
ly low oil
level or other problems causing low oil pressure.
On the digital cluster, a box around the oil pressure symbol \
will begin to
flash when the oil pressure
is low.
2-62

Downloaded from www.Manualslib.com manuals search engine NOTICE:
Damage to your engine from neglected oil problems can be
costly and
is not covered by your warranty.
Engine Coolant Temperature Gage
Standard Cluster
If you have the Standard Cluster, you have a gage that shows the engine
coolant temperature.
If the gage pointer moves to the “H” (red) side, your
engine
is too hot!
It means that your engine coolant has overheated. If you have been
operating your vehicle under normal driving conditions, you shou\
ld pull
off
the road, stop your vehicle and turn off the engine as soon as possible.
If you have a digital cluster, a box around the temperature symbol will also
flash when your engine is too hot.
2-63

Downloaded from www.Manualslib.com manuals search engine You should also use the proper viscosity oil for your vehicle, as shown in
the following chart:
RECOMMENDED SAE VISCOSITY GRADE ENGINE OILS
FOR BEST FUEL ECONOMY AND COLD STARTING, SELECT THE LOWEST
SAL VISCOSITY GRADE OIL
FOR THE EXPECTED TEMPERATURE RANGE.
HOT
WEATHER
F
+ 100
+ 80
+ 60
+ 40
+ 20
0
+ 38
+ 27
+ 16
+4
-7
- 18
COLD
WEATHER
LOOK FOR
ONE OF THESE
LABELS
SAE 1OW-30
SAE 5W-30
PREFERRED
IF NEITHER SAE 5W-30 NOR SAE 1OW-30
GRADE
OILS ARE AVAILABLE, SAE 30
GRADE MAY BE USED AT TEMPERATURES
ABOVE 40 DEGREES
F (4 DEGREES C).
ANY OTHER GRADE OIL NOT RECOMMENDED
DO NOT USE SAE 1OW-40, SAE 2OW-50 OR
As shown in the chart, SAE 5W-30 is best for your vehicle. However, you
can use SAE 1OW-30 if it's going to be 0°F (-18°C) or above. These
numbers
on an oil container show its viscosity, or thickness. Do not use
other viscosity oils, such as
SAE lOW-40 or SAE 20W-50.
6- 12

Downloaded from www.Manualslib.com manuals search engine What to Use
Refer to the Maintenance Schedule to determine what kind of lubricant to
use. See “Recommended Fluids
and Lubricants” in the Index.
Engine Coolant
The following explains your cooling system and how to add coolant when it
is low. If
you have a problem with engine overheating, see “Engine
Overheating” in the Index.
The proper coolant for your vehicle will:
0 Give freezing protection down to -20°F (-29”C), or -34°F (-37°C) in
0 Give boiling protection up to 258°F (125 “C).
0 Protect against rust and corrosion.
0 Help keep the proper engine temperature.
0 Let the warning gages work as they should.
Canada
and for vehicles with the cold climate option.
What to Use
Use a mixture of one-half clean water (preferably distilled) and one-half
antifreeze
that meets “GM Specification 6038-M,” which won’t damage
aluminum parts. You can also use a recycled coolant conforming to
“GM
Specification 603%”’ with a complete coolant flush and refill. If you use
this mixture,
you don’t need to add anything else.
6-26

Downloaded from www.Manualslib.com manuals search engine Air Conditioning
Every now and then have your dealership check your air conditioning
system to be sure it has not
lost any cooling ability. If you think the system
is not working properly, have your dealership
check it out as soon as
possible.
The air conditioning will not work when the temperature is below
40°F
(4 O C).
Lubrication
Accelerator Control System
Refer to the Maintenance Schedule to determine how often the accelerator
linkage pivot points must be lubricated and what type of lubricant
to use.
Accelerator cables and cruise control cables should not be lubricated. Any
cables that are worn or are hard to pull should be replaced.
When cleaning the engine compartment with water or steam, avoid directing
the flow onto the throttle linkage in a manner that would cau\
se moisture
to
enter the cables.
Hood Latches and Hood Hinge
Refer to the Maintenance Schedule to determine how to lubricate the hood
latch and hood hinge assembly.
Sliding Door Tracks
Your vehicle’s sliding door has three tracks which need lubrication.
For the upper and lower tracks, open the door, wipe the track\
clean and then lubricate with Lubriplate
TM White Grease.
For the outside middle track, close
the door after you finish the upper and
lower tracks. Then, wipe
the track clean and lubricate with
Lubriplate
TM White Grease.
Body
Normal use of your vehicle will cause metal to metal wear at some points on
the cab and body
if they are not lubricated.
For exposed surfaces, such as door checks, door lock bolts, lock striker
plates, dovetail bumper wedges, etc., a thin film
of engine oil should be
applied.
Where oil holes are provided in the body or cab, a dripless oil can be used.
The seat adjusters and seat track should be lubricated with chassis grease.
6-42

Downloaded from www.Manualslib.com manuals search engine Explanation Of Scheduled Maintenance Services
Below are explanations of the services listed in the maintenance charts.
The proper fluids and lubricants to use are listed
in this section. Make sure
whoever services your vehicle uses these. All parts should
be replaced and
all necessary repairs done before you or anyone else drives the vehicle.
1.
2.
3.
4.
5.
ENGINE OIL AND OIL FILTER CHANGE“ - ALWAYS USE
API SERVICE
SH OR SG ENERGY CONSERVING I1 OILS OF THE
PROPER VISCOSITY. The
“SH7 or “SG7 designation may be shown
alone or in combination with others, such as “SWCD”, or
“SH, SG,
CD,” or “SG/CD”, etc. To determine the preferred viscosity oil for your
vehicle’s engine see “Engine Oil”
in the Index.
CHASSIS LUBRICATION - Lubricate the front suspension,
steering linkage, transfer case shift linkage, parking brake cab\
le guides,
and brake pedal springs at the intervals specified on the proper
maintenance schedule, or at every engine oil change, whichever \
comes
first.
Ball joints and king pin bushings should not be lubricated unless their
temperature is
10°F (-1 2°C) or higher. When the weather is cold, let
them warm up before lubricating them or they could be damaged.\

Also, be sure to check all the vehicle fluid levels at this \
time.
COOLING SYSTEM SERVICE* - Drain, flush and refill the
system
with new or approved recycled coolant conforming to “GM
Specification 6038-M”. See “Engine Coolant”
in the Index for the
proper coolant and mixture to use
in your vehicle.
Also inspect the hoses and replace them
if they are cracked, swollen, or
deteriorated. Clean the outside of the radiator and air conditioning
condenser. Wash the radiator neck.
To ensure proper operation,
pressure test the radiator and cap.
AIR CLEANER FILTER REPLACEMENT* - Replace at
specified intervals. Ask your dealer for the proper replacement
intervals for your driving conditions.
FRONT WHEEL BEARING REPACK
(2-WHEEL DRIVE ONLY)
- Clean and repack the front wheel
bearings at each brake relining,
or at the specified interval, whichever
comes first.
* An Emission Control Service
7-7

Downloaded from www.Manualslib.com manuals search engine D
Damage Finish
...................................................... 6-61
Sheet Metal
.................................................. 6-60
Daytime Running Lights
..................................... 2-43. 2-60
Indicator Light
.......................................... 2-43. 2-60
Defogger. Rear Window
................... .................... 3-7
DomeLights
.................................................... 2-44
Doors
.......................................................... 2-5
Locks
........................................................ 2-8
PowerLocks
................................................. 2-10
Rear
........................................................ 2-10
Side
......................................................... 2-5
Side. Sliding
.................................................. 2-6
Sliding Tracks
................................................ 642
At Night
.................................................... 4-12
City
........................................................ 4-15
ControlOfAVehicle
........................................... 4-5
Defensive
.................................................... 4-2
Highway Hypnosis
............................................ 4-18
Hydroplaning
................................................ 4-15
InBlizzard
................................................... 4-22
In Mud. Sand. Snow. Or Ice
................................ 4-20. 5-33
InRain
...................................................... 4-13
InWater
..................................................... 4-14
LossofControl
............................................... 4-11
Nightvision
................................................. 4-13
On Hill and Mountain Roads
.................................... 4-18
On Snow or Ice
............................................... 4-20
Passing
..................................................... 4-10
Skidding
.................................................... 4-11
Stuck in Deep Snow
...................................... 4-22. 5-33
Throughwater .......................................... 2-15. 4-14
Uphill
....... .................... ................... 4-19
Winter
...................................................... 4-20
WithaTrailer
................................................ 4-23
DrunkenDriving
................................................. 4-2
Driving
E
Engine
Coolant (Block) Heater
..................................... 2.16. 3.8
Coolant
................................................ 5.14, 6.26
Coolant Temperature Gage
...................................... 2-63
Cover
....................................................... 6-15
Exhaust
................................................ 2.24. 643
FanNoise ................................................... 5-18
Identification
............................................ 6.64. 6.68
Oil (See “Oil”)
Overheating
.................................................. 5-11
RunningWhileParked
......................................... 2-24
Starting
..................................................... 2-14
Equipment. Add-on ............................................. 6-47

Downloaded from www.Manualslib.com manuals search engine Exhaust System ................................................. 6-43
F
FanNoise ...................................................... 5-18
Filter Replacement Chart
.......................................... 6-74
Finish
Care
........................................................ 6-59
Damage
..................................................... 6-61
Automatic Transmission
........................................ 6-20
Brake
....................................................... 6-32
Capacities
................................................... 6-69
CoolantRecovery
............................................. 5-14
FrontAxle
................................................... 6-25
Leak Check
.................................................. 6-36
Powersteering
............................................... 6-30
Radiator
..................................................... 5-15
Rear Axle
................................................... 6-24
RecommendedFluids
.......................................... 7-13
Transfercase
................................................ 6-24
Windshield Washer
............................................ 6-31
FogLamps
..................................................... 2-42
Four-wheel Anti-lock
............................................. 4-7
Frontseats
...................................................... 1-2
Fuel
........................................................... 6-3
FillingYourTank
.............................................. 6-5
Foreign Countries
.............................................. 6-5
Gage
....................................................... 2-61
Gasolines for Cleaner Air
........................................ 6-4
Tankcapacity ................................................ 6-69
Fuses and Circuit Breakers
........................................ 6-72
FuseBlock
.................................................. 6-67
Headlights
................................................... 6-66
Power Windows and Other Power Options
......................... 6-66
Trailer Wiring Harness
......................................... 6-66
Windshield Wipers
....................... .............. 6-66
Fluid
G
Gages ......................................................... 2-61
Coolant Temperature Gage
...................................... 2-63
FuelGage
................................................... 2-61
Odometer
................................................... 2-53
Oil Pressure Gage
............................................. 2-62
Speedometer
................................................. 2-53
Trip Odometer
................................................ 2-53
Voltmeter
.................................................... 2-64
Gasolines for Cleaner Air
.......................................... 6-4
Hatch Release Switch ............................................. 2-28
HalogenBulbs
........................................ ....... 6-36