power steering fluid CHEVROLET ASTRO PASSENGER 1999 2.G Owners Manual
[x] Cancel search | Manufacturer: CHEVROLET, Model Year: 1999, Model line: ASTRO PASSENGER, Model: CHEVROLET ASTRO PASSENGER 1999 2.GPages: 392, PDF Size: 2.6 MB
Page 89 of 392
yellowblue
2-19
Engine Coolant Heater (If Equipped)
In very cold weather, 0F
(
-18C) or colder, the
engine coolant heater can
help. You'll get easier
starting and better fuel
economy during engine
warm
-up. Usually, the
coolant heater should be
plugged in a minimum of
four hours prior to starting
your vehicle.
To Use the Engine Coolant Heater
1. Turn off the engine.
2. Open the hood and unwrap the electrical cord.
The engine coolant heater cord is located on the
driver's side of the engine compartment, near the
power steering fluid reservoir.3. Plug it into a normal, grounded 110
-volt AC outlet.
CAUTION:
Plugging the cord into an ungrounded outlet
could cause an electrical shock. Also, the wrong
kind of extension cord could overheat and cause
a fire. You could be seriously injured. Plug the
cord into a properly grounded three
-prong
11 0
-volt AC outlet. If the cord won't reach, use a
heavy
-duty three-prong extension cord rated for
at least 15 amps.
4. Before starting the engine, be sure to unplug and
store the cord as it was before to keep it away from
moving engine parts. If you don't, it could
be damaged.
How long should you keep the coolant heater plugged
in? The answer depends on the outside temperature, the
kind of oil you have, and some other things. Instead of
trying to list everything here, we ask that you contact
your dealer in the area where you'll be parking your
vehicle. The dealer can give you the best advice for that
particular area.
Page 247 of 392
6-
yellowblue
6-1
Section 6 Service and Appearance Care
Here you will find information about the care of your vehicle. This section begins with service and fuel information,
and then it shows how to check important fluid and lubricant levels. There is also technical information about your
vehicle, and a part devoted to its appearance care.
6
-2 Service
6
-3 Fuel
6
-5 Filling Your Tank
6
-7 Filling a Portable Fuel Container
6
-8 Checking Things Under the Hood
6
-11 Engine Oil
6
-15 Engine Cover
6
-19 Engine Air Cleaner/Filter
6
-20 Automatic Transmission Fluid
6
-24 All-Wheel Drive
6
-25 Rear Axle
6
-26 Radiator Pressure Cap
6
-27 Thermostat
6
-27 Engine Coolant
6
-30 Power Steering Fluid
6
-31 Windshield Washer Fluid
6
-32 Brakes6
-35 Battery
6
-36 Bulb Replacement
6
-42 Windshield Wiper Blade Replacement
6
-43 Tires
6
-51 Appearance Care
6
-52 Cleaning the Inside of Your Vehicle
6
-55 Cleaning the Outside of Your Vehicle
6
-57 Cleaning Tires
6
-57 Finish Damage
6
-57 Underbody Maintenance
6
-58 GM Vehicle Care/Appearance Materials
6
-59 Vehicle Identification Number (VIN)
6
-59 Service Parts Identification Label
6
-60 Electrical System
6
-67 Capacities and Specifications
6
-68 Air Conditioning Refrigerants
6
-69 Normal Maintenance Replacement Parts
Page 256 of 392
yellowblue
6-10
When you open the hood, this is what you will see:
A. Windshield Washer Fluid Fill Location
B. Coolant Fill Location
C. Oil Dipstick Location
D. Transmission Dipstick/Fill Location
E. Engine Air Cleaner/FilterF. Engine Oil Fill Location
G. Brake Master Cylinder Reservoir
H. Power Steering Fluid Reservoir
I. Battery
Page 276 of 392
yellowblue
6-30
Power Steering Fluid
When to Check Power Steering Fluid
It is not necessary to regularly check power steering
fluid unless you suspect there is a leak in the system or
you hear an unusual noise. A fluid loss in this system
could indicate a problem. Have the system inspected
and repaired.
How to Check Power Steering Fluid
When the engine compartment is cool, wipe the cap and
the top of the reservoir clean, then unscrew the cap and
wipe the dipstick with a clean rag. Replace the cap and
completely tighten it. Then remove the cap again and
look at the fluid level on the dipstick.
The level should be at the FULL COLD mark. If
necessary, add only enough fluid to bring the level up to
the mark.
What to Use
To determine what kind of fluid to use, see
ªRecommended Fluids and Lubricantsº in the Index.
Always use the proper fluid. Failure to use the proper
fluid can cause leaks and damage hoses and seals.
Page 363 of 392
yellowblue
7-47
Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by
name, part number or specification may be obtained
from your dealer.
USAGE
FLUID/LUBRICANT
Engine OilEngine Oil with the American
Petroleum Institute Certified For
Gasoline Engines ªStarburstº
symbol of the proper viscosity. To
determine the preferred viscosity
for your vehicle's engine, see
ªEngine Oilº in the Index.
Engine Coolant50/50 mixture of clean, drinkable
water and use only GM
Goodwrench
DEX-COOL or
Havoline DEX-COOL
Coolant. See ªEngine Coolantº in
the Index.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid
(GM Part No. 12377967 or
equivalent DOT
-3 Brake Fluid).
USAGEFLUID/LUBRICANT
Windshield
Washer SolventGM Optikleen Washer Solvent
(GM Part No. 1051515)
or equivalent.
Parking Brake
Cable GuidesChassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI # 2, Category LB
or GC
-LB.
Power Steering
SystemGM Power Steering Fluid
(GM Part No. 1052884
- 1 pint,
1050017
- 1 quart, or equivalent).
Automatic
TransmissionDEXRON-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant,
Superlube (GM Part
No. 12346241 or equivalent).
Chassis
LubricationChassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements
of NLGI # 2, Category LB
or GC
-LB.
Page 387 of 392
yellowblue
9-7
Manual Lumbar Support 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . .
Methanol 6-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mirrors 2-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Convex Outside 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inside Day/Night Rearview 2-40 . . . . . . . . . . . . . . . . . . . . .
Outside 2-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Visor Vanity 2-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
MMT 6-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model Reference vi. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mountain Roads 4
-22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Net, Convenience 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Neutral 2-21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
New Vehicle Break-In 2-15 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Night Vision 4-15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Normal Maintenance Replacement Parts 6-69 . . . . . . . . . . . . .
Odometer 2-59 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Odometer, Trip 2-59 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Recovery 4-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Engine 6-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Opener, Garage Door 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Outside Mirror 2-40 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overhead Console 2-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating Engine 5-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-41 . . . . . . . . . . . . . . . . . . . . . . .
Owner Publications, Ordering 8-11, 8-12 . . . . . . . . . . . . . . . .
Paint Spotting, Chemical 6-57 . . . . . . . . . . . . . . . . . . . . . . . .
Park 2-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Into 2-24 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting Out of 2-26 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking
At Night 2
-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake 2-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Mechanism Check 7-44 . . . . . . . . . . . . . . . . . . . . . . .
Lots 2-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Over Things That Burn 2-27 . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-38 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passing 4-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passlock2-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Payload 4-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-45 . . . . . . . . . . . . . . . . . .
Power
Accessory Outlet 2
-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Locks 2-6 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Option Fuses 6-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat 1-3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering 4-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Steering Fluid 6-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Windows 2-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Pregnancy, Use of Safety Belts 1-25 . . . . . . . . . . . . . . . . . . . .
Problems on the Road 5-1 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Publications, Service and Owner 8-11, 8-12 . . . . . . . . . . . . . .