maintenance schedule CHEVROLET BLAZER 1994 2.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine MAINTENANCE SCHEDULE I
* An Emission Control Service
** See “Explanation of Scheduled Maintenance Services” in the Index
$ The California Air Resources Board has determined that the fail\
ure to perform this
maintenance item will not nullify the emission warranty or limi\
t recall liability prior to the
completion of vehicle useful life. General Motors, however, urges that all re\
commended
maintenance services be performed at the indicated intervals and\
the maintenance be
recorded.
T0801TT1101
7-4

Downloaded from www.Manualslib.com manuals search engine MAINTENANCE SCHEDULE I (continued)
THE SERVICES SHOWN ON THIS CHART UP TO 60,000 MILES (100 000 km) ARE TO BE
DONE AFTER 60,000 MILES AT THE SAME INTERVALS.
T0802R1102
7-5

Downloaded from www.Manualslib.com manuals search engine MAINTENANCE SCHEDULE /I
llf your driving conditions meet tho:
Item Ithis
Section (or see Index), use M;
Miles
(000)
Service
Oil Filter Change*-Every 12 Months, or
3 Cooling System Service* -Every 24 Months or
4 Air Cleaner Filter Replacement*
5 Front Wheel Bearing Repack (2WD Only)
6 Transmission Service
**
7 Fuel Filter Replacement*$
8 Spark Plug Replacement*
9 Spark Plug Wire Inspection*
10 Engine Timing Check*$ (Some
11 Fuel Tank, Cap and Lines Models)
Inspection*$
12 Engine Accessory Drive Belt
I Inspection*
13
I Tire and Wheel Rotation
14
I Drive Axle Service
15
I Brake Systems Inspection**
3 specified in “Scheduled Maintc
lntenance Schedule
II (0)
lance Services” in
* An Emission Control service
** See “Explanation of Scheduled Maintenance Services” in the Index
$ The California Air Resources Board has determined that the fail\
ure to perform this
maintenance item will not nullify the emission warranty
or limit recall liability prior to the
completion of vehicle useful life. General Motors, however, urges that all re\
commended
maintenance services be performed at the indicated intervals and\
the maintenance be
recorded.
THE SERVICES SHOWN ON THIS CHART
UP TO 60,000 MILES (100 000 km) ARE TO BE
DONE AFTER
60,000 MILES AT THE SAME INTERVALS.
T0803/Tl103
7-6

Downloaded from www.Manualslib.com manuals search engine Explanation Of Scheduled Maintenance Services
Below are explanations of the services listed in the maintenance charts.
The proper fluids and lubricants to use are listed in this section. Make sure
whoever services your vehicle
uses these. All parts should be replaced and
all necessary repairs done before you or anyone else drives the vehicle.
1.
2.
3.
4.
5.
ENGINE OIL AND OIL FILTER CHANGE* - ALWAYS USE
API SERVICE SH OR SG ENERGY CONSERVING I1 OILS OF THE
PROPER VISCOSITY. The “SH” or “SG” designation may be shown
alone or in combination with others, such as “SHKD”, or
“SH, SG,
CD,” or “SG/CD”, etc.
To determine the preferred viscosity oil for your
vehicle’s engine (e.g. SAE
5W-30), see “Engine Oil” in the Index.
CHASSIS LUBRICATION - Lubricate the front suspension, ball
joint, steering linkage, and transfer case shift linkage, parking brake
cable guides, propshaft splines, universal joints, brake pedal springs,
and clutch pedal springs at the intervals specified on the proper
maintenance schedule, or at every engine oil change, whichever comes
first.
Ball joints should
not be lubricated unless their temperature is 10°F
(-12°C) or higher. When the weather is cold, let them warm up before
lubricating them
or they could be damaged.
Also, be sure to check all the vehicle fluid levels at this time.
COOLING SYSTEM SERVICE* - Drain, flush and refill the
system with new or approved recycled coolant conforming to “GM
Specification
603%”’. See “Engine Coolant” in the Index for the
proper coolant and mixture to use in your vehicle.
Also inspect
the hoses and replace them if they are cracked, swollen, or
deteriorated. Clean the outside of the radiator and air conditioning
condenser. Wash the radiator neck. To ensure proper operation,
pressure test the radiator and cap.
AIR CLEANER FILTER REPLACEMENT” - Replace at
specified intervals. Ask your dealer for the proper replacement
intervals for your driving conditions.
FRONT WHEEL BEARING REPACK (2-WHEEL DRIVE
ONLY) - Clean and repack the front wheel bearings at each brake
relining,
or at the specified interval, whichever comes first.
*An Emission Control Service
7-7

Downloaded from www.Manualslib.com manuals search engine Maintenance Record
After each of the preceding Scheduled Maintenance Services is performed,
record the date, odometer reading, services performed (list item numbers)
and who performed the services in
the appropriate column. In addition,
retain copies
of your receipts. It is suggested that receipts be kept with your
Owner’s Manual.
7-16

Downloaded from www.Manualslib.com manuals search engine Lights (continued)
Front Parkingnurn Signal
....................................... 6-33
Headlights (See “Headlights”)
Indicator
............................................... 2-74,2.. 75
Malfunction Indicator
...................................... 2-7 1 6-38
Operation
................................................... 2-40
Overhead Console Reading
...................................... 2-53
Service Engine Soon
...................................... 2-7 1, 6-38
Loading Information
............................................. 6-39
Loading Your Vehicle
....................................... 4-1 3. 6-39
Accelerator Control System
..................................... 6-36
EndgateHandle
............................................... 6-37
Front Suspension and Steering Linkage
............................ 6-35
Front Wheel Bearings (Two-Wheel Drive)
......................... 6-35
Propeller Shaft Slip Splines/Universal
Joints ........................ 6-37
Rear
........................................................ 6-34
Replacementchart
............................................ 6-63
Lubrication
..................................................... 6-36
Body
....................................................... 6-37
FrontAxle
................................................... 6-22
HoodLatchesandHinge
........................................ 6-36
Lockcylinders
............................................... 6-37
RearAxle
................................................... 6-20
Recommended Lubricants
...................................... 7-13
Transfercase
................................................ 6-21
Luggage Carrier
................................................. 2-78
M
Maintenance
OtherItems
.................................................. 6-35
Record
...................................................... 7-16
ScheduledMaintenance ......................................... 7-3
Underbody
.................................................. 6-56
WhenTowingaTrailer
......................................... 3-37
Master Cylinder (See “Brakes”)
Mirrors
........................................................ 2-53
Convexoutside
............................................... 2-55
Inside
....................................................... 2-53
Outside
..................................................... 2-54
Vanity
...................................................... 2-55
ModelReference
.................................................. 111
Periodic Inspections ........................................... 7-12
...
0
Odometer ...................................................... 2-66
Off-Road Driving (See “Driving”)
Off-Road Recovery
.............................................. 4-10
Oil
............................................................ 6-8
Additives
.................................................... 6-12
Disposalofused
.............................................. 6-13
Pressure Gage ................................................ 2-72
ToCheck
..................................................... 6-9
6

Downloaded from www.Manualslib.com manuals search engine SafetyChains ................................................... 4-39
Safety Warnings and Symbols ........................................ vi
Scheduled Maintenance Services
..................................... 7-3
Controls ...................................................... 1-2
Easy Entry Seat ................................................ 1-6
ManualFront .................................................. 1-2
Manual Lumbar Adjustment ...................................... 1-3
Power Lumbar Adjustment ....................................... 1-3
Reclining ..................................................... 1-4
SeatbackLatches ............................................... 1-4
Do-It-Yourself ................................................ 6-2
Parts Identification Label ....................................... 6-60
Publications ............................................... 8-7, 8-8
Replacement Parts and Filter Recommendations ..................... 6-62
Service Engine Soon Light ........................................ 2-71
Service Station Checks ............................................ 7-17
Shift Indicator Light ......................................... 2-24, 2-74
Shifting Into Park ................................................ 2-26
Single Belt Accessory Drive ........................................ 6-35
Sliding Rear Quarter Window ...................................... 2-36
Spare Tire ...................................................... 5-24
Endgate-Mounted Carrier ....................................... 2-10
Seats
PowerDriver’s
................................................ 1-3
RearFolding .................................................. 1-7
Service
Removal
.................................................... 5-24
Specificationcharts .............................................. 6-62
Speedometer .................................................... 2-65
Steering ........................................................ 4-8
InEmergencies ................................................ 4-9
Tips ......................................................... 4-8
Starting your Engine ............................................. 2-17
Storage Compartments ............................................ 2-58
GarageDoorOpener ........................................... 2-61
Sunvisors ..................................................... 2-55
Tachometer ..................................................... 2-67
Theft .......................................................... 2-14
Thermostat ..................................................... 6-26
Tires .......................................................... 6-42
Balancing ................................................... 6-47
Chains ...................................................... 6-49
Flat ........................................................ 5-18
Changing a Flat .......................................... 5.18, 5.25
Hub Caps and Wheel Nut Caps .................................. 5-26
Inspection and Rotation ........................................ 6-44
New ........................................................ 6-45
Pressure ..................................................... 6-42
Uniform Tire Quality Grading ................................... 6-46
Loading ..................................................... 6-39
Spare (See “Spare Tire”)
8