air conditioning CHEVROLET BOLT EV 2023 User Guide

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada-
16404388) - 2023 - CRC - 3/7/22
Vehicle Care 217
1. Windshield Washer Fluid Reservoir. SeeWasher Fluid 0218.
2. Cabin Heating Coolant Reservoir. See Cooling System 0217.
3. High Voltage Battery Coolant Reservoir. See Cooling System 0217.
4. HPDM (High Power Distribution Module).
5. APM (Accessory Power Module), OBCM (On-Board Charging Module).
6. Brake Fluid Reservoir. See Brake Fluid
0 219.
7. SPIM, APM, and Charger Module Coolant Reservoir. See Cooling System 0217.
8. Battery. See Battery - North America
0 220.
9. Underhood Compartment Fuse Block. Underhood Compartment Fuse Block
0229.
Cooling System
It is not necessary to regularly check coolant
unless a leak is suspected or an unusual
noise is heard. A coolant loss could indicate
a problem. Have it inspected and repaired
by your dealer.
The following explains the cooling systems
and how to check coolant levels.
.High Voltage Battery
.Single Power Inverter Module (SPIM),
Accessory Power Module (APM), and
Charger Module
.Cabin Heating
High Voltage Battery
During vehicle operation and also during
charging, the high voltage battery cells in
the vehicle are kept within a normal
operating temperature range. If the
temperature rises above this temperature,
the battery cooling system turns on the air
conditioning compressor and cools the
coolant until the correct temperature is
reached. If the temperature falls below this
temperature, a high voltage heater, located
outside the battery on a cradle, heats the
coolant until the correct temperature is
reached.
Single Power Inverter Module (SPIM),
Accessory Power Module (APM), and
Charger Module
The SPIM, APM, and charger module are
cooled using a separate coolant loop. These
modules are kept below a maximum
temperature. If the temperature rises above
this temperature, the electric cooling fan will
turn on to cool the coolant.
Cabin Heating
Cabin heating is maintained by coolant
heated by the Coolant Heater Control
Module (CHCM), separate from the power
electronics and battery coolant loops. This
module heats the coolant based on
temperature inputs from the cabin climate
control systems.
Hybrid Cooling System Pressure Caps
The hybrid cooling system reservoirs have
tamper resistant pressure caps. The coolant
should only be serviced by a qualified
technician.
Checking Coolant
The coolant needs to be replaced at the
appropriate interval. See Maintenance
Schedule 0271.
The coolant reservoirs are in the underhood
compartment. See Underhood Compartment
Overview 0216.

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada-
16404388) - 2023 - CRC - 3/7/22
Vehicle Care 233
The instrument panel fuse block is on the
left side of the instrument panel. To access
the fuses, open the fuse panel door by
pulling out.
To reinstall the door, insert the top tab first,
then push the door back into its original
location.Fuses Usage
F01 Video Processing Module
F02 TCP –Telematics Control
Platform (OnStar)
F03 Side Blind Zone Alert
F04 Passive Entry, Passive Start F05 CGM –Central Gateway
Module
F06 Body Control Module 4 F07 Body Control Module 3
F08 Body Control Module 2
F09 Body control module 1 F10 Police SSV F11 Amplifier
F12 Body Control Module 8
F13 Data Link Connector Fuses
Usage
F14 Parking Assist F15 Headlamp LH
F16 Single Power Inverter Module 1
F17 Body Control Module 6
F18 Body Control Module 5
F19 –
F20 –
F21 –
F22 –
F23 USB
F24 Wireless Charging Module F25 Reflected LED Alert Display
F26 Heated Steering Wheel F27 CGM –Central Gateway
Module 2
F28 Instrument Cluster 2
F29 –
F30 –
F31 – Fuses
Usage
F32 –
F33 Heating, Ventilation, and Air Conditioning Module
F34 Heating, Ventilation and Air Conditioning Display/
Integrated Center Stack
F35 Instrument Cluster 1
F36 Center Stack Module F37 –
F38 –
F39 –
F40 –
F41 –
F42 –
F43 Body Control Module 7
F44 Sensing and Diagnostic Module
F45 Front Camera Module
F46 Vehicle Integration Control Module
F47 Single Power Inverter Module 2

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada-
16404388) - 2023 - CRC - 3/7/22
Service and Maintenance 271
The Additional Required Services are for
vehicles that:
.Carry passengers and cargo within
recommended limits on the Tire and
Loading Information label. SeeVehicle
Load Limits 0158.
.Are driven on reasonable road surfaces
within legal driving limits.
See “Additional Required Services” in the
Maintenance Schedule 0271.
{Warning
Performing maintenance work can be
dangerous and can cause serious injury.
Perform maintenance work only if the
required information, proper tools, and
equipment are available. If they are not,
see your dealer to have a trained
technician do the work. See Doing Your
Own Service Work 0213.
Maintenance Schedule
Tire Rotation and Required Services
Every 12 000 km (7,500 mi)
Tires are rotated to achieve a more uniform
wear for all tires. The first rotation is the
most important. Anytime unusual wear is noticed, rotate the
tires as soon as possible, check for proper
tire inflation pressure, and check for
damaged tires or wheels. If the unusual
wear continues after the rotation, check the
wheel alignment. See
When It Is Time for
New Tires 0245 and
Wheel Replacement 0248.
.Perform Multi-Point Vehicle Inspection.
See Multi-Point Vehicle Inspection (MPVI)
0 272.
.Lubricate body components. See Exterior
Care 0262.
Additional Required Services
Every 36 000 km (22,500 mi)
.Replace passenger compartment air filter.
Or every 24 months, whichever comes
first. More frequent passenger
compartment air filter replacement may
be needed if driving in areas with heavy
traffic, poor air quality, high dust levels,
or environmental allergens. Passenger
compartment air filter replacement may
also be needed if there is reduced airflow,
window fogging, or odors. Your GM
dealer can help determine when to
replace the filter. Every 161 000 km (100,000 mi)
.Replace hood and/or body lift support gas
struts. Or every 10 years, whichever
comes first. See
Gas Strut(s)0224.
Every 240 000 km (150,000 mi)
.Drain and fill vehicle coolant circuits. Or
every five years, whichever comes first.
See Cooling System 0217.
Owner Checks and Services
Every Five Years
.Replace brake fluid.
Every Seven Years
.Replace Air Conditioning Desiccant every
seven years. The air conditioning system
requires maintenance every seven years.
This service requires replacement of the
desiccant to help the longevity and
efficient operation of the air conditioning
system. This service can be complex. See
your dealer.

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada-
16404388) - 2023 - CRC - 3/7/22
Technical Data 277
Vehicle Data
Capacities and Specifications
The following approximate capacities are given in metric and English conversions.
Refer toRecommended Fluids and Lubricants 0273 for more information.
Application Capacities Metric English
Air Conditioning Refrigerant For the air conditioning system refrigerant charge type and
amount, see the refrigerant label under the hood. See your dealer for more information.
Cooling Systems*
IHigh Voltage Battery 7.0 L 7.4 qt
IPower Electronics 3.8 L 4.0 qt
IHeater 2.0 L
2.1 qt
Wheel Nut Torque 140Y 100 lb ft
All capacities are approximate. When adding, be sure to fill to the approximate level, as recommended in this manual. Recheck fluid level
after filling.
*Cooling systems capacity values are based on the individual cooling system and its components.

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada-
16404388) - 2023 - CRC - 3/7/22
Index 297
IndexA
Accessories and Modifications . . . . . . . . . . . . 213
Accessory Power . . . . . . . . . . . . . . . . . . . . . . . . . 163
AdaptiveCruise Control . . . . . . . . . . . . . . . . . . . . . . . . . 174
Add-On Electrical Equipment . . . . . . . . . . . . . . 211
Additional OnStar Information . . . . . . . . . . . . . . . . . . . . 290
Adjustments Lumbar, Front Seats . . . . . . . . . . . . . . . . . . . . 29
Agreements Trademarks and License . . . . . . . . . . . . . . . 138
Air Conditioning . . . . . . . . . . . . . . . . . . . . . . . . . . . 144
Conditioning Regular Operation . . . . . . . . 149
Filter, Passenger Compartment . . . . . . . . 148
Intake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 148
Vents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Airbag System . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38
Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
How Does an Airbag Restrain? . . . . . . . . . . 42
Passenger Sensing System . . . . . . . . . . . . . . 44
What Makes an Airbag Inflate? . . . . . . . . . 42
What Will You See after an AirbagInflates? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
When Should an Airbag Inflate? . . . . . . . . 41
Where Are the Airbags? . . . . . . . . . . . . . . . . 40 Airbags
Adding Equipment to the Vehicle . . . . . . . 47
Passenger Status Indicator . . . . . . . . . . . . . . 84
Readiness Light . . . . . . . . . . . . . . . . . . . . . . . . . 83
Replacing System Parts after a
Crash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
Servicing Airbag-Equipped Vehicles . . . . . . 47
Alarm Vehicle Security . . . . . . . . . . . . . . . . . . . . . . . . 19
Alert Lane Change . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Rear Cross Traffic . . . . . . . . . . . . . . . . . . . . . . 188
Side Blind Zone (SBZA) . . . . . . . . . . . . . . . . . 193
All-Season Tires . . . . . . . . . . . . . . . . . . . . . . . . . . 235
AM-FM Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 115
Antenna Multi-band . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Antilock Brake System (ABS) . . . . . . . . . . . . . 168 Warning Light . . . . . . . . . . . . . . . . . . . . . . . . . . 86
Appearance Care Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262
Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 265
Apple CarPlay and Android Auto . . . . . . . . . 130
Armrest Rear Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Assistance Program, Roadside . . . . . . . . . . . . .281
Assistance Systems Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 188

Chevrolet BOLT EV Owner Manual (GMNA-Localizing-U.S./Canada-
16404388) - 2023 - CRC - 3/7/22
302 Index
Lights (cont'd)Antilock Brake System (ABS)
Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
Brake System Warning . . . . . . . . . . . . . . . . . 85
Charging System . . . . . . . . . . . . . . . . . . . . . . . 84
Cruise Control Light . . . . . . . . . . . . . . . . . . . . . 89
Door Ajar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Electric Parking Brake . . . . . . . . . . . . . . . . . . . 85
Gauges and Indicators . . . . . . . . . . . . . . . . . . 79
High-Beam On . . . . . . . . . . . . . . . . . . . . . . . . . . 89
Lane Keep Assist . . . . . . . . . . . . . . . . . . . . . . . . 86
One-Pedal Driving . . . . . . . . . . . . . . . . . . . . . . . 89
Seat Belt Reminders . . . . . . . . . . . . . . . . . . . . 82
Security . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88
Service Electric Parking Brake . . . . . . . . . . . 85
Service Vehicle Soon . . . . . . . . . . . . . . . . . . . . 85
Sport Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86
StabiliTrak OFF . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Tire Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88
Traction Control System (TCS)/StabiliTrak . . . . . . . . . . . . . . . . . . . . . . 88
Traction Off . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Vehicle Ready . . . . . . . . . . . . . . . . . . . . . . . . . . 88
Locks Automatic Door . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Delayed Locking . . . . . . . . . . . . . . . . . . . . . . . . . 17
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Lockout Protection . . . . . . . . . . . . . . . . . . . . . . . 17 Locks (cont'd)
Power Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Loss of Control . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Lower Anchors and Tethers for Children (LATCH System) . . . . . . . . . . . . . . . . .55
Lumbar Adjustment . . . . . . . . . . . . . . . . . . . . . . . 29
Front Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
M
MaintenanceAir Conditioning Regular Operation . . . . 149
Records . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 275
Maintenance Schedule . . . . . . . . . . . . . . . . . . . . 271 Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . . . . . . . . . . 273
Media
Avoiding Untrusted Devices . . . . . . . . . . . . . 118
Messages Propulsion Power . . . . . . . . . . . . . . . . . . . . . . 101
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Vehicle Speed . . . . . . . . . . . . . . . . . . . . . . . . . . 102
Mirrors Automatic Dimming Rearview . . . . . . . . . . 22
Convex . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Folding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Heated . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Interior Rearview . . . . . . . . . . . . . . . . . . . . . . . 22 Mirrors (cont'd)
Manual Rearview . . . . . . . . . . . . . . . . . . . . . . . 22
Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Mode Car Wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 165
Driver Selected . . . . . . . . . . . . . . . . . . . . . . . . 164
Monitor System, Tire Pressure . . . . . . . . . . . 240
Multi-band Antenna . . . . . . . . . . . . . . . . . . . . . . 118
Multi-Point Vehicle Inspection (MPVI) . . . . 272N
Navigation
Connected Services . . . . . . . . . . . . . . . . . . . . 294
New Vehicle Break-In . . . . . . . . . . . . . . . . . . . . . 161
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .81 Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Off-Road Recovery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Older Children, Restraints . . . . . . . . . . . . . . . . . 49
One-Pedal Driving . . . . . . . . . . . . . . . . . . . . . . . . 167
One-Pedal Driving Light . . . . . . . . . . . . . . . . . . . 89
Online Account . . . . . . . . . . . . . . . . . . . . . . . . . . 280
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 288 Additional Information . . . . . . . . . . . . . . . . . 290
Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 289
OnStar Emergency . . . . . . . . . . . . . . . . . . . . . . . 290
OnStar Security . . . . . . . . . . . . . . . . . . . . . . . . . . 290