transmission oil CHEVROLET C/K 1999 User Guide

Scheduled Maintenance
yellowblue
7-7
Long Trip/Highway Intervals -- Gasoline Engines
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every 12 months, whichever occurs first).
Chassis Lubrication (or every 12 months, whichever
occurs first). Drive Axle Service. Tire Rotation.
Every 15,000 Miles (25 000 km): Shields and
Underhood Insulation Inspection (GVWR above
10,000 lbs. only).
Every 30,000 Miles (50 000 km): Fuel Filter
Replacement. Front Wheel Bearing Repack (2WD
only) (or at each brake relining, whichever
occurs first).
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (vehicles over 8600 GVWR or
driven under severe conditions only).
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection. Fuel Tank, Cap and Lines
Inspection. Exhaust Gas Recirculation System
Inspection. Evaporative Control System Inspection.
Long Trip/Highway Intervals -- Gasoline Engines
Every 100,000 Miles (166 000 km): Spark Plug Wire
Inspection. Spark Plug Replacement. Automatic
Transmission Service (normal conditions). Positive
Crankcase Ventilation (PCV) Valve Inspection.
Every 150,000 Miles (240 000 km): Cooling System
Service (or every 60 months, whichever occurs first).
These intervals only summarize maintenance services.
Be sure to follow the complete scheduled maintenance
on the following pages.

Short Trip/City Scheduled Maintenance -- Gasoline Engines
yellowblue
7-18
50,000 Miles (83 000 km)

Change automatic transmission fluid and filter if the vehicle's GVWR is over
8600 lbs. or if the vehicle is mainly driven under one or more of these
conditions:
± In heavy city traffic where the outside temperature regularly reaches 90
F
(32
C) or higher.
± In hilly or mountainous terrain.
± When doing frequent trailer towing.
± Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and filter at 100,000 miles (166 000 km).
Manual transmission fluid doesn't require change.
51,000 Miles (85 000 km)
Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every 3 months, whichever occurs first).
(See footnote #.)
Check rear/front axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote **.)
ACTUAL
SERVICED BY:MILEAGE
DATE
ACTUAL
SERVICED BY:MILEAGE
DATE

Long Trip/Highway Scheduled Maintenance -- Gasoline Engines
yellowblue
7-30
The services shown in this schedule up to 100,000 miles
(166 000 km) should be performed after 100,000 miles
(166 000 km) at the same intervals. The services shown
at 150,000 miles (240 000 km) should be performed at
the same interval after 150,000 miles (240 000 km).
See ªOwner Checks and Servicesº and ªPeriodic
Maintenance Inspectionsº following.
Footnotes
 The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle's useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
# Lubricate the front suspension, kingpin bushings,
steering linkage, transmission shift linkage, transfer case
shift linkage, parking brake cable guides, rear drivelinecenter splines, front axle propshaft spline and brake
pedal springs. Ball joints and kingpin bushings should
not be lubricated unless their temperature is 10F
(
-12C) or higher, or they could be damaged.
+ A good time to check your brakes is during tire
rotation. See ªBrake System Inspectionº under ªPeriodic
Maintenance Inspectionsº in Part C of this schedule.
** Drive axle service (see ªRecommended Fluids and
Lubricantsº in the Index for proper lubricant to use):

Check fluid level and add fluid as needed.

If your vehicle has a locking differential, drain fluid
and refill at first engine oil change.

3500 HD Models with applications requiring
high
-speed (above 45 mph or 70 km/h) operation for
extended periods of time must have the drive axle
fluid changed every 30,000 miles (50 000 km).

Long Trip/Highway Scheduled Maintenance -- Gasoline Engines
yellowblue
7-34
45,000 Miles (75 000 km)

Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.

Lubricate chassis components (or every 12 months, whichever occurs first).
(See footnote #.)

Check rear/front axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote **.)

Vehicles With GVWR Above 10,000 lbs. Only: Inspect shields and underhood
insulation for damage or looseness. Adjust or replace as required. This is a
Noise Emission Control Service. Applicable only to vehicles sold in the
United States.

Rotate tires. See ªTire Inspection and Rotationº in the Index for proper
rotation pattern and additional information. (See footnote +.)
50,000 Miles (83 000 km)

Change automatic transmission fluid and filter if the vehicle's GVWR is over
8600 lbs. or if the vehicle is mainly driven under one or more of these conditions:
± In heavy city traffic where the outside temperature regularly reaches
90
F (32
C) or higher.
± In hilly or mountainous terrain.
± When doing frequent trailer towing.
± Uses such as found in taxi, police or delivery service.
ACTUAL
SERVICED BY:MILEAGE
DATE
ACTUAL
SERVICED BY:MILEAGE
DATE

Long Trip/Highway Scheduled Maintenance -- Gasoline Engines
yellowblue
7-35
If you do not use your vehicle under any of these conditions, change the fluid
and filter at 100,000 miles (166 000 km).
Manual transmission fluid doesn't require change.
52,500 Miles (87 500 km)

Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.

Lubricate chassis components (or every 12 months, whichever occurs first).
(See footnote #.)

Check rear/front axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote **.)

Rotate tires. See ªTire Inspection and Rotationº in the Index for proper
rotation pattern and additional information. (See footnote +.)
60,000 Miles (100 000 km)

Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service.

Lubricate chassis components (or every 12 months, whichever occurs first).
(See footnote #.)

Check rear/front axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote **.)
(Continued)
ACTUAL
SERVICED BY:MILEAGE
DATE
ACTUAL
SERVICED BY:MILEAGE
DATE

yellowblue
7-42 At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly. Look for any other loose or damaged
safety belt system parts. If you see anything that might
keep a safety belt system from doing its job, have it
repaired. Have any torn or frayed safety belts replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag system
does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace blade
inserts that appear worn or damaged or that streak or
miss areas of the windshield. Also see ªWiper Blades,
Cleaningº in the Index.
Air Cleaner Filter Restriction Indicator Check
Your vehicle has an indicator located on the air cleaner in
the engine compartment that lets you know when the air
cleaner filter is dirty and needs to be changed. Check
indicator at least twice a year or when your oil is changed,
whichever occurs first. See ªAir Cleanerº in the Index for more information.
Inspect your air cleaner filter restriction indicator more
often if the vehicle is used in dusty areas or under off
road conditions.
Weatherstrip Lubrication
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with a clean cloth. During very cold,
damp weather more frequent application may be
required. (See ªRecommended Fluids and Lubricantsº in
the Index.)
Manual Transmission Check
Check the transmission fluid level; add if needed. See
ªManual Transmission Fluidº in the Index. Check for
leaks. A fluid loss may indicate a problem. Have the
system inspected and repaired if needed.
Automatic Transmission Check
Check the transmission fluid level; add if needed. See
ªAutomatic Transmission Fluidº in the Index. A fluid
loss may indicate a problem. Check the system and
repair if needed.

yellowblue
7-48
Part D: Recommended Fluids
and Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from
your dealer.
USAGE
FLUID/LUBRICANT
Engine Oil
(Gasoline
Engine)Engine Oil with the American
Petroleum Institute Certified For
Gasoline Engines ªStarburstº
symbol of the proper viscosity. To
determine the preferred viscosity
for your vehicle's engine, see
ªEngine Oilº in the Index.
Engine Coolant50/50 mixture of clean, drinkable
water and use only GM
Goodwrench

DEX-COOL
or
Havoline
DEX-COOL

Coolant. See ªEngine Coolantº in
the Index.
Hydraulic Brake
SystemDelco Supreme 11
Brake Fluid
(GM Part No. 12377967 or
equivalent DOT
-3 Brake Fluid).
USAGEFLUID/LUBRICANT
Windshield
Washer SolventGM Optikleen
Washer Solvent
(GM Part No. 1051515)
or equivalent.
Hydraulic Clutch
SystemHydraulic Clutch Fluid (GM Part
No. 12345347 or equivalent
DOT
-3 Brake Fluid).
Parking Brake
Cable GuidesChassis Lubricant (GM Part
No. 12377985 or equivalent) or
lubricant meeting requirements of
NLGI # 2, Category LB or
GC
-LB.
Power Steering
SystemGM Power Steering Fluid (GM
Part No. 1052884
- 1 pint,
1050017
- 1 quart, or equivalent).
Manual
Transmission
(5
-Speed with
Low Gear, RPO
MW3)
GM Goodwrench Synthetic
Manual Transmission Fluid (GM
Part No. 12346190
- 1 qt.) or
equivalent SAE 75W
-90 GL-4
Gear Oil.

yellowblue
9-5
Gages
Engine Coolant Temperature 2-69 . . . . . . . . . . . . . . . . . . . .
Engine Oil Pressure 2-72 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel 2-75 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Speedometer 2-63 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tachometer 2-63 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Voltmeter 2-67 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Garage Door Opener 2-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GAWR 4-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Gear Positions, Automatic Transmission 2-16 . . . . . . . . . . . . .
Gear Positions, Manual Transmission 2-19, 2-20 . . . . . . . . . .
Glove Box 2-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GM Mobility Program for Persons with Disabilities 8-5 . . . . .
GM Vehicle Care/Appearance Materials 6-68 . . . . . . . . . . . . .
Gross Axle Weight Rating 4-43 . . . . . . . . . . . . . . . . . . . . . . . .
Gross Vehicle Weight Rating 4-43 . . . . . . . . . . . . . . . . . . . . . .
Guide en Fran†ais ii. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
GVWR 4
-43 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Halogen Bulbs 6-39 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hazard Warning Flashers 5-2 . . . . . . . . . . . . . . . . . . . . . . . . . .
Head Restraints 1-5 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Headlamps 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Bulb Replacement 6-39, 6-40 . . . . . . . . . . . . . . . . . . . . . . .
High/Low Beam Changer 2-36 . . . . . . . . . . . . . . . . . . . . . .
On Reminder 2-41 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Wiring 6-70 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hearing Impaired, Customer Assistance 8-4 . . . . . . . . . . . . . .
Heating 3-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
High-Beam Headlamps 2-36 . . . . . . . . . . . . . . . . . . . . . . . . . .
Highway Hypnosis 4-33 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Hill and Mountain Roads 4
-34 . . . . . . . . . . . . . . . . . . . . . . . . .
Hitches, Trailer 4-55 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hood
Checking Things Under 6
-8 . . . . . . . . . . . . . . . . . . . . . . . . .
Release 6-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Horn 2-35 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Clutch Fluid 6-24, 7-48 . . . . . . . . . . . . . . . . . . . . . .
Hydraulic Clutch System Check 7-42 . . . . . . . . . . . . . . . . . . .
Hydroplaning 4-30 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Positions 2-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Ignition Transmission Lock Check 7-44 . . . . . . . . . . . . . . . . .
Illuminated Entry 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inflation, Tire 6-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Inside Day/Night Rearview Mirror 2-44 . . . . . . . . . . . . . . . . .
Inspections 7-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake System 7-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Drive Axle 7-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Systems 7-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Radiator and Heater Hose 7-46 . . . . . . . . . . . . . . . . . . . . . .
Steering 7-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Suspension 7-46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Linkage 7-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Transfer Case (Four-Wheel Drive) 7-47 . . . . . . . . . . . . . . .
Instrument Panel 2-60 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cleaning 6-63 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cluster 2-62 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse Block 6-71 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Intensity Control 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Interior Lamps 2-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

yellowblue
9-7
Maintenance, Underbody 6-67 . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance When Trailer Towing 4-59 . . . . . . . . . . . . . . . . .
Malfunction Indicator Lamp 2-70 . . . . . . . . . . . . . . . . . . . . . .
Manual Front Seat 1-2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Mirror 2-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Transmission
Check 7
-42 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fluid 6-23, 7-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Shifting 2-19, 2-20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Starting Your Engine 2-13 . . . . . . . . . . . . . . . . . . . . . . . . . .
Manual Windows 2-32 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Memo Pad Holder 2-54, 2-56 . . . . . . . . . . . . . . . . . . . . . . . . .
Methanol 6-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mirrors 2-44 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Camper-Type 2-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Convex Outside 2-50 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Electrochromic Day/Night Rearview 2-45 . . . . . . . . . . . . . .
Inside Day/Night Rearview 2-44 . . . . . . . . . . . . . . . . . . . . .
Manual 2-47 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Power Remote Control 2-50 . . . . . . . . . . . . . . . . . . . . . . . . .
West Coast Type 2-49 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
MMT 6-4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Model Reference vi. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mountain Roads 4
-34 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
New Vehicle Break-In 2-10 . . . . . . . . . . . . . . . . . . . . . . . . . .
Night Vision 4-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Noise Control System 6-12 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Normal Maintenance, Normal Replacement Parts 6-78 . . . . . .
Odometer 2-63 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Odometer, Trip 2-63 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Driving 4-14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Off-Road Recovery 4-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Oil, Engine 6-13, 7-48 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Opener, Garage Door 2-51 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating Engine 5-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Owner Checks and Services 7-41 . . . . . . . . . . . . . . . . . . . . . . .
Owner Publications, Ordering 8-12, 8-13 . . . . . . . . . . . . . . . .
Paint Spotting, Chemical 6-67 . . . . . . . . . . . . . . . . . . . . . . . .
Park, Shifting Into 2-27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Park, Shifting Out of 2-29 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Parking
At Night 2
-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake 2-25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Mechanism Check 7-45 . . . . . . . . . . . . . . . . . . . . . . .
Lots 2-9 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Over Things That Burn 2-30 . . . . . . . . . . . . . . . . . . . . . . . .
With a Trailer 4-58 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Your Vehicle, Manual Transmission 2-30 . . . . . . . . . . . . . .
Passenger Position 1-23 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passing 4-11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Passlock
2-10, 2-73 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Periodic Maintenance Inspections 7-46 . . . . . . . . . . . . . . . . . .
Pickup Box Identification Lamp Bulb Replacement 6-46 . . . .
Pickup Conversion to Chassis Cab 4-48 . . . . . . . . . . . . . . . . .