radiator CHEVROLET CAMARO 1993 User Guide

What to Use:
Use a mixture of one-half clean water
(preferably distilled) and one-half
antifreeze that meets
“GM Specification
1825M,” which won’t damage aluminum
parts. You can also use a recycled coolant
conforming to
GM Specification 1825M
with a complete coolant flush and refill.
If you use this mixture, you don’t need to
add anything else.
Adding only plain water to
- b your coding system can be
dangerous. Plain water, or some
other liquid like alcohol, can boil
before the proper coolant mix will.
Your vehicle’s coolant warning
system is set for the proper coolant I
mix. With plain water or the wrong
mix, your engine could get too hot
but you wouldn’t get the overheat
warning. Your
engine could catch
fire and YOU or others could be
burned. Use a 50/50 mix of clean
water and a proper antifreeze.
--
I If you use an improper coolant mix,
your engine could overheat and be
badly damaged. The repair cost
wouldn’t be covered by your
warranty.
Too much water in 1-
mix can freeze and crack the engine,
radiator, heater core and other parts.
239
ProCarManuals.com

Service & Appearance Care
1
Adding Coolant
To Check Coolant: When your engine is
cold, check the dipstick on the cap of the
coolant recovery tank. The coolant level
should be at
FULL COLD, or a little
higher. When your engine is warm, the
level on the dipstick should be up to
FULL HOT, or a little higher.
If you have the 5.7L LTl (Code P) engine
and this light comes on,
it means you’re
low on engine coolant.
To Add Coolant to the Recovery Tank:
If you need more coolant, add the proper
mix
at the coolant recovery tank, but
only when your engine
is cool. If the tank
is very low or empty, also add coolant to
the radiator. See “Engine Overheating” in
the Index.
9 240
ProCarManuals.com

Turning the radiator pressure
L cap when the engine and
radiator
are hot can allow steam and
scalding liquids to blow out and
burn you badly. Never turn the
pressure
cap - even a little -
when the engine and radiator are
,dd coolant mix at the recovery tank, but
e careful not to spill it.
CA U TION:
I
I
You can be burned if you spill
coolant on hot engine parts.
Coolant contains ethylene glycol,
and it will burn
if the engine parts
are hot enough. Don’t spill coolant
on a hot engine.
Radiator Pressure Cap (All Engines)
~ NOTICE:
Your radiator cap is a 18 psi
(124 kPa) pressure-type cap and
must be tightly installed to prevent
coolant loss and possible engine
damage from overheating. Be sure
the arrows on the cap line
up with
the ovefflow tube on the radiator
filler neck.
ProCarManuals.com

Service & Appearance Care
When you replace your radiator pressure
cap. an
AC3 cap is recommended.
Thermostat
Engine coolant temperature is controlled
by a thermostat in the engine coolant
system. The thermostat stops the flow
of
coolant through the radiator until the
coolant reaches a preset temperature.
When you replace
your thermostat, an
AC@ thermostat is recommended.
3.4L L32 (Code S)
Power Steering Fluid
How to Check Power Steering Fluid:
Unscrew the cap and wipe the dipstick
with a clean rag. Replace the cap and
completely tighten
it. Then remove the
cap again and look at the fluid level
on
the dipstick.
ProCarManuals.com

Service & Appearance Care
When using concentrated washer fluid, follow the
manufacturer’s instructions fo
adding water.
ready-to-use washer id.
Water can cause the solution
tc
freeze and damage your washer fluid tank and other
parts
of the washer system.
Also, water doesn’t clean a,
well as washer fluid.
0 Fill your washer fluid tank
only 314 full when it’s very
cold. This allows for
expansion, which could
damage the
tank if it is
completely full.
0 Don’t use radiator antifreeze ir
your windshield washer. It can
damage your washer systen
and pz
Don’t mix water with
- = - 244
Brake Master Cylinder
Your brake master cylinder is here. It is
filled
with DOT-3 brake fluid.
There are
only two reasons why the brake
fluid level
in your master cylinder might
go down. The first is that the brake fluid
goes down to an acceptable level during
normal brake lining wear. When new
linings are put
in, the fluid level goes
back up. The other reason is that fluid is
leaking out of
the brake system. If it is,
you should have your brake system fixed,
since a leak means that sooner or later
your brakes won’t work well, or won’t
work at all.
So, it isn’t a good idea to “top off’ your
brake fluid. Adding brake fluid won’t
correct a leak. If you add fluid when your
linings are worn, then you’ll have
too
much fluid when you get new brake
linings. You should add (or remove)
brake fluid, as necessary, only when work
is done on the brake hydraulic system.
ProCarManuals.com

Replacement Parts
Air Cleaner Filter . . . . . . . . . . . . . . . . . . . . . . . , . . . . . . . . . . . . . . . . . . . . . . A1 163C
Battery
........................................................ 75-60
Engine Oil Filter VINEngineCodeS
............................................. PF47
VINEngineCodeP
............................................. PF25
FuelFilter
...................................................... GF578
PCV Valve
VINEndingeCodeS
......................................... CV789C
VIN Engine Code
P . . . . . . . . . . . . . , , . . . . . . . . . . . . . . . . . . . . . . . . . . . CV895C
Radiatorcap
................................................... RC24
Spark Plug VIN Engine Code
S . . . . . . . . . . , . . . . . . . . . . . . . . . . . . . oR43TSK (0.045 ” Gap)
VIN Engine
Code P . . . . . . . , . . , . . . . . . . . . . . . . , . . . . oR45LTSP (0.050” Gap)
Thermostat Temperature Specification
. . . . . . . . . . . . . . . . . . . . . . . . . 180°F (82°C)
Wheel Nuts
Wheel Nut Torque . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . , . . 100 lb. ft. (140 Nom)
281 =
ProCarManuals.com

ITEM
NO. SERVICE
5 Cooling System Service* - Drain, flush and refill
the system with new or approved recycled coolant
conforming to
GM Specification 1825M. Keep
coolant at the proper mixture as specified. See
“Coolant”
in the Index. This provides proper freeze
protection, corrosion inhibitor level and engine
operating temperature.
*An Emission Control Service.
ITEM
NO. SERVICE
Inspect hoses and replace if they are cracked,
swollen or deteriorated. Tighten screw-type hose
clamps. Clean the outside of the radiator and air
conditioning condenser. Wash the pressure cap and
neck.
To help ensure proper operation, we recommend a
pressure test
of both the cooling system and the
pressure cap.
295
ProCarManuals.com

... 332
Controls
Air Conditioner .............. 11 2
Brightness .................. 85
comfort .................... 110
Cruise ...................... 80
Features and ................. 47
Heater ...................... 110
Main Light .................. 85
Seats and Seat ............... 12
Adding .................... 240
Engine .................... 238
Recovery Tank ............ 197
Radiator ............. 199. 201
Temperature Gage. Engine ..... 102
Coolant
How to Add to the Coolant
How to Add to the Cooling
....................... 113
Cooling System ............... 195
Courtesy Lights ................ 86
Cruise Control ................. 80
Passing Another Vehicle
While Using
............... 83
To Erase Speed Memory ....... 84
To Get Out of ................ 84
To Increase Speed While
Using
.................... 82
To Reduce Speed While
Using
.................... 83
To Resume a Set Speed ........ 81
ToSet ...................... 81
Using on Hills ............... 83
Curves. Driving on ............. 146
Customer Assistance
Information
................ 313
Customer Satisfaction Procedure . . 314
Daytime Running Lights ........ 85
Deep Snow. If You’re
Stuck in
................... 173
Deep Standing Water. Driving through
.............. 61
Defects. Safety Reporting to General Motors
... 319
Reporting to the Canadian Government
.............. 318
Reporting to the United States Government
......... 318
Defensive Driving ............. 136
Defogger. Rear Window ......... 114
ProCarManuals.com

Gages Engine Coolant Temperature
... 102
Engine Oil Pressure .......... 104
Fuel ...................... 100
Warning Lights and Indicators ... 99
Gasolines for Cleaner Air ....... 221
Glass ........................ 269
Glove Box .................... 92
GM Participation in Better ...........
Business Bureau Mediation/
Arbitration Program
........ 3 16
Halogen Bulbs ............... 247
Hatch Release .................. 51
Hatch Release. Remote .......... 51
Hazard Warning Flashers ........ 184
Head Restraints ................ 14
Headlight Aiming .............. 248
Headlight Highbow Beam ....... 78
Heater Controls ................ 110
Heater. Engine Block ............ 61
Heating ....................... 11 1
Heating. Bi-Level ............... 111
High Beams .................. 154
Highway Hypnosis ............. 164
Hill and Mountain Roads ........ 165
Hills. Parking on .............. 168
Hitches ...................... 176
Hood Release ................. 223
Hood. Checking Things
under the
................... 223
Hook-Ups Front Towing ........ 19 1
Hook-Ups. Rear Towing ........ 192
Horn ......................... 76
How to Add Coolant to the
Coolant Recovery Tank
....... 197
How to Add Coolant to the
Radiator
............... 199. 201
Hydraulic Clutch .............. 237
Hydroplaning ................. 157
Hypnosis. Highway ............ 164
Identification Number.
Vehicle
.................... 275
If a Tire Goes Flat ............. 204
If You’re Stuck in Deep
Snow
..................... 173
If You’re Stuck: In Sand.
Mud. Ice or Snow ............ 215
Ignition Switch ................. 55
Inflatable Restraint. Supplemental . . 25
335 . .
ProCarManuals.com

Index
P (Park) Shifting into ........... 71
P (Park), Shifting out of .......... 72
Paint
Chemical Spotting
........... 273
Finish Care ................. 271
Finish Damage .............. 273
Foreign Material ............. 272
Brake ...................... 70
Downhill .................. 168
On Hills ................... 168
On Hills (with a Trailer) ....... 180
Over Things That Burn ........ 74
Uphill ..................... 168
Your Vehicle
................. 73
Parking
9 9 9 338
PASS-Key II@ ................. 53
Passenger Position (Safety Belts) . . 32
Rear Seat ................... 32
Right Front .................. 32
Passing ...................... 149
Passing (with a Trailer) ......... 178
Pavement Markings ............ 135
Pedal Travel, Brake ............ 146
Periodic Maintenance
Inspections
................. 303
Power Door Locks
.................. 51
Seat, Six-way
................ 13
Steering ................... 146
Steering Fluid ............... 242
Windows ................... 76
Pregnancy, Safety Belt Use
during
...................... 31
Problems on the Road .......... 183
Publications, Service ........... 320
Questions Many People Ask about
Safety Belts
- and the Answers,
Here are
.................. 19
Radiator Pressure Cap ......... 241
Radio Reception Understanding . . 127
Radio, To Play the
AM/FM Stereo with Cassette
Tape Player
................ 1 17
Delco-Base@ AM/FM Stereo
with Compact Disc Player
..... 121
Rain, Driving in the ............ 155
ProCarManuals.com