differential CHEVROLET CAMARO 1994 4.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine Hydraulic Clutch
The hydraulic clutch in your vehicle is
self-adjusting. The clutch master cylinder
reservoir is filled with hydraulic clutch
fluid.
It isn’t a good idea to “top off’ your
clutch fluid. Adding fluid won’t correct a
leak.
A fluid loss in this system could indicate
a problem. Have the system inspected and
repaired.
When to Check and What to Use:
Refer to the Maintenance Schedule to
determine how often you should check
the fluid level
in your clutch master
cylinder reservoir and for the proper fluid.
See “Owner Checks and Services” and
“Recommended Fluids and Lubricants”
in the Index.
How to Check:
The proper fluid should be added if the
level is below the
“STEP” mark on the
reservoir. See the instructions on the
reservoir cap.
Rear Axle
When to Check and Change Lubricant:
Refer to the Maintenance Schedule to
determine how often to check the
lubricant and when
to change it. See
“Periodic Maintenance Inspections’’
in
the Index.
How to Check Lubricant:
If the level is below the bottom of the
filler plug hole, you’ll need to add some
lubricant. Add enough lubricant to raise
the level to the bottom of the filler plug
hole.
What to Use
Standard Differential
Use Axle Lubricant (GM Part No.
105227 1 ) or SAE 80W-90 GL-5 gear
lubricant.
Limited-Slip Differential
To add lubricant when the level is low,
use Axle Lubricant (GM Part
No.
105227 1 ) or SAE 80W-90 GL-5 gear
lubricant. To completely refill after
draining, add
4 ounces (1 18 ml) of
Limited-Slip Differential Additive
(GM Part No. 1052358). Then fill to the
bottom of the filler plug hole with Axle
Lubricant (GM Part
No. 12345977) or
SAE 80W-90 GL-5 gear lubricant.
197 ...

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services
Schedule 1
MAINLY driven under one or more of
the following conditions:
When most trips are less than 4 miles
(6 km).
When most trips are less than 10 miles
(16 km) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as
in stop-and-go traffic.
When towing a trailer.
0 When operating in dusty areas.
Schedule
I should also be followed if the
vehicle is used for deliverv service, police,
taxi or other commercial applications.
* An Emission Control Service.
=t The U.S. En\sironmental Protection Agency
or the California Air Resources Board has
determined that the failure to pellform this
maintemnce item will not
nullifi. the emission
warranty
or limit recall liability prior to the
cvmpletion
cf vehicle usejul life. General
Motors, however, urges rhat all rec.*ornmended
maintenance services
he performed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance Record.”
ITEM NO.
-
1
2
3
4
5
6
7
8 -
9
10
11
WHAT TO SERVICE
See “E,rplanation of Scheduled
Maintenunce Servicae.s”
jullowing
Schedules I and 11.
Engine Oil & Oil Filter Change*
Chassis Lubrication
Tire and Wheel Rotation
& Inspection
Engine Accessory Drive Belt(s) Inspection*
Cooling System Service”
Transmission Service Spark Plug Replacement
(3.4L L32 (Code
S) Engine)*
Spark Plug Replacement
(5.7L LTI (Code P) Engine)*
Spark Plug Wire Inspection*+
Air Cleaner Filter Replacement*
Fuel Tank, Cap & Lines Inspection*?
Rear Axle Fluid Change
(For Vehicles
Towing Trailers
or for Vehicles with
Limited-Slip Differentials)
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occursfirst).
Every 3.000 miles (5 000 km) or 3 months.
Every other oil chenge.
At 6,000 miles (10 000 km) and every
15,000 miles (25 000 km) or as necessary.
Every 30,000 miles (50
000 km) or 24 months.
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Every 30,000 miles (50 000 km).
Every 100,000 miles ( 166 000 km).
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and II.
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
. . .240

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (cont.)
Schedule 11
Follow Schedule I1 ONLY if none of
Jhe driving: conditions specified in
Schedule I appl~
* An Emission Contsol Ses\:icc.
il- The US. Envisonmental Psotection Agency
os the Calijosrtia Ais Resousces Bousd has
detesmined that
the failuse to pesfosm this
maintenance item will not nullib the emissiott
warsanty
or limit secall liability psios to the
completion of whicle useful life. Genesal
Motoss, howews, urges that all sccommended
maintenance semices
be pesformed at the
indicated inten*als and
rhe maintenance he
secorded in “Section E: Maintenance Record.”
ITEM NO.
1
-
2
3
-
4
5
6
-
-
-
7
-
8
9
-
10
11
WHAT TO SERVICE
“E.vplanutiol? c?fSd~eduleci
Mairztetzuncx~ Ses\.ic*es‘’ fhllolz*itlg
Schedules I Ulld !I.
Engine Oil Change”
Oil Filter Change*
Chassis Lubrication
Tire and Wheel Rotation
& Inspection
Engine Accessory Drive Belt(s) Inspection”
Cooling System Service”
Transmission Service Spark Plug Replacement
(3.4L L32 (Code S) Engine)”
Spark Plug Replacement
(5.7L LTI (Code P) Engine)*
Spark
Plug Wire Inspection”?
Air Cleaner Filter Replacement”
Fuel Tank, Cap & Lines Inspection’k+
Rear Axle Fluid Change (For Vehicles
with Limited-Slip Differentials) Every
7,500 miles (1 2 500
km) or 12 months.
At first and then every other oil chqnge.
Every 7,500 miles
( 12 SO0 km) or 12 months.
At 7.500 miles (1 2 SO0 km) and then every
15.000 miles
(25 000 km) or as necessary.
Every 30.000 miles
(50 000 km) or 24 months.
See “Explanation of Scheduled Maintenance
Services“ following Schedules
I and 11.
Every 30,000 miles (SO 000 km).
Every IOO.OOO miles ( 166 000 km).
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Every 30.000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” lollowing Schedules
I and 11.
. . .242

Downloaded from www.Manualslib.com manuals search engine ITEM
NO. SERVICE
6 Transmission Service - For
manual transmissions, fluid
doesn’t require changing. See “Periodic Maintenance
Inspections.”
For automatic transmissions, change both
the fluid and filter
every 15,000 miles (25
000 km)
if the vehicle is mainly driven
under one or more of these
conditions:
In heavy city traffic where the
outside temperature regularly
reaches
90°F (32°C) or
higher.
In hilly or mountainous
terrain.
When doing frequent trailer
towing.
Uses such as found in taxi,
police car or delivery service.
If
you do not use your vehicle
under any
of these conditions,
change both
the fluid and
filter every
100,000 miles
(166 000 km).
ITEM
NO.
7
8
9
10
SERVICE
Spark Plug Replacement* -
Replace spark plugs with the
proper type. See “Replacement
Parts” in the Index.
Spark Plug Wire Inspection*?
-
Inspect for burns, cracks or other
damage. Check the boot
fit at the
distributor and at the spark plugs.
Replace wires as needed.
Air Cleaner Filter Replacement*
- Replace every 30,000 miles
(50 000 km) or more often under
dusty conditions. Ask your
dealer for the proper replacement
intervals for your driving
conditions.
Fuel Tank. Cap and Lines
Inspection”?
- Inspect fuel tank,
cap and lines (including fuel rails
and injection assembly) for
damage or leaks. Inspect fuel cap
gasket for an even filler neck
imprint or any damage. Replace
parts as needed. Periodic
replacement of the fuel filter is
not required.
ITEM
NO. SERVICE
11 Rear Axle Fluid Change - If your
vehicle is used to pull
a trailer,
have the rear axle gear lubricant
changed every
7,500 miles
(12
500 km).
If your vehicle is not used
to pull
a trailer, but has a limited-slip
differential, have the rear axle
gear lubricant changed once after
the first
7,500 miles (12 500 km).
* An Emission Control Service.
t The US. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to pegorm this
maintenance item will not nullify the emission
warranty or limit recall liability prior to the
completion of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance Record.”
245.. .

Downloaded from www.Manualslib.com manuals search engine USAGE FLUID/LUBRICANT
Floor
Shift Linkage
Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
Chassis Lubrication Engine oil.
NLGI Grade 2, Category LB or GC-LB.
Rear Axle
(Standard Differential)
I
Axle Lubricant (GM Part No. 1052271) or SAE SOW-90 GL-5 Gear Lubricant.
I
Rear Axle (Limited- I Axle Lubricant (GM Part No. 12345977) or SAE 80W-90 GL-5 Gear Lubricant, and Limited-
Slip Differential) Slip Differential.Lubricant
Additive (GM Part
No. 1052358 or equivalent) where required. See
“Rear Axle”
in the Index. I
Maintenance Schedule
Section D: Recommended Fluids & Lubricants (Cont.)
Windshield Washer GM Optikleen’ Washer Solvent
(GM Part No. 1051515 or equivalent).
Solvent
I
Hood Latch Assembly
a. Pivots and Spring
b. Release Pawl
Anchor
1
~~
a.
Engine oil.
b. Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
Hood and Door
Hinges, Rear Folding
Seat, Fuel Door Hinge,
Rear Compartment
Lid Hinges NLGI
Grade
2, Category LB or GC-LB.
Engine oil
or Lubriplate Lubricant (GM Part No. 1050109).
~
Weatherstrips I Dielectric Silicone Grease (GM Part No. 12345579 or equivalent).
See “Replacement Parts”
in the Index for recomme’nded replacement filters, valves and spark plugs.
. . .252