engine overheat CHEVROLET CAVALIER 1995 3.G User Guide

Downloaded from www.Manualslib.com manuals search engine When to Check and What to Use
Refer to the Maintenance
Schedule to determine
how often you should
check the fluid level in
your clutch master
cylinder reservoir and
for the proper fluid. See
“Owner Checks and
Services” and
“Recommended Fluids
and Lubricants” in the
Index.
How to Check
You do not need to check the fluid level unless you
suspect a clutch problem. To check the fluid level, take
the cap
off. If the fluid reaches the step inside the
reservoir, the fluid level
is correct.
Engine Coolant
The following explains your cooling system and how to
add coolant when it is low.
If you have a problem with
engine overheating, see “Engine Overheating” in the
Index.
The proper
coolant for your Chevrolet will:
0 Give freezing protection down to -34°F (-37°C).
Give boiling protection up to 262°F (128°C).
Protect against rust and corrosion.
0 Help keep the proper engine temperature.
0 Let the warning lights work as they should.
6-21

Downloaded from www.Manualslib.com manuals search engine What to Use
Use a mixture of one-half clcn11 w:akr (preferably
distilled)
and one-half antifreeze that meets “GM
Specification 1825-M,” which won’t damage aluminum
parts.
You can also use a recycled coolant conforming to
GM Specification 1825-M with a complete coolant tllrsh
and refill. Use
GM Engine Coolant Supplement (sealer)
with any complete coolant flush and refill. If ~OLI use
this mixture, you don’t need to add anything else.
I NOTICE:
, If you use an improper coolant mix, your engine
could overheat and be badly damaged. The
repair cost wouldn’t be covered by your
warranty. Too much water in the
mix can freeze
and crack the engine, radiator, heater core and
other parts.
Adding Coolant
6-22

Downloaded from www.Manualslib.com manuals search engine To Check Coolant To Add Coolant
If you need more coolant, add the proper mix at the
surge tank, but only when the engine is cool.
When your engine is cold, the coolant level should be at
the FULL
COLD mark.
See “Low Coolant Light”
in
the Index. When replacing
the pressure
cap, make sure it is tight.
Surge Tank Pressure Cap
NOTICE:
Your surge tank cap is a 18 psi (124 kPa)
pressure-type cap and must be tightly installed to
prevent coolant loss and possible engine damage
from overheating.
If this light comes on, it means you’re low on engine
coolant. When
you replace your surge tank pressure cap, a GM
cap is recommended.

Downloaded from www.Manualslib.com manuals search engine I 1
Under Hood Fuse Block
Fuse
AIC
ABS
ABS
BATT 1
BATT 2
BLO
COOLING FAN
GEN
IGN
PCM
Circuitry
A/C Compressor (2.3L Engine)
Anti-Lock Brake System
Electronic Variable Orifice Steering,
Anti-Lock Brake System
Power ACC/Stop
Lamp Circuits
Lighting Circuits
Heater/ A/C Blower
Engine Cooling Fan
Generator-Voltage Sense
Ignition Switch Circuits
Powertrain Control Module
Headlamp Wiring
The headlamp wiring is protected by a circuit breaker.
An electrical overload will cause the lamps to go on and
off, or
in some cases to remain off. If this happens, have
your headlamp system checked right away.
Windshield Wipers
The windshield wiper motor is protected by a circuit
breaker and a fuse.
If the motor overheats due to heavy
snow, etc., the wiper will stop until the motor cools. If
the overload is caused by some electrical problem, have
it fixed.
Power Windows and Other Power Options
Circuit breakers in the fuse panel protect the power
windows and other power accessories. When the current
load is too heavy, the circuit breaker
opens and closes,
protecting the circuit
until the problem is fixed.

Downloaded from www.Manualslib.com manuals search engine Driver Position ................................. 1 - 10
Driver’s Seat Manual Lumbar Support ............... 1-2
Driving
AtNight
................................... 4-13
City ....................................... 4-17
Defensive
................................... 4-1
Drunken
.................................... 4-2
Freeway
................................... 4- I8
In a Blizzard
................................ 4-24
In Foreign Countries ........................... 6-4
In the Rain ................................. 4- 14
OnCurves
................................... 4-8
OnGrades
.................................. 4-35
On Hill and Mountain Roads
................... 4-20
On Snow and Ice
............................. 4-23
Through Deep Standing Water
.................. 2- I2
Winter
..................................... 4-22
With
a Trailer ............................... 4-34
DrunkenDriving
................................ 4-2
Easy Entry Seat
................................ 1-4
Electrical Equipment. Adding ................ 3- 12. 6-5 1
Engine .................................... 6-8. 6-9
Enginecoolant ................................. 6-21
Adding
............................... 5-16. 6-22
Checking
................................... 6-23
Engine Coolant Heater
...................... 2- 12. 6. 14
Engine Coolant Temperature Gage
................. 2-64
Engine Identification
............................ 6-5 1
Engineoil .................................... 6-10
Adding
.................................... 6-11
Additives ................................... 6-14
EngineExhaust
................................ 2-25 Checking
................................... 6-10
What Kind
to Use ............................ 6-12
What
to do With Used Oil ..................... 6-14
Whentochange
............................. 6-14
Engine Overheating ............................. 5-12
Engine, Running It While Your Parked .............. 2-26
Engine, Specifications
........................... 6-57
Engine, Starting Your
............................ 2-10
Ethanol (In Fuel) ................................ 6-3
Exhaust. Engine
................................ 2-25
Fabric Cleaning
............................... 6-43
Fifth Gear. Manual Transaxle
..................... 2-19
FillingYourTank
................................ 6-4
Filter. Air Cleaner .............................. 6-15
Filter, Engine Oil
............................... 6-14
Finish Care .................................... 6-46
Finish Damage
................................. 6-48
First ( 1 ), 3 Speed Automatic Transaxle .............. 2-16
First (1 ), 4 Speed Automatic Transaxle .............. 2-18
First Gear, Manual Transaxle
...................... 2-19
Flash-to-Pass Feature ........................... 2-30
Flashers. Hazard Warning
......................... 5-1
Flat Tire, Changing ............................. 5-20
Fluids and Lubricants
....................... 6-55, 7-43
FogLamps
.................................... 2-40
Fold-Down Rear Seat
............................ 1-5
Foreign Countries. Fuel ........................... 6-4
Fourth Gear. Manual Transaxle
.................... 2-19
French Language Manual
11
Front Reading Lamps ............................ 2-40
Front Seatback Latches
........................... 1-4
.. ...........................
FrontTowing ................................... 5-9
9-4

Downloaded from www.Manualslib.com manuals search engine SecondGear ................................ 2-19
Shift Light
............................. 2.20. 2.68
Shiftspeeds
................................ 2-20
Shifting
.................................... 2-18
Third Gear
.................................. 2- 19
Manual Transaxle Fluid
.......................... 6- 19
Adding .................................... 6-19
Checking ................................... 6-19
Mirrors
....................................... 2-42
Convex Outside
............................ 2-43
Inside Day/Night Rearview
.................... 2-42
Power Remote Control
........................ 2-43
Remote Control
.............................. 2-42
Methanol
(In Fuel) ............................... 6-3
MTBE
(In Fuel) ................................. 6-3
Net. Convenience
.............................. 2-44
Neutral (N) Position. Manual Transaxle
............. 2-19
New Vehicle “Break-In”
.......................... 2-7
Nightvision
................................... 4-13
Neutral
(N) Position. Automatic Transaxle
........... 2- 15
OBD I1 ...................................... 2-69
Odometer. Tamper Resistant
...................... 2-59
Odometer. Trip
................................. 2-60
Off-Road Recovery
............................. 4- IO
Oil Warning Light .............................. 2-65
Oil. Engine .................................... 6-10
Ordering
Owner Publications
............................ 8-8
Service and Owner Publications .................. 8-8
Service Bulletins .............................. 8-8
Service Manuals
.............................. 8-8
Overdrive (D). 4 Speed Automatic Transaxle
........ 2-17
Overheated Engine
.............................. 5-12
Owner Checks and Services ....................... 7-38
Owner Publications. Ordering
...................... 8-8
Paint Spotting. Chemical
........................ 6-49
Park (P) Position. Automatic Transaxle
.............. 2-14
Park (P). Shifting Into
........................... 2-22
Park (P). Shifting Out
of ......................... 2-24
ParkingBrake
.................................. 2-21
Parking Lamps
................................. 2-37
Parking on Hills While Towing
a Trailer ............. 4-35
Parking Your Vehicle. Manual Transaxle
............. 2-24
Parking. AtNight
................................ 2-6
Passlock Theft-Deterrent System
................... 2-7
Periodic Maintenance Inspections
.................. 7-42
Power Door Locks
............................... 2-4
Power Remote Control
Mirror ..................... 2-43
Power Steering
.................................. 4-8
Power Steering Fluid Adding
.................................... 6-24
Checking ................................... 6-24
Power Windows
................................ 2-27
Pregnancy. Use of Safety Belts
.................... 1-24
Problems on
the Road ............................ 5-1
Publications. Service and Owner .................... 8-8
ParkingLots .................................... 2-6
Parking Over Things That Burn
.................... 2-25
Passing
....................................... 4-10
Passlock Warning Light
.......................... 2-70
9-7