trunk CHEVROLET CAVALIER 1997 3.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine 10. Tighten the wheel nuts
firmly in a criss-cross sequence, as shown.
Incorrect wheel nuts or improperly tightened
wheel nuts can cause the wheel to become loose
and even come
off. This could lead to an accident.
Be sure to use the correct wheel nuts.
If you have
to replace them, be sure to get new
GM original
equipment wheel nuts.
Stop somewhere
as soon as you can and have the
nuts tightened with
a torque wrench to 100 lb-ft
(140 N-m).
~~
NOTICE:
Improperly tightened wheel nuts can lead to
brake pulsation and rotor damage. To avoid
expensive brake repairs, evenly tighten the wheel
nuts in the proper sequence and to the proper
torque specification.
Don’t try to put
a wheel cover on your compact spare
tire.
It won’t fit. Store the wheel cover and wheel nut
caps in the trunk until you have the flat tire repaired or replaced.
NOTICE:
Wheel covers won’t fit on your compact spare. If
you try to put a wheel cover on your compact
spare,
you could damage the cover or the spare.

Downloaded from www.Manualslib.com manuals search engine Storing the Spare Tire and Tools
A CAUTIOI!. .
Storing a jack, a tire or other equipment in the
passenger compartment
of the vehicle could
cause injury. In a sudden stop or collision, loose
equipment could strike someone. Store all these
in the proper place.
The compact spare is for temporary use only. Replace
the compact spare tire with a full-size tire as
soon as you
can. See “Compact Spare Tire” in the Index. See the
storage instructions label
to replace your compact spare
into your trunk properly.
B
I
A. Wrench
B. Jack
C. Spare Tire
D. Adapter
E. Wing Bolt
E Cover
G. Nut

Downloaded from www.Manualslib.com manuals search engine 3. Disconnect the bulb base from the socket by lifting
the plastic locking tab.
4. Snap a new bulb into the socket.
5. Replace the bulb assembly by reversing Steps
1 through 3, making sure the lower leg of the
headlamp bracket is properly seated into the wedge
shaped retainer.
Rear Exterior Bulbs
Taillamps and Rear Turn Signal Lamps
For the type of bulb to use, see “Replacement Bulbs” in
the Index. The following instructions explain how to
change each bulb.
1. Pull the carpet away from the rear of the trunk.
2. Remove the taillamp bulb assembly by turning it
one-quarter of a turn counterclockwise.
6-37

Downloaded from www.Manualslib.com manuals search engine Back-up Lamps (Sedan)
If you have a four-door sedan, do the following to
replace
a back-up lamp:
3. To remove the bulb, pull it out.
4. Push in a new bulb.
5. Reverse all steps to replace the taillamp assembly.
1.
2.
3.
4.
Use a torx screwdriver to unscrew the back-up lamp
assembly from the fascia.
Gently pull the bulb assembly from the fascia.
Remove the bulb from the socket
by turning it
one-quarter of
a turn counterclockwise.
Replace the bulb and bulb assembly by reversing
these steps.
Back-up Lamps (Coupe)
If you have a two-door coupe, do the following to
replace a back-up lamp:
1.
2.
3.
Open the trunk lid and locate the back-up lamp
assembly on the trunk lid.
Gently remove the bulb from the socket by turning
it
counterclockwise and pulling it out.
Replace the bulb in the socket by aligning the tabs
and turning clockwise.

Downloaded from www.Manualslib.com manuals search engine Center High-Mounted Stoplamp
(Models Without a Spoiler)
To change the bulb, do the following:
1. Open the trunk and view the access hole under the
rear shelf.
2. Remove the bulb sockets by rotating and pull down.
3. Remove the bulb and replace.
4. Re-install the new bulb and socket into the CHMSL.
Center High-Mounted Stoplamp
(Models With
a Spoiler)
To change the bulb, do the following:
1.
2.
3.
4.
Use a torx screwdriver to unscrew the bulb assembly
from the spoiler.
Gently pull out the bulb assembly.
Remove the bulb(s) by gently wiggling the bulb
from the assembly.
Replace the bulb(s) and reverse these steps to replace
the bulb assembly.
Interior Lamps
Dome Lamp With Integral Reading Lamps
To replace a bulb, do the following:
1. Insert a flat screwdriver into the slot at the rear
of the lens.
2. With the screwdriver, push the tab rearward to
3. Push the lens forward to release the two tabs at the
release the lamp
lens.
front
of the lens.
4. Gently remove and replace the bulb( s).
5. Reverse these steps to replace the lens.
Dome Lamp Without Integral Reading Lamps
To
replace a bulb, do the following:
1. From the rear of the dome lamp lens, insert a flat
screwdriver between the roof trim and the lens.
2. With the screwdriver, push the tab at the rear of the
3. Pull the lamp lens reward to release the two front tabs.
4. Gently remove and replace the bulb(s).
5. Reverse these steps to replace the lens.
lens
forward to release the
lens.
6-39

Downloaded from www.Manualslib.com manuals search engine Fuse
WIPER
ERLS
AIR BAG
EXT LAMP
PWR ACC
HVAC
RADIO
ALARM
CRUISE
L HDLP
CIG
Usage
Windshield Wipers,
Windshield Washers
Automatic Transaxle, Brake
Transaxle Shift Interlock, A/C
Compressor, Cruise Control,
Multiport Fuel Injection
Supplemental Inflatable
Restraint System
Exterior Lamps, Instrument
Panel Lights
Power Door Locks, Convertible
Top (Convertible Model)
Heater and A/C Control,
Anti-lock Brake System,
Engine Cooling Fan
Radio, Remote Keyless Entry
Alarm Module
- Interior Lamps,
Warning Chimes
Cruise Control
Left Headlamp Cigarette Lighter,
Horn, Interior
Lamps, Diagnostic Connector
Fuse
INST LPS
STOP HAZ
PWR WIN- DOW
PCM/IGN
INT LAMP
FOG LAMP
IGN
R HDLP
Usage
Instrument Panel Lights,
Warning Chimes
Exterior Lamps, Anti-Lock
Brake System, Cruise Control,
Turn Signals
Power Windows, Power Sunroof,
Convertible Top Controls
(Convertible Model)
(Circuit Breaker)
Powertrain Control Module
Alarm Module: Illuminated Entry,
Warning Chimes, Overhead
Lamps, Mapmeading Lamps,
Glove Box Lamp, Trunk Lamp,
Radio, Power Mirrors, Remote
Keyless Entry
Fog Lamps
(2-24 Only)
Engine Ignition
Right Headlamp
6-61

Downloaded from www.Manualslib.com manuals search engine Jack. Tire .................................... 5-25
Jump Starting
................................... 5-3
Key Lock Cylinders Service
..................... 7-43
Key Release Button
............................. 2-14
Keyless Entry System
............................ 2-6
Keys
.......................................... 2-2
Labels
....................................... 4-33
Certification
................................. 4-34
Service Parts Identification
..................... 6-58
Tire-Loading Information ...................... 4-33
Vehicle Identification Number
................... 6-58
Lamps
........................................ 2-41
Exterior
.................................... 2-41
Fog
........................................ 2-43
FrontReading
................................ 2-45
Interior
..................................... 2-44
Map
....................................... 2-45
OnReminder
................................ 2-42
Latches. Seatback
................................ 1-5
Leaving Your Vehicle
............................. 2-6
Leaving Your Vehicle with the Engine Running
....... 2-28
Lighter
....................................... 2-50
Lights Air Bag Readiness
..... i ................. 1-23. 2-68
Anti-Lock Brake System Warning
............ 2.70. 4.7
Brake System Warning
......................... 2-69
Charging System
............................. 2-69
CheckEngine
................................ 2-73
Enhanced Traction System Active
............ 2.72. 4.9
Enhanced Traction System Warning Light
..... 2.71. 4.9
CheckGages
................................ 2-77
ETS Active .............................. 2.72. 4.9
ETS Warning
............................ 2.71. 4.9
Interior
..................................... 2-44
Low Coolant Warning
......................... 2-73
Oil Pressure Warning
.......................... 2-76
Passlock
TM Warning ........................... 2-77
Safety Belt Reminder
...................... 1.8. 2.68
Loading Your Vehicle
........................... 4-33
Locks Cylinders
................................... 7-43
Door
........................................ 2-4
Key Lock Cylinder Service
..................... 7-43
Power Door
.................................. 2-5
Rear Door Security ............................. 2-5
Steering Column Lock Check
................... 7-44
Trunk
...................................... 2-10
Low Coolant Warning Light
...................... 2-73
Lowering the Convertible Top Manually
............. 2-59
Lowering Your Convertible Top
................... 2-52
Lubricants and Fluids
............................ 7-48
Lubrication Service. Body
........................ 7-43
Maintenance.
NO~Z~I Replacement parts ........... 6-64
Maintenance Record
............................ 7-50
Maintenance Schedule
............................ 7-1
Long Trip/Highway Definition
................... 7-6
Long TripMighway Intervals
..................... 7-6
Owner Checks and Services
..................... 7-41
Periodic Maintenance Inspections
................ 7-46
Recommended Fluids and Lubricants
............. 7-48
Scheduled Maintenance Services
.................. 7-3
Short TripKity Definition
....................... 7-5
Short TripKity Intervals
........................ 7-5
Up-Shift
............................... 2.25. 2.77

Downloaded from www.Manualslib.com manuals search engine Radio Reception .............................. 3-23
Radios
........................................ 3-8
Rain. Driving In
................................ 4-1 8
Raising the Convertible Top Manually
.............. 2-59
Raising Your Convertible Top
..................... 2-58
Rear
Door Security Locks
........................... 2-5
Outside Seat Position
.......................... 1-28
Safety Belt Comfort Guides
..................... 1-3 1
Seatpassengers .............................. 1-28
Towing
..................................... 5-12
Window Defogger
............................. 3-7
Rear Towing
................................... 5- 12
Rear Turn Signal Bulb Replacement
................ 6-37
Rearview Mirror. Inside Daymight
................. 2-46
Reclining Front Seatbacks
......................... 1-4
Recommended Fluids and Lubricants
............... 7-48
Recreational Vehicle Towing
...................... 4-3 1
Refrigerants. Air Conditioning .................... 6-64
Remote Trunk Release
........................... 2- 10
Removing the Boot ............................. 2-56
Replacement
Bulbs
...................................... 6-63
Parts
....................................... 6-64
Wheel ...................................... 6-46
Replacing Safety Belts
........................... 1-48
Reporting Safety Defects
......................... 8-10
Restraints
Checking
................................... 1-48
Child
....................................... 1-37
Head
........................................ 1-5
Replacing Parts After a Crash
................... 1-48
Systemcheck
................................ 7-42
Reverse. Automatic Transaxle
..................... 2-20 Reverse. Manual Transaxle
....................... 2-24
Right Front Passenger Position
.................... 1-22
Roadside Assistance
.............................. 8-5
Roadside Assistance. Canadian
..................... 8-7
Rocking Your Vehicle
........................... 5-35
Rotation. Tires
................................. 6-42
Safety Belt Extender
............................ 1-48
Safety Belts
.................................... 1-7
Care
....................................... 6-52
Center Rear Passenger Position
.................. 1-33
Children
.................................... 1-35
Driver Position
............................... 1-13
Extender .................................... 1-48
How to Wear Properly
......................... 1-13
Incorrect Usage
.................... 1-17.1-46. 1-47
LapBelt
.................................... 1-34
Lap-Shoulder
........................... 1 - 13. 1-28
Larger Children
.............................. 1-45
Passenger Position
.................. 1.22. 1-28. 1-33
Questions and Answers
........................ 1-12
Rear Comfort Guides
.......................... 1-31
Rear Seat Passengers
.......................... 1-28
Reminder Light
.......................... 1-8. 2-68
Replacing After a Crash
........................ 1-48
Right Front Passenger Position
.................. 1-22
Shoulder Belt Height Adjuster
................... 1-16
Smaller Children and Babies
.................... 1-35
Use During Pregnancy
......................... 1-21
WhyTheyWork
............................... 1-8
SafetyChains
.................................. 4-40
Adults
...................................... 1-13
Rear Seat Outside Passenger Positions
............ 1-28
9-8
~~ -..-?..rr-.......i_..i ... ........ .... ..,.. . -.. ........... ... ...._.L.*%.L. ............... "lCi .................... ?.I .........

Downloaded from www.Manualslib.com manuals search engine TrunkLock .................................... 2-10
TTYUsers
..................................... 8-4
Turn Signal and Lane Change Signals
............... 2-34
Turn SignalMultifunction Lever
................... 2-33
Turn Signals When Towing a Trailer
................ 4-41
Underbody Flushing Service
..................... 7-45
Underbody Maintenance
......................... 6-56
Up-Shift Light
............................ 2.25. 2.77
Vehicle Control
...................................... 4-6
Damage Warnings vi1
Dimensions
................................. 6-65
Identification Number
......................... 6-58
Loading
.................................... 4-33
Storage
..................................... 6-35
Ventilation System
............................... 3-6
Visors. Sun
.................................... 2-50
Warning Devices
............................... 5-3
Warning Lights. Gages and Indicators
............... 2-67
Washer Fluid. Windshield
........................ 6-30
.. ..............................
Washing Your Vehicle ...........................
Weatherstrips ..................................
Wheel
Alignment
..................................
Replacement .................................
Used Replacement ............................
Wrench .....................................
Windows .....................................
Auto-Down .................................
Power ......................................
Windshield Washer .............................
Fluid .................................. 2-37.
Fluid Level Check
............................
Windshield Wiper ..............................
Bladecheck .................................
Blade Replacement ...........................
Fuse .......................................
Winter Driving .................................
Wiring. Headlamp ..............................
WreckerTowing ................................
Wrench. Wheel .................................
Nut Torque ............................. 5-31.
6-53 6-53
6-46
6-63
6-46
6-47
5-25
2-32 2-32
2-32
2-37
6-30
7-41 2-35
6-40
6-59
4-26
6-59
.5-8
5-25 7-42
9-11
~~

Downloaded from www.Manualslib.com manuals search engine Service Station Checkpoints
COOLANT
SURGE TANK
P6-26 2.4 L ENGINE
OIL DIPSTICK
P6-12
FUEL
DOOR
WINDSHIELD FLUID RESERVOIR TIRES
P6-30 RELEASE P5-22
BATTERY
P6-35
REMOTE TRUNK RELEASE
(IF EQUIPPED) P2-10
For detailed information, refer to the page number listed, or see the Index in the back of the owner's manual.