steering CHEVROLET COBALT 2007 1.G Service Manual

Fuses Usage
23 Audio System
24Sensing and Diagnostic Module
(Airbag)
25Engine Control Module,
Transaxle Control Module
26 Door Locks
27 Interior Lights
28 Steering Wheel Control Illumination
29 Power WindowsRelays Usage
30 Climate Control System
31 Empty
32 Retained Accessory Power (RAP)
Engine Compartment Fuse Block
The engine compartment fuse block is located on
the driver’s side of the vehicle. Lift off the cover
to check the fuses. SeeEngine Compartment
Overview on page 290for more information
on location.
386

Fuses Usage
COOL FAN 1 Engine Cooling Fan Low Speed
BCM3 Body Control Module 3
BCM2 Body Control Module 2
FOG LAMP Fog Lamps
HORN Horn
RT HI BEAM Passenger’s Side High Beam
LT HI BEAM Driver’s Side High Beam
RT LO BEAM Passenger’s Side Low Beam
LT LO BEAM Driver’s Side Low Beam
DRL Daytime Running Lamps
FUEL PUMP Fuel Pump
EXH Exhaust Emissions
Blank Not Used
INJ Injectors
Blank Not Used
ABS Anti-lock Brake System
PCM/ECMPowertrain Control Module/
Engine Control ModuleFuses Usage
EPS Electric Power Steering
AIR PUMP AIR Pump
PRK LAMP Park Lamps
WPR Windshield Wiper
IP IGN Ignition
A/C CLTCH Air Conditioning Clutch
AIR SOL/
AFTERCOOLAIR Solenoid (L61, LE5),
Aftercooler (L4)
ABS2 Anti-lock Brake System 2
PRK/NEUT Park, Neutral
ECM/TRANS Engine Control Module, Transaxle
BCK UP Back-Up Lamps
TRUNK/
OUTLETTrunk, Accessory Power Outlet
Blank Not Used
Blank Not Used
S BAND/
ONSTARAudio, OnStar
®
ABS3 Anti-lock Brake System 3
388

Scheduled Maintenance (cont’d)
Service MaintenanceIMaintenanceII
Perform any needed additional services. See “Additional Required Services” in
this section.••
Inspect suspension and steering components.See footnote (b).•
Inspect engine cooling system.See footnote (c).•
Inspect wiper blades.See footnote (d).•
Inspect restraint system components.See footnote (e).•
Lubricate body components.See footnote (f).•
Replace passenger compartment air lter.See footnote (l).•
Inspect throttle system.See footnote (g).•
Additional Required Services
The following services should be performed at the rst maintenance service (IorII) after the indicated
miles (kilometers) shown for each item.
Additional Required Services
Service and Miles (Kilometers)25,000
(40 000)50,000
(80 000)75,000
(120 000)100,000
(160 000)125,000
(200 000)150,000
(240 000)
Inspect fuel system for damage or leaks.• •••••
Inspect exhaust system for loose or
damaged components.• •••••
398

Maintenance Footnotes
(a)Visually inspect brake lines and hoses for
proper hook-up, binding, leaks, cracks, chang, etc.
Inspect disc brake pads for wear and rotors for
surface condition. Inspect drum brake linings/shoes
for wear or cracks. Inspect other brake parts,
including drums, wheel cylinders, calipers,
parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose, or missing
parts or signs of wear. Inspect power steering
cables for proper hook-up, binding, cracks,
chang, etc.
(c)Visually inspect hoses and have them replaced
if they are cracked, swollen, or deteriorated.
Inspect all pipes, ttings and clamps; replace
with genuine parts as needed. To help ensure
proper operation, a pressure test of the cooling
system and pressure cap and cleaning the outside
of the radiator and air conditioning condenser is
recommended at least once a year.(d)Inspect wiper blades for wear, cracking,
or contamination. Clean the windshield and wiper
blades, if contaminated. Replace wiper blades
that are worn or damaged. See Windshield Wiper
Blade Replacement on page 337andWindshield
and Wiper Blades on page 378for more
information.
(e)Make sure the safety belt reminder light and all
your belts, buckles, latch plates, retractors, and
anchorages are working properly. Look for
any other loose or damaged safety belt system
parts. If you see anything that might keep a safety
belt system from doing its job, have it repaired.
Have any torn or frayed safety belts replaced.
Also look for any opened or broken airbag
coverings, and have them repaired or replaced.
The airbag system does not need regular
maintenance.
(f)Lubricate all key lock cylinders, door hinges
and latches, hood hinges and latches, and trunk lid
hinges and latches. More frequent lubrication
may be required when exposed to a corrosive
environment. Applying silicone grease on
weatherstrips with a clean cloth will make them
last longer, seal better, and not stick or squeak.
400

On manual transaxle vehicles, put the shift
lever in NEUTRAL, push the clutch pedal
down halfway, and try to start the engine. The
vehicle should start only when the clutch
pedal is pushed down all the way to the oor.
If the vehicle starts when the clutch pedal
is not pushed all the way down, contact your
GM Goodwrench
®dealer for service.
Automatic Transaxle Shift Lock Control
System Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the
vehicle moves, you or others could be
injured.
1. Before you start, be sure you have enough
room around the vehicle. It should be parked
on a level surface.2. Firmly apply the parking brake. SeeParking
Brake on page 123.
Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the ignition to RUN,
but do not start the engine. Without applying
the regular brake, try to move the shift
lever out of PARK (P) with normal effort. If the
shift lever moves out of PARK (P), contact
your GM Goodwrench
®dealer for service.
Ignition Transaxle Lock Check
While parked, and with the parking brake set, try
to turn the ignition to LOCK in each shift lever
position.
With an automatic transaxle, the ignition
should turn to LOCK only when the shift lever
is in PARK (P). The ignition key should
come out only in LOCK.
With a manual transaxle, the ignition key
should come out only in LOCK.
Turn the steering wheel to the left and to the right. It
should only lock when turned to the right. Contact
your GM Goodwrench
®dealer if service is required.
404

Reporting Safety Defects to
General Motors
In addition to notifying NHTSA (or Transport
Canada) in a situation like this, we certainly
hope you will notify General Motors. Please
call the Chevrolet Customer Assistance Center
at 1-800-222-1020, or write:
Chevrolet Motor Division
Chevrolet Customer Assistance Center
P.O. Box 33170
Detroit, MI 48232-5170
In Canada, please call us at 1-800-263-3777
(English) or 1-800-263-7854 (French).
Or, write:
General Motors of Canada Limited
Customer Communication Centre, CA1-163-005
1908 Colonel Sam Drive
Oshawa, Ontario L1H 8P7
Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle
suspension, brakes, electrical, steering, body, etc.
Transmission, Transaxle, Transfer
Case Unit Repair Manual
This manual provides information on unit
repair service procedures, adjustments, and
specications for GM transmissions, transaxles,
and transfer cases.
430

Event Data Recorders
Some information about your vehicle’s performance
and how it is driven may be recorded on various
modules if a crash occurs. Some people refer to
these modules asevent data recorders (EDRs).
These modules may record several seconds of
pre-crash and crash data, such as data related
toengine speed, brake application, throttle
position, vehicle speed, yaw rate, steering
wheel angle, lateral acceleration, safety belt
usage, airbag readiness, airbag performance
andthe severity of the collision.Unlike the ight
data recorders on airplanes, these modules do
not record sounds or conversations.To retrieve this data, special equipment and access
to the vehicle or the module that stores the data
are required. Certain data may also be sent to or
retrieved by OnStar®(see below). GM will not
access this information or share it with others
except: with the consent of the vehicle owner or, if
the vehicle is leased, with the consent of the lessee;
in response to an official request of police or similar
government office; as part of GM’s defense of
litigation through the discovery process; or, as
required by law. Data that GM collects or receives
may also be used for GM research needs or may
be made available to others for research purposes,
where a need is shown and the data is not tied to a
specic vehicle or vehicle owner.
Others may be able to retrieve this data if they
have access to the vehicle and have the special
equipment necessary to download the data.
433

Audio System.............................................. 192
Audio Steering Wheel Controls................. 222
Care of Your CD Player........................... 224
Care of Your CDs.................................... 224
Fixed Mast Antenna................................. 224
Radio with CD................................197, 202
Setting the Time...................................... 194
Theft-Deterrent Feature............................ 222
Understanding Radio Reception............... 223
XM™ Satellite Radio Antenna System...... 224
Automatic Door Lock................................... 100
Automatic Transaxle
Fluid........................................................ 301
Operation................................................. 118
B
Battery........................................................ 321
Electric Power Management..................... 155
Run-Down Protection............................... 156
Before Leaving on a Long Trip.................... 250
Boost Gage................................................. 180Brake
Emergencies............................................ 233
Parking.................................................... 123
Brakes........................................................ 318
System Warning Light.............................. 171
Braking....................................................... 230
Braking in Emergencies............................... 233
Break-In, New Vehicle................................. 111
Bulb Replacement....................................... 331
Back-Up Lamps....................................... 335
Center High-Mounted
Stoplamp (CHMSL)............................... 333
Halogen Bulbs......................................... 331
Headlamp Aiming..................................... 328
Headlamps, Front Turn Signal,
Sidemarker, and Parking Lamps........... 331
License Plate Lamps................................ 336
Replacement Bulbs.................................. 337
Taillamps and Turn Signal Lamps............. 334
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps..................................... 334
Buying New Tires........................................ 351
436

Spare Tire
Compact.................................................. 372
Installing.................................................. 364
Removing................................................ 360
Storing..................................................... 369
Specications, Capacities............................ 390
Speedometer............................................... 166
Split Folding Rear Seat................................. 16
Starting Your Engine................................... 115
Steering...................................................... 236
Steering Wheel Controls, Audio................... 222
Steering Wheel, Tilt Wheel.......................... 145
Storage Areas
Center Console Storage Area................... 136
Convenience Net..................................... 136
Cupholder(s)............................................ 136
Driver’s Storage Compartment................. 136
Glove Box................................................ 136
Stuck in Sand, Mud, Ice, or Snow............... 258
Sun Visors.................................................. 106
Sunroof....................................................... 137T
Tachometer................................................. 166
Taillamps
Turn Signal Lamps................................... 334
Turn Signal, Stoplamps and
Back-up Lamps..................................... 334
Theft-Deterrent, Radio................................. 222
Theft-Deterrent Systems.............................. 107
Content Theft-Deterrent............................ 107
PASS-Key
®III+........................................ 109
PASS-Key®III+ Operation........................ 109
Tilt Wheel.................................................... 145
Time, Setting............................................... 194
Tires........................................................... 338
Aluminum or Chrome-Plated Wheels,
Cleaning............................................... 378
Buying New Tires..................................... 351
Chains..................................................... 357
Changing a Flat Tire................................ 358
Cleaning.................................................. 379
447