key CHEVROLET COBALT 2007 1.G Workshop Manual

Dinghy Towing
You may dinghy tow your vehicle from the front
following these steps:
1. Set the parking brake.
2. Turn the ignition key to ACC to unlock the
steering wheel.
3. Shift an automatic transaxle to NEUTRAL (N)
or a manual transaxle to NEUTRAL.
4. Release the parking brake.To prevent the battery from draining while the
vehicle is being towed, remove the following fuse
from the oor console fuse block: 8 (Ignition
Switch, PASS-Key
®III+). SeeFloor Console Fuse
Block on page 384for more information.
Remember to reinstall the fuse once you have
reached your destination.
Notice:If you exceed 65 mph (105 km/h) while
towing your vehicle, it could be damaged.
Never exceed 65 mph (105 km/h) while towing
your vehicle.
266

After changing the engine oil, the system must be
reset as follows:
1. Turn the ignition to RUN, with the engine off.
2. Press the information and reset buttons
on the DIC at the same time to enter the
personalization menu. SeeDIC Vehicle
Personalization on page 186.
3. Press the information button to scroll through
the available personalization menu modes
until the DIC display shows OIL-LIFE RESET.
4. Press and hold the reset button until the DIC
display shows ACKNOWLEDGED. This will
tell you the system has been reset.
5. Turn the key to LOCK.
If the CHANGE OIL SOON message comes back
on when you start your vehicle, the engine oil
life system has not reset. Repeat the reset
procedure.What to Do with Used Oil
Used engine oil contains certain elements that may
be unhealthy for your skin and could even cause
cancer. Do not let used oil stay on your skin for
very long. Clean your skin and nails with soap and
water, or a good hand cleaner. Wash or properly
dispose of clothing or rags containing used engine
oil. See the manufacturer’s warnings about the use
and disposal of oil products.
Used oil can be a threat to the environment. If you
change your own oil, be sure to drain all the oil from
the lter before disposal. Never dispose of oil by
putting it in the trash, pouring it on the ground, into
sewers, or into streams or bodies of water. Instead,
recycle it by taking it to a place that collects used
oil. If you have a problem properly disposing of
your used oil, ask your dealer, a service station,
or a local recycling center for help.
299

Fuses Usage
1 Fuse Puller
2 Empty
3 Empty
4 Empty
5 Empty
6 Amplier
Fuses Usage
7 Cluster
8 Ignition Switch, PASS-Key
®III+
9 Stoplamp
10Heating, Ventilation, Air
Conditioning, PASS-Key
®III+
11 Empty
12 Spare
13 Airbag
14 Spare
15 Windshield Wiper
16 Climate Control System, Ignition
17 Empty
18 Empty
19Electric Power Steering,
Steering Wheel Control
20 Sunroof
21 Spare
22 Empty
385

Maintenance Footnotes
(a)Visually inspect brake lines and hoses for
proper hook-up, binding, leaks, cracks, chang, etc.
Inspect disc brake pads for wear and rotors for
surface condition. Inspect drum brake linings/shoes
for wear or cracks. Inspect other brake parts,
including drums, wheel cylinders, calipers,
parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose, or missing
parts or signs of wear. Inspect power steering
cables for proper hook-up, binding, cracks,
chang, etc.
(c)Visually inspect hoses and have them replaced
if they are cracked, swollen, or deteriorated.
Inspect all pipes, ttings and clamps; replace
with genuine parts as needed. To help ensure
proper operation, a pressure test of the cooling
system and pressure cap and cleaning the outside
of the radiator and air conditioning condenser is
recommended at least once a year.(d)Inspect wiper blades for wear, cracking,
or contamination. Clean the windshield and wiper
blades, if contaminated. Replace wiper blades
that are worn or damaged. See Windshield Wiper
Blade Replacement on page 337andWindshield
and Wiper Blades on page 378for more
information.
(e)Make sure the safety belt reminder light and all
your belts, buckles, latch plates, retractors, and
anchorages are working properly. Look for
any other loose or damaged safety belt system
parts. If you see anything that might keep a safety
belt system from doing its job, have it repaired.
Have any torn or frayed safety belts replaced.
Also look for any opened or broken airbag
coverings, and have them repaired or replaced.
The airbag system does not need regular
maintenance.
(f)Lubricate all key lock cylinders, door hinges
and latches, hood hinges and latches, and trunk lid
hinges and latches. More frequent lubrication
may be required when exposed to a corrosive
environment. Applying silicone grease on
weatherstrips with a clean cloth will make them
last longer, seal better, and not stick or squeak.
400

On manual transaxle vehicles, put the shift
lever in NEUTRAL, push the clutch pedal
down halfway, and try to start the engine. The
vehicle should start only when the clutch
pedal is pushed down all the way to the oor.
If the vehicle starts when the clutch pedal
is not pushed all the way down, contact your
GM Goodwrench
®dealer for service.
Automatic Transaxle Shift Lock Control
System Check
{CAUTION:
When you are doing this inspection, the
vehicle could move suddenly. If the
vehicle moves, you or others could be
injured.
1. Before you start, be sure you have enough
room around the vehicle. It should be parked
on a level surface.2. Firmly apply the parking brake. SeeParking
Brake on page 123.
Be ready to apply the regular brake
immediately if the vehicle begins to move.
3. With the engine off, turn the ignition to RUN,
but do not start the engine. Without applying
the regular brake, try to move the shift
lever out of PARK (P) with normal effort. If the
shift lever moves out of PARK (P), contact
your GM Goodwrench
®dealer for service.
Ignition Transaxle Lock Check
While parked, and with the parking brake set, try
to turn the ignition to LOCK in each shift lever
position.
With an automatic transaxle, the ignition
should turn to LOCK only when the shift lever
is in PARK (P). The ignition key should
come out only in LOCK.
With a manual transaxle, the ignition key
should come out only in LOCK.
Turn the steering wheel to the left and to the right. It
should only lock when turned to the right. Contact
your GM Goodwrench
®dealer if service is required.
404

Usage Fluid/Lubricant
Manual
Transmission
(2.0L L4
Supercharged
engine)Manual Transmission Fluid
(Part No. 21018899).
Automatic
TransmissionDEXRON
®-VI Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Manual
Transmission
Shift LinkageChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Chassis
LubricationChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Usage Fluid/Lubricant
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring
Anchor, and
Release PawlLubriplate Lubricant Aerosol
(GM Part No. U.S. 12346293, in
Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Weatherstrip
ConditioningWeatherstrip Lubricant
(GM Part No. U.S. 3634770,
in Canada 10953518) or
Dielectric Silicone Grease
(GM Part No. U.S. 12345579,
in Canada 992887).
407

OnStar
If your vehicle has OnStar®and you subscribe
to the OnStar®services, please refer to the
OnStar®Terms and Conditions for information
on data collection and use. See alsoOnStar®
System on page 132for more information.
Navigation System
If your vehicle has anavigation system,
use of the system may result in the storage of
destinations, addresses, telephone numbers,
and other trip information.Please refer to
the navigation system operating manual for
information on stored data and for deletion
instructions.
Radio Frequency
Identication (RFID)
RFIDtechnology is used in some vehicles for
functions such as tire pressure monitoring and
ignition system security, as well as in connection
with conveniences such as key fobs for remote
door locking/unlocking and starting, and in-vehicle
transmitters for garage door openers. RFID
technology in GM vehicles does not use or record
personal information or link with any other GM
system containing personal information.
434

H
Hazard Warning Flashers............................ 144
Head Restraints............................................ 14
Headlamp
Aiming..................................................... 328
Headlamp Wiring......................................... 383
Headlamps.................................................. 152
Bulb Replacement.................................... 331
Daytime Running Lamps.......................... 153
Flash-to-Pass........................................... 146
Halogen Bulbs......................................... 331
Headlamps, Front Turn Signal,
Sidemarker, and Parking Lamps........... 331
High/Low Beam Changer......................... 146
On Reminder........................................... 153
Wiper Activated........................................ 153
Heated Seats................................................ 11
Heater......................................................... 158
Height Adjuster, Driver Seat.......................... 10
Highbeam On Light..................................... 179
High-Speed Operation, Tires........................ 349
Highway Hypnosis....................................... 251
Hill and Mountain Roads............................. 252
Hood
Checking Things Under............................ 288
Release................................................... 289Horn............................................................ 144
How to Use This Manual................................ 4
How to Wear Safety Belts Properly............... 23
Hydraulic Clutch.......................................... 302
I
Ignition Positions......................................... 112
Infants and Young Children, Restraints.......... 43
Ination - Tire Pressure............................... 347
Instrument Panel
Overview.................................................. 142
Instrument Panel (I/P)
Brightness................................................ 154
Cluster..................................................... 165
J
Jump Starting.............................................. 322
K
Keyless Entry System................................... 91
Keys............................................................. 89
441

O
Odometer.................................................... 166
Off-Road Recovery...................................... 239
Oil
Engine..................................................... 293
Pressure Light.......................................... 178
Oil, Engine Oil Life System......................... 298
Older Children, Restraints............................. 40
Online Owner Center................................... 417
OnStar, Privacy........................................... 434
OnStar
®System, see OnStar®Manual........ 132
Other Warning Devices................................ 144
Outlet Adjustment........................................ 161
Outlets
Accessory Power..................................... 156
Outside
Convex Mirror.......................................... 131
Manual Mirror.......................................... 130
Power Mirrors.......................................... 131
Remote Control Mirror.............................. 130
Owner Checks and Services....................... 402
Owners, Canadian.......................................... 3
P
Paint, Damage............................................ 380
Park (P)
Shifting Into............................................. 124
Shifting Out of......................................... 126
Parking
Brake....................................................... 123
Over Things That Burn............................ 127
Parking Your Vehicle................................... 126
Passenger Airbag Status Indicator............... 168
Passenger Compartment Air Filter............... 162
Passenger Sensing System........................... 77
Passing....................................................... 239
PASS-Key
®III+........................................... 109
PASS-Key®III+ Operation........................... 109
Power
Door Locks................................................ 99
Electrical System..................................... 383
Retained Accessory (RAP)....................... 115
Windows.................................................. 105
Pretensioners, Safety Belt............................. 39
Privacy........................................................ 432
Event Data Recorders.............................. 433
Navigation System................................... 434
OnStar..................................................... 434
Radio Frequency Identication.................. 434
Programmable Automatic Door Unlock......... 100
444

Q
Questions and Answers About Safety Belts.... 22
R
Racing or Other Competitive Driving............ 242
Radio Frequency Identication (RFID),
Privacy..................................................... 434
Radios........................................................ 192
Care of Your CD Player........................... 224
Care of Your CDs.................................... 224
Radio with CD................................197, 202
Setting the Time...................................... 194
Theft-Deterrent......................................... 222
Understanding Reception......................... 223
Rear Door Security Locks........................... 100
Rear Safety Belt Comfort Guides.................. 36
Rear Seat Passengers, Safety Belts.............. 33
Rearview Mirror with OnStar
®...................... 130
Rearview Mirrors......................................... 130
Reclining Seatbacks...................................... 12
Recommended Fluids and Lubricants.......... 406
Recreational Vehicle Towing........................ 265Remote Keyless Entry (RKE) System............ 91
Remote Keyless Entry (RKE) System,
Operation................................................... 92
Removing the Flat Tire and Installing the
Spare Tire................................................ 364
Removing the Spare Tire and Tools............ 360
Replacement Bulbs..................................... 337
Reporting Safety Defects
Canadian Government............................. 429
General Motors........................................ 430
United States Government....................... 429
Restraint System Check
Checking the Restraint Systems................. 84
Replacing Restraint System Parts
After a Crash......................................... 85
Retained Accessory Power (RAP)................ 115
Right Front Passenger Position,
Safety Belts............................................... 32
Roadside
Assistance Program................................. 420
Rocking Your Vehicle to Get it Out.............. 259
Routing, Engine Drive Belt.......................... 409
Running the Engine While Parked............... 129
445