headlamp CHEVROLET CORVETTE 1995 4.G User Guide

Downloaded from www.Manualslib.com manuals search engine Headlamp
f
1
1. Open the hood.
2. The headlamps need to be halfway open. Turn the
headlamp switch
on, then quickly back to the
parking lamps setting.
You may have to do this a few
times
to get the half-open position. You can also
open the headlamps manually. See “Headlamp
Doors” in the Index.
3. Remove the two screws on each side of the
headlamp.
4. Remove the two screws from both sides of the cover.
Before you remove the last screw, put your hand
under the cover to hold it.
5. Reach around the hood and pull the cover straight
out. Be careful not to scratch the paint.
6-37

Downloaded from www.Manualslib.com manuals search engine Fog Lamp
You can reach the fog lamps from under the front
bumper.
1. Remove the screw in the access door. Open the door.
2. Turn the bulb base counterclockwise 118 turn and
pull it out.
3. Disconnect the bulb base from the wiring harness.
4. Reverse the steps with a new bulb.
6. Remove the four screws from the retainer near each
comer of the headlamp. Don’t move the large-head
adjusting screws
or your headlamp will not be aimed
properly.
Hold the headlamp and remove the retainer.
7. Remove the headlamp and unplug the electrical
8. Reverse the steps with a new headlamp.
connector.

Downloaded from www.Manualslib.com manuals search engine Wheel Alignment and Tire Balance
The wheels on your vehicle were aligned and balanced
carefully at the factory
to give you the longest tire life
and best overall performance.
In most cases, you will not need to have your wheels
aligned again. However,
if you notice unusual tire wear
or your vehicle pulling one way or the other, the
alignment may need to be reset.
If you notice your
vehicle vibrating when driving
on a smooth road, your
wheels may need to be rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked, or badly rusted
or corroded. If wheel nuts keep coming loose, the wheel,
wheel bolts, and wheel nuts should be replaced.
If the
wheel leaks air, replace it (except some aluminum
wheels, which can sometimes be repaired). See your
Chevrolet dealer
if any of these conditions exist.
Your dealer will know the lund of wheel you need.
Each new wheel should have the same load carrying capacity, diameter, width, offset, and be mounted the
same way as the one it replaces.
If you need to replace any of your wheels, wheel bolts,
or wheel nuts, replace them only with new
GM original equipment parts.
This way, you will be sure to have the
right wheel, wheel bolts, and wheel nuts for your
Corvette model.
I NOTICE:
The wrong wheel can also cause problems with
bearing life, brake cooling,
speedometer/odometer calibration, headlamp aim, bumper height, vehicle ground clearance,
and tire clearance to the body and chassis.
6-54

Downloaded from www.Manualslib.com manuals search engine There are three fuse centers on your vehicle. One is in
the right side of your instrument panel. Turn the knob
and pull the door to access the fuses.
The other two fuse blocks are in the engine
compartment. One
is part of the Forward Lamp wiring
harness
(A), and the other is part of the ECM-Engine
wiring harness
(B).
Look at the silver-colored band inside the fuse. If the
band
is broken or melted, replace the fuse. Be sure you
replace a bad fuse with a new one
of the correct size.
If you ever have a problem on the road and don’t have a
spare fuse, you can borrow one of the correct value. Just
pick some feature
of your vehicle that you can get along
without
-- like the radio or cigarette lighter -- and use
its fuse, if it is the size you need. Replace it as soon as
you can.
Headlamp Wiring
The headlamp wiring is protected by a circuit breaker in
the switch. An electrical overload will cause the lamps
to
go on and off, or in some cases to remain off. If this
happens, have your headlamp wiring checked right
away.
Windshield Wiper Fuses
The windshield wiper motor is protected by a circuit
breaker and a
fuse. If the motor overheats due to heavy
snow, etc., the wiper will stop until the motor cools. If
the overload is caused by some electrical problem and
not snow, etc., be sure to get it fixed.
Power Windows and Other Power Options
Circuit breakers protect the power windows and other
power accessories. When the current load is too heavy,
the circuit breaker opens and closes, protecting the
circuit until the problem is fixed or goes away.
6-68

Downloaded from www.Manualslib.com manuals search engine Forward Lamp Fuse Block -
INTERIOR LIGHTING
PRIMARY COOLING FAN
LH HDLP
MOTOR
RH HDLP MOTOR
EXTERIOR LIGHTING
POWER
ACCSY
AIR PUMP
1. Interior Lighting
2. Primary Cooling Fan
3. LH Headlamp Motor
4. RH Headlamp Motor
5. Secondary Cooling Fan
6. Exterior Lighting
7. Power Accessory (Power Locks, Hatch, Lighter,
Seats)
8. Air Pump
6-72

Downloaded from www.Manualslib.com manuals search engine Leaving your hood open and your underhood lamps on
can drain your battery
. If you need to keep the hood
open for an extended period
of time. remove the
underhood lamps fuse
.
Replacement Bulbs
Air Conditioningmeater Control ................ 37
Automatic Transmission Indicator
........... 194NA
Back-up
................................. 1156
Center High-Mounted Stoplamp (except ZR-
1) ... 1156
Center High-Mounted Stoplamp (ZR-
1) ........ 89 1
Console
.................................. 564
Cornering
................................. 1156
Door Courtesy
........................... .21 2-2
DoorFlood
................................ 73
* These bulbs are not owner.serviceab1e . See your dealer.
Driver Information Center * ......................
Floor Courtesy ............................. 562
Fog
...................................... 896
Front Parkingmurn Signal
................. 2057NA
Headlamp ............................. HP6054
Instrument Cluster
License
................................... 24
MirrorFlood
............................... 74
* ............................
Mirror Reading ............................ 168
Rear Courtesy (Convertible)
.................. 562
Rear Courtesy (except Convertible)
............ 906
Sidemarker
................................ 24
Tail/Stop/Turn
............................ 2057
Visor Vanity Mirror
.......................... 74
Radio
* ......................................
Underhood ................................. 2-2
6-74

Downloaded from www.Manualslib.com manuals search engine Park (P) Position ............................. 2-24
Reverse (R) Position
.......................... 2-25
Second (2) Position
........................... 2-27
Automatic Transmission Fluid
..................... 6-20
Temperature Reading
......................... 2-84
Adding
.................................... 6-22
Checking
................................... 6-21
Axle, Rear
.................................... 6-26
Back-up Lamp. Bulb Replacement
................ 6-41
Battery
....................................... 6-35
Replacement, Passive Keyless Entry
.............. 2-8
Warnings .................................... 5-2
BBB Auto Line
................................. 8-3
Bi-Level
....................................... 3-3
Blizzard
...................................... 4-26
Brake
Adjustment
................................. 6-35
Fluid, Adding
............................... 6-34
Master Cylinder
............................. 6-32
System Parts, Replacing
....................... 6-35
System Warning Light
........................ 2-70
Transmission Shift Interlock (BTSI)
.............. 7-42
Brake, Parking
................................. 2-32
Brakes, Anti-Lock
............................... 4-6
Braking, In Emergencies
.......................... 4-9
Brightness Control
.............................. 2-46
PedalTravel
................................ 6-35
Wear
...................................... 6-34
Braking
........................................ 4-5
“Break-In,
” New Vehicle .......................... 2- 15
BTSI (Brake-Transmission Shift Interlock) ........... 7-42
Bulb Replacement Back-up Lamp
.............................. 6-41
Center High-Mounted Stoplamp (ZR-
1) .......... 6-46
Cornering Lamp
............................. 6-43
Front Turn Signal Lamps
...................... 6-39
Center High-Mounted
Stoplamp (Except ZR-1)
.... 6-45
Chart
...................................... 6-74
FogLamp
.................................. 6-38
Headlamps
................................. 6-37
Rear Cargo Compartment Lamp (Convertible)
..... 6-44
Rear Cargo Compartment Lamp (Coupe)
.......... 6-44
Rear Turn Signal and Taillamp
.................. 6-40
Sidemarker
................................. 6-42
Canada. Vehicles First Sold in
11 .. .......................
Canadian Roadside Assistance ...................... 8-8
Capacities and Specifications ...................... 6-75
Carbon Monoxide
......................... 2.36. 4.27
Care of Your Cassette Tape Player
.................. 3-18
Care
of Your Compact Discs ...................... 3-19
Cassette Tape Player. Care of Your
................. 3-18
Center Console
................................. 2-57
Bulb Replacement
............................. 6-45
Bulb Replacement
............................. 6-46
CertificationRire Label
.......................... 4-28
Changing a Flat Tire
............................. 5-27
Charging System Light
.......................... 2-70
Center High-Mounted
Stoplamp (Except
ZR- 1).
Center High-Mounted Stoplamp (ZR- 1).
Chains. Tire ................................... 6-55
9-2

Downloaded from www.Manualslib.com manuals search engine Gasolines for Cleaner Air ........................ 6-4
Gauges Engine Coolant TemDerature
................... 2-74 " Engine Oil Pressure .......................... 2-80
Fuel ....................................... 2-83
Engine
Oil Temperature
....................... 2-81
Markings
................................... 2-82
GAWR (Gross Axle Weight Rating)
................ 4-28
GVWR (Gross Vehicle Weight Rating)
.............. 4-28
Glass,
Cleaning
................................ 6-59
Halogen Bulbs
................................ 6-36
Hardtop. Convertible
............................ 2-95
.Hatch Release. Remote
........................... 2-9
Hazard Warning Flashers
.......................... 5-1
Headlamp Doors ............................... 2-47
Headlamp HigWLow Beam Changer
................ 2-40
Headlamp. Wiring
.............................. 6-68
Headlamps, Bulb Replacement .................... 6-37
Heating, Manual
................................. 3-6
High Beam Lamps, How to Change
................ 2-40
High Fill Reservoir
(LT5 Engine) .................. 5-20
Highway Hypnosis
.............................. 4-22
Hill and Mountain Roads
......................... 4-22
HoodRelease
................................... 6-8
Horn
......................................... 2-38
Headlamps
.................................... 2-46
Hearing or Speech Impaired, Customer Assistance
...... 8-2
Heritage Pages
................................... 111 ...
Hydraulic Clutch ............................... 6-24
Hydraulic Clutch, Checking and Adding Fluid
........ 6-25
Hydroplaning
.................................. 4- 18
If You're Stuck: In Sand. Mud. Ice or Snow ......... 5-41
Ignition Key Positions
........................... 2-16
Ignition Switch
................................. 2-16
Inside Daymight Rearview Mirror
................. 2-49
Exhaust Systems
............................. 7-44
Manual Transmission
......................... 7-44
Rear Axle Service
............................ 7-44
Restraint Systems
............................ 7-44
Installing the Roof Panel
......................... 2-56
Instrument Cluster
.............................. 2-66
Instrument Panel Cluster,
LTl Engine ............... 2-66
Instrument Panel Cluster,
LT5 Engine ............... 2-67
Instrument Panel, Cleaning
....................... 6-59
Instrument Panel Fuse Block
...................... 6-69
Interior Lamps
................................. 2-49
Jump Starting
................................... 5-2
Key Release Button
............................. 2-17
Inspections
Brakesystem
............................... 7-44
Tireandwheel
.............................. 7-44
Instrumentpanel
............................... 2-64
J ack, Tire .................................... 5-32
Key Lock Cylinders
............................ 7-42
Lamp, Malfunction Indicator
..................... 2-80
Keys
.......................................... 2-1
Lamps
........................................ 2-46
Courtesy
................................... 2-49
Daytime Running
............................ 2-47
9-6

Downloaded from www.Manualslib.com manuals search engine TopStrap ..................................... 1-25
TorqueLock
................................... 2-34
Torque. Wheel Nut
......................... 5.36. 6.77
Towing a Trailer
................................ 4-29
Towing Your Vehicle
............................. 5-6
Trailer, Towing a
............................... 4-29
Transmission Fluid, Automatic
.................... 6-20
Transmission Fluid, Manual
....................... 6-23
Transmitters, Matching to Your Vehicle
.............. 2-7
Trip Odometer
................................. 2-68
Turn Signal and Lane Change Indicator
............. 2-40
Turn Signals/Headlamp Beam Lever
................ 2-39
Front
....................................... 5-9
Rear
....................................... 5-11
Underbody Flushing
........................... 7-43
Underhood Lamps Fuse
.......................... 6-73
Universal Theft-Deterrent
...................... 2- 12
Vehicle Damage Warnings
......................... ix
Vehicle Dimensions Chart
........................ 6-79
Vehicle Identification Number (VIN)
............... 6-66
Vehicle Loading
................................ 4-28
Vehicle Storage
................................ 6-36
Vehicle Symbols ................................... x
Vehicle. Leaving Your
............................ 2-4
Vehicle.
Control of a
............................. 4-5
Vehicles First
Sold in Canada 11 .. ........................
Ventilation System. Flow-Through ................. 3- 10
Ventilation Tips
................................ 3-10
Visor Vanity Mirrors, Covered
..................... 2-51
Visors, Sun
.................................... 2-51
Vision.
Night
.................................. 4-15
Voltmeter
..................................... 2-79
warning Devices
............................... 5-2
Warning Flashers. Hazard
......................... 5-1
Washing Your Vehicle ........................... 6-61
Weatherstrips
.................................. 6-60
Wheel Nut Torque
......................... 5-36. 6-77
Wheel Replacement
............................. 6-54
Wheel Replacement. Used
........................ 6-55
Window
...................................... 2-37
Express Down Feature
........................ 2-37
Power
..................................... 2-37
Windshield, Specially Treated (ZR-
1) ................ 3-9
Windshield Washer ............................. 2-42
Windshield Washer Fluid
.................... 2-42. 6-31
Windshield Wiper Blade Replacement
.............. 6-47
Windshield Wiper Fuses
......................... 6-68
Windshield Wipers
.............................. 2-41
Winter, Driving in
.............................. 4-24
Wiring, Headlamp
.............................. 6-68
Wrecker Towing
................................. 5-6
Warning
Lights. Gauges and Indicators
.............. 2-68
Water. Driving Through Deep Standing
............. 2-22
9-12