fuel filter CHEVROLET CORVETTE 1996 4.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine Capacities (Approximate)
The following approximate capacities are given in English and metric conversions.
Air Conditioning ................. See the refrigerant information label under the hood.
Automatic Transmission
Drain and Refill
.............................................. 5 quarts (4.7 L)*
Overhaul
............................................. 10.8 quarts (10.2 L)*
LT1 ........... ................................... 14.5 quarts (13.7 L)
LT4
.................................................... 14.6quarts(13.8L)
Without Filter Change
....................................... 4.0 quarts (3.8 L)*
With Filter Change ......................................... 4.5 quarts (4.3 L)*
FuelTank ................................ ............. 20.0 gallons (75.7 L)
Manual Transmission (Overhaul)
............................. 2.2 quarts (2.1 L)*
Rear Axle
Lubricant
.................................................. 1.5 quarts (1.42 L)
Limited Slip Additive
...................................... .4.0 ounces (1 18 ml)
Tire Pressures
.......... See Tire-Loading Information label on rear edge of driver’s door
Cooling System
Crankcase
* Recheck fluid level after filling. See Section 6 or the Index.
6-76

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Short Trip/City Definition
Follow the Short TripKity Maintenance Schedule if any
one of these conditions is true for your vehicle:
Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
0 Most trips include extensive idling (such as frequent
driving in stop-and-go traffic).
Most trips are through dusty areas.
0 If the vehicle is used for delivery service, police, taxi
or other commercial application.
One of the reasons you should follow this schedule if
you operate your vehicle under any of these conditions
is that these conditions cause engine oil to break
down sooney:
Short Trip/City Intervals
Every 3,000 Miles (5 000 km): Engine Oil and Filter
Change (or
3 months, whichever occurs first).
Every 6,000 Miles (10 000 km): Chassis Lubrication
(or
6 months, whichever occurs first).
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection, if driving in dusty conditions. Automatic
Transmission Service (severe conditions only).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
Spark Plug Wire Inspection. Spark Plug Replacement.
Automatic Transmission Service (normal conditions).
These intervals only summarize maintenance services.
Be sure to follow the complete maintenance schedule
on
the following pages.
7-4

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
7 Long Tripmighway Definition
Follow this maintenance schedule only if none of the
conditions from the Short TripKity Maintenance
Schedule is true.
Driving a vehicle with a fully warmed engine under
highway conditions causes engine oil to break
down slower:
I Long Trip/Highway Intervals
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every 12 months, whichever occurs first).
Chassis Lubrication (or every 12 months, whichever
occurs first).
I
Every 15,000 Miles (25 000 km): Automatic
Transmission Service (severe conditions only).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Tank, Cap and Lines Inspection.
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
Spark Plug Wire Inspection. Spark Plug Replacement.
Automatic Transmission Service (normal conditions).
These intervals only summarize maintenance services.
Be sure to follow the complete maintenance schedule
on
the following pages.
7-5

Downloaded from www.Manualslib.com manuals search engine Short Trip/City Maintenance Schedule
30,000 Miles (50 000 km)
Cl Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service. *
0 Lubricate the suspension, steering and
parking brake cable guides, underbody
contact points and linkage (or every
6 months, whichever occurs first).
Cl Replace air cleaner filter.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace
parts as needed.
An Emission Control Service. 3'
An Emission Control Service.
I7 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter
at
100,000 miles (166 000 km).
Manual transmission fluid doesn't require change.
DATE ACTUAL MILEAGE SERVICED BY:
I I I
7-12

Downloaded from www.Manualslib.com manuals search engine I Short TripKity Maintenance Schedule I
60,000 Miles (100 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Lubricate the suspension, steering and
parking brake cable guides, underbody
contact points and linkage (or every
6 months, whichever occurs first).
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
An Emission Control Service. *
- In hilly or mountainous terrain.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter at
100,000 miles (166 000 km).
Manual transmission fluid doesn’t require change.
0 Inspect engine accessory drive belt.
An Emission Control Sewice.
Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.?
7-18

Downloaded from www.Manualslib.com manuals search engine 90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service. *
0 Lubricate the suspension, steering and
parking brake cable guides, underbody
contact points and linkage (or every
6 months, whichever occurs first).
0 Change automatic transmission fluid and
filter
if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly 'or mountainous terrain.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter
at
100,000 miles (166 000 km).
Manual transmission fluid doesn't require change.
Cl Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.
I
Short TripKity Maintenance Schedule
7-24
-

Downloaded from www.Manualslib.com manuals search engine I Long Trip/Highway Maintenance Schedult
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
c] Lubricate the suspension, steering and
parking brake cable guides, underbody
contact points and linkage (or every
12 months, whichever occurs first).
0 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32 O C) or higher.
An Emission Control Service. *
- In hilly or mountainous terrain.
- Uses such as found in taxi, police or
delivery service.
I
lfyou do not use your vehicle under any of
these conditions, change the fluid and filter
at
100,000 miles (I 66 000 km).
Manual transmission fluid doesn’t require change.
[7 Replace air cleaner filter.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace
parts as needed.
An Emission Control Service.
An Emission Control Service.
7-31

Downloaded from www.Manualslib.com manuals search engine Long Tripmighway Maintenance Schedulc
60,000 Mt& 0 000 km)
Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
0 Lubricate the suspension, steering and
parking brake cable guides, underbody
contact points and linkage (or every
12 months, whichever occurs first).
Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more of these conditions:
*
- In heavy city traffic where the outside
temperature regularly reaches
90°F
(32°C) or higher.
- In hilly or mountainous terrain.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter
at
100,000 miles (I 66 000 km).
Manual transmission fluid doesn’t require change.
0 Inspect engine accessory drive belt.
An Emission Control Service.
0 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service. 3-
DATE ACTUAL MILEAGE SERVICED BY:
7-34
__

Downloaded from www.Manualslib.com manuals search engine ’ Long Trip/Highway Maintenance Schedule
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service. *
0 Lubricate the suspension, steering and
parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).
17 Change automatic transmission fluid and
filter if the vehicle is mainly driven under
one or more of these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90 OF
(32°C) or higher.
- In hilly or mountainous terrain.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, change the fluid and filter
at
100,000 miles (1 66 000 km).
Manual transmission fluid doesn’t require change.
0 Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines fortdamage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.
DATE
SERVICED BY: ACTUAL MILEAGE
7-37

Downloaded from www.Manualslib.com manuals search engine Fabric Cleaning ............................... 6-55
Fabric Protection
............................... 6-55
Fan Control Buttons
.......................... 3.1. 3.4
Fiberglass Springs
.............................. 6-6 1
Fifth Gear. Manual Transmission ................... 2-24
Filling Your Tank
................................ 6-5
Filter. Air Cleaner .............................. 6- 15
Finish Care .................................... 6-58
FinishDamage
................................. 6-60
First Gear, Automatic Transmission
................ 2-23
First Gear, Manual Transmission
................... 2-24
Flashers, Hazard Warning
......................... 5-1
Flat Tire. Changing
............................. 5-22
Fluid Capacities
................................ 6-76
Fluids and Lubricants
............................ 7-46
Fog Lamp Bulb Replacement
..................... 6-40
FogLamps
.................................... 2-44
Foreign Countries, Fuel
........................... 6-4
Fourth Gear, Manual Transmission
................. 2-24
French Language Manual
11
FrontTowing ................................... 5-8
Front Turn Signal Lamp Bulb Replacement .......... 6-38
Fuel
.......................................... 6-3
Canada
...................................... 6-4
Gauge
....................................... 2-94
In Foreign Countries
........................... 6-4
Fuel, Filling Your Tank
........................... 6-5
Fuses and Circuit Breakers
....................... 6-65
.. ...........................
GaugeMarhngs .............................. 2-96
Gauges Engine Coolant Temperature
.................... 2-82
Engine Oil Pressure
........................... 2-89
Engine Oil Temperature
........................ 2-90
Fuel
....................................... 2-94
Gear Positions
............................ 2-21, 2-24
Gross Axle Weight Rating
........................ 4-28
Gross Vehicle Weight Rating
...................... 4-28
Guide en FranGais
11
GAWR ....................................... 4-28
.. .................................
GVWR ..................................... 4-28
Halogen Bulbs
................................ 6-36
Hardtop. Convertible
............................ 2-64
Hazard Warning Flashers
.......................... 5-1
Headlamp Bulb Replacement
...................... 6-36
Headlamp Doors
............................... 2-43
HighLow Beam Changer
...................... 2-36
Wiring
..................................... 6-64
Hearing Impaired, Customer Assistance
.............. 8-3
Headlamps
.................................... 2-42
Heating
.................................... 3-2, 3-6
Heritage Pages .... 111 ...................................
High-Beam Lamps .............................. 2-36
Highway Hypnosis
.............................. 4-22
Hill and Mountain Roads
......................... 4-22
9-5