warning CHEVROLET CORVETTE 1998 5.G Service Manual

Downloaded from www.Manualslib.com manuals search engine Uniform Tire Quality Grading
The following information relates to the system
developed by the United States National Highway
Traffic Safety Administration, which grades tires by
treadwear, traction and temperature performance. (This
applies only to vehicles sold in the United States.) The
grades are molded on the sidewalls of most passenger
car tires. The Uniform Tire Quality Grading system does
not apply to deep tread, winter-type snow tires,
space-saver or temporary use spare tires, tires with
nominal rim diameters of 10 to 12 inches (25 to
30 cm),
or to some limited-production tires.
While the tires available on General Motors passenger
cars and light trucks may vary with respect to these
grades, they must also conform to Federal safety
requirements and additional General Motors Tire
Performance Criteria (TPC) standards.
Treadwear
The treadwear grade is a comparative rating based on
the wear rate of the tire when tested under controlled
conditions on a specified government test course. For
example, a tire graded 150 would wear one and a half
(1 1/2) times as well on the government course as a tire
graded
100. The relative performance of tires depends
upon the actual conditions of their use, however, and
may depart significantly from the norm due to variations
in driving habits, service practices and differences in
road characteristics and climate.
Traction -- A, B, C
The traction grades, from highest to lowest, are A, B, and
C, and they represent the tire’s ability to stop on wet
pavement as measured under controlled conditions on
specified government test surfaces of asphalt and concrete.
A tire marked C may have poor traction performance.
Warning: The traction grade assigned to this tire is based
on braking (straight ahead) traction tests and does not
include cornering (turning) traction.
6-47

Downloaded from www.Manualslib.com manuals search engine Temperature -- A, B, C
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of
heat and its ability to dissipate heat when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure.
The grade C corresponds to a level of performance
which all passenger car tires must meet under the
Federal Motor Vehicle Safety Standard
No. 109.
Grades B and A represent higher levels of performance
on the laboratory test wheel than the minimum required
by law.
Warning: The temperature grade for this tire is
established for a tire that
is properly inflated and not
overloaded. Excessive speed, underinflation,
or
excessive loading, either separately or in combination,
can cause heat buildup and possible tire failure.
Wheel Alignment and Tire Balance
The wheels on your vehicle were aligned and balanced
carefully at the factory to give you the longest tire life
and best overall performance. Scheduled wheel alignment and wheel balancing are not
needed. However,
if you notice unusual tire wear or
your vehicle pulling one
way or the other, the alignment
may need to be reset.
If you notice your vehicle
vibrating when driving on
a smooth road, your wheels
may need to be rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked, or badly rusted or corroded. If wheel nuts keep coming loose, the wheel,
wheel bolts and wheel nuts should be replaced. If the
wheel leaks air, replace it (except some aluminum
wheels, which can sometimes be repaired). See your
dealer if any of these conditions exist.
Your dealer will know the kind of wheel you need.
Each new wheel should have the same load-carrying
capacity, diameter, width, offset and be mounted the
same way as the one it replaces.
If you need to replace any of your wheels, wheel bolts or wheel nuts, replace them only with new
GM original
equipment parts. This way, you will be sure to have the
right wheel, wheel bolts and wheel nuts for your Corvette model.
6-48,

Downloaded from www.Manualslib.com manuals search engine Appearance Care
Remember, cleaning products can be hazardous. Some
are toxic. Others can burst into flame if you strike a
match or get them on a hot part of the vehicle. Some are
dangerous if you breathe their fumes in a closed space.
When you use anything from a container to clean your
vehicle, be sure to follow the manufacturer’s warnings
and instructions. And always open your doors or
windows when you’re cleaning the inside.
Never use these to clean your vehicle:
Gasoline
Benzene
Naphtha
0 Carbon Tetrachloride
0 Acetone
0 Paint Thinner
Turpentine
0 Lacquer Thinner
0 Nail Polish Remover They can all be
hazardous
-- some more than
others
-- and they can all damage your vehicle, too.
Don’t use any of these unless this manual says you can.
In many uses, these will damage your vehicle:
0 Alcohol
0 Laundry Soap
Bleach
0 Reducing Agents
Cleaning the Inside of Your Vehicle
Use a vacuum cleaner often to get rid of dust and loose
dirt. Wipe vinyl or leather with a clean, damp cloth.
Your dealer has two cleaners, Multi-Purpose Interior
Cleaner and Capture Non-Solvent Dry Spot and Soil
Remover. They will clean normal spots and stains very
well. You can get GM-approved cleaning products from
your dealer. (See “Appearance Care and Materials” in
the Index.)
Here are some cleaning tips:
0 Always read the instructions on the cleaner label.

Downloaded from www.Manualslib.com manuals search engine Section 9 Index
Accessory Outlet .............................. 2-59
Accessory Power Plug
........................... 6-63
Adding Equipment to the Outside of Your Vehicle
...... 6-3
AirBag
....................................... 1-18
How Does it Restrain
.......................... 1-23
How it Works ................................ 1-20
Location
............................... 1.20. 1-21
Servicing
................................... 1-24
What Makes it Inflate
.......................... 1-22
What Will
You See After it Inflates ............... 1-23
When Should it Inflate
......................... 1-22
Air Bag Readiness Light
.................... 1.20. 2.78
AirBagSystem
................................ 1-18
Aircleaner
.................................... 6-16
Air Conditioning
....................... 3.3. 3.7. 3.10
Alignment and Balance. Tire
...................... 6-48
Aluminum Wheels. Cleaning
...................... 6-58
Antenna Integrated
................................... 3-30
PowerMast ................................. 3-29
Antifreeze
..................................... 6-22
Anti-Lock Brakes
...................................... 4-7
Brake System Warning Light
................ 2.78. 4.7
Anti-Lock Brake System Warning Light
............. 2-80
Anti-Theft Radio
............................... 3-25
Appearance Care
............................... 6-52
Appearance Care Materials
....................... 6-6 1
Arbitration Program
.............................. 8-9 Ashtray
....................................... 2-58
Audio Equipment. Adding ........................ 3-27
Automatic
Audio Systems
................................. 3-12
Electronic Dual Climate Control System
............ 3-4
Overdrive
................................... 2-28
Transmission Check
........................... 7-12
Transmission Fluid ............................ 6-18
Transmission. Operation
....................... 2-26
Transmission. Park Mechanism Check
............ 7-14
Transmission. Shifting
......................... 2-26
Transmission. Starting Your Engine
.............. 2-22
Axle. Limited-Slip Rear
......................... 2-39
Axle. Rear
.................................... 6-21
Back-up Lamp Bulb Replacement
................. 6-37
Battery
....................................... 6-32
Jump Starting
................................. 5-3
Replacement. Remote Function Actuation (RFA) System
...................... 2-12
Warnings
................................ 5-3. 5-5
BBB Auto Line ................................. 8-9
Belt. Engine Accessory
.......................... 6-72
Better Business Bureau Mediation
................... 8-9
Blizzard
...................................... 4-26
Brake
Adjustment
.................................. 6-31
Fluid
....................................... 6-29
9-1

Downloaded from www.Manualslib.com manuals search engine Brake (Continued) Master Cylinder
.............................. 6-29
Parking
..................................... 2-32
PedalTravel
................................. 6-31
Replacing System Parts
........................ 6-32
System Warning Light
......................... 2-79
Transmission Shift Interlock
.................... 2-36
Wear
....................................... 6-31
Brakes. Anti-Lock
............................... 4-7
Brake-Transmission Shift Interlock Check
........... 7- 13
Braking
........................................ 4-6
Braking in Emergencies
........................... 4-9
Break.In. New Vehicle
.......................... 2-20
BTSI
......................................... 2-36
BTSICheck
................................... 7-13
Bulb Replacement
......................... 6.33. 6.69
Canadian Roadside Assistance
.................... 8-7
Capacities and Specifications
...................... 6-70
Carbon Monoxide
.................... 2.15.2.37. 4.28
Cassette Deck Service
........................... 7- 11
Cassette Tape Player ............................ 3-12
CareofYour
................................. 3-28
Center Console
................................. 2-55
Certification Label
.............................. 4-29
Chains. Tire
................................... 6-51
Check Gages Light
.............................. 2-85
Checking Your Restraint Systems
.................. 1-37
Chemical Paint Spotting
.......................... 6-60
Child Restraints
................................ 1-27
Add-on
..................................... 1-27
Securing in the Passenger Seat Position
........... 1-28
Top Strap
.................................... 1-3 1
Types ...................................... 1-27
WheretoPut
................................ 1-27
Cigarette Lighter
............................... 2-58
Circuit Breakers and Fuses
....................... 6-64
Cleaner. Air
................................... 6-16
Cleaning Aluminum Wheels
............................ 6-58
Coated Moldings
............................. 6-53
ConvenienceNet
............................. 6-54
Exterior LampsLenses
........................ 6-56
Fabric
...................................... 6-53
Glass
....................................... 6-54
Inside of Your Vehicle
......................... 6-52
Instrument Panel
............................. 6-54
Leather
..................................... 6-53
Outside of Your Vehicle
........................ 6-56
Removable Roof Panel
......................... 6-55
Security Shade
............................... 6-54
Soft-Touch Paint Surfaces
...................... 6-54
Stains
...................................... 6-53
Tires
....................................... 6-58
Vinyl
....................................... 6-53
Weatherstrips
................................ 6-55
Wheels
..................................... 6-58
Windshield and Wiper Blades
................... 6-55
Climate Control. Automatic Electronic Dual
........... 3-4
Clock. Setting the
............................... 3-12
Clutch. Hydraulic
............................... 6-20
Comfort Controls
................................ 3-1
Comfort Controls. Manual
......................... 3-2
Compact Disc
AdapterKit
.................................. 3-17
Care
....................................... 3-29 .
Changer. TmnkMounted ....................... 3-21
9-2

Downloaded from www.Manualslib.com manuals search engine Player ...................................... 3-17
Care
....................................... 3-29
Competitive Driving
............................ 2-24
Console. Center
........................... .. .... 2-55
Control of a Vehicle
.............................. 4-5
Convenience Net
............................... 2-57
Convenience Net. Cleaning
....................... 6-54
Convertible Top
................................ 2-68
Convex Outside Mirror
.......................... 2-54
Coolant
............................. 5.13.5.16. 6.22
SurgeTank
.................................. 5-18
Surge Tank Pressure Cap
....................... 6-26
Coolant Heater. Engine
.......................... 2-24
CoolingSystem
................................ 5-16
Courtesy Lamps
................................ 2-52
InCanada
.................................... 8-8
1ntheU.S. ................................... 8-8
Cruise Control ................................. 2-47
Customer Assistance for Text Telephone Users
......... 8-4
Customer Assistance Infomation
................... 8- 1
Customer Satisfaction Procedure .................... 8-2
Damage. Finish
............................... 6-59
Daytime Running Lamps
......................... 2-50
Dead Battery
................................... 5-3
Defects. Reporting Safety
........................ 8- 10
InCanada
................................... 8-11
To General Motors
............................ 8- 11
Defensive Driving
............................... 4-2
Defogger. Rear Window
......................... 3- 11
Defogging ............................ 3-3.3-7. 3-11
Defrosting ................................ 3-3. 3-11
Dimensions. Vehicle
............................ 6-7 1
Dolby B Noise Reduction ........................ 3-16 Door
Locks
....................................... 2-4
Downshifting
.................................. 2-31
Driver Information Center (DIC)
................... 2-87
Warnings and Messages
........................ 2-97
Controls and Displays
......................... 2-88
ABS active
.................................. 2-98
Charge System Fault
.......................... 2-99
Coolant Over Temp
.......................... 2- 101
Flat Tire
. (lf. lr. rf. rr) ........................ 2-104
High Oil Temperature Reduce Engine rpm
........ 2- 102
High Tire Pressure
. (If. lr. rf. rr) ................ 2-105
High Trans Temp
............................ 2- 102
Low Coolant
................................ 2- 101
LowOilLevel ............................... 2-99
Low
Oil Pressure ............................. 2-98
Low Tire Pressure
. (If. lr. rf. rr) ................ 2-103
Maximum Speed
80 mph (129 Wh) ............ 2-101
Reduced Engine Power
........................ 2-99
ServiceABS
................................. 2-98
Service Column Lock
.......................... 2-98
Service Ride Control
......................... 2- 101
Service Tire Monitor (MON) System (SYS) ....... 2-106
Service Traction System
...................... 2-100
Service Vehicle Soon
.......................... 2-99
Shocks Inoperative
........................... 2- 10 1
Traction System
- OFF ....................... 2-100
Traction System
- ON ........................ 2-100
Traction System
(SYS) Active .................. 2-100
Driver Position
................................. 1-11
Driving
........................................ 4-1
City
........................................ 4-19
Defensive
.................................... 4-2
Driver Information Center
(DIC) Messages
9-3

Downloaded from www.Manualslib.com manuals search engine Driving (Continued) Drunken
..................................... 4-2
Freeway
.................................... 4-20
InaBlizzard
................................. 4-26
IntheRain
.................................. 4-17
Oncurves
.................................. 4-10
OnSnowandIce ............................. 4-25
WetRoads
.................................. 4-17
Winter
...................................... 4-24
In Foreign Countries
........................... 6-4
Night
...................................... 4-15
On Hill and Mountain Roads
.................... 4-22
Through Deep Water
.......................... 4-18
Drunken Driving
................................ 4-2
Electrical Equipment. Adding
.......... 2.23.3.27. 6.62
Electrical System
............................... 6-62
Electronic Dual Climate Control System
.............. 3-4
Accessory Belt
............................... 6-72
Coolant
........................... 5-13,5-16, 6-22
Coolant Heater
............................... 2-24
Coolant Level Check
.......................... 7- 11
Coolant Temperature Gage ................ 2-8 1, 5- 13
Exhaust
........................... 2-15,2-37, 4-28
Identification
................................ 6-62
Oil, Adding ................................. 6-12
Oil, Additives
................................ 6-15
Oil, Life Monitor
............................. 6-15
EMT
......................................... 6-41
Engine
....................................... 6-10
FuseBlock
.................................. 6-67
Oil
........................................ 6-12
Oil, Checking
................................ 6-12
OilLevelCheck
.............................. 7-11
9-4
Oil. Used ................................... 6-16
Overheating
................................. 5-13
Specifications
................................ 6-70
Oil,
When to Change
.......................... 6-15
Running While Parked
......................... 2-38
Starting Your
................................ 2-22
Oil, Pressure Gage
............................ 2-84
EnglisWMetric Button
........................... 2-77
Ethanol
........................................ 6-4
Exhaust, Engine
...................... 2-15,2-37, 4-28
Express-Down Window
.......................... 2-41
Extended Mobility Tires
......................... 6-41
Fabric Cleaning
............................... 6-53
Fabric Protection
............................... 6-53
Fan Control Buttons
.......................... 3-2, 3-6
Feature, Theft-Deterrent
......................... 2-17
Fiberglass Springs
.............................. 6-59
Fifth Gear. Manual Transmission
................... 2-29
Filling
a Portable Fuel Container .................... 6-8
Filling Your Tank ................................ 6-5
Filter, Air Cleaner
.............................. 6-17
Finish Damage
................................. 6-59
Finish Damage
................................. 6-59
First Gear, Automatic Transmission
................ 2-28
First Gear, Manual Transmission
................... 2-29
Flashers, Hazard Warning
......................... 5-2
Flat Tire, What to Do
............................ 5-22
Fluid Capacities
................................ 6-71
Overheated
Engine Protection Operating Mode
..... 5-13
Finishcare
.................................... 6-56
FloorMats
.................................... 2-59
FobTraining
................................... 2-97
FogLamps
.................................... 2-51

Downloaded from www.Manualslib.com manuals search engine Foreign Countries. Fuel ........................... 6-4
Fourth Gear. Manual Transmission
................. 2-29
French Language Manual
11
Front Sidemarker Lamp Bulb Replacement ........... 6-35
FrontTowing
.................................. 5-10
Front
Turn Signal Lamp Bulb Replacement .......... 6-35
Fuel
.......................................... 6-3
Canada
.................................. 6-4. 6-5
Gage
....................................... 2-86
In Foreign Countries ........................... 6-4
Fuel. Filling Your Tank
........................... 6-5
Fuses and Circuit Breakers
....................... 6-64
.. ...........................
Gages Engine Coolant Temperature
.................... 2-8 1
Engine Oil Pressure ........................... 2-84
Fuel
....................................... 2-86
Voltmeter
................................... 2-79
GAWR
.................................. 4.29. 4.30
Gear Positions
.................................. 2-26
Gross Axle Weight Rating ................... 4.29. 4.30
Guide en Fransais
................................. ii
GVWR
.................................. 4.29. 4.30
Gross Vehicle Weight Rating
................. 4.29. 4.30
Halogen Bulbs
................................ 6-33
Hazard Warning Flashers
.......................... 5-2
Headlamp Doors
............................... 2-44
HeadlampMighbeams Bulb Replacement
............ 6-33
Headlamps
.................................... 2-43
High/Low Beam Changer
...................... 2-45
Wiring
..................................... 6-64
Hearing Impaired. Customer Assistance
.............. 8-4
Heating
....................................... 3-10
... Heritagepages ................................... n1
Highway Hypnosis .............................. 4-22
Hill and Mountain Roads
......................... 4-22
Hood
.............................................
Checking Things Under ......................... 6-8
Release
...................................... 6-9
Horn
......................................... 2-41
Hydraulic Clutch
............................... 6-20
Ignition Switch
................................ 2-20
Inadvertent Load Control
......................... 2-53
Inside DayNight Rearview Mirror
................. 2-53
Brakesystem
................................ 7-15
Exhaust System
.............................. 7-15
Radiator and Heater Hose
...................... 7-15
Steering
.................................... 7-15
Tire
........................................ 7-15
Wheel
...................................... 7-15
Instrumentpanel
............................... 2-74
Brightness Control
............................ 2-52
Cleaning
.................................... 6-54
Cluster
..................................... 2-76
FuseBlock
.................................. 6-64
Instrument Panel Cupholder
....................... 2-54
Interior Lamps
................................. 2-52
Jump Starting
.................................. 5-3
High-BeamLamps
.............................. 2-45
Hydroplaning
.................................. 4-18
Inflation. Tire
.................................. 6-44
Inspections
.................................... 7-15
Suspension
.................................. 7-15
......... 9-5

Downloaded from www.Manualslib.com manuals search engine Key Lock Cylinders Service ..................... 7-12
Keys
.......................................... 2-2
Labels
........................................ 4-29
Certification
................................. 4-29
Service Parts Identification
..................... 6-62
Tire-Loading Information
...................... 4-29
Vehicle Identification Number
................... 6-62
Lamps
........................................ 2-50
Cleaning Exterior LampsLenses
................. 6-56
Courtesy
.................................... 2-52
Exterior
.................................... 2-50
Interior
..................................... 2-52
OnReminder
................................ 2-44
Lap Belt Cinch Feature
.......................... 1-12
Latches. Seatback
................................ 1-5
Leaving Your Vehicle
............................. 2-5
Leaving Your Vehicle with the Engine Running
....... 2-35
Lighter
....................................... 2-58
Liihts Air Bag Readiness
....................... 1.20. 2.78
Anti-LGck Brake System Warning
................ 2-80
Anti-Lock Brake Warning
.................. 2.78. 4.7
Brake System Warning
......................... 2-78
CheckEngine
................................ 2-84
CheckGages
................................ 2-85
Safety Belt Reminder
...................... 1.6. 2.78
Loading Your Vehicle
........................... 4-29
Security
.................................... 2-85
Locks
......................................... 2-4
Cylinders
................................... 7-12
Door ........................................ 2-4
Ignition Automatic Transmission Lock Check
...... 7-14
Key Lock Cylinders Service
.................... 7-12 PowerDoor
.................................. 2-5
Using the Wheel Lock Key
..................... 6-50
Lubricants and Fluids ............................ 7-16
Lubrication Service. Body
........................ 7-12
Magnesium Wheel Finish
....................... 6-59
Maintenance Record
............................ 7-18
Maintenance Schedule
............................ 7-1
Periodic Maintenance Inspections
................ 7-15
Recommended Fluids and Lubricants
............. 7-16
Scheduled Maintenance Services
.................. 7-4
Your Vehicle and the Environment
................ 7-2
Maintenance. Underbody
......................... 6-59
Malfunction Indicator Lamp
...................... 2-82
Comfort Control System
........................ 3-2
Frontseat
.................................... 1-2
Transmission Check
........................... 7-12
Transmission Fluid
............................ 6-19
Transmission. Shifting
......................... 2-29
Transmission. Starting Your Engine
.............. 2-22
Memory
....................................... 2-5
Methanol
...................................... 6-4
Mirrors
....................................... 2-53
Convex Outside
.............................. 2-54
Inside Daymight Rearview
..................... 2-53
Power Remote Control
......................... 2-54
Visor Vanity
................................. 2-58
MMT ......................................... 6-4
MountainRoads
................................ 4-22
Multifunction Lever
............................. 2-42
Manual
9-6

Downloaded from www.Manualslib.com manuals search engine Remote Function Actuation System Matching Transmitter(s) to Your Vehicle
........... 2- 11
Resynchronizing Your Transmitter
............... 2- 11
Replacement Parts .............................. 6-70
Replacement, Wheel
............................ 6-48
Reporting Safety Defects ......................... 8- 10
InCanada
................................... 8-11
To General Motors
............................ 8- 11
Resetting the Oil Life Monitor
..................... 6- 15
Checking
................................... 1-33
Child
....................................... 1-27
Replacing
Parts After a Crash ................... 1-34
Systemcheck
................................ 7-12
Retained Accessory Power
(RAP) .................. 2-22
Reverse, Automatic Transmission
.................. 2-27
Reverse, Manual Transmission
.................... 2-29
Ridecontrol
................................... 2-39
Roadside Assistance
.............................. 8-5
Roadside Assistance, Canadian ..................... 8-7
Rocking Your Vehicle ........................... 5-23
RoofPanel
.................................... 2- 60
Rotation, Tire
.................................. 6-45
Operation
.................................... 2-8
Remote HatcNTrunk Lid Release
.................. 2-14
Replacement Bulbs
............................. 6-69
Restraints
Safety Belts
................................... 1-6
Adults
...................................... 1-11
Care
....................................... 6-54
Children
.................................... 1-25
Driver Position
............................... 1-11
Extender .................................... 1-37
How to Wear Properly ......................... 1 . 11
Incorrect Usage .................... 1.13.1.31. 1.32
Lap Belt Cinch Feature
........................ 1-12
Larger Children
.............................. 1-34
Passenger Position
............................ 1-18
Questions and Answers
........................ 1-10
Reminder Light
.......................... 1.6. 2.78
Replacing After a Crash
........................ 1-38
Smaller Children and Babies
.................... 1-25
Use During Pregnancy
......................... 1 . 17
WhyTheyWork
............................... 1-7
Safety Defects. Reporting
........................ 8-10
InCanada
................................... 8-11
To General Motors
............................ 8-11
Safety Warnings and Symbols
...................... vm
Scheduled Maintenance Services .................... 7-4
Seatback Latches
...................................... 1-5
Reclining
.................................... 1-3
Seats
........................................,. l-2
ManualFront ................................. 1-2
Power
....................................... l-2
Securing a Child Restraint ...................... 1-32
sport
........................................ 1-3
Seats and Restraint Systems
........................ 1-1
Seats and Seat Controls
........................... 1-2
Second Gear, Automatic Transmission
.............. 2-28
Second Gear, Manual Transmission
................. 2-29
Security Shade, Cleaning
......................... 6-54
Selective Real Time Damping
..................... 2-39
Lap-Shoulder
................................ 1-11
...
SecurityLight .................................. 2-85
Security
Shade ................................. 2-55
9-8