engine overheat CHEVROLET CORVETTE 2023 User Guide

Chevrolet Corvette Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
16287457) - 2023 - CRC - 3/10/22
Vehicle Care 255
If coolant is needed, be sure the cooling
system is cool, then add the proper
DEX-COOL coolant mixture directly to the
surge tank.1. Open the Hatch/Trunk. See Hatch (Trunk)
0 19.
2. When the cooling system, including the
coolant surge tank pressure cap and
engine, is no longer hot, remove the
pressure cap.
Turn the pressure cap slowly
counterclockwise about one-quarter turn
and then stop.
If a hiss is heard, wait for that to stop.
A hiss means there is still some
pressure left.
3. Keep turning the pressure cap slowly, and remove it.4. Fill the coolant surge tank with theproper mixture until the level inside
stabilizes at the COLD FILL indicator in
the surge tank.
5. With the coolant surge tank pressure cap off, start the engine and let it run until
the engine is hot.
By this time, the coolant level inside the
coolant surge tank may be lower. If the
level is lower, add more of the proper
mixture to the coolant surge tank until
the level stabilizes at the COLD FILL
indicator in the coolant surge tank.
6. Replace the pressure cap tightly. 7. Verify coolant level after the engine is
shut off and the coolant is cold.
If necessary, repeat coolant fill procedure
Steps 3−7.
If the coolant still is not at the proper
level when the system cools down again,
see your dealer.
Caution
If the pressure cap is not tightly installed,
coolant loss and engine damage may
occur. Be sure the cap is properly and
tightly secured.
Engine Overheating
The vehicle has several indicators to warn of
engine overheating.
There is an engine coolant temperature
gauge on the instrument cluster. See Engine
Coolant Temperature Gauge 083. The
vehicle may also display a message on the
Driver Information Center (DIC).
If the decision is made not to lift the hatch
but to get service help right away, see
Roadside Assistance Program 0322.
If the decision is made to lift the hatch,
make sure the vehicle is parked on a level
surface.

Chevrolet Corvette Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
16287457) - 2023 - CRC - 3/10/22
256 Vehicle Care
Then check to see if the engine cooling fans
are running. There are two cooling fans
located in the front (one at each corner) and
two cooling fans in the rear (one on each
side of the engine). If the engine is
overheating, the fans should be running.
If they are not, do not continue to run the
engine, and have the vehicle serviced.
Caution
Do not run the engine if there is a leak
in the engine cooling system. This can
cause a loss of all coolant and can
damage the system and vehicle. Have
any leaks fixed right away.
If Steam Is Coming from the Engine
{Warning
Steam and scalding liquids from a hot
cooling system are under pressure.
Turning the pressure cap, even a little,
can cause them to come out at high
speed and you could be burned. Never
turn the cap when the cooling system,
including the pressure cap, is hot. Wait
for the cooling system and pressure cap
to cool.
If Steam Is Coming from the Engine
Compartment with no Overheat Warning
Water from rain and car washes could enter
the engine compartment and contact hot
surfaces. If steam is coming from the engine
compartment with no accompanying
overheat warning, no service is needed.
If No Steam Is Coming from the Engine
If an engine overheat warning is displayed
but no steam can be seen or heard, the
problem may not be too serious. Sometimes
the engine can get a little too hot when the
vehicle:
.Climbs a long hill on a hot day.
.Stops after high-speed driving.
.Idles for long periods in traffic.
If the overheat warning is displayed with no
sign of steam: 1. Turn the air conditioning off.
2. Turn the heater on to the highest temperature and to the highest fan
speed. Open the windows as necessary.
3. When it is safe to do so, pull off the road, shift to P (Park) or N (Neutral), and
let the engine idle. If the engine coolant temperature gauge is
no longer in the shaded area or an overheat
warning no longer displays, the vehicle can
be driven. Continue to drive the vehicle
slowly for about 10 minutes. Keep a safe
vehicle distance from the vehicle in front.
If the warning does not come back on,
continue to drive normally and have the
cooling system checked for proper fill and
function.
If the warning continues, pull over safely,
and park the vehicle right away.
If there is no sign of steam, idle the engine
for three minutes while parked. If the
warning is still displayed, turn off the
engine until it cools down.Washer Fluid
What to Use
When the vehicle needs windshield washer
fluid, be sure to read the manufacturer
instructions before use. If the vehicle will be
operating in an area where the temperature
may fall below freezing, use a fluid that has
sufficient protection against freezing.

Chevrolet Corvette Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
16287457) - 2023 - CRC - 3/10/22
278 Vehicle Care
UTQGS (Uniform Tire Quality Grading
Standards)
:A tire information system
that provides consumers with ratings
for a tire's traction, temperature, and
treadwear. Ratings are determined by
tire manufacturers using government
testing procedures. The ratings are
molded into the sidewall of the tire.
See Uniform Tire Quality Grading 0287.
Vehicle Capacity Weight
:The number
of designated seating positions
multiplied by 68 kg (150 lbs) plus the
rated cargo load. See Vehicle Load
Limits 0186.
Vehicle Maximum Load on the Tire
:
Load on an individual tire due to curb
weight, accessory weight, occupant
weight, and cargo weight.
Vehicle Placard
:A label permanently
attached to a vehicle showing the
vehicle's capacity weight and the
original equipment tire size and
recommended inflation pressure. See
“Tire and Loading Information Label”
under Vehicle Load Limits 0186.
Tire Pressure
Tires need the correct amount of air
pressure to operate effectively.
{Warning
Neither tire underinflation nor
overinflation is good. Underinflated
tires, or tires that do not have
enough air, can result in:
.Tire overloading and overheating,
which could lead to a blowout
.Premature or irregular wear
.Poor handling
.Reduced fuel economy for
internal combustion engine
vehicles
.Reduced range for electric vehicles
Overinflated tires, or tires that have
too much air, can result in:
.Unusual wear
.Poor handling
.Rough ride
(Continued)
Warning (Continued)
.Needless damage from road
hazards
The Tire and Loading Information label
on the vehicle indicates the original
equipment tires and the correct cold
tire inflation pressures. The
recommended pressure is the minimum
air pressure needed to support the
vehicle's maximum load carrying
capacity. See Vehicle Load Limits 0186.
How the vehicle is loaded affects
vehicle handling and ride comfort.
Never load the vehicle with more
weight than it was designed to carry.
When to Check
Check the pressure of the tires once a
month or more.

Chevrolet Corvette Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
16287457) - 2023 - CRC - 3/10/22
342 Index
DualAutomatic Climate Control System . . . . 163
Clutch Transmission . . . . . . . . . . . . . . . . . . . . 195
Clutch Transmission Fluid . . . . . . . . . . . . . . 249
Clutch Transmission Fluid Life
System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 249
Dual Clutch Transmission
Manual Mode . . . . . . . . . . . . . . . . . . . . . . . . . 198
E
ElectricBrake Boost . . . . . . . . . . . . . . . . . . . . . . . . . . . . 203
Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . 204
Parking Brake Light . . . . . . . . . . . . . . . . . . . . . 88
Electrical Equipment, Add-On . . . . . . . . . . . . . . . . . . . . 230
System Overload . . . . . . . . . . . . . . . . . . . . . . 264
Electrical System Fuses and Circuit Breakers . . . . . . . . . . . . . 266
Instrument Panel Fuse Block . . . . . . . . . . . 266
Rear Compartment Fuse Block . . . . . . . . . 268
Electronic Stability Control (ESC) Off Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 332 Engine
Air Cleaner/Filter . . . . . . . . . . . . . . . . . . . . . . 251
Air Filter Life System . . . . . . . . . . . . . . . . . . 250
Check Light (Malfunction Indicator) . . . . . 86
Compartment Overview . . . . . . . . . . . . . . . . 235
Coolant Temperature Gauge . . . . . . . . . . . . 83
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . 252
Drive Belt Routing . . . . . . . . . . . . . . . . . . . . . 318
Exhaust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 194
Oil Life System . . . . . . . . . . . . . . . . . . . . . . . . 248
Oil Pressure Light . . . . . . . . . . . . . . . . . . . . . . . 91
Overheating . . . . . . . . . . . . . . . . . . . . . . . . . . . 255
Power Messages . . . . . . . . . . . . . . . . . . . . . . . . 98
Running While Parked . . . . . . . . . . . . . . . . . 195
Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 191
Engine Compartment Lamp . . . . . . . . . . . . . . 106
Entry Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
Event Data Recorders . . . . . . . . . . . . . . . . . . . . 329
Exit Lighting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106
Extended Parking . . . . . . . . . . . . . . . . . . . . . . . . 194
Extender, Seat Belt . . . . . . . . . . . . . . . . . . . . . . . . 51
Exterior
Lamp Controls . . . . . . . . . . . . . . . . . . . . . . . . . 102
Lamps Off Reminder . . . . . . . . . . . . . . . . . . . 102
Lighting Battery Saver . . . . . . . . . . . . . . . . . 107
F
FilterEngine Air Cleaner . . . . . . . . . . . . . . . . . . . . . 251
Flash-to-Pass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 103
Flashers, Hazard Warning . . . . . . . . . . . . . . . . 104
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 290
Floor Mats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 304
Fluid Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 260
Dual Clutch Transmission . . . . . . . . . . . . . . 249
Dual Clutch Transmission LifeSystem . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 249
Washer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256
Folding Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Frequency Statement
Radio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 327
Front Air Dam . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 189
Heated and Ventilated Seats . . . . . . . . . . . . 43
Lift System . . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Lift System Light . . . . . . . . . . . . . . . . . . . . . . . 87
Fuel Additives . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Economy, Driving for Better . . . . . . . . . . . 169
Filling a Portable Fuel Container . . . . . . . 229
Filling the Tank . . . . . . . . . . . . . . . . . . . . . . . . 228
Foreign Countries . . . . . . . . . . . . . . . . . . . . . . 228
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82

Chevrolet Corvette Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
16287457) - 2023 - CRC - 3/10/22
Index 345
ManualMode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 198
Map Data Updates . . . . . . . . . . . . . . . . . . . . . . . . 133
Maps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Media Avoiding Untrusted Devices . . . . . . . . . . . . . 118
Memory Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Messages
Engine Power . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Vehicle Speed . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Mirrors Automatic Dimming . . . . . . . . . . . . . . . . . . . . 25
Automatic Dimming Rearview . . . . . . . . . . 26
Convex . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Folding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Heated . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Interior Rearview . . . . . . . . . . . . . . . . . . . . . . . 26
Manual Rearview . . . . . . . . . . . . . . . . . . . . . . . 26
Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Rear Camera . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Tilt in Reverse . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Mode Driver Control . . . . . . . . . . . . . . . . . . . . . . . . . 208
Monitor System, Tire Pressure . . . . . . . . . . . 280
Multi-Point Vehicle Inspection (MPVI) . . . . 308N
Navigation
Connected Services . . . . . . . . . . . . . . . . . . . . 336
Destination . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Using the System . . . . . . . . . . . . . . . . . . . . . . 122
Net, Convenience . . . . . . . . . . . . . . . . . . . . . . . . . . 71
New Vehicle Break-In . . . . . . . . . . . . . . . . . . . . 189
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82 Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Off-Road Recovery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171
Oil
Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . 242, 245
Engine Oil Life System . . . . . . . . . . . . . . . . . 248
Pressure Light . . . . . . . . . . . . . . . . . . . . . . . . . . 91
Older Children, Restraints . . . . . . . . . . . . . . . . . .61
Online Account . . . . . . . . . . . . . . . . . . . . . . . . . . . 321
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 330 Additional Information . . . . . . . . . . . . . . . . . 333
Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 331
OnStar Emergency . . . . . . . . . . . . . . . . . . . . . . . 332
OnStar Security . . . . . . . . . . . . . . . . . . . . . . . . . . 332
Outlets
Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75 Overheating, Engine . . . . . . . . . . . . . . . . . . . . . 255
Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Instrument Panel . . . . . . . . . . . . . . . . . . . . . . . . 4
P
Panel, Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
ParkAssist . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 223, 225
Shifting Into . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Shifting Out of . . . . . . . . . . . . . . . . . . . . . . . . 193
Parking Brake and P (Park) Mechanism
Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262
Extended . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 194
Over Things That Burn . . . . . . . . . . . . . . . . . 194
Parking or Backing Assistance Systems . . . . . . . . . . . . . . . . . . . . 223
Passenger Airbag Status Indicator . . . . . . . . . . . . . . . . . 85
Compartment Air Filter . . . . . . . . . . . . . . . . 166
Sensing System . . . . . . . . . . . . . . . . . . . . . . . . . 56
Perchlorate Materials Requirements, California . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 232
Performance Data Recorder (PDR) . . . . . . . . . . . . . . . . . . . 138
Transmission Active . . . . . . . . . . . . . . . . . . . . . 89