engine overheat CHEVROLET CRUZE 2018 User Guide

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11348462) - 2018 - crc - 5/15/17
274 Vehicle Care
The coolant surge tank is located in
the engine compartment on the
driver side of the vehicle. See
Engine Compartment Overview
0262.
How to Add Coolant to the
Coolant Surge Tank
{Warning
Steam and scalding liquids from a
hot cooling system are under
pressure. Turning the pressure
cap, even a little, can cause them
to come out at high speed and
you could be burned. Never turn
the cap when the cooling system,
including the pressure cap, is hot.
Wait for the cooling system and
pressure cap to cool.
{Warning
Plain water, or other liquids such
as alcohol, can boil before the
proper coolant mixture will. With
(Continued)
Warning (Continued)
plain water or the wrong mixture,
the engine could get too hot but
there would not be an overheat
warning. The engine could catch
fire and you or others could be
burned.
{Warning
Spilling coolant on hot engine
parts can burn you. Coolant
contains ethylene glycol and it will
burn if the engine parts are hot
enough.
Caution
Failure to follow the specific
coolant fill procedure could cause
the engine to overheat and could
cause system damage. If coolant
is not visible in the surge tank,
contact your dealer. If no problem is found, check to see
if coolant is visible in the coolant
surge tank. If coolant is visible but
the coolant level is not at or above
the indicated mark, add a 50/
50 mixture of clean, drinkable water
and DEX-COOL coolant. Be sure
the cooling system, including the
coolant surge tank pressure cap, is
cool before you do it.
1. Remove the coolant surge tank
pressure cap when the cooling
system, including the coolant
surge tank pressure cap and
upper radiator hose, is no
longer hot.
Turn the pressure cap slowly
counterclockwise about
one-quarter of a turn. If you
hear a hiss, wait for that to
stop. This will allow any
pressure still left to be vented
out the discharge hose.

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11348462) - 2018 - crc - 5/15/17
Vehicle Care 275
2. Keep turning the pressure capslowly and remove it.
1.4L L4 Engine (LE2) Shown, 1.6L
L4 Diesel Engine (LH7) Similar
3. Fill the coolant surge tank with the proper mixture to the
indicated level mark.
4. With the coolant surge tank pressure cap off, start the
engine, switch off the A/C and
let the engine run until the
upper radiator hose can be felt
getting hot. Watch out for the
engine cooling fan. By this time, the coolant level
inside the coolant surge tank
may be lower. If the level is
lower, add more of the proper
mixture to the coolant surge
tank until the level reaches the
indicated level mark.
5. Replace the pressure cap. Be sure the pressure cap is
hand-tight.
6. Verify coolant level after the engine is shut off and the
coolant is cold. If necessary,
repeat coolant fill procedure
Steps 1–6.
If the coolant still is not at the
proper level when the system
cools down again, see your
dealer.
Caution
If the pressure cap is not tightly
installed, coolant loss and engine
damage may occur. Be sure the
cap is properly and tightly
secured.
Engine Overheating
The vehicle has an engine coolant
temperature gauge on the
instrument cluster to warn of engine
overheating. See Engine Coolant
Temperature Gauge 0127.
If the decision is made not to lift the
hood when this warning appears,
get service help right away. Contact
your dealer for additional
information.
If the decision is made to lift the
hood, make sure the vehicle is
parked on a level surface.
Then check to see if the engine
cooling fan is running. If the engine
is overheating, the fan should be
running. If it is not, do not continue
to run the engine, and have the
vehicle serviced.
Caution
Do not run the engine if there is a
leak in the engine cooling system.
This can cause a loss of all (Continued)

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11348462) - 2018 - crc - 5/15/17
276 Vehicle Care
Caution (Continued)
coolant and can damage the
system and vehicle. Have any
leaks fixed right away.
If Steam Is Coming from the
Engine Compartment
{Warning
Steam and scalding liquids from a
hot cooling system are under
pressure. Turning the pressure
cap, even a little, can cause them
to come out at high speed and
you could be burned. Never turn
the cap when the cooling system,
including the pressure cap, is hot.
Wait for the cooling system and
pressure cap to cool.
If No Steam Is Coming from
the Engine Compartment
If an engine overheat warning is
displayed but no steam can be seen
or heard, the problem may not betoo serious. Sometimes the engine
can get a little too hot when the
vehicle:
.
Climbs a long hill on a hot day.
. Stops after high-speed driving.
. Idles for long periods in traffic.
If the overheat warning is displayed
with no sign of steam: 1. Turn the air conditioning off.
2. Turn the heater on to the highest temperature and to the
highest fan speed. Open the
windows as necessary.
3. When it is safe to do so, pull off the road, shift to P (Park) or
N (Neutral), and let the
engine idle.
If the engine coolant temperature
gauge is no longer in the overheat
zone, the vehicle can be driven.
Continue to drive the vehicle slowly
for about 10 minutes. Keep a safe
distance from the vehicle in front.
If the warning does not come back
on, continue to drive normally and
have the cooling system checked
for proper fill and function. If the warning continues, pull over,
stop, and park the vehicle
right away.
If there is no sign of steam, idle the
engine for three minutes while
parked. If the warning is still
displayed, turn off the engine until it
cools down.
Washer Fluid
What to Use
When windshield washer fluid is
needed, be sure to read the
manufacturer's instructions before
use. If operating the vehicle in an
area where the temperature may fall
below freezing, use a fluid that has
sufficient protection against
freezing.
Adding Washer Fluid

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11348462) - 2018 - crc - 5/15/17
Index 395
Driving (cont'd)Defensive . . . . . . . . . . . . . . . . . . . . . 197
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 197
For Better Fuel Economy . . . . . . . 28
Hill and Mountain Roads . . . . . . 200
If the Vehicle is Stuck . . . . . . . . . 202
Loss of Control . . . . . . . . . . . . . . . 199
Off-Road Recovery . . . . . . . . . . . 198
Vehicle Load Limits . . . . . . . . . . . 202
Wet Roads . . . . . . . . . . . . . . . . . . . 199
Winter . . . . . . . . . . . . . . . . . . . . . . . . 201
E
Electrical Equipment,
Add-On . . . . . . . . . . . . . . . . . . . . . . . 257
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 291
Fuses and Circuit Breakers . . . 290
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 295
Overload . . . . . . . . . . . . . . . . . . . . . 290
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 382
Engine Air Cleaner/Filter . . . . . . . . . . . . . 270
Check Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . 130
Compartment Overview . . . . . . . 262 Engine (cont'd)
Coolant Temperature
Gauge . . . . . . . . . . . . . . . . . . . . . . 127
Cooling System . . . . . . . . . . . . . . . 272
Drive Belt Routing . . . . . . . . . . . . 366
Exhaust . . . . . . . . . . . . . . . . . . . . . . 217
Heater . . . . . . . . . . . . . . . . . . . . . . . . 213
Oil Life System . . . . . . . . . . . . . . . 268
Oil Pressure Light . . . . . . . . . . . . 135
Overheating . . . . . . . . . . . . . . . . . . 275
Power Messages . . . . . . . . . . . . . 144
Running While Parked . . . . . . . . 218
Starting . . . . . . . . . . . . . . . . . . . . . . . 209
Engines
Diesel Fuel . . . . . . . . . . . . . . . . . . . 246
Entry Lighting . . . . . . . . . . . . . . . . . . . 159
Event Data Recorders . . . . . . . . . . 379
Exhaust Fluid Diesel . . . . . . . . . . . . . . . . . . . . . . . . 219
Exit Lighting . . . . . . . . . . . . . . . . . . . . 159
Extended Parking . . . . . . . . . . . . . . . 216
Extender, Seat Belt . . . . . . . . . . . . . . 74
Exterior Lamp Controls . . . . . . . . . 153
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 160
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 218Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 280 Filter (cont'd)
Replacement (Fuel) . . . . . . . . . . . 254
Filter, Engine Air Cleaner . . . . . . . . . . . 270
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 155
Flashers, Hazard Warning . . . . . . 156
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 318 Changing . . . . . . . . . . . . . . . . . . . . . 326
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 347
Fluid
Automatic Transmission . . . . . . 269
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 278
Diesel Exhaust . . . . . . . . . . . . . . . . . 29
Washer . . . . . . . . . . . . . . . . . . . . . . . 276
Fog Lamps . . . . . . . . . . . . . . . . . . . . . 157
Folding Mirrors . . . . . . . . . . . . . . . . . . 55
Forward Collision Alert (FCA) System . . . . . . . . . . . . . . . . . 238
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 377
Front Fog Lamp Light . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Front Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . 62
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 64
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 244 Additives . . . . . . . . . . . . . . . . . . . . . 245
Biodiesel . . . . . . . . . . . . . . . . . . . . . 249

Chevrolet Cruze Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11348462) - 2018 - crc - 5/15/17
398 Index
LocksAutomatic Door . . . . . . . . . . . . . . . . . 46
Delayed Locking . . . . . . . . . . . . . . . . 46
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Lockout Protection . . . . . . . . . . . . . . 47
Power Door . . . . . . . . . . . . . . . . . . . . . 46
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Loss of Control . . . . . . . . . . . . . . . . . 199
Low Fuel Warning Light . . . . . . . . . 136
Low-Profile Tires . . . . . . . . . . . . . . . . 299
Lower Anchors and Tethers for Children (LATCH
System) . . . . . . . . . . . . . . . . . . . . . . . . 94
M
MaintenanceRecords . . . . . . . . . . . . . . . . . . . . . . 362
Maintenance and Care Additional . . . . . . . . . . . . . . . . . . . . . 356
Maintenance Schedule . . . . . . . . . 350 Recommended Fluids and
Lubricants . . . . . . . . . . . . . . . . . . . 359
Malfunction Indicator Lamp . . . . . 130
Manual Mode . . . . . . . . . . . . . . . . . . . 226
Manual Transmission . . . . . . . . . . . 227 Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Media Avoiding Untrusted Devices . . 169 Messages
Engine Power . . . . . . . . . . . . . . . . 144
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 144
Vehicle Speed . . . . . . . . . . . . . . . . 144
Mirrors Automatic DimmingRearview . . . . . . . . . . . . . . . . . . . . . . 55
Convex . . . . . . . . . . . . . . . . . . . . . . . . . 54
Folding . . . . . . . . . . . . . . . . . . . . . . . . . 55
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 55
Manual Rearview . . . . . . . . . . . . . . . 55
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Mirrors, Interior Rearview . . . . . . . . 55
Monitor System, Tire Pressure . . . . . . . . . . . . . . . . . . . . . . 307
Multi-band Antenna . . . . . . . . . . . . . 169
N
Navigation
OnStar . . . . . . . . . . . . . . . . . . . . . . . 383
New Vehicle Break-In . . . . . . . . . . . 206
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . 125
Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Off-Road Recovery . . . . . . . . . . . . . . . . . . . . . 198
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . 265 Oil (cont'd)
Engine Oil Life System . . . . . . . 268
Pressure Light . . . . . . . . . . . . . . . . 135
Older Children, Restraints . . . . . . . 87
Online Owner Center . . . . . . . . . . . 370
OnStar Additional
Information . . . . . . . . . . . . . . . . . . . . 387
OnStar Connections . . . . . . . . . . . . 384
OnStar Diagnostics . . . . . . . . . . . . . 386
OnStar Emergency . . . . . . . . . . . . . 382
OnStar Navigation . . . . . . . . . . . . . . 383
OnStar Overview . . . . . . . . . . . . . . . 381
OnStar Security . . . . . . . . . . . . . . . . 383
Operation Fog Lamps . . . . . . . . . . . . . . . . . . . 157
Infotainment System . . . . . . . . . . 164
Ordering Service Publications . . . . . . . . . . 376
Outlets Power . . . . . . . . . . . . . . . . . . . . . . . . .115
Overheating, Engine . . . . . . . . . . . . 275
Overview . . . . . . . . . . . . . . . . . . . . . . . 163P
Park Shifting Into . . . . . . . . . . . . . . . . . . . 215
Shifting Out of . . . . . . . . . . . . . . . . 215
Parking . . . . . . . . . . . . . . . . . . . . . . . . . 216
Brake . . . . . . . . . . . . . . . . . . . . . . . . . 229