engine oil capacity CHEVROLET EXPRESS 1996 1.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine Engine Oil (Gasoline Engine)
If your vehicle has a diesel engine, see “Engine Oil
(Diesel Engine)” in the Diesel Engine Supplement.
It’s
a good idea to check your engine oil every time you
get fuel.
In order to get an accurate reading, the oil must
be warm and the vehicle must be
on level ground.
Turn off the engine and give the
oil a few minutes to drain
back
into the oil pan. If you
don’t, the oil dipstick might
not show the actual level.
Checking Engine Oil
Pull out the dipstick and clean it with a paper towel or
cloth, then push
it back in all the way. Remove it again,
keeping
the tip down, and check the level.
When to Add Oil
If the oil is at or below the ADD mark, then you’ll need to
add some
oil. But you must use the right kind. This part
explains what kind
of oil to use. For crankcase capacity,
see “Capacities and Specifications”
in the Index.
I NOTICE:
Don’t add too much oil. If’ your engine has so much
oil that the oil level gets above the upper mark that
shows the proper operating range,
your engine
could be damaged.
6-11

Downloaded from www.Manualslib.com manuals search engine Cooling System Capacity
ENGINE VIN
“VORTEC” 4300 W
“VORTEC” 5000 M
“VORTEC” 5700 R
“VORTEC” 7400
J
QTY Without Rear Heater*
11 quarts ( 10.4 L)
17 quarts ( 16 L)
17 quarts ( 16 L)
23 quarts (2 1.8 L)
QTY With Rear Heater*
14 quarts (13.2 L)
20 quarts (18.9 L)
20 quarts ( 18.9 L)
26 quarts (24.6 L)
After refill, the level MUST be checked as outlined under “Engine Cooling System” in Section 5.
*All quantities are approximate.
Crankcase Capacity
ENGINE
“VORTEC” 4300
“VORTEC”
5000
“VORTEC” 5700
“VORTEC” 7400
VIN
W
M
R
J
Quantity With Filter
4.5 quarts (4.3 L)
5 quarts (4.8 L)
5 quarts (4.8 L)
7 quarts (6.5 L)
All quantities are approximate.
After refill, the level
MUST be checked as outlined under “Engine Oil And Filter Recommendations” in Section 5.
*Add an additional quart (1 L) for RPO 521 and RPO KL5 Models.

Downloaded from www.Manualslib.com manuals search engine Fuel Tank Capacity
TYPE
Standard Tank
Cutaway Standard Tank
Cutaway Optional Tank
All quantities are approximate.
QUANTITY
3 1 gallons (1 17.3 L)
35 gallons (132 L)
55 gallons (208.2 L)
Normal Replacement Parts
Engine “VORTEC” 4300
VIN w
Oil Filter PF52
Air Cleaner Filter* A9 17C
PCV Valve CV789C
Spark
Plugs 4 1-932
Fuel Filter GF48
1
Radiator Cap RC36 VORTEC”
5000
M
PF1218
A9 17C
cv774c
4 1-932
GF48
1
RC36
*For severe dusty conditions, use
AC Air Filter, Part No. 1236C. “VORTEC”
5700
R
PF1218
A9 17C
cv774c
4 1-932
GF48
1
RC36 “VORTEC” 7400
J
PF1218
A917C
cv774c
4 1-932
GF48
1
RC36
6-67

Downloaded from www.Manualslib.com manuals search engine Engine ........................................ 6-8
Coolant
..................................... 6-20
Coolant Level Check
.......................... 7-43
Coolant Temperature Gage
..................... 2-54
Cooling System
.............................. 6-66
Exhaust
..................................... 2-24
Identification
........................... 6-60. 6-65
OilLevelCheck
.............................. 7-43
Overheating
................................. 5- 10
Running While Parked ......................... 2-25
StartingYour
................................ 2-14
Engineoil
.................................... 6-11
Additives ................................... 6-13
Checking
................................... 6-11
Pressure Gage
................................ 2-52
Used
....................................... 6-14
Whentochange
.............................. 6-14
Ethanol
........................................ 6-3
Exhaust, Engine
................................ 2-24
Fabric Cleaning
............................... 6-5 I
Fan Control, Climate Control System ................ 3-2
FillingYourTank
................................ 6-4
Filter, Air
..................................... 6-15
Finish Care
.................................... 6-56
Finish Damage ................................. 6-57
First Gear, Automatic Transmission
................ 2- I9
Flashers, Hazard Warning ......................... 5-1
Flat Tire. Changing
............................. 5-20
Fluid Capacities
................................ 6-65
Fluids and Lubricants
............................ 7-49
Foreign Countries, Fuel
........................... 6-4
Adding ..................................... 6-11
French Language Manual 11
Front Parkingflurn Signal Lamp Bulb Replacement .... 6-34
Front Storage Area
.............................. 2-41
FrontTowing
................................... 5-8
Fuel .......................................... 6-2
Canada
...................................... 6-3
Filling Your Tank
.............................. 6-4
Gage
....................................... 2-53
In Foreign Countries ........................... 6-4
Tank Capacity
............................... 6-67
Fuses and Circuit Breakers
....................... 6-62
Gages
.. ...........................
Engine Coolant Temperature .................... 2-54
Engine Oil Pressure
........................... 2-52
Fuel
....................................... 2-53
Speedometer
................................. 2-45
Voltmeter
................................... 2-55
Gear Positions. Automatic Transmission
............. 2-17
Gross Axle Weight Rating
........................ 4-27
Gross Vehicle Weight Rating
...................... 4-26
Guide en Franpis
11
GAWR ....................................... 4-27
.. .................................
GVWR ....................................... 4-26
Halogen
Bulbs ................................ 6-31
Hazard Warning Flashers .......................... 5-1
Head Restraints
................................. 1-5
Headlamps
.................................... 2-35
Bulb Replacement
............................ 6-31
HighLow Beam Changer ...................... 2-30
OnReminder
................................ 2-36
Wiring
..................................... 6-61
9-4