warning CHEVROLET EXPRESS 1997 1.G Owner's Guide

Downloaded from www.Manualslib.com manuals search engine Temperature -- A, B, C
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation of
heat and its ability
to dissipate heat when tested under
controlled conditions on a specified indoor laboratory
test wheel. Sustained high temperature can cause the
material of the tire
to degenerate and reduce tire life, and
excessive temperature can lead to sudden tire failure.
The grade
C corresponds to a level of performance
which all passenger car tires must meet under the
Federal Motor Vehicle Safety Standard
No. 109. Grades
B and A represent higher levels of performance on the
laboratory test wheel than the minimum required by law.
Warning: The temperature grade for this tire is
established for a tire that is properly inflated and not
overloaded. Excessive speed, underinflation, or
excessive loading, either separately or in combination,
can cause heat buildup and possible tire failure.
Wheel Alignment and Tire Balance
The wheels on your vehicle were aligned and balanced
carefully
at the factory to give you the longest tire life
and best overall performance. Scheduled
wheel alignment
and wheel balancing are not
needed. However, if you notice unusual tire wear or
your vehicle pulling one way or the other, the alignment
may need
to be reset. If you notice your vehicle
vibrating when driving
on a smooth road, your wheels
may need to be rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked, or badly rusted
or corroded. If wheel nuts keep coming loose, the wheel,
wheel bolts and wheel nuts should be replaced.
If the
wheel leaks air, replace
it (except some aluminum
wheels, which can sometimes be repaired). See your
GM dealer if any of these conditions exist.
Your dealer will know
the kind of wheel you need.
Each new wheel should have the same load-carrying
capacity, diameter, width, offset and be mounted the
same way as the one it replaces.
If
you need to replace any of your wheels, wheel bolts
or wheel nuts, replace them only with new
GM original
equipment parts. This way, you will
be sure to have the
right wheel, wheel bolts and wheel nuts for your vehicle.

Downloaded from www.Manualslib.com manuals search engine Tire Chains
NOTICE:
Use tire chains only where legal and only when
you must. Use chains that are the proper size
for your tires. Install them on the tires of the
rear axle.
Tighten them as tightly
as possible with the ends
securely fastened. Drive slowly and follow the chain
manufacturer’s instructions.
If you can hear the
chains contacting your vehicle, stop and retighten
them.
If the contact continues, slow down until it
stops. Driving too fast
or spinning the wheels with
chains on will damage your vehicle.
Appearance Care
Remember, cleaning products can be hazardous. Some
are toxic. Others can burst
into flame if you strike a
match or get them on a hot part of the vehicle. Some are
dangerous if you breathe their fumes in a closed space.
When you use anything from a container to clean your
vehicle, be sure to follow the manufacturer’s warnings
and instructions. And always open your doors or
windows when you’re cleaning the inside.
Never use these to clean your vehicle:
Gasoline
0 Benzene
0 Naphtha
Carbon Tetrachloride
Acetone
Paint Thinner
Turpentine
0 Lacquer Thinner
Nail Polish Remover
They can all be hazardous
-- some more than
others
-- and they can all damage your vehicle, too.
6-49

Downloaded from www.Manualslib.com manuals search engine LAMP OR BULB
INTERIOR
Dome Lamps
Reading Lamps
IP Courtesy Lamp
Stepwell Lamp
Instrument Panel Compartment Lamp
Ashtray Lamp
Sunshade Vanity Mirror
LAMP OR BULB
INSTRUMENT PANEL
Daytime Running Lamps Indicator
Charging System Indicator Lamp
Instrument Cluster Illumination
Headlamp Beam Indicator
Turn Signal Indicator
Brake Warning Indicator
SIR (Air Bag) Safety Belt Warning
Check Gages Indicator
Malfunction Indicator
("Service Engine Soon”) Lamp
TRADE NO.
211-2
21 1-2
194
194
194 194 74
TRADE NO.
74 74
194 74 74
74
74 74
74
74
3
6
2
214
1
1
4
QTY.
1
1
6
1
2
1
1
1
1
1

Downloaded from www.Manualslib.com manuals search engine Section 9 Index
Adjustable Mast Antenna ........................ 3-28
AirBag
....................................... 1-25
Adding Equipment
............................ 1-32
How Does
it Restrain .......................... 1-30
How it Works
................................ 1-28
Location
.................................... 1-28
Readiness Light
......................... 1.27. 2-51
Servicing
................................... 1-31
What Makes it Inflate
.......................... 1-29
What Will
You See After it Inflates ............... 1-30
When Should it Inflate
......................... 1-29
Aircleaner
.................................... 6-17
Air Conditioning Refrigerants
..................... 6-67
Alignment and Balance. Tire
...................... 6-47
Aluminum Wheels. Cleaning
...................... 6-55
Antenna. Adjustable Mast
........................ 3-28
Antenna. Power
................................ 3-28
Antifreeze
..................................... 6-22
Anti-Lock Brake System Warning Light
................ 2-53. 4-7
Brakes
...................................... 4-7
Appearancecare
............................... 6-49
Air Conditioning
................................ 3-7
Air Control. Climate Control System
................. 3-3 Appearance
Care Materials
....................... 6-57
Arbitration Program
.............................. 8-9
Ashtrays ...................................... 2-43
Audio Systems
.................................. 3-8
Automatic Transmission
Transmission Check
........................... 7-46
Transmission Fluid
............................ 6-18
Transmission Operation
........................ 2-20
Shifting
..................................... 2-20
Transmission Park Mechanism Check
............. 7-48
Axle. Locking Rear
............................. 2-23
Axle. Rear
.................................... 6-22
Battery
...................................... 6-32
Jump Starting
................................. 5-3
Replacement. Remote Keyless Entry
............... 2-8
Warnings
.................................... 5-3
Warnings
.................................... 5-3
BBB Auto Line
................................. 8-9
Before Leaving on a Long Trip
.................... 4-21
Better Business Bureau Mediation
................... 8-9
Blizzard. Driving In
............................. 4-25
9-1

Downloaded from www.Manualslib.com manuals search engine Brake Adjustment
.................................. 6-31
Fluid
....................................... 6-28
Master Cylinder
.............................. 6-28
Parking
..................................... 2-23
Pedal Travel
................................. 6-3 1
Replacing System Parts ........................ 6-3 1
System Warning Light
......................... 2-52
Trailer
...................................... 4-34
Transmission Shift Interlock Check
............... 7-47
Wear
....................................... 6-30
Brakes. Anti-Lock
............................... 4-7
Braking in Emergencies
........................... 4-9
Braking
........................................ 4-6
Break-In. New Vehicle
.......................... 2-16
Brightness Control
.............................. 2-38
Bulb Replacement
.............................. 6-32
BTSICheck
................................... 7-47
Canadian Roadside Assistance
.................... 8-7
Carbon Monoxide .................... 2-28.4-26. 4-34
Cassette Deck Service
........................... 7-45
Cassette Tape Player
....................... 3- 11. 3- 13
Cassette Tape Player Care
........................ 3-27
Center High-Mounted Stoplamp
................... 2-61
Center Rear Passenger Position
.................... 1-35
Certification Label
.............................. 4-27
CertificatiodTire Label
.......................... 4-27
Capacities
and Specifications
...................... 6-64
Center Passenger Position
........................ 1-35 Chains. Safety
................................. 4-34
Chains. Tire
................................... 6-49
Changing a Flat Tire
............................. 5-23
Checking Your Restraint Systems
.................. 1-52
Chemical Paint Spotting
.......................... 6-56
Child Restraints
................................ 1-40
Securing in a Rear Outside Seat Position ........... 1-42
Securing
in the Center Front Seat Position ......... 1-44
Securing
in the Center Rear Seat Position .......... 1-44
Securing in the Center Seat Position
.............. 1-44
Securing in the Passenger Seat Position ........... 1-46
Securing
in the Right Front Seat Position .......... 1-46
TopStrap
................................... 1-42
Where to Put
........................... 1-40. 1-41
Cigarette Lighter
............................... 2-45
Circuit Breakers and Fuses
....................... 6-60
Cleaner. Air
................................... 6-17
Cleaning Aluminum Wheels
..................... ....... 6-55
Fabric
...................................... 6-50
Glass
....................................... 6-53
InsideofYourGM
............................ 6-50
Instrumentpanel
............................. 6-52
Leather
..................................... 6-52
Outside
of Your GM ........................... 6-54
Special Problems
............................. 6-51
Stains
...................................... 6-50
Tires
....................................... 6-55
Vinyl
....................................... 6-52
Wheels
..................................... 6-55
Windshield and Wiper Blades
................... 6-53
9-2

Downloaded from www.Manualslib.com manuals search engine Electrical Equipment. Adding
Electrical System
............
Electronic Road Speed Governor
Engine
....................
Coolant ..................
Coolant Level Check .......
Coolant Temperature Gage . .
Exhaust ..................
Fuse Block ...............
Identification .............
Oil Level Check ...........
Overheating ..............
Running While Parked ......
Starting Your .............
Engine Oil .................
Adding ..................
Additives ................
Checking ................
Pressure Gage .............
Used ....................
Cooling System ...........
................... 6-59
................... 6-59
(Gasoline Engines)
... 2-60
.................... 6-9
................... 6-22
................... 7-45
................... 2-59
................... 6-65
................... 2-28
................... 6-63
.............. 6.58. 6..65
................... 7-45
................... 5-12
................... 2-28
................... 2-17
................... 6-12
................... 6-12
................... 6-16
................... 6-13
................... 2-57
................... 6-16
Whentochange
.............................. 6-16
Exhaust. Engine
................................ 2-28
Fabric Cleaning
............................... 6-50
Fan Control. Climate Control System
................ 3-2
Filling Your Tank
................................ 6-5
Filter. Air
..................................... 6-17
Finish Care
.................................... 6-54 Finish Damage
................................. 6-56
First Gear. Automatic Transmission
................ 2-22
Flashers. Hazard Warning
......................... 5-2
Flat Tire. Changing
............................. 5-23
Fluids and Lubricants
............................ 7-51
Foreign Countries. Fuel
........................... 6-5
French Language Manual
11
Front ParkingKurn Signal Lamp Bulb Replacement .... 6-35
Front Storage Area .............................. 2-44
FrontTowing
.................................. 5-10
Fuel .......................................... 6-3
Canada
...................................... 6-5
FillingYourTank
.............................. 6-5
Gage
....................................... 2-58
In Foreign Countries
........................... 6-5
Tankcapacity
............................... 6-66
Fuses
and Circuit Breakers ....................... 6-60
.. ...........................
Gages
Engine Coolant Temperature
.................... 2-59
Engine Oil Pressure
........................... 2-57
Fuel
....................................... 2-58
Speedometer
................................. 2-49
Voltmeter
................................... 2-60
Gear Positions. Automatic Transmission
............. 2-20
Gross Axle Weight Rating ........................ 4-28
Gross Vehicle Weight Rating
...................... 4-27
Guide en Frangais
11
GVWR ....................................... 4-27
GAWR
....................................... 4-28
.. .................................
9-4
.

Downloaded from www.Manualslib.com manuals search engine Halogen Bulbs ................................ 6-32
Hazard Warning Flashers
.......................... 5-2
Head Restraints
................................. 1-5
Bulb Replacement ............................ 6-33
High/Low Beam Changer ...................... 2-34
OnReminder
................................ 2-40
Hearing Impaired. Customer Assistance
.............. 8-4
Heating
........................................ 3-7
High-Beam Headlamps
.......................... 2-34
Highway Hypnosis
.............................. 4-22
Hill and Mountain Roads
......................... 4-22
Hitches. Trailer
................................. 4-33
Hood
Checking Things Under
......................... 6-7
Prop
........................................ 6-8
Release
...................................... 6-7
Horn
......................................... 2-32
Hydroplaning
.................................. 4- 18
Headlamps .................................... 2-39
Wiring
..................................... 6-59
Ignition Switch
................................ 2- 16
Inflation. Tire .................................. 6-42
Inside Daymight Rearview Mirror
................. 2-43
Inspections
.................................... 7-49
Brakesystem
................................ 7-50
Exhaust Systems
............................. 7-49
Radiator and Heater Hose
...................... 7-49
RearAxle
................................... 7-50
Ignition Transmission
Lock Check
................. 7-47 Steering
.................................... 7-49
Suspension
.................................. 7-49
Throttle Linkage
.............................. 7-49
Cleaning
.................................... 6-52
Cluster
..................................... 2-48
FuseBlock
.................................. 6-60
Interior Lamps
................................. 2-40
Brightness Control
............................ 2-38
.................................... J ack. . Tire 5-25
Jump Starting ................................... 5-3
Keyless Entry System
........................... 2-6
Keys
.......................................... 2-2
Labels 4-27
Certification
................................. 4-27
Certification/Tire
............................. 4-27
Service Parts Identification
..................... 6-58
Tire-Loading Information
...................... 4-27
Vehicle Identification Number
................... 6-58
Dome
...................................... 2-40
Interior
..................................... 2-40
OnReminder
................................ 2-40
Panel
....................................... 2-40
Underhood
.................................. 2-42
Lalnps
........................................ 2-38
Leaving
Your Vehicle with the Engine Running ....... 2-26
Lighter
....................................... 2-45

Downloaded from www.Manualslib.com manuals search engine Lights Air Bag Readiness
....................... 1.27. 2.5 1
Anti-Lock Brake System Warning ............ 2.53. 4.7
Brake System Warning
......................... 2-52
Daytime Running Lamps Indicator
............... 2-54
Interior
..................................... 2-40
Safety Belt Reminder
..................... 1 . I 1. 2.50
Service Engine Soon
.......................... 2-54
Loading Your Vehicle
........................... 4-27
Locks
......................................... 2-4
Door
........................................ 2-4
Ignition Transmission Lock Check
............... 7-47
PowerDoor
.................................. 2-5
Rear Door Security
............................. 2-5
Sliding Door Child Security
...................... 2-5
LossofControl
................................ 4-13
Lubricants and Fluids ............................ 7-5 1
Lubrication Service. Body ........................ 7-46
Maintenance. Normal Replacement
Parts ........... 6-67
Maintenance Record
............................ 7-53
Maintenance Schedule
............................ 7- 1
Long Tripmighway Definition ................... 7-6
Long Tripmighway Intervals
..................... 7-7
Owner Checks and Services
..................... 7-45
Periodic Maintenance Inspections
................ 7-49
Recommended Fluids and Lubricants
............. 7-5 1
Scheduled Maintenance Services .................. 7-4 Short
Trip/City Definition
....................... 7-5
Short Trip/City Intervals
........................ 7-5
Maintenance. Underbody
......................... 6-56
Maintenance When Trailer Towing
................. 4-37
Malfunction Indicator Lamp
...................... 2-54
ManualFrontSeat
............................... 1-2
Mirrors
....................................... 2-43
Convex Outside
.............................. 2-44
Inside Daymight Rearview
..................... 2-43
Power Remote Control
......................... 2-43
Visor Vanity
................................. 2-46
MMT
......................................... 6-4
Model Reference
................................. vi
Mountain Roads
................................ 4-22
Multifunction Lever
............................. 2-33
Neutral. Automatic Transmission ................. 2-21
New Vehicle Break-In ........................... 2-16
NightVision
................................... 4-15
Noise Control System
........................... 6-11
Odometer
.................................... 2-49
Odometer. Trip
................................. 2-49
Overheating Engine
............................. 5-12
Off-Road Recovery
............................. 4-11
Oil. Engine
.................................... 6-12
Owner Checks and Services
....................... 7-45
Owner Publications. Ordering
..................... 8-11

Downloaded from www.Manualslib.com manuals search engine Right Front Passenger Position .................... 1-25
Roadside Assistance
.............................. 8-5
Roadside Assistance. Canadian ..................... 8-7
Rocking Your Vehicle
........................... 5-38
Rotation. Tires
................................. 6-43
Safety Belt Extender
............................ 1-52
Safety Belts
................................... 1 - 10
Adults
...................................... 1-15
Care ....................................... 6-53
Center Passenger Position
...................... 1-35
Center Rear Passenger Position
.................. 1-35
Children
.................................... 1-37
Driver Position
............................... 1 - 15
Extender
.................................... 1-52
How to Wear Properly
......................... 1 - 15
Incorrect Usage
.............................. 1-50
LapBelt .................................... 1-36
Lap-Shoulder
................................ 1-15
Lap-Shoulder
................................ 1-33
Lap-Shoulder
................................ 1-33
Larger Children
.............................. 1-49
Questions and Answers
........................ 1 - 14
Rear Seat Outside Passenger Positions
............ 1-32
Rear Seat Passengers
.......................... 1-32
Reminder Light
......................... 1-1 1. 2-50
Replacing After a Crash
........................ 1-52
Right Front Passenger Position
.................. 1-29
Incorrect Usage
.............................. 1 - 19
Lap Belt .................................... 1-36
Passenger Position
............................ 1-25 Shoulder Belt Height Adjuster
................... 1 . 18
Smaller Children and Babies ............... 1.37. 1-39
Use During Pregnancy
......................... 1-24
WhyThey Work
.............................. 1-11
SafetyChains
.................................. 4-34
Safety Defects. Reporting
........................ 8- 10
Safety Warnings and Symbols
....................... 111
Scheduled Maintenance Services .................... 7-4
Seatback Reclining Front
............................... 1-3
Seats ManualFront
................................. 1-2
Power
....................................... 1-3
Rear
........................................ 1-5
Restraint Systems
.............................. 1-1
Seat Controls ................................. 1-2
Securing
a Child Restraint ...................... 1-42
Second Gear. Automatic Transmission
.............. 2-22
Service
........................................ 6-2
Bulletins, Ordering
............................ 8-11
EngineSoonLight
............................ 2-54
Parts Identification Label
....................... 6-58
Publications. Ordering ......................... 8- 11
Work. Doing
Your Own ......................... 6-2
Service and Appearance Care
...................... 6-1
Service and Owner Publications
................... 8- 11
Service Publications ............................. 8- 11
Servicing Your Air Bag-Equipped GM .............. 1-31
Sheet Metal Damage
............................ 6-55
Shift Lever
............................... 2-20. 2-25
...
Manuals. Ordering ............................ 8- 11

Downloaded from www.Manualslib.com manuals search engine TopStrap ..................................... 1-42
TorqueLock
................................... 2-26
Torque. Wheel Nut
......................... 5-34. 6-65
Towing a Trailer
................................ 4-29
Towing Your Vehicle
............................. 5-8
Trailer
Brakes
..................................... 4-34
Driving on Grades
............................ 4-36
Drivingwith
................................. 4-34
Hitches
..................................... 4-33
Maintenance When Towing
..................... 4-37
Parking on Hills
.............................. 4-37
Safety Chains
................................ 4-34
Tongueweight
............................... 4-32
Total Weight on Tires
.......................... 4-33
Towing
..................................... 4-29
Turnsignals
................................. 4-36
Wiring Harness
............................... 4-38
Transmission Fluid
Automatic
................................... 6- 1 8
Transmitters. Keyless Entry
........................ 2-7
Transportation. Courtesy .......................... 8-8
Trip Odometer
................................. 2-49
TTYUsers
..................................... 8-4
Turn Signal and Lane Change Signals
............... 2-33
Turn SignalMultifunction Lever
................... 2-33
Turn Signals When Towing a Trailer
................ 4-36
Weight
..................................... 4-31 Underbody
Maintenance
........................ 6-56
UnderhoodLamp
............................... 2-42
Vehicle Control
...................................... 4-6
Damage Warnings
.............................. iv
Identification Number
......................... 6-58
Loading
.................................... 4-27
Storage
..................................... 6-32
Ventilation System
............................... 3-7
Visor Vanity Mirrors
............................ 2-46
Visors. Sun .................................... 2-46
warning Devices
............................... 5-3
Warning Lights. Gages and Indicators
............... 2-50
Warranty Information ............................ 8-10
Washer Fluid. Windshield
........................ 6-27
Washing Your Vehicle
........................... 6-54
Weatherstrips
.................................. 6-53
Wheel
Alignment
.................................. 6-47
Nut Torque ............................ 5-34. 6-65
Replacement
................................. 6-47
Wrench
..................................... 5-26
Windows
..................................... 2-29
Power
...................................... 2-29
Side Latches
................................. 2-30
Swing-Out .................................. 2-30