heater CHEVROLET EXPRESS 1998 1.G User Guide

Downloaded from www.Manualslib.com manuals search engine ’ A CAUTION:
Snow can trap exhaust gases under your vehicle.
This can cause deadly
CO (carbon monoxide) gas
to get inside.
CO could overcome you and kill
you. You can’t see
it or smell it, so you might not
know it is in your vehicle. Clear away snow from
around the base of your vehicle, especially any
that is blocking your exhaust pipe. And check
around again from time to time to be sure snow
doesn’t collect there.
Open
a window just a little on the side of the
vehicle that’s away from the wind. This will help
keep
CO out.
Run your engine only as long as you must. This saves
fuel. When
you run the engine, make it go a little faster
than just idle. That is, push the accelerator slightly. This
uses less fuel for the heat that you get and it keeps the
battery (or batteries) charged. You will need a
well-charged battery (or batteries)
to restart the vehicle,
and possibly for signaling later on with your headlamps.
Let the heater run for a while.
If you have a diesel engine,
you may have to run it at a
higher speed to get enough heat. Then, shut the engine
off and close the window almost all the way to preserve
the heat. Start the engine again and repeat this only
when
you feel really uncomfortable from the cold. But
do it as little
as possible. Preserve the fuel as long as you
can. To help keep warm, you can get out of the vehicle
and
do some fairly vigorous exercises every half hour or
so until help comes.
4-26

Downloaded from www.Manualslib.com manuals search engine If No Steam Is Coming From Your Engine
If you get the overheat warning but see or hear no
steam, the problem may
not be too serious. Sometimes
the engine can get a little too hot when you:
Climb a long hill on a hot day.
Stop after high-speed driving.
Idle for long periods in traffic.
Tow a trailer. See “Driving on Grades” in the Index.
If you get the overheat warning with no sign of steam,
try this
for a minute or so:
1. If you have an air conditioner, turn it off.
2. Turn on your heater to full hot at the highest fan
speed and open the window as necessary.
3. If you’re in a traffic jam, shift to NEUTRAL (N);
otherwise, shift
to the highest gear while
driving
-- DRIVE (D).
If you no longer have the overheat warning, you can
drive. Just to be safe, drive slower for about
10 minutes.
If the warning doesn’t come back
on, you can
drive normally.
If the warning contikties, pull over, stop, and park your
vehicle right away.
If there’s still no sign of steam, push the accelerator until
the engine speed
is about twice as fast as normal idle
speed. Bring the engine speed back to normal idle speed
after two or three minutes. Now see if the warning stops.
But then, if you still have the warning,
turn ofSthe
engine
and get everyone out of the vehicle until it
cools down.
You may decide not to lift the hood but
to get service
help right away.
5-13

Downloaded from www.Manualslib.com manuals search engine If it isn’t, you may have a leak in the radiator hoses,
heater hoses, radiator, water pump or somewhere else in
the cooling system. Heater and radiator
hoses, and other engine
parts, can be very hot. Don’t touch them.
If you
do, you can be burned.
Don’t run the engine
if there is a leak. If you run
the engine, it could lose all coolant. That could cause an engine fire, and you could be burned.
Get any leak fixed before you drive
the vehicle.
NOTICE:
I
Engine damage from running your engine
without coolant isn’t covered by your warranty.
I I
If there seems to be no leak, start the engine again.
See if the engine cooling fan speed increases when
idle speed is doubled by pushing the accelerator pedal
down.
If it doesn’t, your vehicle needs service. Turn off
the engine.
5-15

Downloaded from www.Manualslib.com manuals search engine How to Add Coolant to the Coolant
Recovery Tank
If you haven’t found a problem yet, but the coolant level
isn’t at the FULL COLD mark, add a 50/50 mixture of
clean water (preferably distilled) and DEX-COOL@
engine coolant at the coolant recovery tank. (See
“Engine Coolant’’
in the Index for more information.)
Adding only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid like alcohol, can boil before the proper
coolant mixture will. Your vehicle’s coolant
warning system is set for the proper coolant
mixture. With plain water or the wrong mixture,
your engine could get too hot but you wouldn’t
get the overheat warning. Your engine could
catch fire and you or others could be burned.
Use
a 50/50 mixture of clean water and
DEX-COOL@ coolant.
I NOTICE:
In cold weather, water can freeze and crack the
engine, radiator, heater core and other parts.
Use the recommended coolant and the proper
coolant mixture.
I
.. .
5-16

Downloaded from www.Manualslib.com manuals search engine NOTICE:
When adding coolant, it is important that you
use only
DEX-COOL@ (silicate-free) coolant.
If coolant other than DEX-COOL is added to
the system, premature engine, heater core or
radiator corrosion may result. In addition, the
engine coolant will require change sooner
-- at
30,000 miles (50 000 km) or 24 months,
whichever occurs first. Damage caused by the
use
of coolant other than DEX-COOL@ is not
covered by your new vehicle warranty.
What to Use
Use a mixture of one-half clean water (preferably
distilled) and one-half
DEX-COOL@ coolant which
won’t damage aluminum parts. If you use this mixture,
you don’t need to add anything else.
I
Adding only plain water to your cooling system
can be dangerous. Plain water, or some other
liquid like alcohol, can boil before the proper
coolant mixture will. Your vehicle’s coolant
warning system is set for the
proper coolant
mixture. With plain water or the wrong mixture,
your engine could get too hot but you wouldn’t
get the overheat warning. Your engine could
catch fire and you or others could be burned.
Use a
50/50 mixture of clean water and
DEX-COOL@ coolant.
6-22

Downloaded from www.Manualslib.com manuals search engine NOTICE:
If you use an improper coolant mixture, your
engine could overheat and be badly damaged.
The repair cost wouldn’t be covered by your
warranty. Too much water in the mixture can
freeze and crack the engine, radiator, heater core
and other parts.
If you have to add coolant more than four times a year,
have your dealer check your cooling system.
NOTICE:
Checking Coolant
If you use the proper coolant, you don’t have to
add extra inhibitors or additives which claim to
improve the system. These can be harmful. When
your engine is cold, the coolant level shoi FULL COLD, or a little higher. Ad
be
at

Downloaded from www.Manualslib.com manuals search engine Engine Compartment Fuse Relay Center
The fuse block is on the driver’s side of the engine
compartment at the rear.
U
NAME
IGN-B
IGN-A
BATT
LIGHTING
RR BLOWER
ENG-I
NAME
BLOWER ABS
CIRCUITS PROTECTED
Front Blower Motor
Electronic Brake Control Module AIC
SPARE
AUX A
AUX B
RH-HDLP
CIRCUITS PROTECTED
Ignition
Switch
Starter Relay, Ignition Switch
Instrument Panel
Fuse Block
Instrument Panel Fuse Block,
Headlamp Switch
Rear Auxiliary Blower Motor Relays
Heated
02 Sensors, Mass Air Flow
Sensor, EGR Valve Solenoid, Evap
Canister Purge Valve, Crankshaft
Position Sensor, Secondary Air Injection Relay (Diesel), Water in
Fuel Sensor (Diesel), Fuel Heater
(Diesel), Glowplug Relay (Diesel),
Wastegate Solenoid (Diesel)
Air Conditioning Clutch Relay
Spare Fuses
Upfitter Provisions Upfitter Provisions
Right-hand Headlamp (Export only)

Downloaded from www.Manualslib.com manuals search engine Cooling System Capacity (Approximate)
ENGINE VIN QTY Without Rear Heater
“VORTEC”4300 W 1 1 Quarts ( 10.4 L)
“VORTEC”5000 M 17 Quarts (16 L)
“VORTEC”5700 R 17 Quarts (1 6 L)
“VORTEC”7400 J 23 Quarts (2 1.8 L)
QTY With Rear Heater
14 Quarts (13.2 L)
20 Quarts (18.9 L)
20 Quarts (18.9 L)
26 Quarts (24.6 L)
After refill, the level MUST be checked as outlined under “Engine Cooling System” in Section 5.
Crankcase Capacity (Approximate)
ENGINE VIN Quantity With Filter
“VORTEC”4300 W 4.5 Quarts (4.3 L)
“VORTEC”5000 M 5 Quarts (4.8 L)
“VORTEC”5700 R 5 Quarts (4.8 L)
“VORTEC”7400 J 6.6 Quarts (6.24 L)
After refill, the level MUST be rechecked. Add enough engine oil so that the fluid is within the proper operating
range. See “Engine Oil” in the Index.
*Add one additional quart for RPO 5Z1 and
RPO KL5 Models.
6-68

Downloaded from www.Manualslib.com manuals search engine Engine ....................................... 6-10
Coolant
..................................... 6-21
Coolant Level Check
.......................... 7-38
Coolant Temperature Gage
..................... 2-57
Cooling System
.............................. 5- 14
Exhaust
...................... 2.29.2.30.2.33 .4.26
FuseBlock
.................................. 6-65
Identification
........................... 6.60. 6.67
OilLevelCheck
.............................. 7-38
Overheating
................................. 5-11
Running While Parked ......................... 2-30
Starting Your
................................ 2- 18
EngineOil
.................................... 6-12
Adding
..................................... 6-13
Additives
................................... 6-15
Checking ................................... 6-13
Pressure Gage
................................ 2-60
Used
....................................... 6-16
Whentochange
.............................. 6-15
Exhaust, Engine
................. 2-29.2-30,2-33, 4-26
Engine Coolant Heater
........................... 2-20
Engine Oil (Continued)
Exterior Lamps
................................. 2-40
Fabric Cleaning
............................... 6-52
Filling a Portable Fuel Container .................... 6-7
FillingYourTank
................................ 6-5
Filter. Air
..................................... 6-16
Finish Care
.................................... 6-55
Finish Damage
................................. 6-57 First Gear. Automatic Transmission
................ 2-23
Flashers. Hazard Warning
......................... 5-2
Flat Tire. Changing
............................. 5-22
Fluids and Lubricants
............................ 7-44
Foreign Countries. Fuel
........................... 6-5
French Language Manual
11
Front Parkingnurn Signal Lamp Bulb Replacement .... 6-35
Front Storage Area
.............................. 2-48
FrontTowing
.................................. 5-10
Fuel .......................................... 6-3
Canada ...................................... 6-3
Filling
a Portable Container ...................... 6-7
FillingYourTank
.............................. 6-5
Gage
....................................... 2-63
In Foreign Countries
........................... 6-5
Tankcapacity
............................... 6-69
Fuses and Circuit Breakers
....................... 6-61
.. ...........................
Gages
Engine Coolant Temperature
.................... 2-57
Engine Oil Pressure
........................... 2-60
Fuel
....................................... 2-63
Speedometer
................................. 2-52
Voltmeter
................................... 2-55
GAWR
....................................... 4-27
Gear Positions. Automatic Transmission
............. 2-21
Gross Axle Weight Rating
........................ 4-27
Gross Vehicle Weight Rating
...................... 4-27
Guide en Franpis
11
GVWR ....................................... 4-27
.. .................................
9-4

Downloaded from www.Manualslib.com manuals search engine Halogen Bulbs ................................ 6-32
Hazard Warning Flashers
.......................... 5-2
Head Restraints
................................. 1-5
Headlamps
.................................... 2-40
Bulb Replacement
............................ 6-33
High/Low Beam Changer
...................... 2-35
OnReminder
................................ 2-41
Wiring
..................................... 6-61
Hearing Impaired. Customer Assistance
.............. 8-4
Heater Controls
................................. 3-2
HeaterIAir Conditioning Controls
................... 3-3
Heating
........................................ 3-6
High-Beam Headlamps
.......................... 2-35
Highway Hypnosis
.............................. 4-2 I
Hill and Mountain Roads ......................... 4-21
Hitches. Trailer
................................. 4-32
Hood Checking Things Under
......................... (5-8
Prop ........................................ 6-9
Release
...................................... 6-8
Horn ......................................... 2-33
Hydroplaning
.................................. 4-17
Ignition Switch
................................ 2-17
Ignition Transmission Lock Check
................. 7-41
Inflation, Tire
.................................. 6-42
Inside Day/Night Rearview Mirror
................. 2-45
Inspections
.................................... 7- 42
Brakesystem
................................ 7-43
Engine Cooling System
........................ 7-42
Exhaust Systems
............................. 7-42 RearAxle
................................... 7-43
Steering
.................................... 7-42
Suspension
.................................. 7-42
Throttle System
.............................. 7-43
Instrument Cluster
.............................. 2-51
Instrument Panel
............................... 2-50
Brightness Control
............................ 2-40
FuseBlock
.................................. 6-62
Interior Lamps
................................. 2-43
Cleaning
.................................... 6-53
.................................... J ack.
Tire 5-23
Jump Starting
................................... 5-3
Keyless Entry System
........................... 2-6
Keys
.......................................... 2-2
Labels Certification
................................. 4-27
Certificationmire
............................. 4-27
Service
Parts Identification ..................... 6-60
Tire-Loading Information
...................... 4-27
Vehicle Identification Number
................... 6-60
Dome
...................................... 2-43
Exterior
.................................... 2-40
Interior
..................................... 2-43
OnReminder
................................ 2-41
Panel
....................................... 2-40
Underhood
.................................. 2-44
Lamps