washer fluid CHEVROLET EXPRESS 2018 User Guide

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374212) - 2018 - crc - 2/2/18
294 Vehicle Care
Cleaning Exterior Lamps/
Lenses, Emblems, Decals, and
Stripes
Use only lukewarm or cold water, a
soft cloth, and a car washing soap
to clean exterior lamps, lenses,
emblems, decals, and stripes.
Follow instructions under "Washing
the Vehicle" previously in this
section.
Lamp covers are made of plastic,
and some have a UV protective
coating. Do not clean or wipe them
while they are dry.
Do not use any of the following on
lamp covers:
.Abrasive or caustic agents.
. Washer fluids and other cleaning
agents in higher concentrations
than suggested by the
manufacturer.
. Solvents, alcohols, fuels,
or other harsh cleaners.
. Ice scrapers or other hard items. .
Aftermarket appearance caps or
covers while the lamps are
illuminated, due to excessive
heat generated.
Caution
Failure to clean lamps properly
can cause damage to the lamp
cover that would not be covered
by the vehicle warranty.
Caution
Using wax on low gloss black
finish stripes can increase the
gloss level and create a
non-uniform finish. Clean low
gloss stripes with soap and
water only.
Air Intakes
Clear debris from the air intakes,
between the hood and windshield
when washing the vehicle.
Windshield and Wiper Blades
Clean the outside of the windshield
with glass cleaner.
Clean rubber blades using a lint-free
cloth or paper towel soaked with
windshield washer fluid or a mild
detergent. Wash the windshield
thoroughly when cleaning the
blades. Bugs, road grime, sap, and
a buildup of vehicle wash/wax
treatments may cause wiper
streaking.
Replace the wiper blades if they are
worn or damaged. Damage can be
caused by extreme dusty
conditions, sand, salt, heat, sun,
snow, and ice.
Weatherstrips
Apply weatherstrip lubricant on
weatherstrips to make them last
longer, seal better, and not stick or
squeak. Lubricate weatherstrips at
least once a year. Hot, dry climates
may require more frequent
application. Black marks from
rubber material on painted surfaces

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374212) - 2018 - crc - 2/2/18
Service and Maintenance 303
Maintenance
Schedule
Owner Checks and Services
At Each Fuel Stop
.Check the engine oil level. See
Engine Oil 0220.
Once a Month
. Check the tire inflation
pressures. See Tire Pressure
0 263.
. Inspect the tires for wear. See
Tire Inspection 0268.
. Check the windshield washer
fluid level. See Washer Fluid
0 235.
Engine Oil Change
When the CHANGE ENGINE OIL
SOON message displays, have the
engine oil and filter changed within
the next 1 000 km/600 mi. If driven
under the best conditions, the
engine oil life system may not
indicate the need for vehicle service
for up to a year. The engine oil and filter must be changed at least once
a year and the oil life system must
be reset. Your trained dealer
technician can perform this work.
If the engine oil life system is reset
accidentally, service the vehicle
within 5 000 km/3,000 mi since the
last service. Reset the oil life
system when the oil is changed.
See
Engine Oil Life System 0222.
Power Take Off (PTO) and
Extended Idle Use
When the vehicle is used with the
PTO equipment or used in a way
that requires extended idle time,
one hour of use shall be deemed
the same as 53 km (33 mi). See
Driver Information Center (DIC)
0111 for hourmeter.
Tire Rotation and Required
Services Every 12 000 km/
7,500 mi
Rotate the tires, if recommended for
the vehicle, and perform the
following services. See Tire
Rotation 0268. .
Check engine oil level and oil
life percentage. If needed,
change engine oil and filter, and
reset oil life system.
See Engine Oil 0220 and
Engine Oil Life System 0222.
. Check engine coolant level. See
Cooling System 0229.
. Check windshield washer fluid
level. See Washer Fluid 0235.
. Visually inspect windshield wiper
blades for wear, cracking,
or contamination. See Exterior
Care 0292. Replace worn or
damaged wiper blades. See
Wiper Blade Replacement
0 242.
. Check tire inflation pressures.
See Tire Pressure 0263.
. Inspect tire wear. See Tire
Inspection 0268.
. Visually check for fluid leaks.
. Inspect engine air cleaner filter.
See Engine Air Cleaner/Filter
0 227.
. Inspect brake system. See
Exterior Care 0292.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374212) - 2018 - crc - 2/2/18
308 Service and Maintenance
.Trained dealer technicians have
access to tools and equipment
to inspect the brakes and
recommend quality parts
engineered for the vehicle.
Fluids
Proper fluid levels and approved
fluids protect the vehicle’s systems
and components. See
Recommended Fluids and
Lubricants 0310 for GM approved
fluids.
. Engine oil and windshield
washer fluid levels should be
checked at every fuel fill.
. Instrument cluster lights may
come on to indicate that fluids
may be low and need to be
filled.
Hoses
Hoses transport fluids and should
be regularly inspected to ensure
that there are no cracks or leaks.
With a multi-point inspection, your
dealer can inspect the hoses and
advise if replacement is needed. Lamps
Properly working headlamps,
taillamps, and brake lamps are
important to see and be seen on
the road.
.
Signs that the headlamps need
attention include dimming, failure
to light, cracking, or damage.
The brake lamps need to be
checked periodically to ensure
that they light when braking.
. With a multi-point inspection,
your dealer can check the lamps
and note any concerns.
Shocks and Struts
Shocks and struts help aid in control
for a smoother ride.
. Signs of wear may include
steering wheel vibration, bounce/
sway while braking, longer
stopping distance, or uneven
tire wear.
. As part of the multi-point
inspection, trained dealer
technicians can visually inspect
the shocks and struts for signs of leaking, blown seals,
or damage, and can advise
when service is needed.
Tires
Tires need to be properly inflated,
rotated, and balanced. Maintaining
the tires can save money and fuel,
and can reduce the risk of tire
failure.
. Signs that the tires need to be
replaced include three or more
visible treadwear indicators; cord
or fabric showing through the
rubber; cracks or cuts in the
tread or sidewall; or a bulge or
split in the tire.
. Trained dealer technicians can
inspect and recommend the right
tires. Your dealer can also
provide tire/wheel balancing
services to ensure smooth
vehicle operation at all speeds.
Your dealer sells and services
name brand tires.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374212) - 2018 - crc - 2/2/18
Service and Maintenance 311
UsageFluid/Lubricant
Key Lock Cylinders, Hood Hinges Multi-Purpose Lubricant, Superlube (GM Part No. 12346241, in Canada 10953474).
Power Steering System GM Power Steering Fluid (GM Part No. 19329450, in Canada 89021186).
Rear Axle (Dual Rear Wheels) SAE 75W-90 Synthetic Axle Lubricant (GM Part No. 88900401, in Canada 89021678).
Rear Axle (Single Rear Wheels) SAE 75W-85 Synthetic Axle Lubricant (GM Part No. 19300457, in Canada 19300458).
Weatherstrip Conditioning Weatherstrip lubricant (GM Part No. 3634770, in Canada 10953518) or equivalent.
Weatherstrip Squeaks Synthetic Grease with Teflon, Superlube (GM Part No. 12371287, in Canada 10953437).
Windshield Washer Automotive windshield washer fluid that meets regional freeze protection requirements.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374212) - 2018 - crc - 2/2/18
Index 347
Driving (cont'd)Wet Roads . . . . . . . . . . . . . . . . . . . 166
Winter . . . . . . . . . . . . . . . . . . . . . . . . 167
Dual Tire
Rotation . . . . . . . . . . . . . . . . . . . . . . 270
E
E85 or FlexFuel . . . . . . . . . . . . . . . . 199
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 212
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 248
Floor Console Fuse Block . . . . 253
Fuses and Circuit Breakers . . . 248
Overload . . . . . . . . . . . . . . . . . . . . . 248
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 333
Engine
Air Cleaner/Filter . . . . . . . . . . . . . 227
Check Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . 105
Compartment Overview . . . . . . . 217
Coolant Heater . . . . . . . . . . . . . . . 177
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . . . . . 101
Cooling System . . . . . . . . . . . . . . . 229 Engine (cont'd)
Drive Belt Routing . . . . . . . . . . . . 317
Exhaust . . . . . . . . . . . . . . . . . . . . . . 181
Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Oil Life System . . . . . . . . . . . . . . . 222
Oil Pressure Gauge . . . . . . . . . . 100
Oil Pressure Light . . . . . . . . . . . . 109
Overheating . . . . . . . . . . . . . . . . . . 233
Power Messages . . . . . . . . . . . . . .116
Running While Parked . . . . . . . . 181
Starting . . . . . . . . . . . . . . . . . . . . . . . 175
Enhanced Technology Glass . . . . 40
Entry/Exit Lighting . . . . . . . . . . . . . . 127
Equipment, Towing . . . . . . . . . . . . . 209
Event Data Recorders . . . . . . . . . . 330
Extender, Seat Belt . . . . . . . . . . . . . . 55
Exterior Lamp Controls . . . . . . . . . 122
Exterior Lamps Off Reminder . . . 123
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 127
F
FanEngine . . . . . . . . . . . . . . . . . . . . . . . . 234
Fast Idle System . . . . . . . . . . . . . . . . 176
Filter, Engine Air Cleaner . . . . . . . . . . . 227 Flash-to-Pass . . . . . . . . . . . . . . . . . . . 123
Flashers, Hazard Warning . . . . . . 125
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 276
Changing . . . . . . . . . . . . . . . . . . . . . 278
FlexFuel E85 . . . . . . . . . . . . . . . . . . . . . . . . . . . 199
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 300
Fluid
AutomaticTransmission . . . . . . . . . . . 223, 226
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 237
Power Steering . . . . . . . . . . . . . . . 235
Washer . . . . . . . . . . . . . . . . . . . . . . . 235
Folding Mirrors . . . . . . . . . . . . . . . . . . 37
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 328
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 42
Front Storage . . . . . . . . . . . . . . . . . . . . 88
Front Turn Signal Bulb Replacement . . . . . . . . . . . . 245
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 197 Additives . . . . . . . . . . . . . . . . . . . . . 198
Economy Driving . . . . . . . . . . . . . . . 23
Filling a Portable FuelContainer . . . . . . . . . . . . . . . . . . . 201

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
11374212) - 2018 - crc - 2/2/18
Index 353
Tires (cont'd)Pressure Monitor Operation . . 265
Pressure Monitor System . . . . . 264
Rotation . . . . . . . . . . . . . . . . . . . . . . 268
Sidewall Labeling . . . . . . . . . . . . . 257
Terminology and Definitions . . 260
Uniform Tire Quality
Grading . . . . . . . . . . . . . . . . . . . . . 273
Wheel Alignment and Tire
Balance . . . . . . . . . . . . . . . . . . . . . 275
Wheel Replacement . . . . . . . . . . 275
When It Is Time for New Tires . . . . . . . . . . . . . . . . . . . . . . . . 270
Winter . . . . . . . . . . . . . . . . . . . . . . . . 256
Tow/Haul Mode . . . . . . . . . . . . . . . . . 185
Tow/Haul Mode Light . . . . . . . . . . . 108
Towing Driving Characteristics . . . . . . . . 202
Equipment . . . . . . . . . . . . . . . . . . . . 209
General Information . . . . . . . . . . 202
Recreational Vehicle . . . . . . . . . . 290
Trailer . . . . . . . . . . . . . . . . . . . . . . . . 205
Trailer Sway Control (TSC) . . . .211
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 289
Traction Control System (TCS)/StabiliTrak Light . . . . . . . . . . . . . 108 Traction Control/Electronic
Stability Control . . . . . . . . . . . . . . . 188
Trailer Sway Control (TSC) . . . . . . . . . . .211
Tow Mirrors . . . . . . . . . . . . . . . . . . . . . 36
Towing . . . . . . . . . . . . . . . . . . . . . . . . 205
Transmission
Automatic . . . . . . . . . . . . . . . . . . . . . 182
Fluid, Automatic . . . . . . . . . 223, 226
Transportation Program, Courtesy . . . . . . . . . . . . . . . . . . . . . . 324
Trip Odometer . . . . . . . . . . . . . . . . . . . 99
Turn and Lane-Change Signals . . . . . . . . . . . . . . . . . . . . . . . . 125
U
Uniform Tire Quality Grading . . . 273
Using This Manual . . . . . . . . . . . . . . . . 2
V
VehicleCanadian Owners . . . . . . . . . . . . . . . 2
Control . . . . . . . . . . . . . . . . . . . . . . . 164
Identification Number (VIN) . . . 314
Load Limits . . . . . . . . . . . . . . . . . . . 169
Messages . . . . . . . . . . . . . . . . . . . . .115
Personalization . . . . . . . . . . . . . . . .116
Remote Start . . . . . . . . . . . . . . . . . . . 28
Security . . . . . . . . . . . . . . . . . . . . . . . . 34 Vehicle (cont'd)
Speed Messages . . . . . . . . . . . . . .116
Towing . . . . . . . . . . . . . . . . . . . . . . . . 289
Vehicle Care
Tire Pressure . . . . . . . . . . . . . . . . . 263
Vehicle Data Recording and Privacy . . . . . . . . . . . . . . . . . . . . . . . . 330
Ventilation, Air . . . . . . . . . . . . . . . . . . 161
Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Voltmeter Gauge . . . . . . . . . . . . . . . 102
W
Warning Brake System Light . . . . . . . . . . . 107
Caution and Danger . . . . . . . . . . . . . 2
Warning Lights, Gauges, and Indicators . . . . . . . . . . . . . . . . . . . . . . 97
Warnings Hazard Flashers . . . . . . . . . . . . . . 125
Washer Fluid . . . . . . . . . . . . . . . . . . . 235
Wheels Alignment and Tire Balance . . 275
Different Size . . . . . . . . . . . . . . . . . 273
Replacement . . . . . . . . . . . . . . . . . 275
When It Is Time for New Tires . . . . . . . . . . . . . . . . . . . . . . . . . . 270
Where to Put the Restraint . . . . . . 74
Wi-Fi . . . . . . . . . . . . . . . . . . . . . . . . . . . 335