wheel size CHEVROLET EXPRESS CARGO 2021 User Guide

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
224 Vehicle Care
TPC Spec number is molded onto the
tire's sidewall near the tire size. If the
tires have an all-season tread design,
the TPC Spec number will be followed
by MS for mud and snow. SeeTire
Sidewall Labeling 0213 for additional
information.
GM recommends replacing worn tires in
complete sets of four (six for dual rear
wheels). Uniform tread depth on all
tires will help to maintain the
performance of the vehicle. Braking and
handling performance may be adversely
affected if all the tires are not replaced
at the same time. If proper rotation and
maintenance have been done, all four
tires (six for dual rear wheels) should
wear out at about the same time.
However, if it is necessary to replace
only one axle set of worn tires, place
the new tires on the rear axle (two for
single rear wheels, four for dual rear
wheels). See Tire Rotation 0221.{Warning
Tires could explode during improper
service. Attempting to mount or
dismount a tire could cause injury or
death. Only your dealer or authorized
tire service center should mount or
dismount the tires.
{Warning
Mixing tires of different sizes (other
than those originally installed on the
vehicle), brands, tread patterns,
or types may cause loss of vehicle
control, resulting in a crash or other
vehicle damage. Use the correct size,
brand, and type of tire on all wheels.
{Warning
Using bias-ply tires on the vehicle
may cause the wheel rim flanges to
develop cracks after many miles of
driving. A tire and/or wheel could fail
(Continued)
Warning (Continued)
suddenly and cause a crash. Use only
radial-ply tires with the wheels on
the vehicle.
Winter tires with the same speed rating
as the original equipment tires may not
be available for H, V, W, Y and ZR
speed rated tires. Never exceed the
winter tires’ maximum speed capability
when using winter tires with a lower
speed rating.
If the vehicle tires must be replaced
with a tire that does not have a TPC
Spec number, make sure they are the
same size, load range, speed rating, and
construction (radial) as the original
tires.
The Tire and Loading Information label
indicates the original equipment tires
on the vehicle. See Vehicle Load Limits
0 132.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Vehicle Care 225
Different Size Tires and Wheels
If wheels or tires are installed that are a
different size than the original equipment
wheels and tires, vehicle performance,
including its braking, ride and handling
characteristics, stability, and resistance to
rollover may be affected. If the vehicle has
electronic systems such as antilock brakes,
rollover airbags, traction control, electronic
stability control, or All-Wheel Drive, the
performance of these systems can also be
affected.
{Warning
If different sized wheels are used, there
may not be an acceptable level of
performance and safety if tires not
recommended for those wheels are
selected. This increases the chance of a
crash and serious injury. Only use GM
specific wheel and tire systems developed
for the vehicle, and have them properly
installed by a GM certified technician.
See Buying New Tires 0223 and
Accessories and Modifications 0178.
Uniform Tire Quality Grading
The following information relates to the
system developed by the United States
National Highway Traffic Safety
Administration (NHTSA), which grades
tires by treadwear, traction, and
temperature performance. This applies
only to vehicles sold in the United
States. The grades are molded on the
sidewalls of most passenger car tires.
The Uniform Tire Quality Grading
(UTQG) system does not apply to deep
tread, winter tires, compact spare tires,
tires with nominal rim diameters of
10 to 12 inches (25 to 30 cm), or to some
limited-production tires.
While the tires available on General
Motors passenger cars and light trucks
may vary with respect to these grades,
they must also conform to federal
safety requirements and additional
General Motors Tire Performance
Criteria (TPC) standards. Quality grades can be found where
applicable on the tire sidewall between
tread shoulder and maximum section
width. For example:
Treadwear 200 Traction AA Temperature A
All Passenger Car Tires Must Conform to
Federal Safety Requirements In Addition
To These Grades.
Treadwear
The treadwear grade is a comparative
rating based on the wear rate of the
tire when tested under controlled
conditions on a specified government
test course. For example, a tire graded
150 would wear one and one-half (1½)
times as well on the government course
as a tire graded 100. The relative
performance of tires depends upon the
actual conditions of their use, however,
and may depart significantly from the
norm due to variations in driving habits,
service practices and differences in road
characteristics and climate.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Vehicle Care 227
{Warning
Using the wrong replacement wheels,
wheel bolts, or wheel nuts can be
dangerous. It could affect the braking and
handling of the vehicle. Tires can lose air,
and cause loss of control, causing a crash.
Always use the correct wheel, wheel
bolts, and wheel nuts for replacement.
Caution
The wrong wheel can also cause
problems with bearing life, brake cooling,
speedometer or odometer calibration,
headlamp aim, bumper height, vehicle
ground clearance, and tire or tire chain
clearance to the body and chassis.
Used Replacement Wheels
{Warning
Replacing a wheel with a used one is
dangerous. How it has been used or how
far it has been driven may be unknown.
It could fail suddenly and cause a crash.
When replacing wheels, use a new GM
original equipment wheel.
Tire Chains
{Warning
Tire chains or other traction devices used
on a vehicle without the proper amount
of clearance can cause damage to the
brakes, suspension, or other vehicle parts.
Use tire chains or traction devices only if
the equipment manufacturer recommends
them for the vehicle tire size combination
and road conditions. Follow the
equipment manfacturer’s instructions. The
area damaged by the tire chains could
cause you to lose control of the vehicle
and you or others may be injured in a
crash. To help avoid damage to the
vehicle, drive slowly, readjust, or remove
the device if it is contacting the vehicle.
Do not spin the vehicle's tires.
Caution
Use tire chains only where legal and only
when necessary. Use chains that are the
proper size for the tires. Install them on
the tires of the rear axle. Do not use
chains on the tires of the front axle.
(Continued)
Caution (Continued)
Tighten them as tightly as possible with
the ends securely fastened. Drive slowly
and follow the chain manufacturer's
instructions. If the chains contact the
vehicle, stop and retighten them. If the
contact continues, slow down until it
stops. Driving too fast or spinning the
wheels with chains on will damage the
vehicle.
For Cutaway models with LT245/75R16 or
LT225/75R16 size single or dual rear tires, use
Low Profile Z-Chain or SAE Class S cables.
For Cargo or Passenger models with
LT225/75R16 or LT245/75R16 size tires, use
Low Profile Z-Chain cables. SAE Class S chains
are not recommended.
If the vehicle has dual rear tires, do not use
individual tire chains. Use tire chains that fit
across both dual tires.
If a Tire Goes Flat
It is unusual for a tire to blow out while
driving, especially if the tires are maintained
properly. See Tires0212. If air goes out of a
tire, it is much more likely to leak out

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
230 Vehicle Care
1. Jack
2. Hoist Handle
3. Extension(s)
4. Wheel Wrench
5. Jack Handle
The spare tire is mounted in the rear
underbody of the vehicle.
Use the hoist handle, extension(s), and the
wheel wrench to remove the
underbody-mounted spare tire.
To lower the spare tire from the vehicle:
1. Spare Tire
2. Tire/Wheel Retainer
3. Hoist Cable
4. Hoist Assembly5. Hoist Shaft
6. Hoist Handle and Extension(s)
7. Wheel Wrench
1. Assemble the wheel wrench (7) to the
hoist handle and the extension(s) (6).
2. Open the passenger side rear door.
3. Insert the chisel end of the hoist handle, on an angle, through the hole in the rear
floor panel above the bumper.
Be sure the hoist handle connects to the
hoist shaft. The chiseled end of the hoist
handle is used to lower the spare tire.
4. Turn the wheel wrench counterclockwise to lower the spare tire to the ground.
Continue to turn the wheel wrench until
the spare tire can be pulled out from
under the vehicle.
5. Pull the spare tire out from under the vehicle.6. Tilt the tire toward the vehicle withsome slack in the cable to access the
tire/wheel retainer.
Tilt the retainer and pull it through the
center of the wheel along with the cable
and spring.
For a vehicle that was completed from a
cab and chassis, refer to the information
from the body supplier/installer.
The spare tire is a full-size tire, like the
other tires on the vehicle.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
236 Vehicle Care
5. Insert the chisel end of the hoist handle,on an angle, through the hole in the rear
floor panel above the bumper and onto
the hoist shaft.
Do not use the chiseled end of the wheel
wrench.
6. Raise the tire part way upward. Make sure the retainer is seated in the wheel
opening.
7. Raise the tire fully against the underside of the vehicle by turning the wheel
wrench clockwise until you hear two
clicks or feel it skip twice. You cannot
overtighten the cable.8. Make sure the tire is stored securely.Push, pull (1), and then try to turn (2) the
tire. If the tire moves, use the wheel
wrench to tighten the cable.
Two clicks mean the tire is up all
the way.
Repeat this tightness check procedure
when checking the spare tire pressure
according to the scheduled maintenance
information or any time the spare tire is
handled due to service of other
components.
Correctly Stored
Incorrectly Stored
9. Return the jacking equipment to the proper location. Secure the items and
replace the jack cover.
Full-Size Spare Tire
If this vehicle came with a full-size spare
tire, it was fully inflated when new,
however, it can lose air over time. Check the
inflation pressure regularly. See Tire Pressure
0 217 and
Vehicle Load Limits 0132. For instructions on
how to remove, install, or store a spare tire,
see Tire Changing 0229.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Vehicle Care 237
After installing the spare tire on the vehicle,
stop as soon as possible and check that the
spare is correctly inflated. The spare tire is
made to perform well at speeds up to
112 km/h (70 mph) at the recommended
inflation pressure, so you can finish
your trip.
Have the damaged or flat road tire repaired
or replaced back onto the vehicle, as soon as
possible, so the spare tire will be available
in case it is needed again.
Do not mix tires and wheels of different
sizes, because they will not fit. Keep the
spare tire and its wheel together.
If this vehicle has a spare tire that does not
match the original road tires and wheels in
size and type, do not include the spare in
the tire rotation.
Jump Starting
Jump Starting - North America
For more information about the vehicle
battery, seeBattery - North America 0199.
If the vehicle battery has run down, you
may want to use another vehicle and some
jumper cables to start your vehicle. Be sure
to use the following steps to do it safely.
{Warning
WARNING: Battery posts, terminals, and
related accessories contain lead and lead
compounds, chemicals known to the
State of California to cause cancer and
birth defects or other reproductive harm.
Batteries also contain other chemicals
known to the State of California to cause
cancer. WASH HANDS AFTER HANDLING.
For more information go to
www.P65Warnings.ca.gov/
passenger-vehicle.
See California Proposition 65 Warning 0178
and the back cover.
{Warning
Batteries can hurt you. They can be
dangerous because:
.They contain acid that can burn you.
.They contain gas that can explode or
ignite.
.They contain enough electricity to
burn you.
If you do not follow these steps exactly,
some or all of these things can hurt you.
Caution
Ignoring these steps could result in costly
damage to the vehicle that would not be
covered by the vehicle warranty. Trying
to start the vehicle by pushing or pulling
it will not work, and it could damage the
vehicle.
1. Check the other vehicle. It must have a 12-volt battery with a negative ground
system.
Caution
If the other vehicle does not have a
12-volt system with a negative ground,
both vehicles can be damaged. Only use
a vehicle that has a 12-volt system with a
negative ground for jump starting.
2. Get the vehicles close enough so the jumper cables can reach, but be sure the
vehicles are not touching each other.
If they are, it could cause a ground
connection you do not want. You would
not be able to start your vehicle, and the
bad grounding could damage the
electrical systems.

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
Index 293
Signals, Turn and Lane-Change . . . . . . . . . . . . 93
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Special Application Services . . . . . . . . . . . . . . 255
Specifications and Capacities . . . . . . . . . . . . . 261
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
StabiliTrakOFF Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Start Assist, Hill . . . . . . . . . . . . . . . . . . . . . . . . . . .147
Start Vehicle, Remote . . . . . . . . . . . . . . . . . . . . . 10
Starter Switch Check . . . . . . . . . . . . . . . . . . . . . 200
Starting the Engine . . . . . . . . . . . . . . . . . . . . . . . 137
Steering . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127 Fluid, Power . . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Wheel Adjustment . . . . . . . . . . . . . . . . . . . . . . 65
Wheel Controls . . . . . . . . . . . . . . . . . . . . . . . . . 66
Storage Areas
Front . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Storage Compartments . . . . . . . . . . . . . . . . . . . 63
Stuck Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
Sun Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Swing-out Windows . . . . . . . . . . . . . . . . . . . . . . 20
Switches Airbag On-Off . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
System Forward Collision Alert (FCA) . . . . . . . . . . . 154
Infotainment . . . . . . . . . . . . . . . . . . . . . . . 96, 276
Noise Control . . . . . . . . . . . . . . . . . . . . . . . . . . 199 Systems
Driver Assistance . . . . . . . . . . . . . . . . . . . . . . 150
T
Taillamps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 203
Text Telephone (TTY) Users . . . . . . . . . . . . . . 267
Theft-Deterrent Systems . . . . . . . . . . . . . . . . . . . 17
Immobilizer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212 All-Season . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Buying New Tires . . . . . . . . . . . . . . . . . . . . . . 223
Chains . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Changing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 229
Designations . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Different Size . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Full-Size Spare . . . . . . . . . . . . . . . . . . . . . . . . . 236
If a Tire Goes Flat . . . . . . . . . . . . . . . . . . . . . 227
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 217
Pressure Light . . . . . . . . . . . . . . . . . . . . . . . . . . 80
Pressure Monitor Operation . . . . . . . . . . . 218
Pressure Monitor System . . . . . . . . . . . . . . 218
Rotation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
Sidewall Labeling . . . . . . . . . . . . . . . . . . . . . . 213
Terminology and Definitions . . . . . . . . . . . 215
Uniform Tire Quality Grading . . . . . . . . . . 225
Wheel Alignment and Tire Balance . . . . 226 Tires (cont'd)
Wheel Replacement . . . . . . . . . . . . . . . . . . . . 226
When It Is Time for New Tires . . . . . . . . . 223
Winter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Top Tier Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 157
Tow/Haul Mode . . . . . . . . . . . . . . . . . . . . . . . . . .145
Tow/Haul Mode Light . . . . . . . . . . . . . . . . . . . . 78
Towing Driving Characteristics . . . . . . . . . . . . . . . . . 160
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
General Information . . . . . . . . . . . . . . . . . . . 160
Recreational Vehicle . . . . . . . . . . . . . . . . . . . 240
Trailer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 164
Trailer Sway Control (TSC) . . . . . . . . . . . . . . 175
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 240
Traction
Control System (TCS)/StabiliTrakLight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Traction Control/Electronic Stability Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .147
Trademarks and License Agreements . . . . . . 117
Trailer
Sway Control (TSC) . . . . . . . . . . . . . . . . . . . . . 175
Tow Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 164

Chevrolet Express Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
14583525) - 2021 - CRC - 12/9/20
294 Index
TransmissionAutomatic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
Fluid, Automatic . . . . . . . . . . . . . . . . . . 186, 189
Transportation Program, Courtesy . . . . . . . 270
Trip Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Turn and Lane-Change Signals . . . . . . . . . . . . 93
U
Uniform Tire Quality Grading . . . . . . . . . . . . 225
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . .2
V
Vehicle Alarm System . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Canadian Owners . . . . . . . . . . . . . . . . . . . . . . . . 2
Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Identification Number (VIN) . . . . . . . . . . . . 260
Load Limits . . . . . . . . . . . . . . . . . . . . . . . . . . . . 132
Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Personalization . . . . . . . . . . . . . . . . . . . . . . . . . 86
Remote Start . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Security . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Speed Messages . . . . . . . . . . . . . . . . . . . . . . . . 86
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 240
Vehicle Ahead Indicator . . . . . . . . . . . . . . . . . . . 79
Vehicle Care Tire Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . 217 Vehicle Data Recording and Privacy . . . . . . 274
Ventilation, Air . . . . . . . . . . . . . . . . . . . . . . . . . . .124
Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Voltmeter Gauge . . . . . . . . . . . . . . . . . . . . . . . . . .73
W
Warning
Brake System Light . . . . . . . . . . . . . . . . . . . . . 77
Caution and Danger . . . . . . . . . . . . . . . . . . . . . 2
Lane Departure (LDW) . . . . . . . . . . . . . . . . . . 157
Warning Lights, Gauges, and Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
Warnings Hazard Flashers . . . . . . . . . . . . . . . . . . . . . . . . . 92
Washer Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 196
Wheels Alignment and Tire Balance . . . . . . . . . . . . 226
Different Size . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . 226
When It Is Time for New Tires . . . . . . . . . . . 223
Where to Put the Restraint . . . . . . . . . . . . . . . . 51
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19 Enhanced Technology Glass . . . . . . . . . . . . . . 21
Manual . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Swing-out Windows . . . . . . . . . . . . . . . . . . . . 20 Windshield
Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . 202
Wiper/Washer . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Winter Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
Winter Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Wiper Blade Replacement . . . . . . . . . . . . . . . . 201