tow CHEVROLET EXPRESS CARGO VAN 2003 1.G Repair Manual

6. Remove any rust or dirt
from the wheel bolts,
mounting surfaces
and spare wheel.
{CAUTION:
Rust or dirt on the wheel, or on the parts to
which it is fastened, can make the wheel nuts
become loose after a time. The wheel could
come off and cause an accident. When you
change a wheel, remove any rust or dirt from
the places where the wheel attaches to the
vehicle. In an emergency, you can use a cloth
or a paper towel to do this; but be sure to use
a scraper or wire brush later, if you need to, to
get all the rust or dirt off.
{CAUTION:
Never use oil or grease on studs or nuts. If
you do, the nuts might come loose. Your wheel
could fall off, causing a serious accident.
7. Put the wheel nuts
back on with the
rounded end of the
nuts toward the wheel.
Tighten each wheel
nut by hand until
the wheel is held
against the hub.
8. Lower the vehicle by turning the jack handle
counterclockwise. Lower the jack completely.
5-76

3. Pull the wheel toward the rear of the vehicle,
keeping the cable tight.4. Attach the ratchet, with the UP side facing you, to
the wheel wrench.
5. Put the ¯at end of the wheel wrench on an angle
through the hole in the rear door frame, above the
bumper.
6. Raise the tire fully against the underside of the
vehicle. Continue turning the ratchet until the tire
is secure and the cable is tight. The spare tire hoist
cannot be overtightened.
7. Make sure the tire is stored securely. Push, pull,
and then try to rotate or turn the tire. If the tire
moves, use the ratchet to tighten the cable.
You will hear two²clicksº when the tire is up all
the way.
Return the jacking equipment to the proper location.
Secure the items and replace the jack cover.
5-79

Here are some cleaning tips:
·Always read the instructions on the cleaner label.
·Clean up stains as soon as you can ± before
they set.
·Carefully scrape off any excess stain.
·Use a clean cloth or sponge, and change to a clean
area often. A soft brush may be used if stains are
stubborn.
·If a ring forms on fabric after spot cleaning, clean
the entire area immediately or it will set.
Using Cleaner on Fabric
1. Vacuum and brush the area to remove any
loose dirt.
2. Always clean a whole trim panel or section. Mask
surrounding trim along stitch or welt lines.
3. Follow the directions on the container label.
4. Apply cleaner with a clean sponge. Don't saturate
the material and don't rub it roughly.
5. As soon as you've cleaned the section, use a
sponge to remove any excess cleaner.
6. Wipe cleaned area with a clean, water-dampened
towel or cloth.
7. Wipe with a clean cloth and let dry.
Special Fabric Cleaning Problems
Stains caused by such things as catsup, coffee (black),
egg, fruit, fruit juice, milk, soft drinks, vomit, urine
and blood can be removed as follows:
1. Carefully scrape off excess stain, then sponge the
soiled area with cool water.
2. If a stain remains, follow the cleaner instructions
described earlier.
3. If an odor lingers after cleaning vomit or urine,
treat the area with a water/baking soda solution:
1 teaspoon (5 ml) of baking soda to 1 cup (250 ml)
of lukewarm water.
4. Let dry.
Stains caused by candy, ice cream, mayonnaise, chili
sauce and unknown stains can be removed as follows:
1. Carefully scrape off excess stain.
2. Clean with cool water and allow to dry completely.
3. If a stain remains, follow the cleaner instructions
described earlier.
5-81

Care of Safety Belts
Keep belts clean and dry.
{CAUTION:
Do not bleach or dye safety belts. If you do, it
may severely weaken them. In a crash, they
might not be able to provide adequate
protection. Clean safety belts only with mild
soap and lukewarm water.
Weatherstrips
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with a clean cloth at least every
six months. During very cold, damp weather more
frequent application may be required. See
Part D: Recommended Fluids and Lubricants on
page 6-18.
Cleaning the Outside of Your
Vehicle
The paint ®nish on your vehicle provides beauty, depth
of color, gloss retention and durability.
Washing Your Vehicle
The best way to preserve your vehicle's ®nish is to keep
it clean by washing it often with lukewarm or cold
water.
Don't wash your vehicle in the direct rays of the sun.
Use a car washing soap. Don't use strong soaps
or chemical detergents. Be sure to rinse the vehicle
well, removing all soap residue completely. You can get
GM-approved cleaning products from your dealer.
See
Vehicle Care/Appearance Materials on page 5-88.
Don't use cleaning agents that are petroleum based,
or that contain acid or abrasives. All cleaning agents
should be ¯ushed promptly and not allowed to dry on the
surface, or they could stain. Dry the ®nish with a soft,
clean chamois or an all-cotton towel to avoid surface
scratches and water spotting.
High pressure car washes may cause water to enter
your vehicle.
5-83

Cleaning the Windshield and Wiper
Blades
If the windshield is not clear after using the windshield
washer, or if the wiper blade chatters when running,
wax, sap or other material may be on the blade or
windshield.
Clean the outside of the windshield with a full-strength
glass cleaning liquid. The windshield is clean if beads do
not form when you rinse it with water.
Grime from the windshield will stick to the wiper blades
and affect their performance. Clean the blade by
wiping vigorously with a cloth soaked in full-strength
windshield washer solvent. Then rinse the blade
with water.
Check the wiper blades and clean them as necessary;
replace blades that look worn.
Cleaning Aluminum Wheels
Keep your wheels clean using a soft clean cloth with
mild soap and water. Rinse with clean water. After
rinsing thoroughly, dry with a soft clean towel. A wax
may then be applied.
The surface of these wheels is similar to the painted
surface of your vehicle. Don't use strong soaps,
chemicals, abrasive polishes, abrasive cleaners,
cleaners with acid, or abrasive cleaning brushes on
them because you could damage the surface. Do not
use chrome polish on aluminum wheels.
Don't take your vehicle through an automatic car wash
that has silicone carbide tire cleaning brushes. These
brushes can also damage the surface of these wheels.
5-85

Inspection (cont.)
Steering and Suspension..............................6-16
Throttle System...........................................6-17
Transfer Case and Front Axle
(All-Wheel Drive)......................................6-17
Instrument Panel Brightness Control..................3-16
Instrument Panel.............................................3-24
Cluster.......................................................3-24
Overview..................................................... 3-4
Interior Lamps................................................3-16
J
Jump Starting.................................................5-41
K
Key Lock Cylinders Service..............................6-13
Keyless Entry System....................................... 2-3
Keys............................................................... 2-2
L
Lamps On Reminder.......................................3-14
Lamps...........................................................3-13
Exterior......................................................3-13
Interior.......................................................3-16Lap Belt........................................................1-26
Lap-Shoulder Belt...........................................1-16
LATCH System...............................................1-51
Child Restraints...........................................1-51
Securing a Child Restraint Designed for the
LATCH System........................................1-53
Leaving Your Vehicle With the Engine
Running.....................................................2-28
Leaving Your Vehicle.......................................2-10
Light.............................................................3-28
Air Bag Off .................................................3-28
Air Bag Readiness.......................................3-27
Anti-Lock Brake System Warning...................3-32
Brake System Warning.................................3-31
Change Engine Oil......................................3-37
Charging System.........................................3-29
Check Gages Warning.................................3-38
Cruise Control.............................................3-38
Daytime Running Lamps Indicator..................3-38
Low Coolant Warning...................................3-33
Malfunction Indicator....................................3-33
Safety Belt Reminder...................................3-26
Security.....................................................3-37
Tow/Haul Mode...........................................3-38
Loading Your Vehicle.......................................4-29
Locking Rear Axle............................................ 4-8
Lockout Protection..........................................2-10
8

Locks............................................................. 2-8
Cargo Door Relocking.................................... 2-8
Door........................................................... 2-7
Leaving Your Vehicle....................................2-10
Lockout Protection.......................................2-10
Power Door.................................................. 2-8
Rear Door Security Locks............................... 2-8
Loss of Control...............................................4-12
Low Coolant Warning Light..............................3-33
M
Maintenance, Normal Replacement Parts..........5-100
Maintenance Schedule.....................................6-11
At Each Fuel Fill.........................................6-11
At Least Once a Month................................6-11
At Least Once a Year..................................6-13
At Least Twice a Year..................................6-12
At the First 100, 1,000 and 6,000 Miles
(160, 1 600 and 10 000km).......................6-11
Brake System Inspection..............................6-17
Engine Cooling System Inspection.................6-16
Exhaust System Inspection...........................6-16
Fuel System Inspection................................6-16
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4Maintenance Schedule (cont.)
Part B - Owner Checks and Services.............6-11
Part C - Periodic MaintenanceInspections......6-16
Part D - Recommended Fluids and
Lubricants...............................................6-18
Part E - Maintenance Record........................6-20
Rear Axle Service........................................6-17
Scheduled Maintenance................................. 6-5
Steering and Suspension Inspection...............6-16
Throttle System Inspection............................6-17
Transfer Case and Front Axle
(All-Wheel Drive) Inspection.......................6-17
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-43
Making Turns.................................................4-42
Malfunction Indicator Light................................3-33
Manual Seats................................................... 1-3
Manual Windows............................................2-16
Matching Transmitter(s) to Your Vehicle............... 2-5
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and
U.S. Virgin Islands) ± Customer Assistance....... 7-4
Mirrors..........................................................2-31
Manual Rearview Mirror................................2-31
Outside Camper-Type Mirrors........................2-32
Outside Convex Mirror.................................2-34
Outside Heated Mirrors................................2-34
9

Rear Door Security Locks.................................. 2-8
Rear Doors....................................................2-14
Rear Heating System......................................3-20
Rear Safety Belt Comfort Guides......................1-31
Rear Seat Audio (RSA)....................................3-71
Rear Seat Operation......................................... 1-6
Rear Seat Outside Passenger Positions.............1-28
Rear Seat Passengers, Safety Belts..................1-28
Rear Seat Radio Controls................................3-71
Rear Window Defogger....................................3-23
Rearview Mirrors.............................................2-31
Reclining Seatbacks.......................................... 1-4
Recreational Vehicle Towing.............................4-29
Remote Keyless Entry System, Operation............ 2-4
Remote Keyless Entry System............................ 2-3
Removing the Flat Tire and Installing the
Spare Tire..................................................5-72
Removing the Rear Seat................................... 1-6
Removing the Spare Tire and Tools...................5-66
Removing the Wheel Covers............................5-72
Replacement Bulbs.........................................5-54
Replacing Brake System Parts..........................5-40
Replacing Restraint System Parts After
a Crash.....................................................1-75
Replacing the Rear Seats.................................. 1-8
Reporting Safety Defects................................... 7-9
Canadian Government................................... 7-9
General Motors............................................. 7-9
United States Government.............................. 7-8Restraint System Check...................................6-12
Checking Your Restraint Systems...................1-74
Replacing Restraint System Parts After
a Crash..................................................1-75
Restraint Systems...........................................1-74
Checking....................................................1-74
Replacing Parts...........................................1-75
Resynchronization............................................. 2-5
Retained Accessory Power (RAP)......................2-21
Right Front Passenger Position, Safety Belts......1-25
Roadside......................................................... 7-5
Assistance Program....................................... 7-5
Rocking Your Vehicle To Get It Out...................4-28
Running Your Engine While You Are Parked.......2-30
S
Safety Belt.....................................................3-26
Reminder Light............................................3-26
Safety Belts...................................................5-83
Care of......................................................5-83
Center Passenger Position....................1-25, 1-26
Driver Position............................................1-16
How to Wear Safety Belts Properly................1-15
Questions and Answers About Safety Belts.....1-14
Rear Safety Belt Comfort Guides for Children
and Small Adults......................................1-31
Rear Seat Passengers.................................1-28
Right Front Passenger Position......................1-25
12

T
Taillamps.......................................................5-52
Theft-Deterrent, Radio.....................................3-73
Theft-Deterrent Systems...................................2-19
Passlock
ž...................................................2-19
Throttle System Inspection...............................6-17
Tilt Wheel........................................................ 3-7
Tire In¯ation Check.........................................6-11
Tires.............................................................5-56
Buying New Tires........................................5-60
Chains.......................................................5-63
Changing a Flat Tire....................................5-65
Dual Tire Operation.....................................5-57
If a Tire Goes Flat.......................................5-64
In¯ation -- Tire Pressure...............................5-56
Inspection and Rotation................................5-58
Uniform Tire Quality Grading.........................5-61
Wheel Alignment and Tire Balance.................5-62
Wheel Replacement.....................................5-62
When It Is Time for New Tires......................5-59
To Use the Engine Coolant Heater....................2-23
Top Strap Anchor Location...............................1-50
Top Strap......................................................1-48
Torque Lock...................................................2-28
Total Weight on Your Vehicle's Tires..................4-39
Tow/Haul Mode Light.......................................3-38
Tow/Haul Mode...............................................4-32Towing..........................................................4-29
Recreational Vehicle.....................................4-29
Towing a Trailer..........................................4-31
Your Vehicle...............................................4-29
Trailer Brakes.................................................4-40
Trailer Wiring Harness.....................................4-44
Transfer Case................................................5-46
Transmission Operation, Automatic....................2-24
Transmission, Transaxle, Transfer Case Unit
Repair Manual............................................7-10
Transmission..................................................5-19
Fluid, Automatic...........................................5-19
Transportation Options...................................... 7-7
Trip Odometer................................................3-25
Turn and Lane Change Signals.......................... 3-8
Turn Signal/Multifunction Lever........................... 3-7
Turn Signals When Towing a Trailer..................4-42
U
Underbody Flushing Service.............................6-15
Understanding Radio Reception........................3-73
Uniform Tire Quality Grading............................5-61
United States ± Customer Assistance.................. 7-4
Using Cleaner on Fabric..................................5-81
Using RDS............................................3-51, 3-62
Using Song List Mode.....................................3-69
14