steering CHEVROLET EXPRESS CARGO VAN 2007 1.G Owner's Guide

Additional Required Services (cont’d)
Service and Miles (Kilometers)25,000
(40 000)50,000
(80 000)75,000
(120 000)100,000
(160 000)125,000
(200 000)150,000
(240 000)
Inspect engine accessory drive belt.
An Emission Control Service.
See footnote (n).•
Inspect evaporative control system.
An Emission Control Service.
See footnotes † and (k).•••
Maintenance Footnotes
(Gasoline Engine)
This maintenance section applies to vehicles with
a gasoline engine. If your vehicle has a diesel
engine, see the maintenance schedule section in
the DURAMAX
®Diesel Engine Supplement.
†The U.S. Environmental Protection Agency or
the California Air Resources Board has determined
that the failure to perform this maintenance item
will not nullify the emission warranty or limit
recall liability prior to the completion of the
vehicle’s useful life. We, however, urge that all
recommended maintenance services be performed
at the indicated intervals and the maintenance
be recorded.#Lubricate the front suspension, kingpin bushings,
steering linkage, and rear driveline center splines.
(a)Visually inspect brake lines and hoses for
proper hook-up, binding, leaks, cracks, chang,
etc. Inspect disc brake pads for wear and rotors
for surface condition. Inspect other brake
parts, including calipers, parking brake, etc.
(b)Visually inspect front and rear suspension and
steering system for damaged, loose, or missing
parts, signs of wear, or lack of lubrication. Inspect
power steering lines and hoses for proper
hook-up, binding, leaks, cracks, chang, etc.
409

Recommended Fluids
and Lubricants
This maintenance section applies to vehicles with
a gasoline engine. If your vehicle has a diesel
engine, see the maintenance schedule section in
the DURAMAX
®Diesel Engine Supplement.
Fluids and lubricants identified below by name,
part number, or specification can be obtained
from your dealer/retailer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certified for Gasoline Engines
starburst symbol. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil (Gasoline
Engine) on page 303.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant
on page 312.
Usage Fluid/Lubricant
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake fluid.
Windshield
WasherGM Optikleen
®Washer Solvent.
Parking Brake
Cable GuidesChassis Lubricant
(GM Part No. U.S. 12377985, in
Canada 88901242) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Power Steering
SystemGM Power Steering Fluid
(GM Part No. U.S. 89021184,
in Canada 89021186).
Automatic
TransmissionDEXRON
®-VI Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241,
in Canada 10953474).
415

Service Publications Ordering
Information
Service Manuals
Service Manuals have the diagnosis and repair
information on engines, transmission, axle
suspension, brakes, electrical, steering, body, etc.
Transmission, Transaxle, Transfer
Case Unit Repair Manual
This manual provides information on unit
repair service procedures, adjustments, and
specifications for GM transmissions, transaxles,
and transfer cases.
Service Bulletins
Service Bulletins give technical service
information needed to knowledgeably service
General Motors cars and trucks. Each bulletin
contains instructions to assist in the diagnosis
and service of your vehicle.In Canada, the service bulletin reference number
can be obtained by contacting your General Motors
dealer or by calling 1-800-GM-DRIVE
(1-800-463-7483). This reference number is
needed to order the service bulletin from Helm, Inc.
RETAIL SELL PRICE: $6.00 US +
Processing Fee
Owner Information
Owner publications are written specifically for
owners and intended to provide basic operational
information about the vehicle. The owner manual
includes the Maintenance Schedule for all models.
In-Portfolio: Includes a Portfolio, Owner Manual,
and Warranty Booklet.
RETAIL SELL PRICE: $35.00 US +
Processing Fee
Without Portfolio: Owner Manual only.
RETAIL SELL PRICE: $25.00 US +
Processing Fee
440

Event Data Recorders
Some information about your vehicle’s
performance and how it is driven may be recorded
on various modules if a crash occurs. Some
people refer to these modules asevent data
recorders (EDRs). These modules may record
several seconds of pre-crash and crash data,
such as data related toengine speed, brake
application, throttle position, vehicle speed,
yaw rate, steering wheel angle, lateral
acceleration, safety belt usage, airbag
readiness, airbag performanceandthe severity
of the collision.Unlike the flight data recorders
on airplanes, these modules do not record
sounds or conversations.To retrieve this data, special equipment and
access to the vehicle or the module that stores
the data are required. Certain data may also
be sent to or retrieved by OnStar®(see below).
GM will not access this information or share it with
others except: with the consent of the vehicle
owner or, if the vehicle is leased, with the consent
of the lessee; in response to an official request
of police or similar government office; as part
of GM’s defense of litigation through the discovery
process; or, as required by law. Data that
GM collects or receives may also be used for
GM research needs or may be made available to
others for research purposes, where a need is
shown and the data is not tied to a specific vehicle
or vehicle owner.
Others may be able to retrieve this data if they
have access to the vehicle and have the special
equipment necessary to download the data.
442

Flash-to-Pass.............................................. 149
Flat Tire...................................................... 365
Flat Tire, Changing...................................... 366
Flat Tire, Storing......................................... 380
Fluid
Automatic Transmission............................ 309
Power Steering........................................ 323
Windshield Washer.................................. 324
Front Axle................................................... 338
Fuel............................................................ 292
Additives.................................................. 294
California Fuel.......................................... 293
E85 (85% Ethanol)................................... 295
Filling a Portable Fuel Container.............. 299
Filling Your Tank...................................... 297
Fuels in Foreign Countries....................... 296
Gage....................................................... 186
Gasoline Octane...................................... 293
Gasoline Specifications............................ 293
Regulator................................................. 123
Fuses
Engine Compartment Fuse Block............. 395
Floor Console Fuse Block........................ 394
Fuses and Circuit Breakers...................... 393
Windshield Wiper..................................... 393G
Gage
Check Gages Warning Light..................... 185
Engine Coolant Temperature.................... 178
Fuel......................................................... 186
Oil Pressure............................................. 182
Speedometer........................................... 168
Voltmeter Gage........................................ 175
Gasoline
Octane..................................................... 293
Specifications........................................... 293
GM Mobility Reimbursement Program.......... 429
H
Hazard Warning Flashers............................ 146
Headlamp Wiring......................................... 393
Headlamps.................................................. 340
Bulb Replacement.................................... 340
Daytime Running Lamps.......................... 156
Exterior Lamps......................................... 155
Flash-to-Pass........................................... 149
Front Turn Signal, Sidemarker and
Parking Lamps..................................... 342
450

Parking
Brake....................................................... 128
Over Things That Burn............................ 131
Passenger Airbag Status Indicator............... 172
Passenger Sensing System........................... 89
Passing....................................................... 241
Passlock
®.................................................... 118
Power
Door Locks.............................................. 109
Reduced Engine Light.............................. 184
Retained Accessory (RAP)....................... 121
Seat.......................................................... 10
Steering Fluid.......................................... 323
Windows.................................................. 116
Pretensioners, Safety Belt............................. 40
Privacy........................................................ 441
Event Data Recorders.............................. 442
Navigation System................................... 443
OnStar..................................................... 443
Radio Frequency Identification.................. 443
Q
Questions and Answers About Safety Belts ... 21
R
Radiator Pressure Cap................................ 315
Radio Frequency Identification (RFID),
Privacy..................................................... 443
Radios........................................................ 187
AM-FM Radio.......................................... 190
Care of Your Cassette Tape Player.......... 224
Care of Your CD Player........................... 226
Care of Your CDs.................................... 225
Radio with Cassette and CD.................... 198
Radio with CD......................................... 193
Radio with Six-Disc CD............................ 211
Setting the Time with Radio Data
Systems (RDS)..................................... 189
Setting the Time without Radio Data
Systems (RDS)..................................... 189
Theft-Deterrent......................................... 223
Understanding Reception ......................... 224
Reading Lamps........................................... 158
Rear Air Conditioning and Heating
System.................................................... 164
Rear Axle.................................................... 337
Locking.................................................... 235
Rear Door Security Locks........................... 110
Rear Doors................................................. 114
Rear Heating System.................................. 163
454

Safety Belts (cont.)
Safety Belt Use During Pregnancy............. 32
Safety Belts Are for Everyone.................... 17
Shoulder Belt Height Adjuster.................... 31
Safety Warnings and Symbols......................... 4
Scheduled Maintenance............................... 405
Seats
Manual........................................................ 9
Power Seat................................................ 10
Rear Seat Operation.................................. 13
Reclining Seatbacks................................... 10
Secondary Latch System............................. 377
Securing a Child Restraint
Center Seat Position.................................. 66
Rear Outside Seat Position or the Second
Row Center Seat Position...................... 63
Right Front Seat Position.................... 68, 72
Security Light.............................................. 183
Service........................................................ 290
Accessories and Modifications.................. 290
Adding Equipment to the Outside of Your
Vehicle................................................. 292
California Proposition 65 Warning............. 291
Doing Your Own Work............................. 291
Engine Soon Light................................... 178
Publications Ordering Information............. 440Servicing Your Airbag-Equipped Vehicle......... 96
Sheet Metal Damage................................... 389
Shifting Into Park (P)................................... 129
Shifting Out of Park (P)............................... 130
Shoulder Belt Height Adjuster........................ 31
Signals, Turn and Lane-Change.................. 148
Sliding Side Door........................................ 111
Spare Tire................................................... 382
Installing.................................................. 370
Removing................................................ 367
Storing..................................................... 380
Specifications, Capacities............................ 398
Speedometer............................................... 168
StabiliTrak
®System..................................... 235
StabiliTrak®Indicator Light........................... 177
StabiliTrak®Not Ready Light........................ 177
Starting Your Engine................................... 122
Steering...................................................... 239
Steering Wheel, Tilt Wheel.......................... 147
Storage Areas............................................. 139
Stuck in Sand, Mud, Ice, or Snow............... 260
Sun Visors.................................................. 117
Swing-Out Side Door, 60/40........................ 112
Swing-Out Windows.................................... 117
456