warning CHEVROLET HHR 2008 1.G Repair Manual

Treadwear
The treadwear grade is a comparative rating
based on the wear rate of the tire when tested
under controlled conditions on a specied
government test course. For example, a tire
graded 150 would wear one and a half (1.5) times
as well on the government course as a tire
graded 100. The relative performance of tires
depends upon the actual conditions of their use,
however, and may depart signicantly from the
norm due to variations in driving habits, service
practices, and differences in road characteristics
and climate.
Traction – AA, A, B, C
The traction grades, from highest to lowest, are
AA, A, B, and C. Those grades represent the tire’s
ability to stop on wet pavement as measured under
controlled conditions on specied government test
surfaces of asphalt and concrete. A tire marked C
may have poor traction performance.
Warning
:The traction grade assigned to this
tire is based on straight-ahead braking traction
tests, and does not include acceleration,
cornering, hydroplaning, or peak traction
characteristics.
Temperature – A, B, C
The temperature grades are A (the highest), B,
and C, representing the tire’s resistance to
the generation of heat and its ability to dissipate
heat when tested under controlled conditions on a
specied indoor laboratory test wheel. Sustained
high temperature can cause the material of the tire
to degenerate and reduce tire life, and excessive
temperature can lead to sudden tire failure.
The grade C corresponds to a level of performance
which all passenger car tires must meet under
the Federal Motor Vehicle Safety Standard
No. 109. Grades B and A represent higher levels
of performance on the laboratory test wheel
than the minimum required by law.
Warning
:The temperature grade for this
tire is established for a tire that is properly
inated and not overloaded. Excessive speed,
underination, or excessive loading, either
separately or in combination, can cause heat
buildup and possible tire failure.
5-72

Changing a Flat Tire (Vehicles with
spare tire)
If a tire goes at, avoid further tire and wheel damage by
driving slowly to a level place. Turn on your hazard
warning ashers.
{CAUTION:
Changing a tire can be dangerous. The vehicle
can slip off the jack and roll over or fall on you
or other people. You and they could be badly
injured or even killed. Find a level place to
change your tire. To help prevent the vehicle
from moving:
1. Set the parking brake rmly.
2. Put an automatic transmission shift lever in
PARK (P), or shift a manual transmission to
FIRST (1) or REVERSE (R).
CAUTION: (Continued)
CAUTION: (Continued)
3. Turn off the engine and do not restart
while the vehicle is raised.
4. Do not allow passengers to remain in the
vehicle.
To be even more certain the vehicle will not
move, you should put blocks at the front and
rear of the tire farthest away from the one
being changed. That would be the tire on the
other side, at the opposite end of the vehicle.
5-86

A
Accessories and Modications............................ 5-3
Adding Equipment to Your Airbag-Equipped
Vehicle.......................................................1-71
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment...........................5-118
Air Cleaner/Filter, Engine.................................5-20
Air Conditioning..............................................3-23
Airbag
Passenger Status Indicator...........................3-32
Readiness Light..........................................3-31
Airbag System................................................1-57
What Will You See After an Airbag Inates?....1-64
When Should an Airbag Inate?....................1-62
Where Are the Airbags?...............................1-60
Airbag Systems
Adding Equipment to Your Airbag-Equipped
Vehicle...................................................1-71
How Does an Airbag Restrain?......................1-63
Passenger Sensing System...........................1-65
Servicing Your Airbag-Equipped Vehicle..........1-70
What Makes an Airbag Inate?......................1-63
Antenna, Fixed Mast.......................................3-80
Antenna, XM™ Satellite Radio Antenna System.....3-80
Antilock Brake System (ABS)............................. 4-5
Antilock Brake, System Warning Light................3-36Appearance Care
Aluminum or Chrome-Plated Wheels.............5-115
Care of Safety Belts...................................5-112
Chemical Paint Spotting..............................5-116
Cleaning Exterior Lamps/Lenses..................5-113
Fabric/Carpet............................................5-111
Finish Care...............................................5-114
Finish Damage..........................................5-116
Instrument Panel, Vinyl, and Other Plastic
Surfaces...............................................5-112
Interior Cleaning........................................5-110
Sheet Metal Damage..................................5-116
Tires........................................................5-116
Underbody Maintenance.............................
5-116
Vehicle Care/Appearance Materials...............5-117
Washing Your Vehicle.................................5-113
Weatherstrips............................................5-113
Windshield and Wiper Blades......................5-114
Appointments, Scheduling Service....................... 7-8
Ashtray.........................................................3-22
Audio System.................................................3-59
Audio Steering Wheel Controls......................3-79
Fixed Mast Antenna.....................................3-80
Radio Reception..........................................3-79
Setting the Clock.........................................3-60
Theft-Deterrent Feature................................3-78
XM™ Satellite Radio Antenna System............3-80
1

Audio System(s).............................................3-62
Automatic Door Lock.......................................2-10
Automatic Headlamp System............................3-17
Automatic Transmission
Fluid..........................................................5-23
Operation...................................................2-28
B
Battery..........................................................5-37
Electric Power Management..........................3-20
Run-Down Protection...................................3-20
Boost Gage...................................................3-45
Brake
Emergencies................................................ 4-6
Brakes..........................................................5-34
System Warning Light..................................3-35
Braking........................................................... 4-3
Braking in Emergencies..................................... 4-6
Break-In, New Vehicle.....................................2-21
Bulb Replacement...........................................5-46
Center High-Mounted Stoplamp (CHMSL)........5-48
Halogen Bulbs............................................5-46
Headlamp Aiming........................................5-43
Headlamps, Front Turn Signal, and Parking
Lamps....................................................5-46Bulb Replacement (cont.)
License Plate Lamps....................................5-50
Replacement Bulbs......................................5-50
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps........................................5-49
Buying New Tires...........................................5-69
C
Calibration.............................................2-39, 2-41
California Fuel.................................................. 5-6
California Perchlorate Materials Requirements....... 5-4
California Proposition 65 Warning....................... 5-3
Canadian Owners................................................ ii
Capacities and Specications..........................5-125
Carbon Monoxide...........................2-37, 4-22, 4-34
Care of
Safety Belts..............................................5-112
Cargo, Rear Side Door....................................2-12
CD, MP3 .......................................................3-72
Center High-Mounted Stoplamp (CHMSL)...........5-48
Chains, Tire...................................................5-74
Charging System Light....................................3-34
Check
Engine Light...............................................3-40
2

Checking Things Under the Hood......................5-10
Chemical Paint Spotting.................................5-116
Child Restraints
Child Restraint Systems...............................1-40
Infants and Young Children...........................1-36
Lower Anchors and Tethers for Children..........1-43
Older Children.............................................1-33
Securing a Child Restraint in a Rear Seat
Position..................................................1-51
Securing a Child Restraint in the Right
Front Seat Position...................................1-53
Where to Put the Restraint...........................1-42
Cigarette Lighter.............................................3-22
Cleaning
Aluminum or Chrome-Plated Wheels.............5-115
Exterior Lamps/Lenses................................5-113
Fabric/Carpet............................................5-111
Finish Care...............................................5-114
Instrument Panel, Vinyl, and Other Plastic
Surfaces...............................................5-112
Interior.....................................................5-110
Tires........................................................5-116
Underbody Maintenance.............................5-116
Washing Your Vehicle.................................5-113
Weatherstrips............................................5-113
Windshield and Wiper Blades......................5-114Climate Control System...................................3-23
Air Filter, Passenger Compartment.................3-26
Outlet Adjustment........................................3-26
Clock, Setting.................................................3-60
Clutch, Hydraulic.............................................5-23
Collision Damage Repair..................................7-10
Compact Spare Tire......................................5-109
Compass...............................................2-39, 2-41
Compressor Kit, Tire Sealant............................5-76
Content Theft-Deterrent....................................2-18
Control of a Vehicle.......................................... 4-3
Convenience Net
............................................2-51
Coolant
Engine Temperature Gage............................3-39
Engine Temperature Warning Light.................3-38
Heater, Engine............................................2-27
Cooling System..............................................5-28
Cruise Control................................................3-12
Cupholder(s)..................................................2-47
Customer Assistance Information
Courtesy Transportation.................................. 7-9
Customer Assistance for Text Telephone (TTY)
Users....................................................... 7-4
Customer Assistance Offices........................... 7-5
Customer Satisfaction Procedure..................... 7-2
GM Mobility Reimbursement Program............... 7-6
3

Customer Assistance Information (cont.)
Reporting Safety Defects to General Motors....7-14
Reporting Safety Defects to the Canadian
Government............................................7-14
Reporting Safety Defects to the United
States Government...................................7-13
Roadside Assistance Program......................... 7-6
Service Publications Ordering Information........7-15
D
Daytime Running Lamps..................................3-16
Defensive Driving............................................. 4-2
Delayed Locking.............................................2-10
Differential, Limited-Slip....................................4-10
Disc, MP3......................................................3-72
Doing Your Own Service Work........................... 5-4
Dome Lamp...................................................3-19
Door
Automatic Door Lock....................................2-10
Delayed Locking..........................................2-10
Locks.......................................................... 2-9
Power Door Locks......................................... 2-9
Programmable Automatic Door Unlock............2-10
Rear Door Security Locks.............................2-11
Rear Side Cargo.........................................2-12Driver
Seat Height Adjuster...................................... 1-3
Driver Information Center (DIC).........................3-46
DIC Operation and Displays..........................3-46
DIC Vehicle Personalization..........................3-54
DIC Warnings and Messages........................3-48
Driving
At Night.....................................................4-18
Before a Long Trip......................................4-20
Defensive..................................................... 4-2
Drunken....................................................... 4-2
Highway Hypnosis.......................................4-20
Hill and Mountain Roads..............................4-20
In Rain and on Wet Roads...........................4-18
Rocking Your Vehicle to Get it Out.................4-26
Winter........................................................4-22
E
EDR .............................................................7-16
Electrical System
Add-On Equipment.....................................5-118
Engine Compartment Fuse Block.................5-122
Floor Console Fuse Block...........................5-120
Fuses and Circuit Breakers.........................5-119
Headlamp Wiring.......................................5-119
4

Electrical System (cont.)
Power Windows and Other Power Options....5-119
Windshield Wiper Fuses.............................5-119
Electronic Stability Control................................4-10
Electronic Stability Control Indicator Light...........3-37
Engine
Air Cleaner/Filter.........................................5-20
Check and Service Engine Soon Light............3-40
Coolant......................................................5-24
Coolant Heater............................................2-27
Coolant Temperature Gage...........................3-39
Coolant Temperature Warning Light................3-38
Drive Belt Routing.......................................6-15
Engine Compartment Overview......................5-12
Exhaust.....................................................2-37
Oil .............................................................5-15
Oil Life System...........................................5-19
Overheating................................................5-26
Running While Parked..................................2-38
Starting......................................................2-25
Enhanced Traction System (ETS)........................ 4-9
Warning Light.............................................3-37
Entry/Exit Lighting...........................................3-19
Event Data Recorders.....................................7-16
Extender, Safety Belt.......................................1-32F
Filter
Engine Air Cleaner......................................5-20
Finish Damage.............................................5-116
Fixed Mast Antenna........................................3-80
Flashers, Hazard Warning.................................. 3-6
Flash-to-Pass................................................... 3-8
Flat Tire........................................................5-75
Flat Tire, Changing.........................................5-86
Flat Tire, Storing...........................................5-106
Fluid.............................................................5-23
Windshield Washer......................................5-33
Fog Lamp
Fog ...........................................................3-18
Fog Lamp Light..............................................3-44
Folding Rear Seat...........................................1-10
Folding Seatback, Passenger............................. 1-8
Front Console Storage Area.............................2-47
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-6
Filling a Portable Fuel Container....................5-10
Filling the Tank............................................. 5-7
Fuels in Foreign Countries.............................. 5-7
5

Fuel (cont.)
Gage.........................................................3-44
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-5
Fuses
Engine Compartment Fuse Block.................5-122
Floor Console Fuse Block...........................5-120
Fuses and Circuit Breakers.........................5-119
Windshield Wiper.......................................5-119
G
Gage
Boost.........................................................3-45
Engine Coolant Temperature.........................3-39
Fuel..........................................................3-44
Speedometer..............................................3-30
Tachometer.................................................3-30
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-5
Glove Box.....................................................2-47
GM Mobility Reimbursement Program.................. 7-6
H
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-7
Headlamp
Aiming.......................................................5-43
Headlamp Wiring...........................................5-119
Headlamps....................................................3-15
Bulb Replacement.......................................5-46
Daytime Running Lamps...............................3-16
Flash-to-Pass............................................... 3-8
Halogen Bulbs............................................5-46
Headlamps, Front Turn Signal, and Parking
Lamps....................................................5-46
High/Low Beam Changer................................ 3-8
On Reminder..............................................3-16
Wiper Activated...........................................3-16
Heated Seats................................................... 1-4
Heater...........................................................3-23
Height Adjuster, Driver Seat............................... 1-3
Hideaway Rear Storage Bins............................2-51
Highbeam On Light.........................................3-44
Highway Hypnosis...........................................4-20
Hill and Mountain Roads..................................4-20
6

Hood
Checking Things Under................................5-10
Release.....................................................5-11
Horn............................................................... 3-6
How to Wear Safety Belts Properly...................1-18
Hydraulic Clutch.............................................5-23
I
Ignition Positions.............................................2-22
Infants and Young Children, Restraints...............1-36
Ination - Tire Pressure...................................5-60
Inator Kit, Tire...............................................5-76
Instrument Panel
Overview..................................................... 3-4
Storage Area..............................................2-47
Instrument Panel (I/P)
Brightness..................................................3-18
Cluster.......................................................3-29
J
Jump Starting.................................................5-38
K
Keyless Entry System....................................... 2-4
Keys............................................................... 2-3
L
Labeling, Tire Sidewall.....................................5-53
Lamps
Dome........................................................3-19
Mirror Reading............................................3-19
Rear Reading.............................................3-19
Lap-Shoulder Belt...........................................1-26
LATCH System
Child Restraints...........................................1-43
License Plate Lamps.......................................5-50
Liftgate
Carbon Monoxide........................................2-12
Light
Airbag Readiness........................................3-31
Antilock Brake System Warning.....................3-36
Brake System Warning.................................3-35
Charging System.........................................3-34
Engine Coolant Temperature Warning.............3-38
7

Light (cont.)
Enhanced Traction System (ETS) Warning
Light......................................................3-37
Fog Lamp..................................................3-44
Highbeam On.............................................3-44
Malfunction Indicator....................................3-40
Oil Pressure...............................................3-43
Passenger Airbag Status Indicator..................3-32
Safety Belt Reminders..................................3-30
Security.....................................................3-44
Tire Pressure..............................................3-39
Up-Shift.....................................................3-35
Lighting
Entry/Exit...................................................3-19
Lights............................................................3-15
Flash-to-Pass............................................... 3-8
High/Low Beam Changer................................ 3-8
On Reminder..............................................3-16
Limited-Slip Differential....................................4-10
Loading Your Vehicle.......................................4-27
Lockout Protection..........................................2-12
Locks
Automatic Door Lock....................................2-10
Delayed Locking..........................................2-10
Door........................................................... 2-9
Lockout Protection.......................................2-12
Power Door.................................................. 2-9
Programmable Automatic Door Unlock............2-10Locks (cont.)
Rear Door Security Locks.............................2-11
Loss of Control...............................................4-16
Lumbar
Power Controls............................................. 1-4
M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-8
At Least Once a Month.................................. 6-9
At Least Once a Year.................................... 6-9
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-7
Maintenance Record....................................6-16
Maintenance Replacement Parts....................6-14
Maintenance Requirements............................. 6-2
Owner Checks and Services........................... 6-8
Recommended Fluids and Lubricants.............6-12
Scheduled Maintenance................................. 6-4
Using.......................................................... 6-2
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Light................................3-40
Manual Seats................................................... 1-2
Manual Transmission
Fluid..........................................................5-23
Operation...................................................2-31
Manual, Using.................................................... iii
8