engine overheat CHEVROLET IMPALA 2020 User Guide

Chevrolet Impala Owner Manual (GMNA-Localizing-U.S./Canada-13688912) -
2020 - CRC - 6/5/19
Vehicle Care 211
If coolant is visible but the coolant
level is not at or above the mark
pointed to, add a 50/50 mixture of
clean drinkable water and
DEX-COOL coolant.
Be sure the cooling system is cool
before this is done.
If no coolant is visible in the coolant
surge tank, add coolant as follows:
How to Add Coolant to the
Coolant Surge Tank
If no problem is found, check to see
if coolant is visible in the coolant
surge tank. If coolant is visible but
the coolant level is not at theindicated level mark, add a 50/
50 mixture of clean, drinkable water
and DEX-COOL coolant at the
coolant surge tank, but be sure the
cooling system, including the
coolant surge tank pressure cap, is
cool before you do it.
{Warning
Spilling coolant on hot engine
parts can burn you. Coolant
contains ethylene glycol and it will
burn if the engine parts are hot
enough.
{Warning
Steam and scalding liquids from a
hot cooling system are under
pressure. Turning the pressure
cap, even a little, can cause them
to come out at high speed and
you could be burned. Never turn
the cap when the cooling system,
(Continued)
Warning (Continued)
including the pressure cap, is hot.
Wait for the cooling system and
pressure cap to cool.
Caution
Failure to follow the specific
coolant fill procedure could cause
the engine to overheat and could
cause system damage. If coolant
is not visible in the surge tank,
contact your dealer.
1. Remove the coolant surge tankpressure cap when the cooling
system, including the coolant

Chevrolet Impala Owner Manual (GMNA-Localizing-U.S./Canada-13688912) -
2020 - CRC - 6/5/19
212 Vehicle Care
surge tank pressure cap and
upper radiator hose, is no
longer hot.
Turn the pressure cap slowly
counterclockwise about
one-quarter of a turn. If you
hear a hiss, wait for that to
stop. This will allow any
pressure still left to be vented
out the discharge hose.
2. Keep turning the pressure cap slowly and remove it.
3. Fill the coolant surge tank with the proper mixture to the
indicated level mark.
4. With the coolant surge tank pressure cap off, start the
engine and let it run until you
can feel the upper radiator
hose getting hot. Watch out for
the engine cooling fans.
By this time, the coolant level
inside the coolant surge tank
may be lower. If the level is
lower, add more of the proper
mixture to the coolant surge
tank until the level reaches the
indicated level mark. 5. Replace the pressure cap
tightly.
6. Verify coolant level after the engine is shut off and the
coolant is cold. If necessary,
repeat coolant fill procedure
Steps 1–6.
If the coolant still is not at the
proper level when the system
cools down again, see your
dealer.
Caution
If the pressure cap is not tightly
installed, coolant loss and engine
damage may occur. Be sure the
cap is properly and tightly
secured.
Engine Overheating
There is a coolant temperature
gauge on the instrument cluster that
indicates an overheated engine
condition. See Engine Coolant
Temperature Gauge 0100. If the decision is made not to lift the
hood when this warning appears,
get service help right away. See
Roadside Assistance Program
0
294.
If the decision is made to lift the
hood, make sure the vehicle is
parked on a level surface.
Then check to see if the engine
cooling fans are running. If the
engine is overheating, the fans
should be running. If not, do not
continue to run the engine and have
the vehicle serviced.
Caution
Do not run the engine if there is a
leak in the engine cooling system.
This can cause a loss of all
coolant and can damage the
system and vehicle. Have any
leaks fixed right away.

Chevrolet Impala Owner Manual (GMNA-Localizing-U.S./Canada-13688912) -
2020 - CRC - 6/5/19
Vehicle Care 213
If Steam Is Coming from the
Engine Compartment
{Warning
Steam and scalding liquids from a
hot cooling system are under
pressure. Turning the pressure
cap, even a little, can cause them
to come out at high speed and
you could be burned. Never turn
the cap when the cooling system,
including the pressure cap, is hot.
Wait for the cooling system and
pressure cap to cool.
See Overheated Engine Protection
Operating Mode 0213 for
information on driving to a safe
place in an emergency.
If No Steam Is Coming from
the Engine Compartment
If an engine overheat warning is
displayed but no steam can be seen
or heard, the problem might not be
too serious. Sometimes the engine
can get a little too hot when the
vehicle: .
Climbs a long hill on a hot day.
. Stops after high-speed driving.
. Idles for long periods in traffic.
. Tows a trailer.
If the overheat warning displays with
no sign of steam: 1. Turn the air conditioning off.
2. Turn the heater on to the highest temperature and to the
highest fan speed. Open the
windows as necessary.
3. When it is safe to do so, pull off the road, shift to P (Park) or
N (Neutral), and let the
engine idle.
If the coolant temperature gauge is
no longer in the overheat zone, the
vehicle can be driven. Continue to
drive the vehicle slowly for about
10 minutes. Keep a safe vehicle
distance from the vehicle in front.
If the warning does not come back
on, continue to drive normally and
have the cooling system checked
for proper fill and function. If the warning continues, pull over,
stop, and park the vehicle
right away.
If there is no sign of steam, idle the
engine for three minutes while
parked. If the warning is still
displayed, turn off the engine until it
cools down. Also, see
Overheated
Engine Protection Operating Mode
0 213.
Overheated Engine
Protection
Operating Mode
This emergency operating mode
allows the vehicle to be driven to a
safe place in an emergency
situation. If an overheated engine
condition exists, an overheat
protection mode which alternates
firing groups of cylinders helps
prevent engine damage. In this
mode, there is significant loss in
power and engine performance.
The engine coolant temperature
gauge indicates if an overheat
condition exists. Driving extended

Chevrolet Impala Owner Manual (GMNA-Localizing-U.S./Canada-13688912) -
2020 - CRC - 6/5/19
214 Vehicle Care
distances and/or towing a trailer in
the overheat protection mode
should be avoided.
Washer Fluid
What to Use
When windshield washer fluid is
needed, be sure to read the
manufacturer's instructions before
use. If operating the vehicle in an
area where the temperature may fall
below freezing, use a fluid that has
sufficient protection against
freezing.
Adding Washer Fluid
Open the cap with the washer
symbol on it. Add washer fluid until
the tank is full. SeeEngine
Compartment Overview 0203 for
reservoir location.
Caution
. Do not use washer fluid that
contains any type of water
repellent coating. This can
cause the wiper blades to
chatter or skip.
. Do not use engine coolant
(antifreeze) in the
windshield washer. It can
damage the windshield
washer system and paint.
. Do not mix water with
ready-to-use washer fluid.
Water can cause the
solution to freeze and
damage the washer fluid
tank and other parts of the
washer system.
. When using concentrated
washer fluid, follow the
manufacturer instructions for
adding water.
. Fill the washer fluid tank
only three-quarters full when
it is very cold. This allows
(Continued)
Caution (Continued)
for fluid expansion if
freezing occurs, which could
damage the tank if it is
completely full.
Brakes
Disc brake pads have built-in wear
indicators that make a high-pitched
warning sound when the brake pads
are worn and new pads are needed.
The sound can come and go or can
be heard all the time when the
vehicle is moving, except when
applying the brake pedal firmly.
{Warning
The brake wear warning sound
means that soon the brakes will
not work well. That could lead to
a crash. When the brake wear
warning sound is heard, have the
vehicle serviced.

Chevrolet Impala Owner Manual (GMNA-Localizing-U.S./Canada-13688912) -
2020 - CRC - 6/5/19
Index 319
Driving (cont'd)Hill and Mountain Roads . . . . . . 145
If the Vehicle is Stuck . . . . . . . . . 147
Loss of Control . . . . . . . . . . . . . . . 143
Off-Road Recovery . . . . . . . . . . . 143
Vehicle Load Limits . . . . . . . . . . . 147
Wet Roads . . . . . . . . . . . . . . . . . . . 144
Winter . . . . . . . . . . . . . . . . . . . . . . . . 145
Dual Automatic Climate
Control System . . . . . . . . . . . . . . . . 133
E
E85 or FlexFuel . . . . . . . . . . . . . . . . 186
Electric Parking Brake . . . . . . . . . . 161
Electric Parking Brake Light . . . . 105
Electrical Equipment,Add-On . . . . . . . . . . . . . . . . . . . . . . . 197
Electrical System Engine Compartment Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 226
Fuses and Circuit Breakers . . . 226
Instrument Panel Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 229
Overload . . . . . . . . . . . . . . . . . . . . . 225
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 306
Engine Air Cleaner/Filter . . . . . . . . . . . . . 208 Engine (cont'd)
Check Light (Malfunction
Indicator) . . . . . . . . . . . . . . . . . . . . 103
Compartment Overview . . . . . . . 203
Coolant Temperature
Gauge . . . . . . . . . . . . . . . . . . . . . . 100
Cooling System . . . . . . . . . . . . . . . 209
Drive Belt Routing . . . . . . . . . . . . 289
Exhaust . . . . . . . . . . . . . . . . . . . . . . 157
Heater . . . . . . . . . . . . . . . . . . . . . . . . 154
Oil Life System . . . . . . . . . . . . . . . 206
Oil Pressure Light . . . . . . . . . . . . 108
Overheated Protection Operating Mode . . . . . . . . . . . . . 213
Overheating . . . . . . . . . . . . . . . . . . 212
Power Messages . . . . . . . . . . . . . .113
Running While Parked . . . . . . . . 157
Starting . . . . . . . . . . . . . . . . . . . . . . . 153
Entry Lighting . . . . . . . . . . . . . . . . . . . 130
Equipment, Towing . . . . . . . . . . . . . 195
Event Data Recorders . . . . . . . . . . 302
Exit Lighting . . . . . . . . . . . . . . . . . . . . 130
Extended Parking . . . . . . . . . . . . . . . 157
Extender, Seat Belt . . . . . . . . . . . . . . 50
Exterior Lamp Controls . . . . . . . . . 125
Exterior Lamps Off Reminder . . . 126
Exterior Lighting Battery Saver . . . . . . . . . . . . . . . . . . . . . . . . . 131
F
Filter,
Engine Air Cleaner . . . . . . . . . . . 208
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 126
Flashers, Hazard Warning . . . . . . 127
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 252 Changing . . . . . . . . . . . . . . . . . . . . . 253
FlexFuel E85 . . . . . . . . . . . . . . . . . . . . . . . . . . . 186
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 272
Fluid
Automatic Transmission . . . . . . 207
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 215
Washer . . . . . . . . . . . . . . . . . . . . . . . 214
Folding Mirrors . . . . . . . . . . . . . . . . . . 24
Forward Collision Alert (FCA) System . . . . . . . . . . . . . . . . . 178
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 300
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 34
Heated and Ventilated . . . . . . . . . . 40
Fuel Additives . . . . . . . . . . . . . . . . . . . . . 186
Economy, Driving for Better . . . 140
Filling a Portable Fuel
Container . . . . . . . . . . . . . . . . . . . 189
Filling the Tank . . . . . . . . . . . . . . . 187

Chevrolet Impala Owner Manual (GMNA-Localizing-U.S./Canada-13688912) -
2020 - CRC - 6/5/19
322 Index
Locks (cont'd)Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Lockout Protection . . . . . . . . . . . . . . 19
Power Door . . . . . . . . . . . . . . . . . . . . . 18
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Loss of Control . . . . . . . . . . . . . . . . . 143
Low Fuel Warning Light . . . . . . . . . 108
Low-Profile Tires . . . . . . . . . . . . . . . . 233
Lower Anchors and Tethers for Children (LATCH
System) . . . . . . . . . . . . . . . . . . . . . . . . 70
Lumbar Adjustment . . . . . . . . . . . . . . 36 Front Seats . . . . . . . . . . . . . . . . . . . . . 36
M
MaintenanceRecords . . . . . . . . . . . . . . . . . . . . . . 286
Maintenance and Care Additional . . . . . . . . . . . . . . . . . . . . . 281
Maintenance Schedule . . . . . . . . . 276 Recommended Fluids andLubricants . . . . . . . . . . . . . . . . . . . 284
Malfunction Indicator Lamp . . . . . 103
Manual Mode . . . . . . . . . . . . . . . . . . . 160
Memory Seats . . . . . . . . . . . . . . . . . . . 37
Messages Engine Power . . . . . . . . . . . . . . . . .113
Vehicle . . . . . . . . . . . . . . . . . . . . . . . .112 Messages (cont'd)
Vehicle Speed . . . . . . . . . . . . . . . . .113
Mirrors Automatic Dimming . . . . . . . . . . . . . 24
Automatic Dimming
Rearview . . . . . . . . . . . . . . . . . . . . . . 25
Convex . . . . . . . . . . . . . . . . . . . . . . . . . 23
Folding . . . . . . . . . . . . . . . . . . . . . . . . . 24
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 24
Manual Rearview . . . . . . . . . . . . . . . 25
Power . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Tilt in Reverse . . . . . . . . . . . . . . . . . . 24
Mirrors, Interior Rearview . . . . . . . . 25
Monitor System, Tire Pressure . . . . . . . . . . . . . . . . . . . . . . 241
N
NavigationConnected Services . . . . . . . . . . 313
Net, Convenience . . . . . . . . . . . . . . . 87
New Vehicle Break-In . . . . . . . . . . . 151
O
Odometer . . . . . . . . . . . . . . . . . . . . . . . . 98 Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Off-Road Recovery . . . . . . . . . . . . . . . . . . . . . 143
Oil Engine . . . . . . . . . . . . . . . . . . . . . . . . 204 Oil (cont'd)
Engine Oil Life System . . . . . . . 206
Pressure Light . . . . . . . . . . . . . . . . 108
Older Children, Restraints . . . . . . . 64
Online Owner Center . . . . . . . . . . . 293
OnStar . . . . . . . . . . . . . . . . . . . . . . . . . 303
OnStar Additional
Information . . . . . . . . . . . . . . . . . . . . 307
OnStar Emergency . . . . . . . . . . . . . 306
OnStar Overview . . . . . . . . . . . . . . . 305
OnStar Security . . . . . . . . . . . . . . . . 307
Operating Mode
Overheated EngineProtection . . . . . . . . . . . . . . . . . . . 213
Outlets Power . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Overheated Engine Protection Operating Mode . . . . 213
Overheating, Engine . . . . . . . . . . . . 212
Overview Instrument Panel . . . . . . . . . . . . . . . . 5P
ParkShifting Out of . . . . . . . . . . . . . . . . 156
Park Assist . . . . . . . . . . . . . . . . . . . . . 176