power steering CHEVROLET KODIAK 2008 User Guide

Remember to reset the Engine Oil Life System
whenever the oil is changed. For more information, see
Engine Oil Life System (Gasoline Engine) on page 5-36
orEngine Oil Life System (DURAMAX
®/Isuzu Diesel
Engines) on page 5-37orEngine Oil Life System
(Caterpillar
®Diesel Engine) on page 5-39.
(9)= This vehicle has the Engine Oil Life System. This
system will show you when to change the engine oil
and filter — usually between 3,000 miles (5 000 km) and
15,000 miles (24 000 km) since your last oil change.
Under severe conditions, the indicator may come
on before 3,000 miles (5 000 km). Never drive your
diesel engine vehicle more than 15,000 miles
(24 000 km), or 12 months, or 750 engine hours, without
an oil and filter change.
Remember to reset the Engine Oil Life System
whenever the oil is changed. For more information, see
Engine Oil Life System (Gasoline Engine) on page 5-36
orEngine Oil Life System (DURAMAX
®/Isuzu Diesel
Engines) on page 5-37orEngine Oil Life System
(Caterpillar
®Diesel Engine) on page 5-39.
(10)= Inspect rear axle air shift motor for fluid leaks.
Remove plug to check fluid level. Inspect air lines
and hoses for proper hook-up, binding, leaks, etc.
Inspect at 1,000 miles (1 600 km) and 22,500 miles
(36 000 km) and then every 22,500 miles (36 000 km)
thereafter.(11)= Chassis Lubrication Service: Lubricate all grease
fittings in front suspension, front axle, and steering
linkage. Do not lubricate kingpin bushings with air
pressure equipment; instead, use a hand grease gun to
ensure complete purge and eliminate sealer cap
distortion. Front axle tie rod ends, both upper and lower
kingpin fittings, and both steering linkage relay rod ends
should be greased with the vehicle loaded on the ground
and wheels turned straight ahead, not with the vehicle on
a hoist. Apply kingpin bushing lubricant to both upper and
lower kingpin grease fittings until new lubricant purges
from between the upper shim pack and thrust bearing.
Lubricate transmission and shift linkage, hood latches
and hood hinges, parking brake lever pivot, clevis pins
and linkage, disc brake caliper rails, clutch linkage and
release bearing (if equipped), bearing pads, propshaft
universal joints, brake camshaft bracket, slack adjusters,
pedal shaft, clutch cross shaft, clutch pedal springs, and
clutch cable bushing at transmission. Lubricate
suspension, axle, and steering linkage more often when
operating under dusty or muddy conditions and in
excessive off-road use. Frequently power-washed
vehicles will require more frequent lubrication.
6-21

(12)= Check steering system:
•Look for damaged, loose, or missing parts. Inspect
the steering linkage relay rod and tie rod ends for
looseness or lack of lubricant. Also look for parts
showing signs of wear or lack of lubrication. Replace
parts as needed. Also check steering gear mounting
bolts, pitman arm nut, gear housing upper cover and
side cover attaching bolts, steering column mounting
bolts and cardan joint clamp bolts; tighten if
necessary. See the service manual.
•Inspect power steering hoses, tubes, and fittings for
leaks. Hoses and lines must not be twisted, kinked,
or tightly bent. Make sure clips, clamps, supporting
tubes, and hoses are in place and properly secured.
•Check steering gear for leakage around pitman shaft
and housing. If leakage is evident (lubricant oozing
out, not just oily film), leak should be corrected
immediately.
(13)= Check front and rear suspension. Look for
damaged, loose, or missing parts or parts showing signs
of wear or lack of lubrication. Replace parts as needed.
(14)= Adjust tire pressures as indicated on the
Certification or Tire Information label for optimum tire
life. SeeTires on page 5-82for further details. Check
tires for excessive or abnormal wear or damage. Also
check for damaged wheels. Replace wheels and/or tires
as needed.(15)= Check spring-to-axle U-bolts and shackle bolts
for proper torque. See the service manual for torque
sequence and specifications. When parts are replaced,
the torque must be checked and adjusted more often
during the first 6,000 miles (10 000 km). Check torque at
500 miles (800 km) and 2,000 miles (3 000 km) after
first use of parts.
(16)= Check complete exhaust system, including DPF
pressure lines, and cab areas near the exhaust system
for broken, damaged, missing, or out-of-position parts.
Also inspect for open seams, holes, loose connections, or
other conditions which could let exhaust fumes seep into
the driver compartment. Needed repairs should be made
at once. To help maintain system integrity, replace
exhaust pipes whenever a new muffler is put on.
(17)= Check all gasoline engine drive belts for cracks,
fraying, and wear. Replace as needed.
(18)= Adjust valve lash. Incorrect valve clearance will
result in increased engine noise and reduced engine
output.
(19)= With the engine off and below normal operating
temperature, check to see that the thermostatically
controlled engine cooling fan can be rotated by hand on
viscous-operated drives. Replace as needed.
(20)= Check shields and underhood insulation for
damage or looseness. Adjust or replace as needed.
6-22

Part C: Recommended Fluids and
Lubricants
Fluids and lubricants identified below by name, part
number, or specification can be obtained from your
dealer/retailer.
Usage Fluid/Lubricant
Engine Oil
(Gasoline
Engine)Engine oil which meets
GM Standard GM6094M and
displays the American Petroleum
Institute (API) Certified for Gasoline
Engines starburst symbol. To
determine the proper viscosity for
your vehicle’s engine, see “Engine
Oil” in the Index.
Engine Oil
(DURAMAX
®/
Isuzu Diesel
Engines)Engine oils with the letters CJ-4 are
required for your vehicle. The CJ-4
designation can appear either alone
or in combination with other
American Petroleum Institute (API)
designations, such as API CJ-4/SL.
These letters show API levels of
quality. To determine the preferred
viscosity for your vehicle’s diesel
engine, see “Engine Oil” in the Index.
Engine Oil
(Caterpillar
®
Diesel Engine)See the Caterpillar
®Operation &
Maintenance Manual for engine oil
recommendations.
Usage Fluid/Lubricant
Engine Coolant
(Caterpillar
®
Diesel Engine)See the Caterpillar
®Operation &
Maintenance Manual for engine
coolant recommendations.
Engine Coolant
(Gasoline
Engine &
DURAMAX
®/
Isuzu Diesel
Engines)50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
Coolant. SeeEngine Coolant
(Caterpillar®Diesel Engines) on
page 5-44orEngine Coolant
(Gas and DURAMAX
®/Isuzu 7.8L
L6 Engines) on page 5-44.
Hydraulic Brake
SystemDelco
®Supreme 11 Brake Fluid or
equivalent DOT-3 brake fluid.
Windshield
Washer SolventOptikleen
®Washer Solvent.
Clutch Bearing
LubricantClutch Bearing Lubricant
(GM Part No. 12378484 or
equivalent NLGI #3 consistency).
Exhaust Brake
Ball Joint Cap
LubricantHigh-Temperature Grease
(GM Part No. U.S. 1051344, in
Canada 903037) or NLGI #3
consistency.
Power Steering
SystemDEXRON
®-VI Automatic
Transmission Fluid.
Manual
TransmissionSynthetic Manual Transmission Fluid
(GM Part No. U.S. 88861952, in
Canada 88861953).
6-31

Exhaust Brake Indicator Light...........................3-40
Exhaust Restrictor...........................................2-22
Extender, Safety Belt.......................................1-28
Exterior Lamps...............................................3-14
F
Filter
Engine Air Cleaner......................................5-39
Filter Minder Gage..........................................3-45
Finish Damage...............................................5-99
Fixed Mast Antenna........................................3-58
Flashers, Hazard Warning.................................. 3-6
Flat Tire........................................................5-92
Fluid.............................................................5-43
Power Steering...........................................5-54
Windshield Washer......................................5-55
Four-Wheel Drive....................................2-32, 5-73
Front Axle......................................................5-74
Front Wheel Bearings with Oil-Filled Hubs..........5-81
Fuel............................................................... 5-7
Additives...................................................... 5-8
Change Filter Warning Light..........................3-44
Diesel Engine Fuel........................................ 5-9
Filling a Portable Fuel Container....................5-21
Filling the Tank...........................................5-20
Filter..........................................................5-78
Filter Replacement.......................................5-18
Fuels in Foreign Countries............................5-19Fuel (cont.)
Gage.........................................................3-43
Gasoline Octane........................................... 5-7
Gasoline Specifications.................................. 5-7
Primary Filter and Water Separator................5-79
Running Out of...........................................2-50
Running Out of Fuel....................................5-17
Secondary Filter and Water Separator/
Heater....................................................5-80
Very Cold Weather Operation........................5-12
Water in Fuel..............................................5-12
Water in Warning Light.................................3-44
What Fuel to Use.......................................... 5-9
Fuses
Fuses and Circuit Breakers.........................5-103
Instrument Panel Fuse Block.......................5-103
Underhood Fuse Block...............................5-106
Windshield Wiper.......................................5-102
G
Gage
Air Pressure...............................................3-46
Check Gages Warning Light..........................3-42
Engine Coolant Temperature.........................3-35
Filter Minder...............................................3-45
Fuel..........................................................3-43
Hourmeter..................................................3-46
Oil Pressure...............................................3-37
5

Outlet Adjustment............................................3-23
Outlets
Accessory Power.........................................3-19
Outside
Convex Mirrors............................................2-52
Heated Mirrors............................................2-52
Manual Mirrors............................................2-51
Power Mirrors.............................................2-51
Overspeed Warning Light.................................3-39
P
Paint, Damage...............................................5-99
Park Brake............................................2-38, 2-41
Parking.........................................................2-37
Brake Burnish Procedure..............................2-43
Over Things That Burn.................................2-44
Two-Speed Rear Axle..................................2-27
Part A - Scheduled Maintenance Services............ 6-3
Part B - Owner Checks and Services................6-25
Part C - Recommended Fluids and Lubricants....6-30
Part D - Maintenance Record...........................6-32
Passing.........................................................4-11
Perchlorate Materials Requirements, California...... 5-5
Power
Door Locks.................................................. 2-7
Electrical System.......................................5-103
Reduced Engine Light..................................3-41Power (cont.)
Steering Fluid.............................................5-54
Windows...................................................... 2-9
Power Take-Off Light.......................................3-42
Power Take-Off (PTO).....................................2-32
Privacy..........................................................7-11
Event Data Recorders..................................7-11
Navigation System.......................................7-12
OnStar.......................................................7-12
Radio Frequency Identification.......................7-12R
Radio Frequency Identification (RFID), Privacy....7-12
Radios..........................................................3-47
Radio(s)........................................................3-48
Radios
Reception...................................................3-58
Setting the Clock.........................................3-48
Theft-Deterrent............................................3-57
Range Inhibit Warning Indicator........................3-32
Reading Lamps..............................................3-17
Rear Axle......................................................5-72
Differential Lock Control................................. 4-7
Shift Motor.................................................5-73
Rear Heating System......................................3-24
Rear Seat Operation.......................................1-10
Rearview Mirrors.............................................2-51
9