service CHEVROLET LOW CAB FORWARD 2017 Owners Manual

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
376 Service and Maintenance
one side, unusual sounds when
braking, increased brake pedal
travel or harder pedal. The front and
rear brakes are attached to an auto
adjuster mechanism. If there are no
defects, as the pedal travel is
properly maintained, adjustments
are not necessary. Check regularly
that the brake fluid reservoir
(left-hand side of the instrument
panel) or HBB reservoir (5500HD,
5500XD models: left side behind the
cab) is properly filled and check for
fluid leaks. Any of these conditions
could indicate the need for brake
system inspection and/or service.
G: Exhaust System :Be alert for
any changes in the sound of the
exhaust system or any smell of
fumes. These are signs the system
may be leaking. Have it checked
and/or repaired at once. (Refer to
"Engine Exhaust Emissions Caution
(Carbon Monoxide)" under Engine
Exhaust 0178).
H: Windshield Wipers and
Washers : Check operation and
condition of the wiper blades. Check
the flow of the washer spray. I: Defroster :
Turn the outlet
selector knob to "Defroster" and the
fan speed control knob to the fully
clockwise position. Then check the
airflow from the ducts at the inside
base of the windshield.
J: Rearview Mirrors and Sun
Visors : Check that friction joints
hold mirrors and sun visors in place.
K: Horn : Sound the horn, now and
then, to be sure it works.
L: Lap-Shoulder Belts : Check the
seat belt system (including webbing,
buckles, latch plates and anchors)
for proper operation, and for
damage.
M: Seat Adjusters : When
adjusting the driver's manual seat,
be sure the seat adjusters latch by
pushing the seat forward and
backward. Do not attempt to adjust
the seat when the vehicle is in
motion.
N: Lamps : Check panel lighting,
warning lamps, indicator lamps and
interior lamps. On the outside,
check: license plate lamps, side
marker lamps, reflectors on outside mirrors, headlamps, parking lamps,
identification and clearance lamps,
taillights, brake lamps, turn signals,
cornering lamps, backup lamps and
hazard warning flashers. Have
headlamp aim checked immediately
if beams seem improperly aimed.
O: Glass, Mirrors, Lights and/or
Reflectors Condition :
Look for
broken, scratched, dirty or damaged
glass, mirrors, lamps or reflectors
that could reduce the view or
visibility, or cause injury. Replace,
clean or repair promptly.
P: Door Latches : Check that doors
close, latch and lock tightly. Check
for broken, damaged or missing
parts that might prevent tight
latching.
Q :Tilt Cab (Driving Position) : Be
sure the tilt lever is down and
locked.
R: Fluid Leaks : Check for fuel,
water, oil or other fluid leaks by
looking at the surface beneath the
vehicle after it has been parked for
a while. If you notice diesel fumes or
fluid at any time, have the cause
found and corrected at once.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Service and Maintenance 377
S: Underbody :Corrosive materials
used for ice removal, snow removal
and dust control can collect on the
underbody. If these materials are
not removed, accelerated corrosion
(rust) can occur on underbody parts
such as fuel lines, frame, floor pan
and exhaust system. At least every
spring, flush these materials from
the underbody with plain water.
Take care to clean well any areas
where mud and other debris can
collect. Sediment packed in closed
areas of the frame should be
loosened before being flushed.
Checking Components that
Showed Abnormalities during
Previous Operation
Check the components that showed
abnormalities during the previous
operation. Have any abnormalities
repaired by your dealer before using
the vehicle.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
378 Service and Maintenance
Recommended Fluids, Lubricants, and Parts
Recommended Fluids and Lubricants
Fluids and lubricants identified below by name, part number, or specification can be obtained from your dealer.Usage Fluid/Lubricant
Automatic Transmission (Diesel
Engine) Automatic Transmission Fluid (GM Part No. 19354076).
Automatic Transmission (Gasoline
Engine) DEXRON
®-VI Automatic Transmission Fluid.
Battery Terminals Petroleum Jelly (outer surfaces)
Brake Fluid DOT 3 Hydraulic Brake Fluid (GM Part No. 19299818).
Cab-Door Hinges and Latches
Lubricant Multi-Purpose Lubricant, Superlube (GM Part No. 12346241) or equivalent
containing zinc oxide.
Chassis Lubricant Chassis Lubricant (GM Part No. 12377985) or high temperature equivalent.
Diesel Exhaust Fluid (DEF) Diesel Exhaust Fluid (GM Part No. 19286291) or diesel exhaust fluid that meets ISO 22241-1 or displays the API Diesel Exhaust Fluid
Certification Mark.
Driveshaft Center Bearing, Wheel
Hub Bearing Lubricant NLGI #2 or #3
Driveshaft, Universal Joints and
Sliding Sleeve Lubricant NLGI #1 or #2 multi-purpose type grease

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Service and Maintenance 379
UsageFluid/Lubricant
Engine Coolant (Diesel Engine) 50/50 mixture of clean, drinkable water and GM extended life coolant. (GM Part No. 12378560) SeeEngine Coolant0263.
Engine Coolant (Gasoline Engine) 50/50 mixture of clean, drinkable water and use only DEX-COOL
®coolant.
See Engine Coolant 0263.
Engine Oil (Diesel Engine) Engine oils with the letters CK-4 are required for your vehicle. The CK-4 designation can appear either alone or in combination with other American
Petroleum Institute (API) designations, such as API CK-4/SL. These letters
show API levels of quality. To determine the preferred viscosity for your
vehicle's diesel engine, seeEngine Oil (Gasoline)0257 orEngine Oil
(Diesel) 0251.
Engine Oil (Gasoline Engine) Engine oil meeting the dexos1™ specification of the proper SAE viscosity
grade. ACDelco dexos1 Synthetic Blend is recommended.
See Engine Oil (Gasoline) 0257 orEngine Oil (Diesel) 0251.
Hydraulic Brake Booster (If
Equipped) DEXRON
®-VI Automatic Transmission Fluid.
Power Steerig Fluid DEXRON
®-VI Automatic Transmission Fluid.
Rear Axle Multi purpose gear oil SAE80W-90 GL-5, SAE90 GL-5
Rear Axle
(Limited slip differential (LSD)) Multi purpose gear oil SAE80W-90 GL-5, SAE90 GL-5 for limited slip
differential together with limited slip differential lubricant additive (GM
Part No. 88900330) or equivalent.
Windshield Washer Solvent Automotive windshield washer fluid that meets regional freeze protection requirements.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
380 Service and Maintenance
Be sure to use the LSD gear oil
additive mentioned above in
vehicles equipped with limited slip
differentials, and ensure there is an
appropriate amount of the LSD gear
oil additive, otherwise a chattering
noise and/or excessive vibration
may occur when turning.
If abnormal noises occur despite
having used the specified LSD gear
oil additive, have it inspected and
serviced at your dealer.Maintenance
Replacement Parts
Replacement Parts
Please contact your dealer for
genuine GM parts.
{Warning
If part replacement is necessary,
the part must be replaced with
one of the same part number or
with an equivalent part. Use of a
replacement part of lesser quality
may result in personal injury or
damage to the vehicle.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Service and Maintenance 381
3.0L Diesel
PartGM Part Number
Engine Air Cleaner 98177271
Engine Oil Filter 98018858
Fuel Filter Main: 98203599
Pre: 98037481
5.2L Diesel
Part GM Part Number
Engine Air Cleaner 98177271
Engine Oil Filter 98298404
Fuel Filter: Engine Side 98147525
Fuel Filter: Chassis Side 98037481
6.0L Gas
PartGM Part Number
Engine Air Cleaner 97062294
Engine Oil Filter 89017524

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
382 Service and Maintenance
Replacement Fasteners
During vehicle maintenance, any
fasteners used to replace older
ones must have the same
measurements and strength as
those removed, whether metric or
customary. Fasteners taken from
the vehicle should be saved for
reuse in the same location when
possible. Where a fastener cannot
be used again, take care to choose
a replacement that matches the old
one. For information and help, see
your dealer.
{Warning
This vehicle is primarily
dimensioned in the metric system.
Most fasteners are metric and
many are very close in dimension
to well-known customary
fasteners in the inch system.
Mismatched or incorrect fasteners
can result in damage to the
vehicle or possibly personal
injury.

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Technical Data 389
Vehicle Data
Capacities and Specifications
These specifications are given here for information only. Before using them, see the Cautions and other instructions
throughout this manual–the index may help you locate such items. For more information, see the Service Manual
covering the chassis or body part in question. Your dealer may also be able to help.
Engine Specifications
Description Water-cooled, overhead
camshaft, direct injection engine with a charge air cooled turbocharger. Water-cooled, overhead
valve, engine Water-cooled, overhead
camshaft, direct injection engine with a charge air cooled turbocharger.
Manufacturer Isuzu GMPT Isuzu
Model 3.0L Diesel Engine 6.0L Gasoline Engine 5.2L Diesel Engine
Engine type Inline 4, Four Cycle V8, Four Cycle Inline 4, Four Cycle
Induction Turbocharged W/Charge
Air Cooler Mass Air Turbocharged W/Charge
Air Cooler
Bore 95.4 mm 101.6 mm 115 mm
Stroke 104.9 mm 92 mm 125 mm
Displacement 2.999 L (183.0 CID) 6.000 L (364 CID) 5.193 L (317 CID)
Full load RPM 2,800 r/min 4,300 r/min 2,400 r/min
Compression ratio 17.5 to 1 9.67 to 1 16.5 to 1
Firing order 1-3-4-2 1-8-7-2-6-5-4-3 1-3-4-2

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Technical Data 391
Transmission Specifications
Model A460Six-speed automatic
transmission (overdrive
gear for 5th and 6th),
lock-up clutch for 2nd
to 6th. 6L90
Six-speed automatic
transmission (overdrive
gear for 5th and 6th),
lock-up clutch for 2nd
to 6thA465 Model
Six-speed automatic
transmission (overdrive
gear for 5th and 6th),
lock-up clutch for 2nd
to 6th
Gear ratio 1st 3.742 to 1 4.027 to 1 3.742 to 1 2nd 2.003 to 1 2.364 to 1 2.003 to 13rd 1.343 to 1 1.532 to 1 1.343 to 1
4th 1.000 to 1 1.152 to 1 1.000 to 1
5th 0.773 to 1 0.852 to 1 0.773 to 1
6th 0.634 to 1 0.667 to 1 0.634 to 1
Reverse 3.539 to 1 3.064 to 1 3.539 to 1
Transmission oil capacity 13.4 L (28.3 pt) 12.17 L (25.72 pt) 13.1 L (27.7 pt)
Weights
Model 3.0 Diesel Engine 6.0L Gasoline Engine 5.2 Diesel Engine
Axle weight rating : Front 3500HD: 2431 kg (5,360 lb) 3500: 2204 kg (4,860 lb) 4500: 3007 kg (6,630 lb)4500HD: 2431 kg (5,360 lb)
4500XD: 3007 kg (6,630 lb)
5500HD: 3098 kg (6,830 lb) 5500XD: 3300 kg (7,275 lb)
Engine Oil Service
Model 3.0 Diesel Engine 6.0L Gasoline Engine 5.2 Diesel Engine

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
392 Technical Data
Engine oil capacityWhen changing oil only:
7.5 L (7.9 qt)*1
When changing oil andfilter: 8.2 L (8.7 qt)*1
When changing oil andfilter: 5.7 L (6.0 qt)*1When changing oil only: 9.5 L (10.0 qt)*1
When changing oil andfilter: 11.0 L (11.6 qt)*1
Engine Cooling System Service
Model 3.0 Diesel Engine 6.0L Gasoline Engine 5.2 Diesel Engine
Capacity 12.6 L (13.3 qt) 15.0 L (15.9 qt) 19.6 L (20.7 qt)
Engine oil Thermostat:
Starts to open 85 °C (185 °F) 85.5-87.5 °C
(185.9-189.5 °F)82-85 °C (180-185 °F)
Radiator pressure 108 kPa (16 psi) 103 kPa (15 psi) 108 kPa (16 psi)
Transmission Service
Model A460 6L90 A465
Transmission oil capacity 13.4 L (28.3 qt)
*312.7 L (25.7 qt)*313.1 L (27.7 qt)*3
Rear Axle Service
Model 3.0 Diesel Engine 6.0L Gasoline Engine 5.2 Diesel Engine
Differential gear oil
capacity 9.0 L (19.0 qt)
*49.7 L (20.5 qt)*44500HD/4500XD:
9.0 L (19.0 qt)*4
5500HD/5500XD:
10.0 L (21.1 qt)*4
Limited slip differential
lubricant additive 0.5 L (1.06 qt)*50.6 L (1.27 qt)*54500HD/4500XD:
0.5 L (1.06 qt)*5
5500HD/5500XD:
0.6 L (1.27 qt)*5