turn signal CHEVROLET LOW CAB FORWARD 2017 Owner's Guide
[x] Cancel search | Manufacturer: CHEVROLET, Model Year: 2017, Model line: LOW CAB FORWARD, Model: CHEVROLET LOW CAB FORWARD 2017Pages: 414, PDF Size: 7.97 MB
Page 372 of 414

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Service and Maintenance 371
Rear
1. Rear Turn Signal Lamp
2. Back-up Lamp
3. License Plate Lamp
4. Taillamp/Stoplamp
Lubrication
One of the most important items of
good vehicle care is the lubrication
of all necessary points with the
Right Lubricant, at the Right Time
and in the Right Way. It is the
owner's responsibility to maintain
proper lubrication practices as
recommended in the following
pages.Greasing Chassis Components
The type (characteristics) of the
grease specified for use with a
chassis component differs from that
of the grease specified for use with
another component. Be sure to use
only the specified grease for each
component and perform greasing
according to the Maintenance
Schedule.
King pins (left and right)
Driveshaft splines and center
bearing (3500)
Driveshaft splines (4500/5500)
Center bearing (4500/5500)
Page 377 of 414

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
376 Service and Maintenance
one side, unusual sounds when
braking, increased brake pedal
travel or harder pedal. The front and
rear brakes are attached to an auto
adjuster mechanism. If there are no
defects, as the pedal travel is
properly maintained, adjustments
are not necessary. Check regularly
that the brake fluid reservoir
(left-hand side of the instrument
panel) or HBB reservoir (5500HD,
5500XD models: left side behind the
cab) is properly filled and check for
fluid leaks. Any of these conditions
could indicate the need for brake
system inspection and/or service.
G: Exhaust System :Be alert for
any changes in the sound of the
exhaust system or any smell of
fumes. These are signs the system
may be leaking. Have it checked
and/or repaired at once. (Refer to
"Engine Exhaust Emissions Caution
(Carbon Monoxide)" under Engine
Exhaust 0178).
H: Windshield Wipers and
Washers : Check operation and
condition of the wiper blades. Check
the flow of the washer spray. I: Defroster :
Turn the outlet
selector knob to "Defroster" and the
fan speed control knob to the fully
clockwise position. Then check the
airflow from the ducts at the inside
base of the windshield.
J: Rearview Mirrors and Sun
Visors : Check that friction joints
hold mirrors and sun visors in place.
K: Horn : Sound the horn, now and
then, to be sure it works.
L: Lap-Shoulder Belts : Check the
seat belt system (including webbing,
buckles, latch plates and anchors)
for proper operation, and for
damage.
M: Seat Adjusters : When
adjusting the driver's manual seat,
be sure the seat adjusters latch by
pushing the seat forward and
backward. Do not attempt to adjust
the seat when the vehicle is in
motion.
N: Lamps : Check panel lighting,
warning lamps, indicator lamps and
interior lamps. On the outside,
check: license plate lamps, side
marker lamps, reflectors on outside mirrors, headlamps, parking lamps,
identification and clearance lamps,
taillights, brake lamps, turn signals,
cornering lamps, backup lamps and
hazard warning flashers. Have
headlamp aim checked immediately
if beams seem improperly aimed.
O: Glass, Mirrors, Lights and/or
Reflectors Condition :
Look for
broken, scratched, dirty or damaged
glass, mirrors, lamps or reflectors
that could reduce the view or
visibility, or cause injury. Replace,
clean or repair promptly.
P: Door Latches : Check that doors
close, latch and lock tightly. Check
for broken, damaged or missing
parts that might prevent tight
latching.
Q :Tilt Cab (Driving Position) : Be
sure the tilt lever is down and
locked.
R: Fluid Leaks : Check for fuel,
water, oil or other fluid leaks by
looking at the surface beneath the
vehicle after it has been parked for
a while. If you notice diesel fumes or
fluid at any time, have the cause
found and corrected at once.
Page 409 of 414

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
408 Index
Brakes (cont'd)Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 280
Parking . . . . . . . . . . . . . . . . . . . . . . . 221
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 137
Break-In, New Vehicle . . . . . . . . . . 162
Bulb Replacement
Headlamp Aiming . . . . . . . . . . . . . 288
Headlamps . . . . . . . . . . . . . . . . . . . 288
Headlamps and Front TurnSignal . . . . . . . . . . . . . . . . . . . . . . . 291
Interior Lamps . . . . . . . . . . . . . . . . 298
License Plate Lamps . . . . . . . . . 297
Roofmarker Lamps . . . . . . . . . . . 295
Sidemarker Lamps . . . . . . . . . . . 295
Taillamps, Turn Signal, Stoplamps, and Back-up
Lamps . . . . . . . . . . . . . . . . . . . . . . 297
Buzzers, Warning . . . . . . . . . . . . . . . 101
C
Cab Tilting . . . . . . . . . . . . . . . . . . . . . . 247
California
Perchlorate MaterialsRequirements . . . . . . . . . . . . . . . 245
California Proposition 65 Warning . . . . . . . . . . . . . . . 245, 326
Capacities and Specifications . . . . . . . . . . . . . . . . . 389 Carbon Monoxide
Engine Exhaust . . . . . . . . . . . . . . . 178
Winter Driving . . . . . . . . . . . . . . . . 145
Cargo Lamp . . . . . . . . . . . . . . . . . . . . 107
Caution, Danger, and Warning . . . . 3
CD Player . . . . . . . . . . . . . . . . . . . . . . 114
Check Engine Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . . 84
Child Restraints Infants and Young Children . . . . . 57
Systems . . . . . . . . . . . . . . . . . . . . . . . . 57
Cigarette Lighter . . . . . . . . . . . . . . . . . 74
Cleaning Exterior Care . . . . . . . . . . . . . . . . . 334
Interior Care . . . . . . . . . . . . . . . . . . 340
Climate Control Systems . . . . . . . 126 Air Conditioning . . . . . . . . . . . . . . 126
Heating . . . . . . . . . . . . . . . . . . . . . . . 126
Cluster, Instrument . . . . . . . . . . . . . . 77
Cold Weather Operation . . . . . . . . 235
Collision Damage Repair . . . . . . . 401
Compartments Storage . . . . . . . . . . . . . . . . . . . . . . . . . 60
Control of a Vehicle . . . . . . . . . . . . . 133
Coolant
Engine . . . . . . . . . . . . . . . . . . . . . . . . 263
Engine Temperature Gauge . . . . 82 Cooling . . . . . . . . . . . . . . . . . . . . . . . . . 126
Cornering Lamps . . . . . . . . . . . . . . . 106
Cover
Engine . . . . . . . . . . . . . . . . . . . . . . . . 250
Covers Winter . . . . . . . . . . . . . . . . . . . . . . . . 172
Cruise Control . . . . . . . . . . . . . 224, 227
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Cupholders . . . . . . . . . . . . . . . . . . . . . . 62
Customer Assistance . . . . . . . . . . . 399 Offices . . . . . . . . . . . . . . . . . . . . . . . . 399
Text Telephone (TTY)
Users . . . . . . . . . . . . . . . . . . . . . . . 399
Customer Information Service PublicationsOrdering Information . . . . . . . . 403
Customer Satisfaction Procedure . . . . . . . . . . . . . . . . . . . . . 398
D
Damage Repair, Collision . . . . . . . 401
Danger, Warning, and Caution . . . . 3
Daytime Running Lamps (DRL)Indicator Light . . . . . . . . . . . . . . . . . . 92
Devices Auxiliary . . . . . . . . . . . . . . . . . . . . . . 124
Diesel Engine Engine Alarm andAutomatic Shutdown . . . . . . . . 174
Page 413 of 414

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
412 Index
Proposition 65 Warning,California . . . . . . . . . . . . . . . . . 245, 326
R
Radio Frequency Statement . . . . 404
Radio Reception . . . . . . . . . . . . . . . . 112
Radios
AM-FM Radio . . . . . . . . . . . . . . . . . 108
Rear Axle . . . . . . . . . . . . . . . . . . . . . . . 283
Rear Seats . . . . . . . . . . . . . . . . . . . . . . 48
Rear Storage . . . . . . . . . . . . . . . . . . . . 63
Recommended Fluids and Lubricants . . . . . . . . . . . . . . . . . . . . . 378
Reduced Engine Power Light . . . . 91
Reimbursement Program, GM Mobility . . . . . . . . . . . . . . . . . . . 400
Remote Keyless Entry (RKE)
System . . . . . . . . . . . . . . . . . . . . . . . . . 32
Replacement Parts Maintenance . . . . . . . . . . . . . . . . . . 380
Reporting Safety Defects
General Motors . . . . . . . . . . . . . . . 405
U.S. Government . . . . . . . . . . . . . 405
Roads Driving, Wet . . . . . . . . . . . . . . . . . . 143
Roadside Assistance
Program . . . . . . . . . . . . . . . . . . . . . . . 400
Roofmarker Lamps . . . . . . . . . . . . . 295
Rotation, Tires . . . . . . . . . . . . . . . . . . 323 Routing, Engine Drive Belt . . . . . . 396
Running out of Fuel . . . . . . . . . . . . . 238
Running the Vehicle While
Parked . . . . . . . . . . . . . . . . . . . . . . . . 179
S
Safety Defects ReportingGeneral Motors . . . . . . . . . . . . . . . 405
U.S. Government . . . . . . . . . . . . . 405
Safety System Check . . . . . . . . . . . . 55
Scheduling Appointments . . . . . . . 401
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . 49 Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Extender . . . . . . . . . . . . . . . . . . . . . . . . 55
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . 53
Reminders . . . . . . . . . . . . . . . . . . . . . . 83
Three-Point . . . . . . . . . . . . . . . . . . . . . 51
Use During Pregnancy . . . . . . . . . . 53
Seats Position, Front . . . . . . . . . . . . . . . . . . 44
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
Security Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 39
Selector Lever . . . . . . . . . . . . . . . . . . 214
Service . . . . . . . . . . . . . . . . . . . . . . . . . 131 Accessories and
Modifications . . . . . . . . . . . . . . . . 245
Climate Control System . . . . . . . 126
Doing Your Own Work . . . . . . . . 245 Service (cont'd)
Publications Ordering
Information . . . . . . . . . . . . . . . . . . 403
Scheduling Appointments . . . . . 401
Transmission Warning Light . . . . 88
Vehicle Soon Light . . . . . . . . . . . . . . 84
Shift Lock Control Function Check, Automatic
Transmission . . . . . . . . . . . . . . . . . . 285
Shopping Bag Hooks . . . . . . . . . . . . 64
Sidemarker Lamps . . . . . . . . . . . . . 295
Signals, Turn and Lane-Change . . . . . . . . . . . . . . . . . 105
Specifications and
Capacities . . . . . . . . . . . . . . . . . . . . . 389
Speed Limiter . . . . . . . . . . . . . . . . . . . 231
Speedometer . . . . . . . . . . . . . . . . . . . . 80
Starting and Stopping the Vehicle . . . . . . . . . . . . . . . 165, 168
Steering . . . . . . . . . . . . . . . . . . . . . . . . 143 Fluid, Power . . . . . . . . . . . . . . . . . . 273
Wheel Adjustment . . . . . . . . . . . . . . 72
Stoplamps and Back-up Lamps
Bulb Replacement . . . . . . . . . . . . 297
Storage Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Storage Areas Glove Box . . . . . . . . . . . . . . . . . . . . . . 61
Page 414 of 414

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
10716700) - 2017 - crc - 12/6/16
Index 413
Storage Areas (cont'd)Information on Loading the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 64
Instrument Panel . . . . . . . . . . . . . . . 61
Storage Compartments . . . . . . . . . . 60
Stuck Vehicle . . . . . . . . . . . . . . . . . . . 148
Sun Visors . . . . . . . . . . . . . . . . . . . . . . . 43
System Noise Control . . . . . . . . . . . . . . . . . 284
T
Tachometer . . . . . . . . . . . . . . . . . . . . . . 81
TaillampsBulb Replacement . . . . . . . . . . . . 297
Temperature, Operating . . . . . . . . 172
Text Telephone (TTY) Users . . . . 399
Three-Point Seat Belt . . . . . . . . . . . . 51
Tires If a Tire Goes Flat . . . . . . . . . . . . 326
Pressure . . . . . . . . . . . . . . . . . . . . . . 322
Rotation . . . . . . . . . . . . . . . . . . . . . . 323
Tires and Wheels . . . . . . . . . . . . . . . 308
Towing Vehicle . . . . . . . . . . . . . . . . . . . . . . . 332
Trademarks and License Agreements . . . . . . . . . . . . . . . . . . . 125
Transmission Automatic . . . . . . . . . . . . . . . . . . . . . 204
Fluid, Automatic . . . . . . . . . . . . . . 260 Transmission (cont'd)
Overdrive Off, Automatic . . . . . . 215
Service Warning Light . . . . . . . . . . 88
Trip Odometer . . . . . . . . . . . . . . . . . . . 80
Turn and Lane-Change
Signals . . . . . . . . . . . . . . . . . . . . . . . . 105
Turn Signal Bulb Replacement . . . . . . . . . . . . 297
U
USB Port . . . . . . . . . . . . . . . . . . . . . . . 121
Using This Manual . . . . . . . . . . . . . . . . 3
V
VehicleControl . . . . . . . . . . . . . . . . . . . . . . . 133
Getting In and Out . . . . . . . . . . . . . . 35
Identification Number (VIN) . . . 383
Messages . . . . . . . . . . . . . . . . . . . . . . 97
Security . . . . . . . . . . . . . . . . . . . . . . . . 39
Service Soon Light . . . . . . . . . . . . . 84
Starting and Stopping . . . . 165, 168
Towing . . . . . . . . . . . . . . . . . . . . . . . . 332
Vehicle Care
Tire Pressure . . . . . . . . . . . . . . . . . 322
Vehicle Data Recording and Privacy . . . . . . . . . . . . . . . . . . . . . . . . 405
Ventilation, Air . . . . . . . . . . . . . . . . . . 129
Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
W
Wait to Start Light . . . . . . . . . . . . . . . 89
Warning Brake System Light . . . . . . . . . . . . . 84
Caution and Danger . . . . . . . . . . . . . 3
Warning Buzzers . . . . . . . . . . . . . . . 101
Warning Lights, Gauges, and Indicators . . . . . . . . . . . . . . . . . . . . . . 76
Warnings Hazard Flashers . . . . . . . . . . . . . . 105
Washer Fluid . . . . . . . . . . . . . . . . . . . 274
Water in Fuel . . . . . . . . . . . . . . . . . . . 236
Wheels and Tires . . . . . . . . . . . . . . . 308
Windows Power . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Windshield Wiper/Washer . . . . . . . . . . . . . . . . . . 73
Winter Driving . . . . . . . . . . . . . . . . . . . . . . . . 145
Winter Cover . . . . . . . . . . . . . . . . . . . 172
Wiper Blade Replacement . . . . . . 286