bulb CHEVROLET LOW CAB FORWARD 2018 User Guide
[x] Cancel search | Manufacturer: CHEVROLET, Model Year: 2018, Model line: LOW CAB FORWARD, Model: CHEVROLET LOW CAB FORWARD 2018Pages: 358, PDF Size: 6.32 MB
Page 261 of 358

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
260 Vehicle Care
3. To install the lamps, performthe same sequence of
operations in reverse, taking
care to turn the connector
clockwise to lock it securely.
If the socket is not locked securely,
water could get inside the lamp and
lead to a breakdown.
Replacing a Front Turn
Signal Lamp
Do not replace a bulb with other
than the specified wattage. This will
cause abnormal flashing,
particularly for turn signal lamps. When replacing a bulb, make sure
the light switch is OFF.
1. While referring to “Replacing
the Headlights”, tilt the turn
signal lamp assembly down
toward the front of the vehicle
and remove it.
2. Disconnect the connector for the turn signal light and then
remove the socket.
3. Pull the bulb from the socketand replace it with a new one.
4. To install the lamps, perform the same sequence of
operations in reverse, taking
care to turn the connector
clockwise to lock it securely.
If the socket is not locked securely,
water could get inside the light and
lead to a breakdown.
Page 262 of 358

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
Vehicle Care 261
Roofmarker Lamps
1. Loosen the screws (2) andremove the lens (1).
2. Remove the bulb (3) from the socket (4) and replace it with a
new one.
3. To install the lights, follow the removal procedure in reverse.
If the screwing procedure is
inadequate, water may infiltrate into
the lamp unit.
Sidemarker Lamps
(Including Turn Signal
and Cornering Lamps)
Do not replace a bulb with other
than the specified wattage. This will
cause abnormal flashing,
particularly for turn signal lamps.
When replacing a bulb, make sure
the light switch is "OFF".
1. Open the front door, remove the rubber cap (1) in the lower
part of the door, and loosen
the nut (2).
2. Slide the cornering lamp (3)and the side turn signal lamp
forward relative to the vehicle.
Disconnect the clip (1) on the
lamp’s rear side from the door
panel (2) and pull out the lamp.
If you pull out the light rear
section by too much when
removing the clip on the rear
side, the clip on the lamp front
side may be damaged.
Page 263 of 358

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
262 Vehicle Care
3. When the clip (1) has beenremoved, pull the lamp out
while sliding it out toward the
rear of the vehicle.
4. Loosen the socket by turning it counterclockwise.5. Pull the bulb out from the
socket and replace it with a
new one.
6. To install the lights, perform the same sequence of operations
in reverse taking care of the
following points:
A. Turn the socket clockwiseto lock securely.
If the socket is not locked
securely, water could get
inside the light and lead to
a breakdown.B. Insert the clip on the backof the rear part of the light
into the door panel.
C. Push the front part of the light into the door panel,
and insert the clip on the
back of the front part of the
light in the door panel.
Page 264 of 358

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
Vehicle Care 263
D. Open the front door, tightenthe nut from the inside of
the door, and install the
rubber cap.
Taillamps, Turn Signal,
Stoplamps, and Back-Up
Lamps
1. Turn Signal Lamp
2. Taillamp/Stoplamp
3. Back-Up Lamp
4. Lens
1. Loosen the screws and remove the lens.
2. Loosen the bulb by turning it counterclockwise while
pressing on it.
3. To install the lights, follow the removal procedure in reverse.
License Plate Lamp
1. Bulb
2. Lens
3. Screw
4. Cover
1. Loosen the screws and removethe cover.
2. Remove the lens.
3. Loosen the bulb by turning it counterclockwise while
pressing on it.
4. To install the lights, follow the removal procedure in reverse.
Page 265 of 358

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
264 Vehicle Care
Interior Lamps
1. Remove the lens and pull outthe bulb.
2. To install the lights, follow the removal procedure in reverse.
Electrical System
Electrical System
Overload
Electrical System
Following the after-delivery service,
it is the owner's responsibility to
check all wiring periodically for
cracked, chafed or oil-soaked
insulation and maintain it in a clean
and tight condition to ensure
satisfactory operation of the
electrical system.
Replacing the Fuses and Relays
Your vehicle is equipped with fuses
and fusible links to protect your
electrical wiring and equipment in
case of electrical overload.
When the lights do not come on or
flash, or the equipment in the
electrical system does not operate,
check to see if a fuse has blown. Fuses :
In case of an electrical
overload, the fuse will blow and stop
the flow of current in the circuit
before electrical components
become damaged.
The cause of the circuit overload
must be identified and corrected
before the blown fuse is replaced,
or else the new fuse will also blow.
Since different circuits handle
different amounts of current, fuses
of various ampere ratings are used.
Be sure to replace a blown fuse with
a fuse of the correct rating.
To know if a fuse is blown or not,
remove the suspected fuse and look
at the wire for a break. If the wire is
broken, replace the fuse with one of
equal amperage rating.
The amperage rating of each fuse is
molded in its head.
Fuses are installed in the fuse
panel.
Page 353 of 358

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
352 Index
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 126
Break-In, New Vehicle . . . . . . . . . . 147
Bulb ReplacementHeadlamp Aiming . . . . . . . . . . . . . 254
Headlamps . . . . . . . . . . . . . . . . . . . 254
Headlamps and Front TurnSignal . . . . . . . . . . . . . . . . . . . . . . . 257
Interior Lamps . . . . . . . . . . . . . . . . 264
License Plate Lamps . . . . . . . . . 263
Roofmarker Lamps . . . . . . . . . . . 261
Sidemarker Lamps . . . . . . . . . . . 261
Taillamps, Turn Signal, Sto- plamps, and Back-up
Lamps . . . . . . . . . . . . . . . . . . . . . . 263
Buzzers, Warning . . . . . . . . . . . . . . . . 91
C
Cab Tilting . . . . . . . . . . . . . . . . . . . . . . 220
California Perchlorate Materials Re-quirements . . . . . . . . . . . . . . . . . . 218
California Proposition 65 Warning . . . . . . . . . . . . . . . 218, 287
Capacities and Specifica- tions . . . . . . . . . . . . . . . . . . . . . . . . . . 335
Carbon Monoxide
Engine Exhaust . . . . . . . . . . . . . . . 159
Winter Driving . . . . . . . . . . . . . . . . 133
Cargo Lamp . . . . . . . . . . . . . . . . . . . . . 96 Caution, Danger, and Warning . . . . 3
CD Player . . . . . . . . . . . . . . . . . . . . . . 103
Check
Engine Light (Malfunction In-dicator) . . . . . . . . . . . . . . . . . . . . . . . . 74
Child Restraints Infants and Young Children . . . . . 51
Systems . . . . . . . . . . . . . . . . . . . . . . . . 51
Cigarette Lighter . . . . . . . . . . . . . . . . . 67
Cleaning Exterior Care . . . . . . . . . . . . . . . . . 293
Interior Care . . . . . . . . . . . . . . . . . . 299
Climate Control Systems . . . . . . . 115 Air Conditioning . . . . . . . . . . . . . . .115
Heating . . . . . . . . . . . . . . . . . . . . . . . .115
Cluster, Instrument . . . . . . . . . . . . . . 70
Cold Weather Operation . . . . . . . . 209
Collision Damage Repair . . . . . . . 345
Compartments
Storage . . . . . . . . . . . . . . . . . . . . . . . . . 54
Control of a Vehicle . . . . . . . . . . . . . 122
Coolant
Engine . . . . . . . . . . . . . . . . . . . . . . . . 231
Engine Temperature Gauge . . . . 72
Cooling . . . . . . . . . . . . . . . . . . . . . . . . . 115
Cornering Lamps . . . . . . . . . . . . . . . . 95
Cover
Engine . . . . . . . . . . . . . . . . . . . . . . . . 222 Covers
Winter . . . . . . . . . . . . . . . . . . . . . . . . 154
Cruise Control . . . . . . . . . . . . . . . . . . 202 Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Cupholders . . . . . . . . . . . . . . . . . . . . . . 56
Customer Assistance . . . . . . . . . . . 343 Offices . . . . . . . . . . . . . . . . . . . . . . . . 343
Text Telephone (TTY)
Users . . . . . . . . . . . . . . . . . . . . . . . 343
Customer Information Service Publications Order-
ing Information . . . . . . . . . . . . . . 347
Customer Satisfaction Pro- cedure . . . . . . . . . . . . . . . . . . . . . . . . 342
D
Damage Repair, Collision . . . . . . . 345
Danger, Warning, and Caution . . . . 3
Daytime Running Lamps (DRL)Indicator Light . . . . . . . . . . . . . . . . . . 82
Devices
Auxiliary . . . . . . . . . . . . . . . . . . . . . . .113
Diesel Engine Engine Alarm and Auto-matic Shutdown . . . . . . . . . . . . . 155
High Idle System . . . . . . . . . . . . . 155
Diesel Exhaust Fluid . . . . . . . . 24, 170
Diesel Exhaust Fluid (DEF) Gauge . . . . . . . . . . . . . . . . . . . . . . . . . 73
Page 355 of 358

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
354 Index
Fuel (cont'd)Running out of Fuel . . . . . . . . . . . 212
Water in Fuel . . . . . . . . . . . . . . . . . 209
Fuel for Diesel Engines . . . . . . . . . 206
G
Gauges
Diesel Exhaust Fluid (DEF) . . . . . 73
Engine Coolant Temperature . . . 72
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Odometer . . . . . . . . . . . . . . . . . . . . . . . 71
Speedometer . . . . . . . . . . . . . . . . . . . 71
Tachometer . . . . . . . . . . . . . . . . . . . . . 72
Trip Odometer . . . . . . . . . . . . . . . . . . 71
Warning Lights and Indi-cators . . . . . . . . . . . . . . . . . . . . . . . . . 69
General Information Vehicle Care . . . . . . . . . . . . . . . . . . 218
Getting In and Out of the Ve-
hicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Glove Box . . . . . . . . . . . . . . . . . . . . . . . 55
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 344
H
Hazard Warning Flashers . . . . . . . . 94
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 254
Bulb Replacement . . . . . . . 254, 257 Headlamps (cont'd)
Daytime Running Lamps
(DRL) Indicator Light . . . . . . . . . . 82
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 93
High-Beam On Light . . . . . . . . . . . . 81
High/Low Beam Changer . . . . . . . 93
Heated Mirrors . . . . . . . . . . . . . . . . . . . 34
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 154
Heating . . . . . . . . . . . . . . . . . . . . . . . . . 115
High Idle System . . . . . . . . . . . . . . . 155
High-Beam On Light . . . . . . . . . . . . . 81
Hill and Mountain Roads . . . . . . . . 132
Hooks Shopping Bag . . . . . . . . . . . . . . . . . . 58
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
HVAC . . . . . . . . . . . . . . . . . . . . . . . . . . . 115
I
Idle Shutdown . . . . . . . . . . . . . . . . . . 155
Idle Shutdown Light . . . . . . . . . . . . . 81
Ignition Positions . . . . . . . . . . . . . . . 148
Infants and Young Children, Restraints . . . . . . . . . . . . . . . . . . . . . . 51
Information on Loading the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 58
Instrument Cluster . . . . . . . . . . . . . . . 70
Instrument Panel Storage Area . . . . . . . . . . . . . . . . . . . 55 Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North
America . . . . . . . . . . . . . . . . . . . . . . . 287
K
Keyless EntryRemote (RKE) System . . . . . . . . . 26
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
L
Lamps Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Cornering . . . . . . . . . . . . . . . . . . . . . . . 95
Dome . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Exterior Controls . . . . . . . . . . . . . . . . 92
Interior . . . . . . . . . . . . . . . . . . . . . . . . 264
License Plate . . . . . . . . . . . . . . . . . 263
Malfunction Indicator (Check
Engine) . . . . . . . . . . . . . . . . . . . . . . . 74
Roofmarker . . . . . . . . . . . . . . . . . . . 261
Sidemarker . . . . . . . . . . . . . . . . . . . 261
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . . 48
Lighter, Cigarette . . . . . . . . . . . . . . . . 67
Lighting Illumination Control . . . . . . . . . . . . . 95
Lights
Antilock Brake System(ABS) Warning . . . . . . . . . . . . . . . . 77
Page 357 of 358

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
356 Index
Proposition 65 Warning,California . . . . . . . . . . . . . . . . . 218, 287
R
Radio Frequency Statement . . . . 348
Radio Reception . . . . . . . . . . . . . . . . 101
Radios
AM-FM Radio . . . . . . . . . . . . . . . . . . . 97
Rear Axle . . . . . . . . . . . . . . . . . . . . . . . 249
Rear Seats . . . . . . . . . . . . . . . . . . . . . . 42
Rear Storage . . . . . . . . . . . . . . . . . . . . 57
Recommended Fluids and Lubricants . . . . . . . . . . . . . . . . . . . . . 326
Reduced Engine Power Light . . . . 81
Reimbursement Program, GM Mobility . . . . . . . . . . . . . . . . . . . 344
Remote Keyless Entry (RKE)
System . . . . . . . . . . . . . . . . . . . . . . . . . 26
Replacement Parts Maintenance . . . . . . . . . . . . . . . . . . 328
Reporting Safety Defects
General Motors . . . . . . . . . . . . . . . 349
U.S. Government . . . . . . . . . . . . . 349
Roads Driving, Wet . . . . . . . . . . . . . . . . . . 132
Roadside Assistance
Program . . . . . . . . . . . . . . . . . . . . . . . 344
Roofmarker Lamps . . . . . . . . . . . . . 261
Rotation, Tires . . . . . . . . . . . . . . . . . . 284 Routing, Engine Drive Belt . . . . . . 341
Running out of Fuel . . . . . . . . . . . . . 212
Running the Vehicle While
Parked . . . . . . . . . . . . . . . . . . . . . . . . 160
S
Safety Defects ReportingGeneral Motors . . . . . . . . . . . . . . . 349
U.S. Government . . . . . . . . . . . . . 349
Safety System Check . . . . . . . . . . . . 49
Scheduling Appointments . . . . . . . 345
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . 43 Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Extender . . . . . . . . . . . . . . . . . . . . . . . . 49
Lap Belt . . . . . . . . . . . . . . . . . . . . . . . . 48
Reminders . . . . . . . . . . . . . . . . . . . . . . 73
Three-Point . . . . . . . . . . . . . . . . . . . . . 45
Use During Pregnancy . . . . . . . . . . 47
Seats Position, Front . . . . . . . . . . . . . . . . . . 38
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Security Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 33
Selector Lever . . . . . . . . . . . . . . . . . . 194
Service . . . . . . . . . . . . . . . . . . . . . . . . . 120 Accessories and Modifica-
tions . . . . . . . . . . . . . . . . . . . . . . . . 218
Climate Control System . . . . . . . .115
Doing Your Own Work . . . . . . . . 218 Service (cont'd)
Publications Ordering Infor-
mation . . . . . . . . . . . . . . . . . . . . . . 347
Scheduling Appointments . . . . . 345
Transmission Warning Light . . . . 78
Vehicle Soon Light . . . . . . . . . . . . . . 74
Shift Lock Control Function Check, Automatic Trans-
mission . . . . . . . . . . . . . . . . . . . . . . . . 251
Shopping Bag Hooks . . . . . . . . . . . . 58
Sidemarker Lamps . . . . . . . . . . . . . 261
Signals, Turn and Lane-- Change . . . . . . . . . . . . . . . . . . . . . . . . 94
Specifications and Capa-
cities . . . . . . . . . . . . . . . . . . . . . . . . . . 335
Speedometer . . . . . . . . . . . . . . . . . . . . 71
Starting and Stopping the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 149
Steering . . . . . . . . . . . . . . . . . . . . . . . . 131 Fluid, Power . . . . . . . . . . . . . . . . . . 240
Wheel Adjustment . . . . . . . . . . . . . . 65
Stoplamps and Back-up Lamps Bulb Replacement . . . . . . . . . . . . 263
Storage Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Storage Areas Glove Box . . . . . . . . . . . . . . . . . . . . . . 55
Page 358 of 358

Chevrolet Low Cab Forward Owner Manual (GMNA-Localizing-U.S.-
11254764) - 2018 - crc - 12/5/16
Index 357
Storage Areas (cont'd)Information on Loading the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . 58
Instrument Panel . . . . . . . . . . . . . . . 55
Storage Compartments . . . . . . . . . . 54
Stuck Vehicle . . . . . . . . . . . . . . . . . . . 136
Sun Visors . . . . . . . . . . . . . . . . . . . . . . . 37
System Noise Control . . . . . . . . . . . . . . . . . 250
T
Tachometer . . . . . . . . . . . . . . . . . . . . . . 72
TaillampsBulb Replacement . . . . . . . . . . . . 263
Temperature, Operating . . . . . . . . 153
Text Telephone (TTY) Users . . . . 343
Three-Point Seat Belt . . . . . . . . . . . . 45
Tires If a Tire Goes Flat . . . . . . . . . . . . 287
Pressure . . . . . . . . . . . . . . . . . . . . . . 284
Rotation . . . . . . . . . . . . . . . . . . . . . . 284
Tires and Wheels . . . . . . . . . . . . . . . 272
Towing Vehicle . . . . . . . . . . . . . . . . . . . . . . . 291
Trademarks and License Agreements . . . . . . . . . . . . . . . . . . . 114
Transmission Automatic . . . . . . . . . . . . . . . . . . . . . 185
Fluid, Automatic . . . . . . . . . . . . . . 229 Transmission (cont'd)
Overdrive Off, Automatic . . . . . . 195
Service Warning Light . . . . . . . . . . 78
Trip Odometer . . . . . . . . . . . . . . . . . . . 71
Turn and Lane-Change
Signals . . . . . . . . . . . . . . . . . . . . . . . . . 94
Turn Signal Bulb Replacement . . . . . . . . . . . . 263
U
USB Port . . . . . . . . . . . . . . . . . . . . . . . 110
Using This Manual . . . . . . . . . . . . . . . . 3
V
VehicleControl . . . . . . . . . . . . . . . . . . . . . . . 122
Getting In and Out . . . . . . . . . . . . . . 29
Identification Number (VIN) . . . 330
Messages . . . . . . . . . . . . . . . . . . . . . . 86
Security . . . . . . . . . . . . . . . . . . . . . . . . 33
Service Soon Light . . . . . . . . . . . . . 74
Starting and Stopping . . . . . . . . . 149
Towing . . . . . . . . . . . . . . . . . . . . . . . . 291
Vehicle Care
Tire Pressure . . . . . . . . . . . . . . . . . 284
Vehicle Data Recording and Privacy . . . . . . . . . . . . . . . . . . . . . . . . 349
Ventilation, Air . . . . . . . . . . . . . . . . . . 118
Visors . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
W
Wait to Start Light . . . . . . . . . . . . . . . 79
Warning Brake System Light . . . . . . . . . . . . . 75
Caution and Danger . . . . . . . . . . . . . 3
Warning Buzzers . . . . . . . . . . . . . . . . 91
Warning Lights, Gauges, and Indicators . . . . . . . . . . . . . . . . . . . . . . 69
Warnings Hazard Flashers . . . . . . . . . . . . . . . . 94
Washer Fluid . . . . . . . . . . . . . . . . . . . 241
Water in Fuel . . . . . . . . . . . . . . . . . . . 209
Wheels and Tires . . . . . . . . . . . . . . . 272
Windows Power . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Windshield Wiper/Washer . . . . . . . . . . . . . . . . . . 66
Winter Driving . . . . . . . . . . . . . . . . . . . . . . . . 133
Winter Cover . . . . . . . . . . . . . . . . . . . 154
Wiper Blade Replacement . . . . . . 252