coolant temperature CHEVROLET LOW CAB FORWARD 2020 Owner's Guide

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
250 Vehicle Care
If Steam Is Not Coming from the
Engine CompartmentIf the engine coolant temperature
gauge shows an overheat condition,
or you have reason to suspect the
engine may be overheating, take
the following steps:1. Operate the hazard warning flasher and pull the vehicle
immediately over to a safe
place that does not impede
traffic and park it.
2. Idle the engine and wait until the engine coolant temperature
drops to safety zone. If your air
conditioner (if equipped) is on,
turn it off. And turn on the
heater to help the engine
expel heat.
3. When the needle of the engine coolant temperature gauge
returns to the middle of the
safety zone, stop the engine.
If the needle of engine coolant
temperature gauge does not
drop inside into the safety
zone, turn the engine off and
have your vehicle serviced at
the nearest dealer. When the cooling fan for the
radiator is not turning, turn off
the engine immediately.
{Warning
Even when the engine has been
stopped, the engine coolant in the
radiator remains under pressure.
Immediately removing the radiator
cap could cause steam or hot
water to blow out, and you could
be scalded as a result. The
engine coolant in the reserve tank
may also be hot. Immediately
removing the cap could cause hot
water to blow out, and possibly
scald you. Perform inspection,
refilling, and replacement of
coolant only when its temperature
has cooled.
When removing the radiator cap
and reserve tank cap, use a thick
cloth to cover the cap and turn it
little by little.
You and others could be seriously
injured.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Vehicle Care 251
4. If no steam or engine coolantcan be seen or heard from the
engine compartment:
.Tilt the cab or open the
engine access cover.
‐If the engine coolant is
boiling, wait until it stops
before proceeding.
‐ Look at the see-through
reserve tank. The
engine coolant level
should be between the
"MAX" and "MIN" lines
on the reserve tank.
‐ If necessary, pour
engine coolant (See
Engine Coolant 0243
for the proper coolant
and water mixture) into
the reserve tank only,
not directly into the
radiator. Also, do not
check engine coolant
level at the radiator.
. Make sure the fan belts are
not broken, or off the
pulleys, and that the fan
turns when the engine is started. Make sure the fan
blade and pulleys are not
broken.
. Check the radiator hoses
and connections, heater
hoses and connections,
radiator, water pump, EGR
cooler, and SCR system
and hoses for leakage.
If you do not find a leak or
other problem, carefully add
engine coolant to the
reserve tank.
If the engine coolant level in
the reserve tank is at the
correct level but there is still
an indication on the
instrument panel of an
overheat condition:
You must let the engine
cool first. You may then add
engine coolant directly to
the radiator. See “Adding
Engine Coolant” under
Engine Coolant 0243.
5. Inspect to see if there is any dirt, etc. attached to the front
surface of the radiator. Also, inspect to see if there is
anything blocking the core.
If there is anything attached,
clean and remove it.
6. After the inspection, regardless of the vehicle condition, please
contact the nearest dealer.
Once the engine coolant
temperature gauge no longer
signals an overheat condition, you
can resume driving at a reduced
speed. Return to normal driving
after about 10 minutes if the gauge
pointer does not again show an
overheat condition.
When tap water only has been used
for engine coolant in an emergency,
change the engine coolant as soon
as possible.
Engine damage may be caused if
an overheating engine is suddenly
refilled with water. Instead, refill
slowly.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Service and Maintenance 339
Recommended Fluids, Lubricants, and Parts
Recommended Fluids and Lubricants
Fluids and lubricants identified below by name, part number, or specification can be obtained from your dealer.Usage Fluid/Lubricant
Automatic Transmission Automatic Transmission Fluid (GM Part No. 19354076).
Battery Terminals Petroleum Jelly (outer surfaces)
Brake Fluid DOT 3 Hydraulic Brake Fluid (GM Part No. 19353126).
Cab-Door Hinges and Latches
Lubricant Multi-Purpose Lubricant, Superlube (GM Part No. 12346241) or equivalent
containing zinc oxide.
Chassis Lubricant Chassis Lubricant (GM Part No. 12377985) or high temperature equivalent.
Diesel Exhaust Fluid (DEF) Diesel Exhaust Fluid (GM Part No. 19353126) or diesel exhaust fluid that meets ISO 22241-1 or displays the API Diesel Exhaust Fluid
Certification Mark.
Driveshaft Center Bearing, Wheel
Hub Bearing Lubricant NLGI #2 or #3
Driveshaft, Universal Joints and
Sliding Sleeve Lubricant NLGI #1 or #2 multi-purpose type grease
Engine Coolant 50/50 mixture of clean, drinkable water and GM extended life coolant. (GM Part No. 12378560) SeeEngine Coolant0243.

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
366 Index
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . 253Antilock . . . . . . . . . . . . . . . . . . . . . . . 207
Exhaust Light . . . . . . . . . . . . . . . . . . . 65
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 258
Parking . . . . . . . . . . . . . . . . . . . . . . . .211
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 134
Break-In, New Vehicle . . . . . . . . . . 156
Bulb Replacement Headlamp Aiming . . . . . . . . . . . . . 267
Headlamps . . . . . . . . . . . . . . . . . . . 267
Headlamps and Front TurnSignal . . . . . . . . . . . . . . . . . . . . . . . 270
Interior Lamps . . . . . . . . . . . . . . . . 277
License Plate Lamps . . . . . . . . . 276
Roofmarker Lamps . . . . . . . . . . . 274
Sidemarker Lamps . . . . . . . . . . . 274
Taillamps, Turn Signal, Stoplamps, and Back-up
Lamps . . . . . . . . . . . . . . . . . . . . . . 276
Buzzers, Warning . . . . . . . . . . . . . . . . 79
C
Cab Tilting . . . . . . . . . . . . . . . . . . . . . . 233
California Perchlorate MaterialsRequirements . . . . . . . . . . . . . . . 230 California
Proposition
65 Warning . . . . . . . . . .230, 259, 301,
Back Cover
Capacities and Specifications . . . . . . . . . . . . . . . . . 349
Carbon Monoxide
Engine Exhaust . . . . . . . . . . . . . . . 168
Winter Driving . . . . . . . . . . . . . . . . 142
Cargo Lamp . . . . . . . . . . . . . . . . . . . . . 84
Caution, Danger, and Warning . . . . 3
CD Player . . . . . . . . . . . . . . . . . . . . . . . 90
Check Engine Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . . . 61
Child Restraints
Systems . . . . . . . . . . . . . . . . . . . . . . . . 39
Cleaning Exterior Care . . . . . . . . . . . . . . . . . 307
Interior Care . . . . . . . . . . . . . . . . . . 313
Climate Control Systems . . . . . . . 121
Air Conditioning . . . . . . . . . . . . . . 121
Heating . . . . . . . . . . . . . . . . . . . . . . . 121
Cluster, Instrument . . . . . . . . . . . . . . 57
Cold Weather Operation . . . . . . . . 221
Collision Damage Repair . . . . . . . 359 Compartments
Storage . . . . . . . . . . . . . . . . . . . . . . . . . 42
Control of a Vehicle . . . . . . . . . . . . . 130
Coolant Engine . . . . . . . . . . . . . . . . . . . . . . . . 243
Engine Temperature Gauge . . . . 60
Cooling . . . . . . . . . . . . . . . . . . . . . . . . . 121
Cornering Lamps . . . . . . . . . . . . . . . . 83
Cover
Engine . . . . . . . . . . . . . . . . . . . . . . . . 235
Covers
Winter . . . . . . . . . . . . . . . . . . . . . . . . 163
Cruise Control . . . . . . . . . . . . . . . . . . 214 Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70
Cupholders . . . . . . . . . . . . . . . . . . . . . . 44
Customer Assistance . . . . . . . . . . . 357 Offices . . . . . . . . . . . . . . . . . . . . . . . . 357
Text Telephone (TTY)Users . . . . . . . . . . . . . . . . . . . . . . . 357
Customer Information Publications Ordering
Information . . . . . . . . . . . . . . . . . . 362
Customer Satisfaction Procedure . . . . . . . . . . . . . . . . . . . . . 356
Cybersecurity . . . . . . . . . . . . . . . . . . . 364

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
Index 367
D
Damage Repair, Collision . . . . . . . 359
Danger, Warning, and Caution . . . . 3
Daytime Running Lamps (DRL)Indicator Light . . . . . . . . . . . . . . . . . . 69
Devices Auxiliary . . . . . . . . . . . . . . . . . . . . . . 107
Diesel Engine Engine Alarm andAutomatic Shutdown . . . . . . . . 164
Diesel Exhaust Fluid . . . . . . . . . . . . 180
Diesel Exhaust Fluid (DEF) Gauge . . . . . . . . . . . . . . . . . . . . . . . . . 60
Diesel Exhaust Fluid (DEF)
Warning Light . . . . . . . . . . . . . . . . . . 68
Diesel Particulate Filter . . . . . . . . . 171
Distracted Driving . . . . . . . . . . . . . . . 130
Dome Lamps . . . . . . . . . . . . . . . . . . . . 84
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Power Locks . . . . . . . . . . . . . . . . . . . . 21
Drive Belt Routing, Engine . . . . . . 355
Driver Behavior . . . . . . . . . . . . . . . . . 129
Driver Information Center (DIC) . . . . . . . . . . . . . . . . . . . 70
Driving Better Fuel Economy . . . . . . . . . 129
Emergencies . . . . . . . . . . . . 145, 155 Driving (cont'd)
Hill and Mountain Roads . . . . . . 141
If the Vehicle is Stuck . . . . . . . . . 144
Wet Roads . . . . . . . . . . . . . . . . . . . 140
Winter . . . . . . . . . . . . . . . . . . . . . . . . 142
E
Electrical Equipment,
Add-On . . . . . . . . . . . . . . . . . . . . . . . 227
Electrical System
Overload . . . . . . . . . . . . . . . . . . . . . 277
Emergencies . . . . . . . . . . . . . . 145, 155
Engine Air Cleaner/Filter . . . . . . . . . . . . . 243
Alarm and Automatic
Shutdown . . . . . . . . . . . . . . . . . . . 164
Check Light (Malfunction Indicator) . . . . . . . . . . . . . . . . . . . . . . 61
Checks Before Operating . . . . . 166
Compartment Overview . . . . . . . 234
Coolant . . . . . . . . . . . . . . . . . . . . . . . 243
Coolant Temperature Gauge . . . . 60
Cover . . . . . . . . . . . . . . . . . . . . . . . . . 235
Drive Belt Routing . . . . . . . . . . . . 355
Exhaust . . . . . . . . . . . . . . . . . . . . . . 168
Heater . . . . . . . . . . . . . . . . . . . . . . . . 163
High Idle System . . . . . . . . . . . . . 165
Oil Pressure Light . . . . . . . . . . . . . . 67 Engine (cont'd)
Overheating . . . . . . . . . . . . . . . . . . 249
Reduced Power Light . . . . . . . . . . . 69
Running While Parked . . . . . . . . 170
Shutdown Warning Light . . . . . . . . 68
Engine Oil Level Indicator Light . . . . . . . . . . . . 67
Engines Diesel Fuel . . . . . . . . . . . . . . . . . . . 218
Exhaust Brake . . . . . . . . . . . . . . . . . . 213
Exhaust Brake Light . . . . . . . . . . . . . 65
Exhaust Fluid Diesel . . . . . . . . . . . . . . . . . . . . . . . . 180
Extender, Seat Belt . . . . . . . . . . . . . . 37
Exterior Lamp Controls . . . . . . . . . . 80
F
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171 Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 260
Filter, Engine Air Cleaner . . . . . . . . . . . 243
Fixed Mast Antenna . . . . . . . . . . . . . 90
Flash-to-Pass . . . . . . . . . . . . . . . . . . . . 81
Flashers, Hazard Warning . . . . . . . 82
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 300
Fluid Automatic Transmission . . . . . . 241
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 258

Chevrolet Low Cab Forward 5.2L Diesel Engine 4500 HD/XD/5500 HD/XD
Owner Manual (GMNA-Localizing-U.S.-13337621) - 2020 - crc - 12/5/18
368 Index
Fluid (cont'd)Power Steering . . . . . . . . . . . . . . . 252
Washer . . . . . . . . . . . . . . . . . . . . . . . 252
Frequency Statement
Radio . . . . . . . . . . . . . . . . . . . . . . . . . 362
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 26
Fuel Biodiesel . . . . . . . . . . . . . . . . . . . . . 219
Cold Weather Operation . . . . . . 221
Diesel Engines . . . . . . . . . . . . . . . 218
Economy, Driving for Better . . . 129
Filling the Tank . . . . . . . . . . . . . . . 225
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . 260
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Running out of Fuel . . . . . . . . . . . 224
Water in Fuel . . . . . . . . . . . . . . . . . 221
Fuel for Diesel Engines . . . . . . . . . 218
G
Gauges
Diesel Exhaust Fluid (DEF) . . . . . 60
Engine Coolant Temperature . . . 60
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 59
Odometer . . . . . . . . . . . . . . . . . . . . . . . 58
Speedometer . . . . . . . . . . . . . . . . . . . 58
Tachometer . . . . . . . . . . . . . . . . . . . . . 59
Trip Odometer . . . . . . . . . . . . . . . . . . 58 Gauges (cont'd)
Warning Lights and
Indicators . . . . . . . . . . . . . . . . . . . . . 56
General Information
Vehicle Care . . . . . . . . . . . . . . . . . . 230
Getting In and Out of the Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 17
Glove Box . . . . . . . . . . . . . . . . . . . . . . . 43
GM Mobility Reimbursement Program . . . . . . . . . . . . . . . . . . . . . . . 358
H
Hazard Warning Flashers . . . . . . . . 82
HeadlampsAiming . . . . . . . . . . . . . . . . . . . . . . . . 267
Bulb Replacement . . . . . . . 267, 270
Daytime Running Lamps(DRL) Indicator Light . . . . . . . . . . 69
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 81
High-Beam On Light . . . . . . . . . . . . 69
High/Low Beam Changer . . . . . . . 81
Heated Mirrors . . . . . . . . . . . . . . . . . . . 22
Heater Engine . . . . . . . . . . . . . . . . . . . . . . . . 163
Heating . . . . . . . . . . . . . . . . . . . . . . . . . 121
High Idle System . . . . . . . . . . . . . . . 165
High-Beam On Light . . . . . . . . . . . . . 69
Hill and Mountain Roads . . . . . . . . 141 Hooks
Shopping Bag . . . . . . . . . . . . . . . . . . 45
Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
HVAC . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
I
Idle Shutdown . . . . . . . . . . . . . . . . . . 164
Idle Shutdown Light . . . . . . . . . . . . . 68
Ignition Positions . . . . . . . . . . . . . . . 157
Information Publication Ordering . . . . . . . . . . 362
Information on Loading the
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 46
Instrument Cluster . . . . . . . . . . . . . . . 57
Instrument Panel Storage Area . . . . . . . . . . . . . . . . . . . 43
Instrument Panel
Overview . . . . . . . . . . . . . . . . . 8, 10, 11
Introduction . . . . . . . . . . . . . . . . . . . . . . . 2
J
Jump Starting - North America . . . . . . . . . . . . . . . . . . . . . . . 301
K
Keyless EntryRemote (RKE) System . . . . . . . . . 14
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13