check oil CHEVROLET MALIBU 1997 5.G User Guide

Downloaded from www.Manualslib.com manuals search engine Turn off the engine and give the oil a few minutes to
drain back into the oil pan. If you don’t, the oil dipstick
might not show the actual level.
Checking Engine Oil When
to Add Oil
If
the oil is at or below the ADD line, then you’ll need
to add at least one quart of
oil. But you must use the
right kind. This part explains what kind
of oil to use. For
crankcase capacity, see “Capacities and Specifications”
in the Index.
NOTICE:
Pull out the dipstick and clean it with a paper towel or
cloth, then push it back in all the way. Remove it again,
keeping the tip down, and check the level.
Don’t add too much oil. If your engine has so
much oil that the oil level gets above the upper
mark that shows the proper operating range,
your engine could be damaged.
6-13

Downloaded from www.Manualslib.com manuals search engine What to Do with Used Oil
Did you know that used engine oil contains certain
elements that may be unhealthy for your skin and could
even cause cancer? Don’t let used oil stay on your skin
for very long. Clean your skin and nails with soap and
water, or a good hand cleaner. Wash or properly throw
away clothing or rags containing used engine oil. (See
the manufacturer’s warnings about the use and disposal
of oil products.)
Used oil can be a real threat to the environment. If you
change your own oil, be sure to drain all free-flowing oil
from the filter before disposal. Don’t ever dispose of oil
by putting it
in the trash, pouring it on the ground, into
sewers, or into streams or bodies of water. Instead,
recycle it by taking it to a place that collects used oil. If
you have a problem properly disposing of your used oil,
ask your dealer, a service station or
a local recycling
center for help.
Air Cleaner
The air cleaner is located on the driver’s side of the
engine compartment.
To check or replace the air filter:
1. Unscrew the four Phillips-head screws, then pull the
cover back.
2. Remove the air cleaner filter.
3. Be sure to install the air cleaner filter and replace the \
cover tightly.

Downloaded from www.Manualslib.com manuals search engine Refer to the Maintenance Schedule to determine when to
replace the air filter. See “Scheduled Maintenance Services” in the Index.
Operating the engine with the air cleaner off can
cause you or others to be burned. The air cleaner
not only cleans the air,
it stops flame if the engine
backfires.
If it isn’t there, and the engine
backfires, you could be burned. Don’t drive with
it
off, and be careful working on the engine with
the
air cleaner off.
NOTICE:
If the air cleaner is off, a backfire can cause a
damaging engine fire. And, dirt can easily get
into your engine, which will damage it. Always
have the air cleaner in place when you’re driving.
Automatic Transaxle Fluid
It is not necessary to check the transaxle fluid level.
A transaxle fluid leak is the only reason for fluid loss.
If a leak occurs, take the vehicle to your Chevrolet
dealership Service Department and have it repaired as
soon as possible. You may
also have your fluid level
checked by your dealer or service center when you have
your oil changed.
Engine Coolant
The cooling system in your vehicle is filled with new
DEX-COOL” engine coolant. This coolant is designed
to remain in your vehicle for
5 years or 150,000 miles
(240 000 km), whichever occurs fist, if you add only
DEX-COOL TM extended life coolant.
The following explains your cooling system
and how to
add coolant when it is low.
If you have a problem with
engine overheating, see “Engine Overheating” in
the Index.

Downloaded from www.Manualslib.com manuals search engine IShort TripKity Maintenance Schedule I
The services shown in this schedule up to 100,000 miles
(166
000 km) should be performed after 100,000 miles
(166
000 km) at the same intervals. The services shown
at 150,000 miles
(240 000 km) should be performed at
the same interval after
150,000 miles (240 000 km).
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior
to the
completion of the vehicle’s useful life. We, however,
urge that
all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspection” in Part
C of this schedule.
3,000 Miles (5 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
DATE ACTUAL MILEAGE SERVICED BY: I
7-7

Downloaded from www.Manualslib.com manuals search engine Long Trip/Highway Maintenance Schedule
The services shown in this schedule up to 100,000 miles
(166
000 km) should be performed after 100,000 miles
(166
000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after 150,000 miles (240
000 km).
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion of the vehicle’s useful
life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
+ A good time to check your brakes is during tire
rotation. See “Brake System Inspection” under “Periodic
Maintenance Inspections” in
Part C of this schedule.
7,500 Miles (12 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
I7 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information. (See footnote
+.)
An Emission Control Service.
I DATE ACTUAL MILEAGE SERVICED BY:
7-27

Downloaded from www.Manualslib.com manuals search engine Part B: Owner Checks and Services
Listed below are owner checks and services which
should be performed at the intervals specified to help
ensure the safety, dependability and emission control
performance of your vehicle.
Be sure any necessary repairs
are completed at once.
Whenever any fluids or lubricants
are added to your
vehicle, make sure they
are the proper ones, as shown in
Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
pe@orm these underhood checks
at each fuel fill.
Engine Oil Level Check
Check the engine oil level and add the proper oil
if necessary. See “Engine Oil” in the Index for
further details.
Engine Coolant Level Check
Check the engine coolant level and add the proper
coolant mix if necessary. See “Engine Coolant” in the
Index for further details.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the
windshield washer tank and add the proper fluid if
necessary. See “Windshield Washer Fluid” in the Index
for further details.
At Least Once a Month
Tire Inflation Check
Make sure tires are inflated to the correct pressures.
See “Tires”
in the Index for further details.
Cassette Deck Service
Clean cassette deck. Cleaning should be done every
50 hours of tape play. See “Audio Systems” in the
Index for further details.
7-37

Downloaded from www.Manualslib.com manuals search engine Brake Adjustment
.................................. 6-28
Fluid
....................................... 6-24
Master Cylinder
.............................. 6-24
Parking
..................................... 2-22
Pedal Travel
................................. 6-28
Replacing System Parts
........................ 6-28
System Warning Light
.................... 2.55. 6.25
Trailer
...................................... 4-36
Transaxle Shift Interlock
.................. 2.25. 7.39
Transaxle Shift Interlock Check
.................. 7-39
Wear
....................................... 6-27
Brakes. Anti-Lock
.......................... 2.56. 4.7
Braking
........................................ 4-6
Braking in Emergencies
........................... 4-9
Break.In. New Vehicle
.......................... 2- 13
BTSICheck
................................... 7-39
Bulb Replacement
.............................. 6-29
Back-up Lamp
.............................. 6-32
CHMSL
.................................... 6-32
Dome Lamp
................................. 6-34
Headlamps
.................................. 6-29
Taillamp
.................................... 6-32
Canadian Roadside Assistance
.................... 8-7
Capacities and Specifications
...................... 6-61
Carbon Monoxide
............... 2.10.2.26.4.27. 4.36
Cassette Deck Service
........................... 7-37
Cassette Tape Player
........................ 3.9. 3. 18
Cassette Tape Player Care
........................ 3-23
CD Adapter Kit
................................ 3- 13
CDPlayer
..................................... 3-14
CD Player Theft-Deterrent Feature ................. 3- 19
BTSI
.................................... 2.25. 7.39
Center Console Storage Area
...................... 2-42
Center High-Mounted Stoplamp Bulb Replacement
.... 6-32
Center Rear Passenger Position
.................... 1-33
Certification Label
.............................. 4-31
Chains. Safety
................................. 4-36
Chains. Tire
................................... 6-43
Changing a Flat Tire
............................. 5-20
Charging System Indicator Light
Check Engine Light
............................
Check Oil Light ........................... 2-61
Checking Your Restraint Systems
.................
Chemical Paint Spotting .........................
Child Restraints ...............................
Securing in a Rear Outside Seat Position ..........
YY ..................
Securing in the Center Rear Seat Position .......... 1-40
Securing
in the Right Front Seat Position .......... 1-42
TopStrap
................................... 1-37
Where to Put
................................ 1-36
Circuit Breakers and Fuses
....................... 6-55
Cleaner. Air ................................... 6-17
Aluminum Wheels
............................ 6-50
Exterior LampsLenses
........................ 6-49
Fabric
...................................... 6-45
Glass
....................................... 6-47
Inside
of Your Chevrolet ....................... 6-44
Instrumentpanel
............................. 6-47
Outside of Your Chevrolet
...................... 6-48
Special Problems
............................. 6-46
Stains
...................................... 6-46
Tires
....................................... 6-50
Vinyl
....................................... 6-46
Wheels
..................................... 6-50
Windshield and
Wiper Blades ................... 6-48
Cleaning
...................................... 6-44 2-54
2-57
6-12 1-47
6-51
1-35
1-38
9-2

Downloaded from www.Manualslib.com manuals search engine Electrical Equipment. Adding ..... 2.15.2.16.3.22. 6.64
Electrical System
............................... 6-54
Engine
.................................. 6.10. 6.11
Coolant
..................................... 6-18
Coolant Heater
............................... 2-17
Coolant Levelcheck
.......................... 7-37
Coolant Temperature Gage
..................... 2-56
Exhaust
...................... 2.10.2.26.4.27. 4.36
FuseBlock
.................................. 6-58
Identification
................................ 6-53
Oil Level Check
.............................. 7-37
Overheating
................................. 5-12
Running While Parked
......................... 2-26
Specifications
................................ 6-62
Starting Your
........................... 2- 14. 2. 16
EngineOil .................................... 6-12
Adding
..................................... 6-13
Additives
................................... 6-16
Checking ................................... 6-13
Pressure Warning Light
........................ 2-60
Used
....................................... 6-17
What Kind to Use
............................. 6- 15
Ethanol ........................................ 6-4
Exterior Lamps
................................. 2-36
Whentochange
.............................. 6-16
Fabric Cleaning ............................... 6-45
FillingYourTank
................................ 6-5
Filter. Air
..................................... 6-17
Finishcare
.................................... 6-49 Finish Damage
................................. 6-51
First Gear. Automatic Transaxle
................... 2-21
Flashers. Hazard Warning
......................... 5-2
Flash-to-Pass .................................. 2-30
Flat Tire. Changing
............................. 5-20
Fluids and Lubricants
............................ 7-42
FogLmps
.................................... 2-38
Following Distance with a Trailer
.................. 4-37
Foreign Countries. Fuel
........................... 6-5
FrenchLanguageManual
11
FrontTowing .................................. 5-10
Fuel .......................................... 6-3
Filling Your Tank
.............................. 6-5
Gage
....................................... 2-64
In Foreign Countries
........................... 6-5
Fuses and Circuit Breakers
....................... 6-55
.. ...........................
Gages Engine Coolant Temperature
.................... 2-56
Fuel
....................................... 2-64
Tachometer
.................................. 2-52
Garment
Hook ................................. 2-46
GAWR
....................................... 4-31
Gear Positions. Automatic Transaxle
................ 2-19
GloveBox
.................................... 2-42
Gross Axle Weight Rating
........................ 4-31
Gross Vehicle Weight Rating ...................... 4-31
Guide en Frangais
11
GVWR ....................................... 4-31
.. .................................
9-4

Downloaded from www.Manualslib.com manuals search engine Leaving Your Vehicle ............................. 2-6
Leaving Your Vehicle with the Engine Running
....... 2-24
Lighter
....................................... 2-44
Lights Air Bag Readiness
....................... 1.22. 2.54
Anti-Lock Brake System Warning
............ 2.56. 4.7
Brake System Warning
.................... 2.55. 6.25
Charging System Indicator
...................... 2-54
CheckEngine
................................ 2-57
CheckOil
.............................. 2.61. 6.12
Cruise
...................................... 2-62
DoorAjar
................................... 2-63
Interior
..................................... 2-38
Low Coolant Warning
.................... 2.57. 6.21
LowWash
.................................. 2-62
Oil Pressure Warning
.......................... 2-60
Passlock@ Warning
........................... 2-6 1
Safety Belt Reminder
...................... 1.8. 2.53
Service Vehicle
Soon .......................... 2-63
Loading Your Vehicle ........................... 4-30
Lock Out Switch
............................... 2-28
Locks
......................................... 2-4
Cylinders
................................... 7-38
Door
........................................ 2-4
Key Lock Cylinder Service
..................... 7-38
PowerDoor
.................................. 2-5
Rear Door Security
............................. 2-5
Low Coolant Warning Light
................. 2.57. 6.21
Lubricants and Fluids ............................ 7-42
Lubrication Service. Body
........................ 7-38 Maintenance.
~ormal Replacement parts ........... 6-62
Maintenance Record
............................ 7-43
Maintenanceschedule
............................ 7-1
Introduction
.................................. 7-2
Long Tripmighway Definition
................... 7-6
Long Tripmighway Intervals
..................... 7-6
Owner Checks and Services
..................... 7-37
Periodic Maintenance Inspections
................ 7-41
Recommended Fluids and Lubricants
............. 7-42
Scheduled Maintenance Services
.................. 7-4
Selecting the Right Schedule
..................... 7-4
Short TripKity Definition ....................... 7-5
Short TripKity Intervals ........................ 7-5
Maintenance. Underbody
......................... 6-51
Maintenance When Trailer Towing
................. 4-40
Making Turns with a Trailer
...................... 4-38
Malfunction Indicator Lamp
...................... 2-57
ManualFrontSeat
............................... 1-2
Manual Remote Control Mirror .................... 2-40
Methanol
...................................... 6-4
Mirror Reading Lamps ........................... 2-39
Mirrors
....................................... 2-40
Convex Outside
.............................. 2-41
Inside Daymight Rearview
..................... 2-40
Manual Remote Control
........................ 2-40
Outside
..................................... 2-40
Power Remote Control
......................... 2-41
Visorvanity
................................. 2-45
Mountain Roads
................................ 4-22
Multifunction Lever
............................. 2-29
9-6

Downloaded from www.Manualslib.com manuals search engine Net. Convenience .............................. 2-44
Neutral. Automatic Transaxle
..................... 2-20
New Vehicle “Break-In” ......................... 2- 13
Night Vision
................................... 4-15
Odometer
.................................... 2-51
Odometer. Trip
................................. 2-51
Oil. Engine .................................... 6-12
Oil Pressure Warning Light
....................... 2-60
Outside Mirror
................................. 2-40
Overheating Engine
............................. 5-12
Owner Checks and Services
....................... 7-37
Owner Publications. Ordering
..................... 8- 12
Off-Road Recovery
............................. 4- 11
Paint
Spotting. Chemical ........................ 6-51
Park Automatic Transaxle
.......................... 2- 19
Shifting Into
................................. 2-23
Shifting Out
of ............................... 2-25
AtNight
.................................... 2-12
Brake
...................................... 2-22
Brake Mechanism Check
....................... 7-40
Lots
....................................... 2-12
Over Things That Burn
........................ 2-25
WithaTrailer ................................ 4-39
Passenger Position
.............................. 1-2 1
Passing ....................................... 4-12
Passing with a Trailer
............................ 4-37
Parking Passlock”
.................................... 2-12
Passlock” Warning Light
........................ 2-61
Periodic Maintenance Inspections
.................. 7-41
Power Accessory Outlet
............................. 2-46
DoorLocks
................................... 2-5
Option Fuses
................................ 6-54
Remote Control Mirror
........................ 2-41
Seat
......................................... 1-3
Steering
..................................... 4-9
Steering Fluid
................................ 6-22
Windows
................................... 2-27
Pregnancy. Use of Safety Belts
.................... 1-20
Problems on the Road
............................ 5-2
Publications. Service and Owner
................... 8-12
Radiator
..................................... 5-14
Radio Reception
................................ 3-22
Radios
........................................ 3-7
Rain, Driving In
................................ 4-16
Rear Door Security Locks
........................... 2-5
Outside Seat Position
.......................... 1-27
Safety Belt Comfort Guides
..................... 1-30
Seatpassengers
.............................. 1-27
Towing
..................................... 5-11
Window Defogger
............................. 3-5
Rearview Mirror
................................ 2-40
Inside Daymight
............................. 2-40
Reclining Front Seatbacks
......................... 1-4
Recreational Vehicle Towing
...................... 4-28
9-7
...