wiring CHEVROLET MALIBU 1997 5.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine Trunk Remote Trunk Release
To unlock the trunk from the outside, insert the key and
turn the trunk lock cvlinder.
It can be dangerous to drive with the trunk lid
open because carbon monoxide
(CO) gas can
come into your vehicle.
You can’t see or smell
CO. It can cause unconsciousness and even death.
If you must drive with the trunk lid open or if
electrical wiring or other cable connections must
pass through the seal between the body and the
trunk lid:
Make sure all windows are shut.
%MI the fan on your heating or cooling
system
to its highest speed with the setting on
VENT. That will force outside air into your
vehicle.
See “Comfort Controls” in the Index.
instrument panel, open them all the
way.
If you have air outlets on or under the
See “Engine Exhaust” in the Index.
Press the remote release
button, located on the lower left side
of the instrument
panel, to release the trunk
lid. Make sure the lockout
feature is not activated.
Also, the remote trunk
release will only work
when the gearshift
lever is in
PARK (P) or
NEUTRAL (N).
Remote Trunk Release Lockout
Your remote trunk release is equipped with a lockout
feature to help prevent unauthorized entry into the trunk
when leaving the vehicle unattended. The switch
is
located on the inside of the trunk lid, mounted to the
trunk lid latch.
2-10

Downloaded from www.Manualslib.com manuals search engine Air Bag Readiness Light
There is an air bag readiness light on the instrument
panel, which shows the air bag symbol. The system
checks the air bag’s electrical system for malfunctions.
The light tells you if there is an electrical problem. The
system check includes the air bag sensor, the air bag
modules, the wiring and the crash sensing and
diagnostic module. For more information on the air bag
system, see “Air Bag” in the Index.
This light will. come
on
~ when you start your engine,
and it will flash for a few
seconds. Then the light
should go out. This means
the system is ready.
If the air bag readiness light stays on after you start the
engine or comes on when you are driving, your air bag
system may not work properly. Have your vehicle
serviced right away. The
air bag readiness light should flash for a few
seconds when you turn the ignition key to
ON. If the
light doesn’t come on then, have it fixed
so it will be
ready to warn you if there is a problem.
Charging System Indicator Light
The charging system
indicator light will come on
when you turn on the ignition, but the engine
is
not running, as a check to show you
it is working.
Then it should go out.
If it stays on,
or comes on while yoa aye- driving and you
hear
a chime, you may have a problem with the
electrical charging system. It could indicate that you
have a loose generator drive belt or another electrical
problem. Have it checked right away. Driving while this
light is on could drain your battery.
If you must drive a short distance with the light on, be
certain to
turn off all your accessories, such as the radio
and air conditioner.
2-54

Downloaded from www.Manualslib.com manuals search engine Making Turns
I NOTICE:
Making very sharp turns while trailering could cause the trailer to come in contact with the
vehicle. Your vehicle could be damaged. Avoid
making very sharp turns while trailering.
When you’re turning with a trailer, make wider
turns than normal.
Do this so your trailer won’t
strike soft shoulders, curbs, road signs, trees or other
objects. Avoid jerky
or sudden maneuvers. Signal well
in advance.
Turn Signals When Towing a Trailer
When you tow a trailer, your vehicle may need a
different
turn signal flasher and/or extra wiring. Check
with your Chevrolet dealer. The green arrows on your
instrument panel will flash whenever you signal a
turn
or lane change. Properly hooked up, the trailer lamps
will also flash, telling other drivers you’re about to turn,\

change lanes or stop.
When towing a trailer, the green arrows on your
instrument panel will flash for turns even if the bulbs on
the trailer are burned out. Thus, you may think drivers
behind you are seeing your signal when they are not. It’s
important to check occasionally to be sure the trailer bulbs are still working.
4-38

Downloaded from www.Manualslib.com manuals search engine 3. Remove the lamp assembly from the vehicle by
pulling forward. Use care not to scratch the vehicle
with the lamp or the lamp with the fender.
harness and twist the bulb less than one-quarter
of a
turn to the left and remove. Gently wiggle the bulb
from the socket.
4. For the high or low-beam bulbs, unclip the wiring
5. For the turn signal bulb, press the tab on the white
bulb socket and twist it less than one-quarter
of a
turn to the left.
6. Reconnect the wiring harness to the bulb or
lamp assembly.
lining up the lamp to the mounting balls.
7. Replace the lamp to its original position by carefully
8. Press down on the two latches. Replace the splash
shield by pushing down on the retainer.
6-31

Downloaded from www.Manualslib.com manuals search engine Electrical System Headlamp Wiring
Add-on Electrical Equipment
NOTICE:
Don’t add anything electrical to your Chevrolet
unless you check with your dealer first.
Some
electrical equipment can damage your vehicle
and the damage wouldn’t be covered by your
warranty. Some add-on electrical equipment
can keep other components from working as
they should.
Your vehicle has an air bag system. Before attempting to add anything electrical to your Chevrolet, see “Servicing
Your Air Bag-Equipped Chevrolet” in the Index. The
headlamp wiring is protected by fuses, one for each
headlamp, in the fuse block.
An electrical overload will
cause the lamps to turn
off. If this happens, have your
headlamp wiring checked right away.
dshield Wipers
lne windshield wiper motor is protected by an internal
circuit breaker and a fuse.
If the motor overheats due to
heavy snow, etc., the wiper will stop until the motor
cools. If
the overload is caused by some electrical
problem and not snow, etc., be sure to get it fixed.
Power Windows and Other Power Options
Circuit breakers in the fuse block protect the power
windows and other power accessories. When
the current
load is too heavy, the circuit breaker opens and closes,
protecting the circuit until the problem
is fixed or
goes away.
6-54

Downloaded from www.Manualslib.com manuals search engine Fuses and Circuit Breakers
The wiring circuits in your vehicle are protected
from short circuits by a combination of fuses, circuit
breakers and fusible thermal links
in the wiring itself.
This greatly reduces the chance of fires caused by
electrical problems.
Look at the silver-colored band inside the fuse. If the
band is broken or melted, replace the fuse. Be sure you
replace a bad fuse with a new one
of the identical size
and rating.
If
you ever have a problem on the road and don’t have a
spare fuse, you can borrow one that has the same
amperage. Just pick a feature of your vehicle that you
can get along without
-- like the radio or cigarette
lighter
-- and use its fuse, if it is the correct amperage.
Replace it as soon as you can. Also, there are spare fuses
in the left side instrument panel door.
There are three fuse blocks in your vehicle: two
instrument panel fuse blocks and the engine
compartment fuse block.
Instrument Panel Fuse Block
The instrument panel fuse
blocks are located at each end of the instrument panel.
To access the fuses, open
the fuse panel door by
pulling out.
To replace the door, insert
the hooks at the front end
first, then push the door
in
to the instrument panel to
I secure it.
6-55

Downloaded from www.Manualslib.com manuals search engine Halogen Bulbs ................................ 6-29
Hazard Warning Flashers
.......................... 5-2
Head Restraints
................................. 1-5
Headlamps
.................................... 2-36
Bulb Replacement
............................ 6-29
High& ow Beam Changer
...................... 2-30
OnReminder
................................ 2-36
Wiring
..................................... 6-54
Hearing Impaired. Customer Assistance
.............. 8-4
Heating
........................................ 3-4
High-Beam Headlamps
.......................... 2-30
Highway Hypnosis
.............................. 4-22
Hill and Mountain Roads
......................... 4-22
Hitches. Trailer
................................. 4-36
Hood Checking Things Under
......................... 6-7
Release
...................................... 6-8
Hydroplaning
.................................. 4- 18
HOITI
......................................... 2-28
Ignition Positions
.............................. 2- 13
Ignition Transaxle Lock Check
.................... 7-40
Illuminated EntryLExit
........................... 2-39
Inflation. Tire
.................................. 6-36
Inside Daymight Rearview Mirror
................. 2-40
Brakesystem
................................ 7-41
Exhaust Systems
............................. 7-41
Front-Wheel-Drive Axle Boot
.................. 7-41
Front-Wheel-Drive Axle Seal
................... 7-41
Radiator and Heater Hose
...................... 7-41
Steering
.................................... 7-41
Inspections
.................................... 7-41 Suspension
.................................. 7-41
Instrument Panel
............................... 2-48
Cleaning
.................................... 6-47
Cluster
..................................... 2-50
FuseBlock
.................................. 6-55
Intensity Control
............................. 2-38
Interior Lamps
................................. 2-38
Throttle Linkage
.............................. 7-41
Jack. Tire
.................................... 5-22
Jump Starting
................................... 5-3
Key Lock Cylinders Service
..................... 7-38
Keyless Entry System
............................ 2-6
Battery Replacement
........................... 2-8
Operation
.................................... 2-7
Synchronization
............................... 6-9
Keys
.......................................... 2-2
Labels
....................................... 6-53
Certification
................................. 4-31
Service
Parts Identification ..................... 6-53
Tire-Loading Information
...................... 4-30
Vehicle Identification Number
................... 6-53
Exterior
.................................... 2-36
Interior
..................................... 2-38
OnReminder
................................ 2-36
Lamps
........................................ 2-36
Fog
........................................ 2-38
MirrorReading
............................... 2-39
9-5

Downloaded from www.Manualslib.com manuals search engine Underbody Hushing Service ..................... 7-40
Underbody Maintenance ......................... 6-51
Vehicle
Control
...................................... 4-6
Damage Warnings .............................. vii
Dimensions
................................. 6-62
Identification Number ......................... 6-53
Loading .................................... 4-30
Storage ..................................... 6-29
Ventilation System ............................... 3-6
Visor Vanity Mirrors ............................ 2-45
Visors. Sun .................................... 2-45
warning Devices ............................... 5-2
Warning Eights. Gages and Indicators ............... 2-52
Washer Fluid. Windshield ........................ 6-23
Washing Your Vehicle ........................... 6-48
Weatherstrips .................................. 6-48
Wheel
Alignment
.................................. 6-42
Nut Torque ............................. 5.29. 6.61
Replacement ................................. 6-42
Used Replacement ............................ 6-43
Wrench ..................................... 5-22
Windows ..................................... 2-27
Auto-Down ................................. 2-28
Lock Out Switch ............................. 2-28
Power ...................................... 2-27
Windshield Washer ............................. 2-32
Fluid .................................. 2.32. 6.23
Fluid Level Check ............................ 7-37
Windshield Wiper ......................... 2.30. 6.54
Bladecheck ................................. 7-38
Blade Replacement ........................... 6-35
Winter Driving ................................. 4-24
Wiring. Headlamp .............................. 6-54
Wrecker Towing ................................. 5-8
Wrench. Wheel ................................. 5-22
9-11