warning CHEVROLET MALIBU 2004 5.G Service Manual

Temperature – A, B, C
The temperature grades are A (the highest), B, and C,
representing the tire’s resistance to the generation
of heat and its ability to dissipate heat when tested
under controlled conditions on a specied indoor
laboratory test wheel. Sustained high temperature can
cause the material of the tire to degenerate and
reduce tire life, and excessive temperature can lead to
sudden tire failure. The grade C corresponds to a
level of performance which all passenger car tires must
meet under the Federal Motor Vehicle Safety Standard
No. 109. Grades B and A represent higher levels of
performance on the laboratory test wheel than the
minimum required by law.
Warning: The temperature grade for this tire is
established for a tire that is properly inated and not
overloaded. Excessive speed, underination, or
excessive loading, either separately or in combination,
can cause heat buildup and possible tire failure.
Wheel Alignment and Tire Balance
The wheels on your vehicle were aligned and balanced
carefully at the factory to give you the longest tire life
and best overall performance.
Scheduled wheel alignment and wheel balancing are
not needed. However, if you notice unusual tire wear or
your vehicle pulling one way or the other, the alignment
may need to be reset. If you notice your vehicle
vibrating when driving on a smooth road, your wheels
may need to be rebalanced.
Wheel Replacement
Replace any wheel that is bent, cracked or badly rusted
or corroded. If wheel nuts keep coming loose, the
wheel, wheel bolts and wheel nuts should be replaced.
If the wheel leaks air, replace it (except some
aluminum wheels, which can sometimes be repaired).
See your dealer if any of these conditions exist.
Your dealer will know the kind of wheel you need.
5-62

Changing a Flat Tire
If a tire goes at, avoid further tire and wheel damage
by driving slowly to a level place. Turn on your
hazard warning ashers.
{CAUTION:
Changing a tire can be dangerous. The vehicle
can slip off the jack and roll over or fall on you
or other people. You and they could be badly
injured or even killed. Find a level place to
change your tire. To help prevent the vehicle
from moving:
1. Set the parking brake rmly.
2. Put the shift lever in PARK (P).
3. Turn off the engine and do not restart
while the vehicle is raised.
4. Do not allow passengers to remain in
the vehicle.
CAUTION: (Continued)
CAUTION: (Continued)
To be even more certain the vehicle won’t
move, you should put blocks at the front and
rear of the tire farthest away from the one
being changed. That would be the tire, on the
other side, at the opposite end of the vehicle.
5-66

Appearance Care
Remember, cleaning products can be hazardous. Some
are toxic. Others can burst into ames if you strike a
match or get them on a hot part of the vehicle. Some are
dangerous if you breathe their fumes in a closed space.
When you use anything from a container to clean your
vehicle, be sure to follow the manufacturer’s warnings
and instructions. And always open your doors or windows
when you are cleaning the inside.
Never use these to clean your vehicle:
Gasoline
Benzene
Naphtha
Carbon Tetrachloride
Acetone
Paint Thinner
Turpentine
Lacquer Thinner
Nail Polish RemoverThey can all be hazardous — some more than
others — and they can all damage your vehicle, too.
Do not use any of these unless this manual says
you can. In many uses, these will damage your vehicle:
Alcohol
Laundry Soap
Bleach
Reducing Agents
Cleaning the Inside of Your Vehicle
Use a vacuum cleaner often to get rid of dust and
loose dirt. Wipe vinyl, leather, plastic and painted
surfaces with a clean, damp cloth.
Cleaning Fabric/Carpet
Your dealer has cleaners for the cleaning of fabric and
carpet. They will clean normal spots and stains very well.
You can get GM-approved cleaning products from
your dealer. SeeVehicle Care/Appearance Materials
on page 5-84.
5-78

A
Accessory Power Outlets.................................3-20
Adding Washer Fluid.......................................5-34
Additional Program Information........................... 7-9
Additives, Fuel................................................. 5-7
Add-On Electrical Equipment............................5-87
Adjustable Throttle and Brake Pedal..................2-24
Adjusting the Speakers
(Balance/Fade)....................3-55, 3-62, 3-73, 3-86
Air Bag
Readiness Light..........................................3-34
Air Bag Systems.............................................1-52
How Does an Air Bag Restrain?....................1-58
Servicing Your Air Bag-Equipped Vehicle.........1-60
What Makes an Air Bag Inate?....................1-58
What Will You See After an Air Bag Inates?......1-58
When Should an Air Bag Inate?...................1-57
Where Are the Air Bags?..............................1-54
Air Cleaner/Filter, Engine.................................5-22
Airbag Sensing and Diagnostic Module (SDM).......7-10
AM .............................................................3-116
Antenna, Backglass.......................................3-119
Antenna, Fixed Mast......................................3-118
Antenna, XM™ Satellite Radio Antenna
System.....................................................3-119
Anti-lock Brake System (ABS)............................ 4-7
Anti-Lock Brake, System Warning Light..............3-37Appearance Care............................................5-78
Care of Safety Belts....................................5-81
Chemical Paint Spotting...............................5-84
Cleaning the Inside of Your Vehicle................5-78
Cleaning the Outside of Your Vehicle..............5-81
Finish Damage............................................5-83
Sheet Metal Damage...................................5-83
Underbody Maintenance...............................5-84
Vehicle Care/Appearance Materials................5-84
Weatherstrips..............................................5-81
Arming the System.........................................2-18
Audio Speakers..............................................3-98
Audio System(s).............................................3-52
Audio Steering Wheel Controls....................3-115
Backglass Antenna.....................................3-119
Care of Your Cassette Tape Player...............3-117
Care of Your CD and DVD Player................3-118
Care of Your CDs and DVDs.......................3-118
Fixed Mast Antenna...................................3-118
Radio with Cassette and CD.........................3-69
Radio with CD....................................3-53, 3-58
Radio with Six-Disc CD................................3-82
Rear Seat Audio (RSA).....................3-111, 3-113
Setting the Time for Radios with Radio Data
Systems (RDS)........................................3-53
Setting the Time for Radios without Radio
Data Systems (RDS)................................3-52
1

Audio System(s) (cont.)
Theft-Deterrent Feature...............................3-115
Understanding Radio Reception...................3-116
XM™ Satellite Radio Antenna System...........3-119
Automatic Climate Control System.....................3-25
Automatic Headlamp System............................3-17
Automatic Transaxle
Fluid..........................................................5-23
Operation...................................................2-27
B
Backglass Antenna........................................3-119
Backing Up....................................................4-44
Battery..........................................................5-38
Battery Replacement......................................... 2-8
Battery Run-Down Protection............................3-20
Before Leaving on a Long Trip.........................4-23
Before You Drive............................................3-97
Brake
Parking......................................................2-29
System Warning Light..................................3-36
Brake Fluid....................................................5-35
Brake Pedal, Throttle.......................................2-24
Brake Wear...................................................5-37
Brakes..........................................................5-35
Braking........................................................... 4-6
Braking in Emergencies..................................... 4-8Break-In, New Vehicle.....................................2-22
Bulb Replacement...........................................5-45
Center High-Mounted Stoplamp (CHMSL)........5-47
Halogen Bulbs............................................5-45
Headlamps.................................................5-45
Replacement Bulbs......................................5-49
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps........................................5-47
Buying New Tires...........................................5-60
C
California Fuel.................................................. 5-6
Canada – Customer Assistance.......................... 7-5
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-7
Capacities and Specications............................5-96
Carbon Monoxide...........4-26, 4-40, 2-13, 2-15, 2-33
Care of
Safety Belts................................................5-81
Your Cassette Tape Player..........................3-117
Your CD and DVD Player...........................3-118
Your CDs and DVDs..................................3-118
Cargo Lamp...................................................3-20
Cassette Tape Messages.................................3-79
Cassette Tape Player Service............................. 6-9
CD Adapter Kits.............................................3-80
CD Messages........................3-58, 3-69, 3-82, 3-96
2

Coolant
Engine Temperature Gage............................3-39
Engine Temperature Warning Light.................3-38
Heater, Engine............................................2-25
Surge Tank Pressure Cap.............................5-26
Cooling System..............................................5-29
Cruise Control................................................3-10
Cruise Control Light........................................3-43
Cupholder(s)..................................................2-44
Current and Past Model Order Forms................7-13
Customer Assistance Information
Courtesy Transportation.................................. 7-8
Customer Assistance for Text Telephone (TTY)
Users....................................................... 7-4
Customer Assistance Offices........................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-6
Reporting Safety Defects to General Motors.......7-12
Reporting Safety Defects to the Canadian
Government............................................7-12
Reporting Safety Defects to the United States
Government............................................7-11
Roadside Assistance Program......................... 7-6
Service Publications Ordering Information........7-12D
Daytime Running Lamps (DRL).........................3-17
Defensive Driving............................................. 4-2
Defogging and Defrosting.........................3-24, 3-29
Delayed Headlamps........................................3-18
Delayed Locking.............................................2-12
Dinghy Towing................................................4-32
Disarming the System.....................................2-19
Doing Your Own Service Work........................... 5-4
Dolly Towing..................................................4-34
Dome Lamp...................................................3-19
Door
Delayed Locking..........................................2-12
Door Ajar Reminder.....................................2-12
Locks........................................................2-10
Power Door Locks.......................................2-11
Programmable Automatic Door Locks.............2-12
Driver
Position, Safety Belt.....................................1-16
Six-Way Power Seat...................................... 1-3
Driver Information Center (DIC).........................3-45
DIC Operation and Displays..........................3-46
DIC Warnings and Messages........................3-50
4

Driving
At Night.....................................................4-16
City...........................................................4-21
Defensive..................................................... 4-2
Drunken....................................................... 4-2
Freeway.....................................................4-22
Hill and Mountain Roads..............................4-24
In Rain and on Wet Roads...........................4-18
Winter........................................................4-26
Driving On Grades..........................................4-45
Driving on Snow or Ice....................................4-27
Driving Through Deep Standing Water...............4-20
Driving Through Flowing Water.........................4-20
Driving with a Trailer.......................................4-44
DVD
Cleaning the Video Screen..........................3-118
Cleaning Your DVD Player..........................3-118
Distortion..................................................3-116
Rear Seat Entertainment System...................3-96
DVD Messages.............................................3-102
DVD Player..................................................3-100
E
Electrical System
Add-On Equipment......................................5-87
Fuses........................................................5-88
Headlamp Wiring.........................................5-87Electrical System (cont.)
Power Windows and Other Power Options......5-87
Windshield Wiper Fuses...............................5-87
Electronic Range Select Mode..........................2-29
Emergency Trunk Release Handle.....................2-14
Emissions Inspection and Maintenance
Programs...................................................3-41
Engine
Air Cleaner/Filter.........................................5-22
Battery.......................................................5-38
Check and Service Engine Soon Light............3-39
Coolant......................................................5-24
Coolant Heater............................................2-25
Coolant Temperature Gage...........................3-39
Coolant Temperature Warning Light................3-38
Drive Belt Routing.......................................6-14
Engine Compartment Overview......................5-14
Exhaust.....................................................2-33
Oil .............................................................5-17
Overheating................................................5-27
Starting......................................................2-23
Engine Compartment Fuse Block......................5-91
Engine Cooling When Trailer Towing..................4-46
Engine Oil Additives........................................5-20
Enhanced Traction System (ETS)........................ 4-9
Active Light................................................3-38
Warning Light.............................................3-37
5

Gasoline
Octane........................................................ 5-5
Specications............................................... 5-6
Gate Operator and Canadian Programming........2-43
Glove Box.....................................................2-44
GM Mobility Program for Persons with
Disabilities.................................................... 7-6
H
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-6
Headlamp High/Low-Beam Changer.................... 3-9
Headlamp Wiring............................................5-87
Headlamps....................................................5-45
Bulb Replacement.......................................5-45
Halogen Bulbs............................................5-45
Headlamps Off in Park (P)...............................3-18
Headlamps On Reminder................................... 3-9
Headphones...................................................3-97
Heated Seats................................................... 1-4
Highway Hypnosis...........................................4-24
Hill and Mountain Roads..................................4-24
Hitches..........................................................4-43
HomeLink
®Transmitter....................................2-40
HomeLink®Transmitter, Programming................2-41Hood
Release.....................................................5-12
Horn............................................................... 3-7
How the System Alarm is Activated...................2-19
How to Add Coolant to the Coolant Surge Tank......5-30
How to Check................................................5-58
How to Detect a Tamper Condition....................2-19
How to Inspect the Engine Air Cleaner/Filter.......5-22
How to Turn Off the System Alarm....................2-19
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-15
Hydroplaning..................................................4-20
I
If No Steam Is Coming From Your Engine..........5-28
If Steam Is Coming From Your Engine...............5-27
If the Light is Flashing.....................................3-40
If the Light Is On Steady.................................3-41
If You Are Caught in a Blizzard.........................4-28
If You Are Stuck in Sand, Mud, Ice or Snow.......4-30
If You Do Decide To Pull a Trailer.....................4-41
Ignition Positions.............................................2-22
Infants and Young Children, Restraints...............1-34
Ination - Tire Pressure...................................5-57
Information Mode (INFO Button)........................3-46
7

Instrument Panel
Cluster.......................................................3-32
Overview..................................................... 3-4
Instrument Panel Brightness.............................3-19
Instrument Panel Fuse Block............................5-89
Interior Lamps................................................3-19
J
Jump Starting.................................................5-39
K
Keyless Entry System....................................... 2-5
Keys............................................................... 2-3
L
Lamps
Exterior......................................................3-14
Interior.......................................................3-19
Lap-Shoulder Belt...................................1-16, 1-25
LATCH System
Child Restraints...........................................1-44
Securing a Child Restraint Designed for the
LATCH System........................................1-46Leaving Your Vehicle.......................................2-13
Leaving Your Vehicle With the Engine Running......2-31
Liftgate..........................................................2-15
Liftgate Rack System
Table.........................................................2-47
Light
Air Bag Readiness.......................................3-34
Anti-Lock Brake System Warning...................3-37
Brake System Warning.................................3-36
Charging System.........................................3-35
Cruise Control.............................................3-43
Engine Coolant Temperature Warning.............3-38
Enhanced Traction System (ETS) Active Light....3-38
Enhanced Traction System (ETS) Warning
Light......................................................3-37
Malfunction Indicator....................................3-39
Oil Pressure...............................................3-42
Safety Belt Reminder...................................3-34
Security.....................................................3-43
Service Vehicle Soon...................................3-44
Loading Your Vehicle.......................................4-34
Lockout Protection..........................................2-13
Locks
Delayed Locking..........................................2-12
Door..........................................................2-10
Leaving Your Vehicle....................................2-13
Lockout Protection.......................................2-13
8

Locks (cont.)
Power Door................................................2-11
Programmable Automatic Door Locks.............2-12
Loss of Control...............................................4-15
Lumbar
Manual Controls............................................ 1-3
M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-9
At Least Once a Month.................................. 6-9
At Least Once a Year..................................6-10
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-7
Maintenance Record....................................6-15
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-13
Owner Checks and Services........................... 6-9
Recommended Fluids and Lubricants.............6-12
Scheduled Maintenance................................. 6-4
Using Your................................................... 6-3
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-46Making Turns.................................................4-45
Malfunction Indicator Light................................3-39
Manual Lumbar Controls.................................... 1-3
Manual Seats................................................... 1-2
Map Pocket...................................................2-45
Matching Transmitter(s) to Your Vehicle............... 2-7
Message
DIC Warnings and Messages........................3-50
Mexico, Central America and Caribbean
Islands/Countries (Except Puerto Rico and
U.S. Virgin Islands) – Customer Assistance....... 7-5
Mirrors
Automatic Dimming Rearview........................2-35
Automatic Dimming Rearview with OnStar
®.....2-36
Manual Rearview Mirror................................2-35
Manual Rearview Mirror with OnStar
®.............2-35
Outside Convex Mirror.................................2-37
Outside Power Heated Mirrors.......................2-37
Outside Power Mirrors..................................2-37
MyGMLink.com................................................ 7-4
N
New Vehicle Break-In......................................2-22
Normal Maintenance Replacement Parts............6-13
9