fuel CHEVROLET MALIBU 2006 6.G Service Manual

Vehicle Data Collection and Event
Data Recorders
Your vehicle, like other modern motor vehicles, has a
number of sophisticated computer systems that monitor
and control several aspects of the vehicle’s performance.
Your vehicle uses on-board vehicle computers to monitor
emission control components to optimize fuel economy,
to monitor conditions for airbag deployment and, if so
equipped, to provide anti-lock braking and to help the
driver control the vehicle in difficult driving situations.
Some information may be stored during regular
operations to facilitate repair of detected malfunctions;
other information is stored only in a crash event by
computer systems, such as those commonly called
event data recorders (EDR).
In a crash event, computer systems, such as the Airbag
Sensing and Diagnostic Module (SDM) in your vehicle
may record information about the condition of the vehicle
and how it was operated, such as data related to engine
speed, brake application, throttle position, vehicle speed,
safety belt usage, airbag readiness, airbag performance,
and the severity of a collision. This information has been
used to improve vehicle crash performance and may be
used to improve crash performance of future vehicles
and driving safety. Unlike the data recorders on many
airplanes, these on-board systems do not record sounds,
such as conversation of vehicle occupants.To read this information, special equipment is needed
and access to the vehicle or the device that stores
the data is required. GM will not access information
about a crash event or share it with others other than:with the consent of the vehicle owner or, if the
vehicle is leased, with the consent of the lessee,
in response to an official request of police or similar
government office,
as part of GM’s defense of litigation through the
discovery process, or
as required by law.
In addition, once GM collects or receives data, GM may:
use the data for GM research needs,
make it available for research where appropriate
condentiality is to be maintained and need is
shown, or
share summary data which is not tied to a specic
vehicle with non-GM organizations for research
purposes.
Others, such as law enforcement, may have access to
the special equipment that can read the information
if they have access to the vehicle or the device
that stores the data.
7-10

A
Accessories and Modications............................ 5-3
Accessory Power Outlet(s)...............................3-21
Adding Equipment to Your Airbag-Equipped
Vehicle.......................................................1-70
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-98
Adjustable Throttle and Brake Pedal..................2-25
Air Cleaner/Filter, Engine.................................5-22
Air Conditioning......................................3-22, 3-27
Airbag
Readiness Light..........................................3-35
Airbag Sensing and Diagnostic Module (SDM)....7-10
Airbag System................................................1-59
Adding Equipment to Your Airbag-Equipped
Vehicle...................................................1-70
How Does an Airbag Restrain?......................1-67
Servicing Your Airbag-Equipped Vehicle..........1-69
What Makes an Airbag Inate?......................1-67
What Will You See After an Airbag Inates?....1-68
When Should an Airbag Inate?....................1-65
Where Are the Airbags?...............................1-62
Antenna, Backglass.......................................3-108
Antenna, Fixed Mast......................................3-108Antenna, XMâ„¢ Satellite Radio Antenna
System.....................................................3-108
Anti-Lock Brake System (ABS)........................... 4-7
Anti-Lock Brake, System Warning Light..............3-37
Appearance Care
Aluminum Wheels........................................5-95
Care of Safety Belts....................................5-93
Chemical Paint Spotting...............................5-96
Cleaning Exterior Lamps/Lenses....................5-93
Cleaning the Inside of Your Vehicle................5-89
Fabric/Carpet..............................................5-90
Finish Care.................................................5-94
Finish Damage............................................5-96
Instrument Panel, Vinyl, and Other Plastic
Surfaces.................................................5-92
Leather......................................................5-91
Sheet Metal Damage...................................5-96
Tires..........................................................5-95
Ultra Lux Suede..........................................5-92
Underbody Maintenance...............................5-96
Vehicle Care/Appearance Materials................5-97
Washing Your Vehicle...................................5-93
Weatherstrips..............................................5-93
Windshield and Wiper Blades........................5-94
1

C
Calibration.............................................2-39, 2-41
California Fuel.................................................. 5-6
California Proposition 65 Warning....................... 5-3
Canadian Owners................................................ ii
Capacities and Specications..........................5-107
Carbon Monoxide...........2-15, 2-16, 2-36, 4-27, 4-42
Care of
Safety Belts................................................5-93
Your CD and DVD Player...........................3-107
Your CDs and DVDs ..................................3-107
Cargo Lamp...................................................3-20
Center Console Storage Area...........................2-50
Chains, Tire...................................................5-70
Charging System Light....................................3-36
Check
Engine Light...............................................3-41
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-96
Child Restraints
Child Restraint Systems...............................1-40
Infants and Young Children...........................1-36
Lower Anchors and Tethers for Children..........1-45
Older Children.............................................1-34
Securing a Child Restraint in a Rear Seat
Position..................................................1-54
Securing a Child Restraint in the Right Front
Seat Position...........................................1-56Child Restraints (cont.)
Where to Put the Restraint...........................1-44
Cigarette Lighter.............................................3-22
Cleaning
Aluminum Wheels........................................5-95
Exterior Lamps/Lenses.................................5-93
Fabric/Carpet..............................................5-90
Finish Care.................................................5-94
Inside of Your Vehicle..................................5-89
Instrument Panel, Vinyl, and Other Plastic
Surfaces.................................................5-92
Leather......................................................5-91
Tires..........................................................5-95
Ultra Lux Suede..........................................5-92
Underbody Maintenance...............................5-96
Washing Your Vehicle...................................5-93
Weatherstrips..............................................5-93
Windshield and Wiper Blades........................5-94
Climate Control System...................................3-22
Automatic...................................................3-27
Outlet Adjustment........................................3-31
Collision Damage Repair..................................7-11
Comfort Guides, Rear Safety Belt.....................1-30
Compact Spare Tire........................................5-88
Compass...............................................2-39, 2-41
Competitive Driving.........................................4-18
Content Theft-Deterrent....................................2-18
Control of a Vehicle.......................................... 4-5
Convenience Net............................................2-52
3

E
Electrical System
Add-On Equipment......................................5-98
Engine Compartment Fuse Block.................5-102
Fuses........................................................5-99
Headlamp Wiring.........................................5-99
Instrument Panel Fuse Block.......................5-100
Power Windows and Other Power Options......5-99
Rear Compartment Fuse Block....................5-104
Windshield Wiper Fuses...............................5-99
Engine
Air Cleaner/Filter.........................................5-22
Battery.......................................................5-42
Check and Service Engine Soon Light............3-41
Coolant......................................................5-26
Coolant Heater............................................2-26
Coolant Temperature Gage...........................3-40
Coolant Temperature Warning Light................3-40
Engine Compartment Overview......................5-12
Exhaust.....................................................2-36
Oil .............................................................5-17
Oil Life System...........................................5-20
Overheated Protection Operating Mode...........5-31
Overheating................................................5-29
Starting......................................................2-24
Enhanced Traction System (ETS)......................4-11
Active Light................................................3-39
Warning Light.............................................3-39Entry/Exit Lighting...........................................3-19
Event Data Recorders (EDR)............................7-10
Extender, Safety Belt.......................................1-34
Exterior Lamps...............................................3-14
F
Filter
Engine Air Cleaner......................................5-22
Finish Damage...............................................5-96
Fixed Mast Antenna.......................................3-108
Flashers, Hazard Warning.................................. 3-6
Flash-to-Pass................................................... 3-8
Flat Tire........................................................5-71
Flat Tire, Changing.........................................5-72
Flat Tire, Storing.............................5-82, 5-84, 5-86
Fluid
Automatic Transaxle.............................5-23, 5-24
Power Steering...........................................5-36
Windshield Washer......................................5-38
Fog Lamps ....................................................3-18
Folding Seatback, Passenger............................. 1-8
Front Reading Lamps......................................3-20
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-6
Filling a Portable Fuel Container....................5-10
Filling Your Tank........................................... 5-8
5

Fuel (cont.)
Fuels in Foreign Countries.............................. 5-7
Gage .........................................................3-46
Gasoline Octane........................................... 5-5
Gasoline Specications.................................. 5-5
Fuses...........................................................5-99
Engine Compartment Fuse Block.................5-102
Instrument Panel Fuse Block.......................5-100
Rear Compartment Fuse Block....................5-104
Windshield Wiper.........................................5-99
G
Gage
Engine Coolant Temperature.........................3-40
Fuel..........................................................3-46
Speedometer..............................................3-34
Tachometer.................................................3-34
Garage Door Opener.......................................2-46
Gasoline
Octane........................................................ 5-5
Specications............................................... 5-5
Glove Box.....................................................2-50
GM Mobility Reimbursement Program.................. 7-5
H
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-7
Headlamp Wiring............................................5-99
Headlamps
Automatic Headlamp System.........................3-17
Bulb Replacement.......................................5-47
Daytime Running Lamps...............................3-16
Delayed.....................................................3-16
Flash-to-Pass............................................... 3-8
Halogen Bulbs............................................5-47
Headlamps, Front Turn Signal, and Parking
Lamps ....................................................5-48
High/Low Beam Changer................................ 3-8
On Reminder..............................................3-16
Headlamps Off in Park (P)...............................3-16
Heated Seats................................................... 1-4
Heater...................................................3-22, 3-27
Highbeam On Light.........................................3-45
Highway Hypnosis...........................................4-25
Hill and Mountain Roads..................................4-25
Hood
Checking Things Under................................5-10
Release.....................................................5-11
Horn ............................................................... 3-6
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-19
6

Lighting
Entry/Exit...................................................3-19
Parade Dimming..........................................3-19
Loading Your Vehicle.......................................4-33
Lockout Protection..........................................2-14
Locks
Delayed Locking..........................................2-13
Door ..........................................................2-11
Lockout Protection.......................................2-14
Power Door ................................................2-12
Programmable Automatic Door Locks.............2-13
Rear Door Security Locks.............................2-14
Loss of Control...............................................4-17
Lumbar
Manual Controls............................................ 1-3
M
Maintenance Schedule
Additional Required Services........................... 6-6
At Each Fuel Fill........................................... 6-8
At Least Once a Month.................................. 6-9
At Least Once a Year.................................... 6-9
Introduction.................................................. 6-2
Maintenance Footnotes.................................. 6-7
Maintenance Record....................................6-14
Maintenance Requirements............................. 6-2
Normal Maintenance Replacement Parts.........6-13Maintenance Schedule (cont.)
Owner Checks and Services........................... 6-8
Recommended Fluids and Lubricants.............6-12
Scheduled Maintenance................................. 6-4
Using.......................................................... 6-2
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Light................................3-41
Manual Lumbar Controls.................................... 1-3
Manual Seats................................................... 1-2
Map Pocket...................................................2-50
Message
DIC Warnings and Messages........................3-50
Mirrors
Automatic Dimming Rearview with Compass....2-41
Automatic Dimming Rearview with OnStar
®.....2-38
Automatic Dimming Rearview with OnStar®
and Compass..........................................2-39
Manual Rearview Mirror................................2-38
Manual Rearview Mirror with OnStar
®.............2-38
Outside Convex Mirror.................................2-43
Outside Power Heated Mirrors.......................2-43
Outside Power Mirrors..................................2-43
MyGMLink.com................................................ 7-3
N
New Vehicle Break-In......................................2-22
Normal Maintenance Replacement Parts............6-13
8