automatic transmission CHEVROLET MALIBU 2020 Owner's Guide

Chevrolet Malibu Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13555849) - 2020 - CRC - 8/16/19
308 Service and Maintenance
Maintenance Schedule
Additional Required
Services - Severe12 000 km/7,500 mi
24 000 km/15,000 mi
36 000 km/22,500 mi
48 000 km/30,000 mi
60 000 km/37,500 mi
72 000 km/45,000 mi
84 000 km/52,500 mi
96 000 km/60,000 mi
108 000 km/67,500 mi
120 000 km/75,000 mi
132 000 km/82,500 mi
144 000 km/90,000 mi
156 000 km/97,500 mi
168 000 km/105,000 mi 180 000 km/112,500 mi
192 000 km/120,000 mi
204 000 km/127,500 mi
216 000 km/135,000 mi
228 000 km/142,500 mi
240 000 km/150,000 mi
Rotate tires and perform Required Services.
Check engine oil level and oil life percentage.
Change engine oil and filter, if needed. Check
engine air filter life percentage and status.
Change engine air filter, if needed.
@ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @ @
Replace passenger compartment air filter. (1)@ @@@@@
Inspect evaporative control system. (2)@ @@
If the vehicle is not equipped with the engine air
filter life system, replace engine air cleaner
filter. (3)@@@
Change automatic transmission fluid. (Except
1.5L engine.)@@@
Change automatic transmission fluid and filter.
(1.5L engine only.)@@@
Replace spark plugs. Inspect spark plug wires
and/or boots.@ @
Drain and fill engine cooling system and Power
Electronics cooling system. (4)@
Visually inspect accessory drive belts. (5)@
Replace brake fluid. (6)
Replace windshield wiper blades. (7)
@ @ @ @ @ @ @ @ @ @
Replace hood and/or body lift support gas
struts. (8)@ @
Replace air conditioning desiccant. (9)

Chevrolet Malibu Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13555849) - 2020 - CRC - 8/16/19
Service and Maintenance 313
Recommended Fluids, Lubricants, and Parts
Recommended Fluids and Lubricants
UsageFluid/Lubricant
Automatic Transmission (2.0L Engine) DEXRON-VI Automatic Transmission Fluid.
Automatic Transmission (1.5L Engine) Continuously Variable Ratio Transmission (CVT) Fluid. (GM Part No. 19355873, in Canada 19355874).
Engine Coolant 50/50 mixture of clean, drinkable water and use only DEX-COOL Coolant.
Engine Oil Engine oil meeting the dexos1 specification of the proper SAE viscosity
grade. ACDelco dexos1 full synthetic is recommended. See Engine Oil
0 219.
Hood Latch Assembly, Secondary Latch, Pivots, Spring Anchor, and Release Pawl Lubriplate Lubricant Aerosol (GM Part No. 89021668, in
Canada 89021674) or lubricant meeting requirements of NLGI #2 Category
LB or GC-LB.
Hydraulic Brake System DOT 3 Hydraulic Brake Fluid (GM Part No. 19353126, in Canada 19353127).
Key Lock Cylinders, Hood and Door Hinges Multi-Purpose Lubricant, Superlube (GM Part No. 12346241, in
Canada 10953474).
Weatherstrip Conditioning Weatherstrip Lubricant (GM Part No. 3634770, in Canada 10953518) or equivalent.
Windshield Washer Automotive windshield washer fluid that meets regional freeze protection requirements.

Chevrolet Malibu Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13555849) - 2020 - CRC - 8/16/19
318 Technical Data
Engine Specifications
EngineVIN CodeTransmission Spark Plug Gap
1.5L L4 Engine TAutomatic 0.60–0.70 mm (0.024–
0.028 in)
2.0L L4 Engine XAutomatic 0.75–0.90 mm (0.030–
0.035 in)
Spark plug gaps are preset by the manufacturer. Re-gapping the spark plug is not recommended and can damage
the spark plug.
Engine Drive Belt Routing
1.5L L4 Engine
2.0L L4 Engine

Chevrolet Malibu Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13555849) - 2020 - CRC - 8/16/19
340 OnStar
security, or the operation of the
vehicle or the vehicle systems.
Software updates or changes may
affect or erase data or settings that
are stored in the vehicle, such as
saved navigation destinations or
pre-set radio stations. Neither
OnStar nor GM is responsible for
any affected or erased data or
settings. These updates or changes
may also collect personal
information. Such collection is
described in the OnStar privacy
statement or separately disclosed at
the time of installation. These
updates or changes may also cause
a system to automatically
communicate with GM servers to
collect information about vehicle
system status, identify whether
updates or changes are available,
or deliver updates or changes. An
active OnStar agreement constitutes
consent to these software updates
or changes and agreement that
either OnStar or GM may remotely
deliver them to the vehicle.Privacy
The complete OnStar Privacy
Statement may be found at
www.onstar.com (U.S.),
or www.onstar.ca (Canada). We
recommend that you review it. If you
have any questions, call
1-888-4ONSTAR (1-888-466-7827)
or press
Qto speak with an
Advisor. Users of wireless
communications are cautioned that
the privacy of any information sent
via wireless cellular communications
cannot be assured. Third parties
may unlawfully intercept or access
transmissions and private
communications without consent.
OnStar - Software
Acknowledgements
Certain OnStar components include
libcurl and unzip software and other
third party software. Below are the
notices and licenses associated with
libcurl and unzip and for other third
party software please see http://
opensource.lge.com/index
www.onstar.com/us/en/ libcurl:
COPYRIGHT AND PERMISSION
NOTICE
Copyright (c) 1996 - 2010, Daniel
Stenberg, .
All rights reserved.
Permission to use, copy, modify,
and distribute this software for any
purpose with or without fee is
hereby granted, provided that the
above copyright notice and this
permission notice appear in all
copies.
THE SOFTWARE IS PROVIDED
“AS IS,”
WITHOUT WARRANTY OF
ANY KIND, EXPRESS OR
IMPLIED, INCLUDING BUT NOT
LIMITED TO THE WARRANTIES
OF MERCHANTABILITY, FITNESS
FOR A PARTICULAR PURPOSE
AND NONINFRINGEMENT OF
THIRD PARTY RIGHTS. IN NO
EVENT SHALL THE AUTHORS OR
COPYRIGHT HOLDERS BE
LIABLE FOR ANY CLAIM,
DAMAGES OR OTHER LIABILITY,
WHETHER IN AN ACTION OF
CONTRACT, TORT OR

Chevrolet Malibu Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13555849) - 2020 - CRC - 8/16/19
Index 347
Assistance Program,Roadside . . . . . . . . . . . . . . . . . . . . . . 323
Assistance Systems for Driving . . . . . . . . . . . . . . . . . . . . . . . . 188
Assistance Systems for Parking and Backing . . . . . . . . . . 183
Auto Stop
Stop/Start System . . . . . . . . . . . . 158
Automatic Door Locks . . . . . . . . . . . . . . . . . . . . . 21
Emergency Braking (AEB) . . . . 190
Headlamp System . . . . . . . . . . . . 128
Transmission . . . . . . . . . . . . . . . . . 164
Transmission Fluid . . . . . . . . . . . 222
Automatic Transmission Manual Mode . . . . . . . . . . . . . . . . . 165
Shift Lock Control Function
Check . . . . . . . . . . . . . . . . . . . . . . . 234
B
BatteryExterior Lighting BatterySaver . . . . . . . . . . . . . . . . . . . . . . . 132
Load Management . . . . . . . . . . . . 131
Power Protection . . . . . . . . . . . . . 132
Battery - North America . . . . 232, 286
Blade Replacement, Wiper . . . . . 235 Brake
Parking, Electric . . . . . . . . . . . . . . 168
System Warning Light . . . . . . . . 106
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . 230 Antilock . . . . . . . . . . . . . . . . . . . . . . . 166
Assist . . . . . . . . . . . . . . . . . . . . . . . . . 169
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 231
Parking . . . . . . . . . . . . . . . . . . . . . . . 167
Braking . . . . . . . . . . . . . . . . . . . . . . . . . 146 AutomaticEmergency (AEB) . . . . . . . . . . . 190
Braking System Front Pedestrian (FPB) . . . . . . . 191
Break-In, New Vehicle . . . . . . . . . . 155
Bulb Replacement Halogen Bulbs . . . . . . . . . . . . . . . . 238
Headlamp Aiming . . . . . . . . . . . . . 237
Headlamps . . . . . . . . . . . . . . . . . . . 238
Headlamps, Front Turn
Signal, Sidemarker, and
Parking Lamps . . . . . . . . . . . . . . 238
License Plate Lamps . . . . . . . . . 240
Taillamps, Turn Signal, Stoplamps, and
Back-up Lamps . . . . . . . . 239, 240
Buying New Tires . . . . . . . . . . . . . . . 266
C
Calibration . . . . . . . . . . . . . . . . . . . . . . . 91
California Perchlorate MaterialsRequirements . . . . . . . . . . . . . . . 213
California Proposition
65 Warning . . . . . . . . . .213, 232, 286, Back Cover
Canadian Vehicle Owners . . . . . . . . 2
Capacities and
Specifications . . . . . . . . . . . . . . . . . 317
Carbon Monoxide Engine Exhaust . . . . . . . . . . . . . . . 163
Trunk . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Winter Driving . . . . . . . . . . . . . . . . 150
Cargo Tie-Downs . . . . . . . . . . . . . . . . . . . . . . 86
Caution, Danger, and Warning . . . . 2
Center Console Storage . . . . . . . . . 86
Chains, Tire . . . . . . . . . . . . . . . . . . . . 271
Charging
Wireless . . . . . . . . . . . . . . . . . . . . . . . . 92
Charging System Light . . . . . . . . . 104
Check
Engine Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . 104

Chevrolet Malibu Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13555849) - 2020 - CRC - 8/16/19
Index 349
DrivingAssistance Systems . . . . . . . . . . 188
Better Fuel Economy . . . . . . . . . 144
Characteristics and
Towing Tips . . . . . . . . . . . . . . . . . 203
Defensive . . . . . . . . . . . . . . . . . . . . . 145
Drunk . . . . . . . . . . . . . . . . . . . . . . . . . 145
Hill and Mountain Roads . . . . . . 149
If the Vehicle is Stuck . . . . . . . . . 151
Loss of Control . . . . . . . . . . . . . . . 148
Off-Road Recovery . . . . . . . . . . . 147
Vehicle Load Limits . . . . . . . . . . . 151
Wet Roads . . . . . . . . . . . . . . . . . . . 148
Winter . . . . . . . . . . . . . . . . . . . . . . . . 150
Dual Automatic Climate Control System . . . . . . . . . . . . . . . . 137
E
Electric Parking Brake . . . . . . . . . . 168
Electric Parking Brake Light . . . . 106
Electrical Equipment,
Add-On . . . . . . . . . . . . . . . . . . . . . . . 210
Electrical System Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 243
Fuses and Circuit Breakers . . . 242
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 247 Electrical System (cont'd)
Overload . . . . . . . . . . . . . . . . . . . . . 242
Emergency OnStar . . . . . . . . . . . . . . . . . . . . . . . 336
Engine Air Cleaner/Filter . . . . . . . . . . . . . 223
Check Light (MalfunctionIndicator) . . . . . . . . . . . . . . . . . . . . 104
Compartment Overview . . . . . . . 216
Coolant Temperature
Gauge . . . . . . . . . . . . . . . . . . . . . . 101
Coolant Temperature Warning Light . . . . . . . . . . . . . . . .110
Cooling System . . . . . . . . . . . . . . . 225
Drive Belt Routing . . . . . . . . . . . . 318
Exhaust . . . . . . . . . . . . . . . . . . . . . . 163
Heater . . . . . . . . . . . . . . . . . . . . . . . . 159
Oil Life System . . . . . . . . . . . . . . . 221
Oil Pressure Light . . . . . . . . . . . . .110
Overheating . . . . . . . . . . . . . . . . . . 228
Power Messages . . . . . . . . . . . . . 120
Running While Parked . . . . . . . . 163
Starting . . . . . . . . . . . . . . . . . . . . . . . 157
Engine Air Filter Life System . . . . 223
Entry Lighting . . . . . . . . . . . . . . . . . . . 131
Equipment, Towing . . . . . . . . . . . . . 208
Event Data Recorders . . . . . . . . . . 332
Exit Lighting . . . . . . . . . . . . . . . . . . . . 131 Extended Parking . . . . . . . . . . . . . . . 162
Extender, Seat Belt . . . . . . . . . . . . . . 52
Exterior Lamp Controls . . . . . . . . . 125
Exterior Lamps Off Reminder . . . 127
Exterior Lighting Battery
Saver . . . . . . . . . . . . . . . . . . . . . . . . . 132
F
Filter,Engine Air Cleaner . . . . . . . . . . . 223
Flash-to-Pass . . . . . . . . . . . . . . . . . . . 127
Flashers, Hazard Warning . . . . . . 128
Flat Tire . . . . . . . . . . . . . . . . . . . . . . . . 271 Changing . . . . . . . . . . . . . . . . . . . . . 280
Floor Mats . . . . . . . . . . . . . . . . . . . . . . 300
Fluid Automatic Transmission . . . . . . 222
Brakes . . . . . . . . . . . . . . . . . . . . . . . . 231
Washer . . . . . . . . . . . . . . . . . . . . . . . 229
Folding Mirrors . . . . . . . . . . . . . . . . . . 27
Forward Collision Alert (FCA) System . . . . . . . . . . . . . . . . . 188
Frequency Statement Radio . . . . . . . . . . . . . . . . . . . . . . . . . 329
Front Pedestrian Braking (FPB) System . . . . . . . . . . . . . . . . . 191
Front Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 35

Chevrolet Malibu Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13555849) - 2020 - CRC - 8/16/19
354 Index
RoofSunroof . . . . . . . . . . . . . . . . . . . . . . . . . 30
Rotation, Tires . . . . . . . . . . . . . . . . . . 265
Routing, Engine Drive Belt . . . . . . 318
Running the Vehicle While Parked . . . . . . . . . . . . . . . . . . . . . . . . 163
S
Safety Defects ReportingCanadian Government . . . . . . . . 331
General Motors . . . . . . . . . . . . . . . 331
U.S. Government . . . . . . . . . . . . . 330
Safety Locks . . . . . . . . . . . . . . . . . . . . . 21
Safety System Check . . . . . . . . . . . . 52
Scheduling Appointments . . . . . . . 325
Sealant Kit, Tire . . . . . . . . . . . . . . . . 273
Seat Belts . . . . . . . . . . . . . . . . . . . . . . . 45 Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
Extender . . . . . . . . . . . . . . . . . . . . . . . . 52
How to Wear Seat BeltsProperly . . . . . . . . . . . . . . . . . . . . . . . 47
Lap-Shoulder Belt . . . . . . . . . . . . . . 49
Reminders . . . . . . . . . . . . . . . . . . . . 102
Replacing after a Crash . . . . . . . . 53
Use During Pregnancy . . . . . . . . . . 51
Seats
Adjustment, Front . . . . . . . . . . . . . . . 35
Head Restraints . . . . . . . . . . . . . . . . 33 Seats (cont'd)
Heated and Ventilated Front . . . . 41
Heated, Rear . . . . . . . . . . . . . . . . . . . 45
Lumbar Adjustment, Front . . . . . . 36
Memory . . . . . . . . . . . . . . . . . . . . . . . . . 38
Power Adjustment, Front . . . . . . . 36
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Reclining Seatbacks . . . . . . . . . . . . 36
Securing Child Restraints . . . . 80, 82
Security
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . 111
OnStar . . . . . . . . . . . . . . . . . . . . . . . 337
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 24
Vehicle Alarm . . . . . . . . . . . . . . . . . . . 24
Service . . . . . . . . . . . . . . . . . . . . . . . . . 142 Accessories andModifications . . . . . . . . . . . . . . . . 213
Climate Control System . . . . . . . 134
Doing Your Own Work . . . . . . . . 214
Maintenance Records . . . . . . . . 315
Maintenance, General
Information . . . . . . . . . . . . . . . . . . 302
Parts Identification . . . . . . . . . . . . 316
Scheduling Appointments . . . . . 325
Service Electric Parking Brake Light . . . . . . . . . . . . . . . . . . . . 107
Services Special Application . . . . . . . . . . . 309 Servicing the Airbag . . . . . . . . . . . . . 64
Shift Lock Control Function
Check, Automatic
Transmission . . . . . . . . . . . . . . . . . . 234
Shifting Into Park . . . . . . . . . . . . . . . . . . . . . . 160
Out of Park . . . . . . . . . . . . . . . . . . . 161
Side Blind Zone Alert (SBZA) . . . 193
Signals, Turn and Lane-Change . . . . . . . . . . . . . . . . . 129
Spare Tire
Compact . . . . . . . . . . . . . . . . . . . . . . 285
Special Application Services . . . . 309
Specifications and Capacities . . . . . . . . . . . . . . . . . . . . . 317
Speedometer . . . . . . . . . . . . . . . . . . . . 99
StabiliTrak
OFF Light . . . . . . . . . . . . . . . . . . . . . 109
Start Assist, Hill . . . . . . . . . . . . . . . . . 169
Start Vehicle, Remote . . . . . . . . . . . 16
Starter Switch Check . . . . . . . . . . . 234
Starting the Engine . . . . . . . . . . . . . 157
Steering . . . . . . . . . . . . . . . . . . . . . . . . 146 Heated Wheel . . . . . . . . . . . . . . . . . . 89
Wheel Adjustment . . . . . . . . . . . . . . 89
Wheel Controls . . . . . . . . . . . . . . . . . 89
Stop/Start System . . . . . . . . . . . . . . 158

Chevrolet Malibu Owner Manual (GMNA-Localizing-U.S./Canada/Mexico-
13555849) - 2020 - CRC - 8/16/19
Index 355
Stoplamps and Back-up LampsBulb Replacement . . . . . . . 239, 240
Storage Areas Center Console . . . . . . . . . . . . . . . . . 86
Convenience Net . . . . . . . . . . . . . . . 86
Glove Box . . . . . . . . . . . . . . . . . . . . . . 85
Umbrella . . . . . . . . . . . . . . . . . . . . . . . . 86
Storage Compartments . . . . . . . . . . 85
Storing the Tire Sealant and Compressor Kit . . . . . . . . . . . . . . . 279
Struts
Gas . . . . . . . . . . . . . . . . . . . . . . . . . . . 236
Stuck Vehicle . . . . . . . . . . . . . . . . . . . 151
Summer Tires . . . . . . . . . . . . . . . . . . 252
Sun Visors . . . . . . . . . . . . . . . . . . . . . . . 30
Sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . 3
System Engine Air Filter Life . . . . . . . . . . 223
Forward CollisionAlert (FCA) . . . . . . . . . . . . . . . . . . 188
Infotainment . . . . . . . . . . . . . 133, 334
Systems Driver Assistance . . . . . . . . . . . . . 182
T
Tachometer . . . . . . . . . . . . . . . . . . . . . . 99 Taillamps
Bulb Replacement . . . . . . . 239, 240
Text Telephone (TTY) Users . . . . 322
Theft-Deterrent Systems . . . . . . . . . 25 Immobilizer . . . . . . . . . . . . . . . . . . . . . 25
Time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . 250 All-Season . . . . . . . . . . . . . . . . . . . . 251
Buying New Tires . . . . . . . . . . . . . 266
Chains . . . . . . . . . . . . . . . . . . . . . . . . 271
Changing . . . . . . . . . . . . . . . . . . . . . 280
Compact Spare . . . . . . . . . . . . . . . 285
Designations . . . . . . . . . . . . . . . . . 254
Different Size . . . . . . . . . . . . . . . . . 268
If a Tire Goes Flat . . . . . . . . . . . . 271
Inspection . . . . . . . . . . . . . . . . . . . . 264
Low Profile . . . . . . . . . . . . . . . . . . . 251
Pressure . . . . . . . . . . . . . . . . . 257, 259
Pressure Light . . . . . . . . . . . . . . . . .110
Pressure Monitor Operation . . 260
Pressure Monitor System . . . . . 259
Rotation . . . . . . . . . . . . . . . . . . . . . . 265
Sealant andCompressor Kit . . . . . . . . . . . . . 273
Sealant and Compressor
Kit, Storing . . . . . . . . . . . . . . . . . . 279
Sidewall Labeling . . . . . . . . . . . . . 252
Terminology and Definitions . . 255 Tires (cont'd)
Uniform Tire Quality
Grading . . . . . . . . . . . . . . . . . . . . . 268
Wheel Alignment and Tire
Balance . . . . . . . . . . . . . . . . . . . . . 270
Wheel Replacement . . . . . . . . . . 270
When It Is Time for New Tires . . . . . . . . . . . . . . . . . . . . . . . . 266
Winter . . . . . . . . . . . . . . . . . . . . . . . . 251
Top Tier Fuel . . . . . . . . . . . . . . . . . . . 198
Towing Driving Characteristics . . . . . . . . 203
Equipment . . . . . . . . . . . . . . . . . . . . 208
General Information . . . . . . . . . . 202
Recreational Vehicle . . . . . . . . . . 289
Trailer . . . . . . . . . . . . . . . . . . . . . . . . 206
Vehicle . . . . . . . . . . . . . . . . . . . . . . . 289
Traction
Control System(TCS)/StabiliTrak Light . . . . . . 109
Off Light . . . . . . . . . . . . . . . . . . . . . . 108
Traction Control/Electronic Stability Control . . . . . . . . . . . . . . . 170
Trailer Towing . . . . . . . . . . . . . . . . . . . . . . . . 206
Transmission Automatic . . . . . . . . . . . . . . . . . . . . . 164
Fluid, Automatic . . . . . . . . . . . . . . 222