check engine light CHEVROLET MONTE CARLO 1981 4.G Owner's Manual

Downloaded from www.Manualslib.com manuals search engine FUSES AND CIRCUIT BREAKER
The wiring circuits in yoUr 198 -1 Chevrolet are protected from short circuits by
a
combination of fuses, circllit breakers, and fusible thermal links in the
wiring itself. This greatly reduces the hazard of electrically caused fires in the
automobile. The fuse junction block is located under the left side of the
instrument panel .
The headlight
wiring is protected by a circuit bre a ker in the light switch . An
electrical overload
will cause the lights to go on and off, or in some cases to
remain off. If this happens, have your headlight wiring checked right away.
Be sides a fuse , the windshield wiper
motor is also protected by a circuit
breaker .
If the motor overheats, due to over load ing caused by heavy snow,
etc
., the wiper will remain stopped until the motor cools. Be sure to have th';·
cause of the overloading corrected.
Also , a
circuit breaker , on the f~se. panel, protects the power window, power
seat , rear
window defogger (elec.) and oth'9rcircuits when vehicle is so
equipped. Where current load is too heavy , the circuit breaker intermittently
opens and. c loses , protecting the circu it until the cause is found and
eliminated.
Fuses, located in th .e Junction Block beneath the dash on the
driver'S side are:
Fuses
Instrument Lamp , Heater Dial, Audio Alarm ........................ 5 Amp
Electronic Control Module. . . . . . . . . . . . . . . . . . . 10 Amp Cru ise Control ,Rear Defogger , Gages , Warning
Lamps, Warning Buzzers, Closed Loop
......................... 20 Amp
License , Parking
Lamp, Sidemarker Lamps, Tail Lamp ............. 20 Amp
Heater ,
AIC ................................. _ ................... 25 Amp
W iS Wiper ..... · ................................................. 25 Amp Stop Lamp ,Hazard Lamp, Courtesy Light, Dome Light,
Glove
Box Light , Underhond Light ............................. 20 Amp
Luggage Lamp, Lighter, Clock, Key .Warning Buzz er, Dome & .
Read Light, Power Antenna , Closed Loop ....................... 20 Amp
Radio, Delay Wiper ,
Idle Stop Sol. .............. _ ................. 10 Amp
Back-up Lamps, Dir.
S ig. Lamps ................................. 20 Amp
Choke Heater ............. .............. _ ............... ........ 20 Amp
7·3

Downloaded from www.Manualslib.com manuals search engine AJt Cleaner. Ail CoricIitionor FOlK Season .. Mainten ance .. AM" Pressu-e. Tires. AM" Vents. Alterna tOf tGEN) l.ghl AUniIlUffi Cafe .. AM or AM-FM Radios Antenna Antifreeze . Appearaoc e Care . Ash1rays & Lignler s. Assistance. Owl"lef Automat ic Door Locks. Automatic Transmission CorwElfter ClUlch Maintenanr;e
"""'-OpefaJ .... '1 TiPS.: AKIe. Re ar Standard . lifnited-SHp . Babies. AesCraint 01 .. BaIt Joints .. fun..., E mergency S ta ring F reedom. Gas Caution ..• GEN 191I... .•.• Test Indicator ...
. ........ 5-9
2-24
5-11
5-12
2-23 ....... 2·17 ... 2:27. 2-28 2·29 (Seo "Coolant") ,.,
2·22 6·' ,.,
2·10 5-5 .. 2 -9 2 ·'
5 ·'
5·' 1·10. ,-" . 5·1 0
3 ·' 5-10 3·' 2-17 5·10 Betore Dr iving Your Vehide... \. Bells: Sea!....,.. . (See I'Se at Belts") Blower, Healer & Air Cond.. 2-24. 2-25
Body Da mage . 4-4
.. """ ~,. Pedal Travel Trailer Towing .... Warning Ught .
2·14 2-\4 H2 2-17
Breakers . <;ircui t. • ..... 2-21. 7·3 Bteak ..... Period. New Vehicle ..• 2·2 Srioj'!( Headlights 2·7. 2·21 Brighl Metal Cleaning 4-4
Bulbs & Fuses.. 7·3. 7-4 Bumpers & HiIC:·~s. '·13 ~ 'Jack Operation ...... 3-4 B.w:ers._ . (See "'SOunds'" CoirpJler Con"mand Cont rOl System:~ 2·\8, 5·3 Cop Coolant A ecovery Tant.: .. ................. , .. 5-6 F uel.. 5-2 f>o¥Iier Steefing.. _____ -._ ....... ...... 0<. _____ -5-9 Radiator ... 5·8 Capacity, Cargo Weight. 5-11 Capacities. FlUid:. 7- Car Break-In Period . New.. 2-2 . car -Chemicals ... carbon Monoxide cautJorI .... ___ 4·' 2·' Care & Cleaning. Appearance . . .. 4·' Cargo Capacity . 5-11 Cargo on Root . Carrying,. '·2 Catalytic Converter . . ..................... ....... 5-2 ~ Command Control System .. -2·18. , ·3 Chains. Tire .. 5·15
7-6
Changing Wheets & Tires .. _ Cl-£O< ENGtl'E light .. Chectlbt, DrillSf . Child Seals & Restr ainls Chrome Protection .. ag.yette lighter ... CirCUIt Beakers QtiZOtlS Band Raoio . C!earIing .. Clock.I .. Cloth Trim Care .. ClutCh . Converter
Cold W&ather Starting ....
3 ·4 . 3·5 2 ·18. 5-3 ,., I -tO. 1·11 ... 2·22 2·21 , 7·3 2·29 . ..... 4·' 2-22 '·2 2·10 2·8 ~ip""lt Plocedu.-e . . ... 6 ·1
Condi lioner, Air (See "All" Cooditioner"~ Cons umer Relation s ... Converter ClUtch Con...eJo: Mirror Cooling System Afltilreeze (CooIanI) .. Overheating R ecovery Tank Service,. Thermoslal . COfl"lefing Lights . CorTosion Pmlection. Countries. Oper-ating in Fo.-eign .. Courtesy lights CruISe Control Cus!omer Service . 5·6
3·3
3 ·4 ,
5·6 '·7 '·8 2·7 . . 4-5 2· ' 2·30
2·12
6·' Damage, Sheet Metal . 4·4 Detogger,Re..-WiNJoW.. 2-25 DelrOSlor. Windshield . 2·24. 2·25 Delay Wipers 2·20 Descending a· Grade 2-9 Ditlererlliai (Rear Axle) limited·Slip __ 5·9 ,Malt)l~O 5 ·9
Trailllfing. 1·1 2
Dimensions 7· , Oimn'\e( Switch, Head~L 2·14 O ipshCks A.utomalic Tfansmission .. . 5-4 Engine Oil 5·3 Power Steering. 5-9 Directional Signals.. 2-7 Disc Brakes 2·15 Door loc::ks . __ ................ 1-2 Orivet' Checklist 1-1 Driving Down S teep Grades .... 2-9 in OU'sty Areas . 5 .... on Slippery Surlaces .................... 2·9 Economy ripS. Fuel .............................. 2-4 E lectric· Po_oo QpIion$ .. (See "Power"') Electrical System Banerv .. S-1 0 Bulbs .. . ....... ...... .... ........... 7,4 Circuit Breakers ....... , ........................ , 7-3 Fuses:. 7·3 GEN (Genefalor) lighI ..................... 2· 17 Jump S tarting 3- Spark Plugs 7-2 Voltmeter . 2·19 Emetgency. In Case oj Bralle WCIIllWlg li!1Il .. Eroglne Hot light .. • .. 2·17 . 2·17

Downloaded from www.Manualslib.com manuals search engine Freeing Vehicle When Stuck . Hazard Warnong FlaSher Jacking Jump Starti ng
Towing: Cru EtIlIssion Caution EmISSic:m Control
3·9 3·' 3·4, 3'5
C ata lytic Conve rter 5-2 ~te< Command ContrOl System 2·18. ; ·3 CHECK ENGINE ligh t Exha ust Ga s Caution
F uel Requ irements (Gas) E",,~
2·18. 5·3 ,., , .,
... " Break -In Code Coo~ng
(See Ma intenance Schedule) 2·2 , .; ;·6 El ,.,
.. , 2·9 ,.,
(See "Fuel") ' ·5 . .. 3·1 Ideflti hcation Jump Starting . C>r Overheating . Spec~fcations Starling . Cold WeaHJeI Star ting (Gasoline) Temperature Gage Tempera ture 19h1 Thermostat E OOIN E ligh!
{See ··Oir . . EllIjne··) 3·3 ,., ,.,
'·6 2·t9 2· 17 5·6 2·t8 El"9oo Oil. (See ·'Oi l. E'ngine.') E thylene Glycot Antifree ze
E)(hausl Gas Cau tion E~~. System , If'Ispection. Ederior Fnsh Care .
Fabric Care
Fan,
Healer & Air Cond FASTEN SEAT BELTS Light. . Fastener s. RepIacemeflI .. Fifter s
Air Cleal'lEl!' . , Finish Care. Firish Damage . Flammable C\e.aoets .. .. F lashers Hazard w arning . Turn Signal..
Flooded EngIne . Starling . Floor Controls .. F luid Capacities .. FM Radios .. Folding Seats ...
5·' ,.,
, .,
... . 4·4 ,., 2-24. 2·25 '·6 5 ·'
;., ,., ,., . . • -1
3·.1 ..... 2:7 . ....... , 2·9 ......... 2·13 ..... ..... 7·1
F Ofeign CounlrllltS . Operation in ... FOUl' Season Ioit ~ . Four·WayHazard FlasheI' ... Freedom Battery .. Freeirig Car When Stt.JCk.". , .... Cop . Economy Tips .. Gogo Gasohol .. a...... Octane RaIing ..
;., , ., . 2 ·15 . '. ..... 2-3 ....... .. . 2-3
7 ·7
Overse3$ OpefatiOtl _. Tanl( Capacity Fuse
Cha rt
Circuit Breakers ...
""'" Engrne Temperat lJ'e
Fuel.. Oil Prossure Tachometef (Engille $peed) Voltmetet' , .. Gasoline
GEN (Gener ator) Light
Glas s Clea ning
Gto"e 80)( Guard AQaIIlSl Theft Hazar d Warning Flasher Headlight s Circuil &eakel IJimmtIf Switc h
instrument Pa~ SWitch Light s ON Reminder .. Head Restraint s .. tEAT Light. Heated Rear Wmdow .
2·' ,.,
'·3 '·3
2-1 9 2-15 2·19 2·18
2· 19
(See "Fuer') 2-\7 ..,
2-16 ,.,
3'
.7-3 2,14 2--?1
2-21
'·5 2·17 2·25 Heat er/Air Condihoner2·23. 2-24 High ·Beam Head~ghl!i 2-2t _ 1·13 5·10 . (Inside Back Colter) 5·10. !Inside Sack Cover)
Hitches. Traile( . Hood Latches .. Hood Release . Horn .. HOT UghL Ideotihcation Nt.mbers 19r>ilion K9YS Lock . In Case of EIT1efgenc:y .nocator lights ... Infant Seats & Aestra.nt .. II1l1ati04'l Pressure. Tires. Inlets . Air.
2-t3 2·t7 7.·5
,.,
2·' ,., (See "UghIS") 1 ·10. r_ll 5·12 2·23 Inside Rearview Muror , '-3 Instrumetl t Pan&! & Controts .. 2·15 InleilOl Appe«i¥1Ce Care.. 4-1 Interior & inst rumen t Lights (See "Lights" ) Jacl:: Operation & Stowage.. 3- 4. 3 ·5 . 3-6 ~ S\aI1ing .. 3- 1 Keys...... '·1 Lane Ct\ange &. Turn Signals 2-7 Lap- Shoulcler Belts . (See "Seat Bells") L_
,_­Hood ...
,..
(Inside 8acto: Cover) Sealback. From. 1-4 Trunk . 2-22 lighter. Cigarette ... 2·22 ligh<' BRAKE .... ...................... .................. 2·1 7
Bright s On. !lui> c.... O£CI( ENGINE Choke Warning .. Comoring .................. . CouttKY·· ClimrneI-Swoi1ch. HNdigflt .. Electrical S)Stem (GEN) ..
2-21 ,..
2·18.,5·2 2-17 .. ....... 2-7 '·30 2-1. 2-11

Downloaded from www.Manualslib.com manuals search engine SERVICE STATION INFORMATION
Refer to "Service and Maintenance,"
Section 5 for Further Details
Fuel Cap -Localed behind the license plate.
See fuel cap removal procedl,lre on page 5-1.
Fuel Requirements -Use unleaded gasoline only. See "Fuel Requirements "
in "Starting and Operating. " Section 2 of this manual.
Hood Release - Located beneath the instrument panel to the left of the
steering column. To open, pull the handle to release the hood lock. Then push down slightly on the hood while lifting the underhood lever , and raise the hood. (See illustration).
Engine Oil Oipstiek-Located on right or left side of engine block depending on engine model. Check the engine oil level when the oil is warm, such as during a fuel stop. Keep the oil level above the "Add " line on the dipstick .
Engine Oil Recommendation (Gasoline Engine) -Use only SF-quality oils. (See "Service and Maintenance," Section 50f this manuaL) The chart on page 5·5 will serve as a guide for choosing the proper viscosity oil.
Tire Inflation. Pressures -Check at least monthly (including the spare, unless it is a stowaway spare). Keep them inflated to pressures shown on
the Tire Placard on the left door. (Keep compact spare tires inflated to 415 kPa or 60 psL)
Engine Cooling System -Check the fluid level in the "see·through " coolant recovery tank at regular intervals , such as during a fuel stop. (See "Engine Cooling System " in "Service and Maintenance, " Section 5 of this manual.
Windshield Washer -Check reservoir fluid level regularly. Use a washer fluid, such as GM Optikleen .
Battery -Your new car has a Delco FREE[X)M It battery. You will never have
to add water. The hydror:neter (test indicator) in ,the cover provides infor­mation for testing purposes only.