wheel torque CHEVROLET MONTE CARLO 1996 5.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine 8. Lower the vehicle by turning the jack handle
counterclockwise. Lower the jack completely.
9. Tighten the wheel nuts
firmly
in a crisscross
sequence as shown.
Incorrect wheel nuts or improperly tightened
wheel nuts can cause the wheel to become loose
and even come off. This could lead to an accident.
Be sure to use the correct wheel nuts.
If you have
to replace them, be sure to get new
GM original
equipment wheel nuts.
Stop somewhere as soon as you can and have the
nuts tightened with a torque wrench to
100 lb-ft
(140 Nom).

Downloaded from www.Manualslib.com manuals search engine Storing the Flat Tire and Tools
NOTICE:
Improperly tightened wheel nuts can lead to
brake pulsation and rotor damage.
To avoid
expensive brake repairs, evenly tighten the wheel
nuts in the proper sequence and to the proper
torque specification.
10. Don't try to put a wheel cover on your compact spare
tire, It won't
fit. Store the wheel cover in the trunk
until you have the flat tire repaired or replaced.
I NOTICE:
Wheel covers won't fit on your compact spare. If
you try to put a wheel cover on your compact
spare, you could damage the cover or the spare.
I
' A CAUTI(
I
Storing a jack, a tire or other equipment in the
passenger compartment
of the vehicle could
cause injury. In
a sudden stop or collision, loose
equipment could strike someone. Store all these
in the proper place.
After you've put the compact spare tire on your vehicle
you'll need to store the flat tire in your trunk. Use the
following procedure to secure the flat tire in the trunk.
Put the flat tire in the trunk
so the side that faces out
when it is on the vehicle is facing down. The full-size
tire will not fit down into the well. Place
it so the front is
in the well and the rear is out of the well.
5-30

Downloaded from www.Manualslib.com manuals search engine I NOTICE:
Continuing to drive with worn-out brake pads
could result in costly brake repair.
Some driving conditions or climates may cause a brake
squeal when the brakes are first applied or lightly applied.
This does
not mean something is wrong with your brakes.
Free movement
of brake calipers and properly torqued
wheel nuts are necessary to help prevent brake
pulsation. When tires are rotated, inspect brake calipers
for movement, brake pads for wear, and evenly torque
wheel nuts in the proper sequence to
GM specifications.
Brake linings should always be replaced
as complete
axle sets.
Brake Pedal Travel
See your dealer if the brake pedal does not return to
normal height, or if there is a rapid increase
in pedal
travel. This could be
a sign of brake trouble.
Brake Adjustment
Every time you apply the brakes, with or without the
vehicle moving, your brakes adjust for wear.
Replacing Brake System Parts
The braking system on a modern vehicle is complex.
Its many parts have to be
of top quality and work well
together
if the vehicle is to have really good braking.
Vehicles we design and test have top-quality
GM brake
parts in them,
as your Chevrolet does when it is new.
When you replace parts
of your braking system -- for
example, when your brake linings wear down and you
have to have new ones put
in -- be sure you get new
genuine
GM replacement parts. If you don’t, your
brakes may no longer work properly. For example, if
someone puts in brake linings that are wrong for your
vehicle, the balance between your front and rear brakes
can change
-- for the worse. The braking performance
you’ve come to expect can change in many other ways
if
someone puts in the wrong replacement brake parts.
Battery
Every new Chevrolet has a Delco Freedom@ battery.
You never have to add water to one
of these. When
it’s time for
a new battery, we recommend a Delco
Freedom@ battery. Get one
that has the replacement
number shown on the original battery’s label.
6-28

Downloaded from www.Manualslib.com manuals search engine After the tires have been rotated, adjust the front and
rear inflation pressures as shown on the Tire-Loading
Information label. Make certain that all wheel nuts are properly tightened. See “Wheel Nut Torque” in
I1 the Index.
I
When It’s Time for New Tires
(
Rust or dirt on a wheel, or on the parts to which
it is fastened, can make wheel nuts become loose
after
a time. The wheel could come off and cause
an accident. When you change a wheel, remove
any rust or
dirt from places where the wheel
attaches to the vehicle. In an emergency, you can
use a cloth or a paper towel to do this; but be
sure to use a scraper
or wire brush later, if you
need to, to get all the rust or dirt off. (See
‘(Changing
a Flat Tire? in the Index.)
One way to tell when it’s
time for new tires is to
check the treadwear indicators, which will appear when your tires have
only 1/16 inch (1.6
mm) or
less of tread remaining.
You need a new tire if any of the following statements
are true:
You can see the indicators at three or more places
around the tire.
You can see cord or fabric showing through the
tire’s rubber.
The tread or sidewall is cracked, cut or snagged deep
enough to show cord or fabric.
0 The tire has a bump, bulge or split.
The tire has a puncture, cut or other damage that
can’t be repaired well because of the size or location
of the damage.
6-39

Downloaded from www.Manualslib.com manuals search engine Thermostat .................................... 6-23
Tilt Steering Wheel
............................. 2-24
Time. Setting the
................................ 3-5
TireLoading
................................... 4-26
Tire-Loading Information Label
................... 4-26
BuyingNew
................................. 6-40
Tire Chains
.................................... 6-43
Tires
......................................... 6-36
Alignment
and Balance ........................ 6-42
Chains
..................................... 6-43
Changing a Flat
.............................. 5-22
Cleaning
.................................... 6-50
Compact Spare
............................... 5-33
Inflation
.................................... 6-37
Inflation Check
............................... 7-36
Inspection and Rotation
........................ 6-38
Loading
.................................... 4-26
Pressure
.................................... 6-37
Storing the Flat
............................... 5-30
Storing the Spare
............................. 5-32
Temperature
................................. 6-4 I
Traction .................................... 6-41
Treadwear
................................... 6-41
Uniform Quality Grading
....................... 6-40
Wear Indicators
.............................. 6-39
Wheel Replacement
........................... 6-42
When It’s Time for New
....................... 6-39
TopStrap
..................................... 1-33
TorqueLock
................................... 2-20
Torque, Wheel
Nut .............................. 5-29
TowingaTrailer
................................ 4-28
Towing Your Vehicle
............................. 5-7 Trailer
Brakes
Driving
Driving
Hitches
..................................... 4-32
onGrades
............................ 4-33
with ................................. 4-32
..................................... 4-31
Maintenance When Towing
..................... 4-34
Parking on Hills
.............................. 4-34
Safety Chains
................................ 4-31
Tongueweight
............................... 4-30
Total Weight on Tires
.......................... 4-31
Towing
..................................... 4-28
TurnSignals
................................. 4-33
Weight
..................................... 4-30
Transaxle Fluid. Automatic
....................... 6-16
Transmitters. Remote Lock Control
.................. 2-4
Transportation. Courtesy
.......................... 8-6
Trip Odometer
................................. 2-41
Trunk
......................................... 2-6
Lock
........................................ 2-6
Release. Remote
............................... 2-7
TTYUsers ..................................... 8-3
Turn Signal and Lane Change Signals
............... 2-25
Turn Signal/Multifunction Lever
................... 2-24
Turn Signals When Towing
a Trailer ................ 4-33
Underbody Flushin, o Service ..................... 7-39
Underhood Electrical Center
................. 6-56. 6-58
Underbody Maintenance
......................... 6-50
9-9

Downloaded from www.Manualslib.com manuals search engine ..
I
Vehicle Wheel
.................................. Control ...................................... 4-5 .. Alignment 6-42 ... u......... Damage Warnings .............. ; ................. vii
Nut Torque ................................... 5-29
Dimensions
................................. 6-63 Replacement .................................. 6-42
Identification Number
......................... 6-52
Wrench ...................................... 5-24
Loading
.................................... 4-26 Windows ............................ :: ....... 2-23 .
Storage ..................................... 6-29 Auto-Down ................................. 2-23
Ventilation System
............................... 3-3 Pnwer ........................................ 2-23
Visors, Sun
.................................... 2-37
..
Visor Vanity Mirrors ............................ 2-37 ...............
Windshield Washer 2-26 ..............................
Fluid .................................. 2-26, 6-24
~
Fluid Level Check ............................ 7-36
Windshield Wiper
.............................. 2-26
Rlad~ Renlwkment ........................... 6-36
warning
Devices ............................... 5-2 ... ........ Warning Lights. Gages and Indicators 2-42 Fuses .............................. 1 ........ 6-53'
Washing Your Vehicle
; 6-48 Winter Driving ., 4-22
Weatherstrips
.................................. 6-48 Wrecker Towing ........................ ; 5-7
.. Wrench, Wheel ...... ., .............. : ............. 5-24
Y1UU .. =" .......... ~ ~ ............... Washer Fluid, Windshield ........................ 6-24 ....... .......................... ..................... ..... Wiring, Headlamp ................................ 6-53
..........
9-10