power steering CHEVROLET MONTE CARLO 2004 User Guide

Fuses Usage
CIG/AUXAccommodated Device
(Accessory)
BCM Body Control Module (Accessory)
SRS Supplemental Restraint System
ABS/PCMAnti-Lock Brake System,
Powertrain Control Module,
Brake Switch, Crank Relay,
Canister Vent Solenoid
(Run, Crank)
STOPBrake Lamps, Body Control
Module (Run, Crank)
TURN SIGNAL Turn Signal Flashers
CRUISECruise Control Steering
Column Controls
AC/CRUISEHVAC Temp Door Motors &
Module, Cruise Control Module
A/C FAN HVAC Blower
STR COL Steering Wheel LightingFuses Usage
DR LKBody Control Module,
Door Lock Controls
PWR MIR Power Mirrors
CLSTR/BCMCluster, Body Control Module,
Data Link Connector (Battery)
LH HTD ST/BCMDriver’s Heated Seat, Body
Control Module, Battery
controlled Loads
Circuit Breakers Usage
RETAINED
ACCESSORY
PWR BRKRPower Windows,
Sunroof Breaker
Relays Usage
RETAINED
ACCESSORY
PWR RELAYRetained Accessory Power Relay
HEADLAMP
RELAYHeadlamp Relay
5-105

Service25,000
(41 500)50,000
(83 000)75,000
(125 000)100,000
(166 000)125,000
(207 500)150,000
(240 000)
Replace spark plugs. Inspect spark
plug wires.An Emission Control
Service.•
Engine cooling system service
(or every 5 years, whichever occurs
rst).An Emission Control Service.
See footnote (i).•
Inspect engine accessory drive belt.
An Emission Control Service.•
Maintenance Footnotes
†The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
(a)Visually inspect brake lines and hoses for proper
hook-up, binding, leaks, cracks, chang, etc. Inspect
disc brake pads for wear and rotors for surface
condition. Inspect other brake parts, including calipers,
parking brake, etc.(b)Visually inspect front and rear suspension and
steering system for damaged, loose or missing parts or
signs of wear. Inspect power steering lines and
hoses for proper hook-up, binding, leaks, cracks,
chang, etc.
(c)Visually inspect hoses and have them replaced if they
are cracked, swollen or deteriorated. Inspect all pipes,
ttings and clamps; replace with genuine GM parts as
needed. To help ensure proper operation, a pressure test
of the cooling system and pressure cap and cleaning the
outside of the radiator and air conditioning condenser is
recommended at least once a year.
6-7

Recommended Fluids and
Lubricants
Fluids and lubricants identied below by name, part
number or specication may be obtained from your
dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets GM
Standard GM6094M and displays
the American Petroleum Institute
Certied for Gasoline Engines
starburst symbol. To determine the
proper viscosity for your vehicle’s
engine, seeEngine Oil on
page 5-18.
Engine Coolant50/50 mixture of clean, drinkable
water and use only
DEX-COOL
®Coolant. SeeEngine
Coolant on page 5-31.
Hydraulic Brake
SystemDelco Supreme 11 Brake Fluid or
equivalent DOT-3 brake uid.
Windshield
Washer SolventGM Optikleen
®Washer Solvent.
Power Steering
SystemGM Power Steering Fluid
(GM Part No. U.S. 89021184, in
Canada 89021186).
Usage Fluid/Lubricant
Automatic
TransaxleDEXRON®-III Automatic
Transmission Fluid.
Key Lock
CylindersMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
SuperchargerSupercharger Oil (GM Part No. U.S.
12345982, in Canada 10953513).
SeeSupercharger Oil on page 5-24.
Hood Latch
Assembly,
Secondary
Latch, Pivots,
Spring Anchor
and Release
PawlLubriplate Lubricant Aerosol
(GM Part No. U.S. 12346293, in
Canada 992723) or lubricant
meeting requirements of NLGI #2,
Category LB or GC-LB.
Hood and Door
HingesMulti-Purpose Lubricant, Superlube
(GM Part No. U.S. 12346241, in
Canada 10953474).
Weatherstrip
ConditioningDielectric Silicone Grease
(GM Part No. U.S. 12345579, in
Canada 992887).
6-12

A
Accessory Power Outlets.................................3-19
Adding Washer Fluid.......................................5-48
Additional Program Information.........................7-10
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment...........................5-103
Adjusting the Speakers
(Balance/Fade)............................3-59, 3-70, 3-81
Air Bag
Readiness Light..........................................3-34
Air Bag Systems.............................................1-48
How Does an Air Bag Restrain?....................1-54
Servicing Your Air Bag-Equipped Vehicle.........1-56
What Makes an Air Bag Inate?....................1-54
What Will You See After an Air Bag Inates?......1-55
When Should an Air Bag Inate?...................1-53
Where Are the Air Bags?..............................1-51
Air Cleaner/Filter, Engine.................................5-26
Airbag Sensing and Diagnostic Module (SDM)....7-10
ALARM (Content Theft Operation).....................2-47
AM ...............................................................3-93
Antenna, Backglass.........................................3-95
Antenna, XM™ Satellite Radio Antenna System.....3-96
Anti-lock Brake System (ABS)............................ 4-7
Anti-Lock Brake, System Warning Light..............3-37Appearance Care............................................5-94
Care of Safety Belts....................................5-97
Chemical Paint Spotting..............................5-100
Cleaning the Inside of Your Vehicle................5-94
Cleaning the Outside of Your Vehicle..............5-97
Finish Damage............................................5-99
Sheet Metal Damage...................................5-99
Underbody Maintenance.............................5-100
Vehicle Care/Appearance Materials...............5-100
Weatherstrips..............................................5-97
Arming with the Power Lock Switch...................2-15
Arming with the Remote Keyless Entry
Transmitter.................................................2-16
Ashtrays........................................................3-20
Audio System(s).............................................3-55
Audio Steering Wheel Controls......................3-92
Backglass Antenna......................................3-95
Care of Your Cassette Tape Player................3-93
Care of Your CD Player...............................3-95
Care of Your CDs........................................3-94
Chime Level Adjustment...............................3-96
Radio with Cassette.....................................3-56
Radio with Cassette and CD.........................3-78
Radio with CD............................................3-67
Setting the Time..........................................3-55
Theft-Deterrent Feature................................3-91
1

Flash-to-Pass Feature....................................... 3-9
Flat Tire........................................................5-81
Flat Tire, Changing.........................................5-82
Fluid
Automatic Transaxle.....................................5-28
Power Steering...........................................5-47
Windshield Washer......................................5-48
FM Stereo.....................................................3-93
FOB PROG (Remote Keyless Entry Transmitter
Programming).............................................2-50
FOB HORN
(Remote Audible Verication)..........................2-46
FOB LIGHT (Remote Visual Verication)..............2-45
Fog Lamps....................................................3-16
Folding Rear Seat............................................ 1-8
Following Distance..........................................4-42
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-43
Gasoline Octane........................................... 5-4Fuel (cont.)
Gasoline Specications.................................. 5-5
Low Warning Message.................................3-50
Fuses
Fuses and Circuit Breakers.........................5-104
Windshield Wiper.......................................5-103
G
Gage
Engine Coolant Temperature.........................3-38
Fuel..........................................................3-43
Speedometer..............................................3-32
Tachometer.................................................3-33
Voltmeter Gage...........................................3-35
Garage Door Opener.......................................2-36
Gasoline
Octane........................................................ 5-4
Specications............................................... 5-5
Gate Operator and Canadian Programming........2-38
Glove Box.....................................................2-40
GM Mobility Program for Persons with
Disabilities.................................................... 7-6
6

H
Hazard Warning Flashers................................... 3-6
Head Restraints............................................... 1-6
Headlamp
Aiming.......................................................5-60
Headlamp High/Low-Beam Changer.................... 3-8
Headlamp Wiring...........................................5-103
Headlamps
Bulb Replacement.......................................5-60
Halogen Bulbs............................................5-60
Headlamps, Front Turn Signal, Sidemarker,
and Parking Lamps..................................5-60
Heated Outside Mirrors....................................2-33
Heated Seats................................................... 1-4
Heating.........................................................3-23
Highbeam Out Warning Message......................3-51
Highway Hypnosis...........................................4-24
Hill and Mountain Roads..................................4-24
Hitches..........................................................4-41
HomeLink
®Transmitter....................................2-36
HomeLink®Transmitter, Programming................2-36
Hood
Checking Things Under................................5-10
Release.....................................................5-10
Horn............................................................... 3-7
Hot Coolant Temperature Warning Message........3-45
How to Add Coolant to the Coolant
Recovery Tank............................................5-39How to Add Coolant to the Radiator..................5-42
How to Add Fluid............................................5-30
How to Check........................................5-28, 5-73
How to Check and Add Oil...............................5-25
How to Check Power Steering Fluid..................5-48
How to Inspect the Engine Air Cleaner/Filter.......5-26
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-15
Hydroplaning..................................................4-20
I
If No Steam Is Coming From Your Engine..........5-36
If Steam Is Coming From Your Engine...............5-35
If the Light Is Flashing.....................................3-40
If the Light Is on Steady..................................3-40
If You Are Caught in a Blizzard.........................4-28
If You Are Stuck in Sand, Mud, Ice or Snow.......4-30
If You Do Decide To Pull A Trailer.....................4-39
Ignition Positions.............................................2-17
Illumination on Remote Activation........................ 2-6
Infants and Young Children, Restraints...............1-31
Ination - Tire Pressure...................................5-72
Instrument Panel
Cluster.......................................................3-29
Overview..................................................... 3-4
Instrument Panel Brightness.............................3-16
7

Power (cont.)
Six-Way Seats.............................................. 1-3
Steering Fluid.............................................5-47
Windows....................................................2-14
Power Steering...............................................4-12
Programmable Automatic Door Locks.................. 2-9
Programmable Modes....................................... 2-9
Programming Mode.........................................2-42
Programming the HomeLink
®Transmitter...........2-36
Q
Questions and Answers About Safety Belts.........1-15
R
Radiator Pressure Cap....................................5-34
Radio Data System (RDS)...............3-56, 3-67, 3-78
Radio Messages.............................3-61, 3-72, 3-83
Radios..........................................................3-55
Care of Your Cassette Tape Player................3-93
Care of Your CD Player...............................3-95
Care of Your CDs........................................3-94
Radio with Cassette.....................................3-56
Radio with Cassette and CD.........................3-78
Radio with CD............................................3-67
Setting the Time..........................................3-55
Theft-Deterrent............................................3-91Radios (cont.)
Understanding Reception..............................3-93
RDS Messages..............................3-60, 3-71, 3-82
Reading Lamps..............................................3-18
Rear Safety Belt Comfort Guides......................1-26
Rear Seat Passenger Positions.........................1-23
Rear Seat Passengers, Safety Belts..................1-23
Rear Storage Area..........................................2-40
Rear Window Defogger....................................3-25
Rearview Mirror, Automatic Dimming..................2-32
Rearview Mirror, Automatic Dimming with
OnStar
®.....................................................2-32
Rearview Mirror with OnStar®...........................2-31
Rearview Mirrors.............................................2-31
Reclining Seatbacks.......................................... 1-4
Recommended Fluids and Lubricants.................6-12
Recreational Vehicle Towing.............................4-31
Remote Keyless Entry System............................ 2-3
Remote Keyless Entry System, Operation............ 2-4
Remote Trunk Release....................................2-11
Removing the Flat Tire and Installing
the Spare Tire.............................................5-86
Removing the Spare Tire and Tools...................5-83
Removing the Wheel Covers and the Wheel Nut
Caps.........................................................5-85
Replacement Bulbs.........................................5-63
Replacing Brake System Parts..........................5-53
Replacing Restraint System Parts After a Crash.....1-58
11

Seats
Easy Entry Seat............................................ 1-7
Head Restraints............................................ 1-6
Heated Seats............................................... 1-4
Manual........................................................ 1-2
Manual Lumbar............................................. 1-3
Reclining Seatbacks...................................... 1-4
Seatback Latches.......................................... 1-6
Six-Way Power Seats.................................... 1-3
Split Folding Rear Seat.................................. 1-8
Securing a Child Restraint
Designed for the LATCH System...................1-42
Rear Seat Position......................................1-43
Right Front Seat Position..............................1-45
Selecting Outside Air or Recirculation................3-22
Selecting the Fan Speed..................................3-22
Service........................................................... 5-3
Adding Equipment to the Outside of Your
Vehicle..................................................... 5-4
Doing Your Own Work................................... 5-3
Engine Soon Light.......................................3-39
Message....................................................3-49
Publications Ordering Information...................7-13
Traction System Warning Message.................3-44
Vehicle Soon Message.................................3-51
Service Bulletins.............................................7-13
Service Manuals.............................................7-13
Setting Preset Stations....................3-58, 3-69, 3-80
Setting the Time.............................................3-55Setting the Tone (Bass/Treble)..........3-59, 3-70, 3-81
SETTINGS (Display Current Settings)................2-43
Sheet Metal Damage.......................................5-99
Shifting Into Park (P).......................................2-26
Shifting Out of Park (P)...................................2-28
Skidding........................................................4-16
Some Other Rainy Weather Tips.......................4-20
Special Fabric Cleaning Problems.....................5-95
Specications, Capacities...............................5-110
Speedometer..................................................3-32
Split Folding Rear Seat..................................... 1-8
Starting Your 3400 V6 Engine...........................2-18
Starting Your 3800 Series II V6 Engine..............2-19
Starting Your Engine.......................................2-18
Steering........................................................4-12
Steering in Emergencies..................................4-13
Steering Tips..................................................4-12
Steering Wheel Controls, Audio.........................3-92
Storage Areas
Center Console Storage Area........................2-40
Convenience Net.........................................2-40
Glove Box..................................................2-40
Rear Storage Area.......................................2-40
Storing the Flat Tire and Tools..........................5-91
Storing the Spare Tire and Tools.......................5-92
Stuck in Sand, Mud, Ice or Snow......................4-30
Sun Visors.....................................................2-14
Sunroof.........................................................2-41
13

W
Warning Lights, Gages and Indicators................3-28
Warnings
Hazard Warning Flashers............................... 3-6
Other Warning Devices.................................. 3-6
Safety and Symbols......................................... iii
Vehicle Damage.............................................. iv
Washer Fluid Low Warning Message.................3-49
Washing Your Vehicle......................................5-97
Weight of the Trailer........................................4-40
Weight of the Trailer Tongue.............................4-40
What Kind of Engine Oil to Use........................5-20
What Kind of Oil to Use..................................5-25
What to Do with Used Oil................................5-24
What to Use..........................................5-32, 5-48
Wheels
Alignment and Tire Balance..........................5-79
Replacement...............................................5-79
When to Add Engine Oil..................................5-19
When to Change Engine Oil
(GM Oil Life System)...................................5-22
When to Check......................................5-24, 5-72
When to Check and Change............................5-28
When to Check Power Steering Fluid................5-47
When to Inspect the Engine Air Cleaner/Filter.....5-26When You Are Ready to Leave After Parking
on a Hill.....................................................4-44
Where to Put the Restraint...............................1-38
Why Safety Belts Work....................................1-12
Windows.......................................................2-13
Power........................................................2-14
Windshield Washer.........................................3-10
Fluid..........................................................5-48
Windshield Wiper
Blade Replacement......................................5-64
Fuses......................................................5-103
Windshield Wipers............................................ 3-9
Winter Driving................................................4-26
X
XM™ Satellite Radio Antenna System................3-96
XM™ Satellite Radio Service
(48 Contiguous US States) . . . 3-56, 3-67, 3-78, 3-93
Y
Your Vehicle and the Environment....................... 6-2
16