warning CHEVROLET OPTRA 2005 1.G Service Manual

Compact Spare Tire
Although the compact spare tire was fully inflated when
your vehicle was new, it can lose air after a time.
Check the inflation pressure regularly. It should be
60 psi (420 kPa).
After installing the compact spare on your vehicle, you
should stop as soon as possible and make sure
your spare tire is correctly inflated. The compact spare
is made to perform well at speeds up to 50 mph
(80 km/h), so you can finish your trip and have your
full-size tire repaired or replaced where you want.
Of course, it is best to replace your spare with a full-size
tire as soon as you can. Your spare will last longer
and be in good shape in case you need it again.
Notice:When the compact spare is installed, do
not take your vehicle through an automatic car wash
with guide rails. The compact spare can get
caught on the rails. That can damage the tire and
wheel, and maybe other parts of your vehicle.
Do not use your compact spare on other vehicles.
And do not mix your compact spare tire or wheel with
other wheels or tires. They will not fit. Keep your
spare tire and its wheel together.
Notice:Tire chains will not t your compact spare.
Using them can damage your vehicle and can
damage the chains too. Do not use tire chains on
your compact spare.
Appearance Care
Cleaning products can be hazardous. Some are toxic.
Other cleaning products can burst into flames if a match
is struck near them or if they get on a hot part of the
vehicle. Some are dangerous if their fumes are inhaled
in an enclosed space. When anything from a container
is used to clean the vehicle, be sure to follow the
manufacturer’s warnings and instructions. Always open
the doors or windows of the vehicle when cleaning
the inside.
Never use these to clean the vehicle:
•Gasoline
•Benzene
•Naphtha
•Carbon Tetrachloride
•Acetone
•Paint Thinner
•Turpentine
•Lacquer Thinner
•Nail Polish Remover
They can all be hazardous — some more than
others —and they can all damage the vehicle, too.
5-66

A
Accessory Power Outlets.................................3-18
Adding Equipment to Your Airbag-Equipped
Vehicle.......................................................1-62
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-75
Air Cleaner/Filter, Engine.................................5-17
Air Conditioning..............................................3-21
Airbag
Passenger Status Indicator...........................3-30
Readiness Light..........................................3-29
Airbag Sensing and Diagnostic Module (SDM)...... 7-9
Airbag System................................................1-48
Adding Equipment to Your Airbag-Equipped
Vehicle...................................................1-62
How Does an Airbag Restrain?......................1-55
Passenger Sensing System...........................1-58
Servicing Your Airbag-Equipped Vehicle..........1-62
What Makes an Airbag Inflate?......................1-55
What Will You See After an Airbag Inflates?....1-56
When Should an Airbag Inflate?....................1-53
Where Are the Airbags?...............................1-51
Antenna, Backglass.........................................3-54
Anti-Lock Brake System (ABS)........................... 4-6
Anti-Lock Brake, System Warning Light..............3-33Appearance Care............................................5-66
Aluminum Wheels........................................5-71
Chemical Paint Spotting...............................5-73
Cleaning Exterior Lamps/Lenses....................5-70
Fabric/Carpet..............................................5-67
Finish Care.................................................5-70
Finish Damage............................................5-72
Glass Surfaces............................................5-69
Instrument Panel.........................................5-69
Interior Plastic Components...........................5-69
Leather......................................................5-68
Sheet Metal Damage...................................5-72
Tires..........................................................5-72
Underbody Maintenance...............................5-73
Vehicle Care/Appearance Materials................5-74
Vinyl..........................................................5-68
Washing Your Vehicle...................................5-69
Weatherstrips..............................................5-69
Windshield and Wiper Blades........................5-71
Ashtrays........................................................3-19
Audio System(s).............................................3-42
Audio Steering Wheel Controls......................3-52
Backglass Antenna......................................3-54
Care of Your CD Player...............................3-53
Care of Your CDs........................................3-53
Radio with CD....................................3-42, 3-46
Understanding Radio Reception.....................3-53
1

Automatic Transaxle
Fluid..........................................................5-19
Operation...................................................2-21
B
Backglass Antenna..........................................3-54
Battery..........................................................5-33
Before Leaving on a Long Trip.........................4-20
Brake
Anti-Lock Brake System (ABS)........................ 4-6
Emergencies................................................ 4-8
Parking......................................................2-27
System Inspection.......................................6-23
System Warning Light..................................3-32
Brakes..........................................................5-30
Braking........................................................... 4-5
Braking in Emergencies..................................... 4-8
Break-In, New Vehicle.....................................2-18
Bulb Replacement...........................................5-38
Center High-Mounted Stoplamp (CHMSL)........5-42
Fog Lamps.................................................5-40
Front Turn Signal and Parking Lamps.............5-39
Halogen Bulbs............................................5-38
Headlamp Aiming........................................5-37
Headlamps.................................................5-38Bulb Replacement (cont.)
Replacement Bulbs......................................5-43
Sidemarker Lamps.......................................5-41
Taillamps, Turn Signal, Stoplamps and
Back-up Lamps........................................5-42
Turn Signal Lamps......................................5-40
Buying New Tires...........................................5-54
C
California Fuel.................................................. 5-5
Canadian Owners................................................ ii
Capacities and Specifications............................5-82
Carbon Monoxide...........2-11, 2-13, 2-31, 4-23, 4-35
Care of
Your CD Player...........................................3-53
Your CDs ...................................................3-53
Center High-Mounted Stoplamp (CHMSL)...........5-42
Center Rear Passenger Position, Safety Belts.....1-24
Chains, Tire...................................................5-57
Charging System Light....................................3-32
Check
Engine Light...............................................3-36
Checking Things Under the Hood......................5-10
Chemical Paint Spotting...................................5-73
2

Engine (cont.)
Engine Compartment Overview......................5-12
Exhaust.....................................................2-31
Oil .............................................................5-14
Overheating................................................5-23
Starting......................................................2-19
Event Data Recorders (EDR)............................. 7-9
Extender, Safety Belt.......................................1-24
Exterior Lamps...............................................3-15
F
Filter
Engine Air Cleaner......................................5-17
Finish Damage...............................................5-72
Flash-to-Pass.................................................3-10
Flat Tire........................................................5-58
Flat Tire, Changing.........................................5-59
Flat Tire, Storing.............................................5-65
Fluid
Automatic Transaxle.....................................5-19
Manual Transaxle........................................5-19
Power Steering...........................................5-28
Windshield Washer......................................5-29
Fog Lamp Light..............................................3-39
Fog Lamps............................................3-16, 5-40Front Armrest Storage Area..............................2-36
Front Storage Area.........................................2-36
Fuel............................................................... 5-5
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-41
Gasoline Octane........................................... 5-5
Gasoline Specifications.................................. 5-5
Low Warning Light.......................................3-41
System Inspection.......................................6-23
Fuses
Engine Compartment Fuse Block...................5-79
Fuses and Circuit Breakers...........................5-76
Instrument Panel Fuse Block.........................5-77
Windshield Wiper.........................................5-76
G
Gage
Engine Coolant Temperature.........................3-35
Fuel..........................................................3-41
Speedometer..............................................3-28
Tachometer.................................................3-28
5

Gasoline
Octane........................................................ 5-5
Specifications............................................... 5-5
Glove Box.....................................................2-35
GM Mobility Reimbursement Program.................. 7-5
H
Hazard Warning Flashers................................... 3-8
Head Restraints............................................... 1-6
Headlamp
Aiming.......................................................5-37
Headlamp Wiring............................................5-76
Headlamps....................................................5-38
Bulb Replacement.......................................5-38
Daytime Running Lamps...............................3-15
Flash-to-Pass..............................................3-10
Front Turn Signal and Parking Lamps.............5-39
Halogen Bulbs............................................5-38
High/Low Beam Changer..............................3-10
On Reminder..............................................3-15
Sidemarker Lamps.......................................5-41
Turn Signal Lamps......................................5-40
Heater...........................................................3-21
Highbeam On Light.........................................3-40
Highway Hypnosis...........................................4-21
Hill and Mountain Roads..................................4-21Hold Mode Light.............................................3-35
Hood
Checking Things Under................................5-10
Release.....................................................5-10
Horn............................................................... 3-8
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-13
Hydraulic Clutch.............................................5-19
I
Ignition Positions.............................................2-18
Infants and Young Children, Restraints...............1-27
Inflation -- Tire Pressure..................................5-51
Inspection
Brake System.............................................6-23
Engine Cooling System................................6-23
Exhaust System..........................................6-23
Fuel System...............................................6-23
Part C - Periodic Maintenance.......................6-22
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-22
Throttle System...........................................6-23
Instrument Panel
Brightness..................................................3-17
Cluster.......................................................3-26
Overview..................................................... 3-4
6

J
Jump Starting.................................................5-34
K
Keyless Entry System....................................... 2-3
Keys............................................................... 2-2
L
Labelling, Tire Sidewall....................................5-46
Lamps
Dome........................................................3-17
Exterior......................................................3-15
Fog ...................................................3-16, 5-40
Map ..........................................................3-18
LATCH System
Child Restraints...........................................1-39
Securing a Child Restraint Designed for the
LATCH System........................................1-41
Liftgate..........................................................2-13
Light
Airbag Readiness........................................3-29
Anti-Lock Brake System Warning...................3-33
Brake System Warning.................................3-32Light (cont.)
Charging System.........................................3-32
Cruise Control.............................................3-39
Daytime Running Lamps Indicator..................3-40
Door Ajar...................................................3-40
Fog Lamp..................................................3-39
Highbeam On.............................................3-40
Hold Mode.................................................3-35
Low Fuel Warning.......................................3-41
Malfunction Indicator....................................3-36
Oil Pressure...............................................3-38
Passenger Airbag Status Indicator..................3-30
Safety Belt Reminder...................................3-29
Safety Belt Reminder Tone...........................3-29
Speed Sensitive Power Steering (SSPS)
Warning Light..........................................3-34
TCS Warning Light......................................3-34
Traction Control System (TCS) Warning..........3-34
Trunk Ajar..................................................3-40
Loading Your Vehicle.......................................4-28
Lockout Protection..........................................2-11
Locks
Central Door Unlocking System....................... 2-9
Door........................................................... 2-8
Lockout Protection.......................................2-11
Power Door.................................................. 2-9
Rear Door Security Locks.............................2-10
7

Long Trip/Highway Scheduled Maintenance........6-13
Loss of Control...............................................4-13
Low Fuel Warning Light...................................3-41
Lumbar
Manual Controls............................................ 1-4
M
Maintenance, Normal Replacement Parts............5-83
Maintenance Schedule
At Each Fuel Fill.........................................6-18
At Least Once a Month................................6-18
At Least Once a Year..................................6-19
At Least Twice a Year..................................6-18
Brake System Inspection..............................6-23
Engine Cooling System Inspection.................6-23
Exhaust System Inspection...........................6-23
Fuel System Inspection................................6-23
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-13
Maintenance Requirements............................. 6-2
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-18
Part C - Periodic Maintenance Inspections......6-22Maintenance Schedule (cont.)
Part D - Recommended Fluids
and Lubricants.........................................6-24
Part E - Maintenance Record........................6-26
Selecting the Right Schedule.......................... 6-5
Short Trip/City Scheduled Maintenance............. 6-6
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..........................6-22
Throttle System Inspection............................6-23
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Malfunction Indicator Light................................3-36
Manual Lumbar Controls.................................... 1-4
Manual Seats............................................1-2, 1-3
Manual Transaxle
Fluid..........................................................5-19
Operation...................................................2-25
Manual Windows............................................2-15
Map Lamps....................................................3-18
Mirrors
Manual Rearview Mirror................................2-33
Outside Convex Mirror.................................2-34
Outside Heated Mirrors................................2-34
Outside Manual Mirrors................................2-33
Outside Power Mirrors..................................2-34
MyGMLink.com................................................ 7-3
8

N
New Vehicle Break-In......................................2-18
Normal Maintenance Replacement Parts............5-83
O
Odometer......................................................3-28
Odometer, Trip...............................................3-28
Off-Road Recovery..........................................4-11
Oil
Engine.......................................................5-14
Pressure Light.............................................3-38
Older Children, Restraints................................1-25
Online Owner Center........................................ 7-3
Other Warning Devices...................................... 3-8
Outlet Adjustment............................................3-24
Outside
Convex Mirror.............................................2-34
Heated Mirrors............................................2-34
Manual Mirrors............................................2-33
Power Mirrors.............................................2-34
Owners, Canadian............................................... ii
P
Park (P)
Shifting Into................................................2-28
Shifting Out of............................................2-29
Parking
Brake........................................................2-27
Over Things That Burn.................................2-31
Parking Your Vehicle.......................................2-30
Part A - Scheduled Maintenance Services............ 6-4
Part B - Owner Checks and Services................6-18
Part C - Periodic Maintenance Inspections..........6-22
Part D - Recommended Fluids and Lubricants....6-24
Part E - Maintenance Record...........................6-26
Passenger Airbag Status Indicator.....................3-30
Passenger Compartment Air Filter.....................3-24
Passenger Sensing System..............................1-58
Passing.........................................................4-12
Power
Accessory Outlets........................................3-18
Door Locks.................................................. 2-9
Electrical System.........................................5-76
Steering Fluid.............................................5-28
Windows....................................................2-15
Pretensioners, Safety Belt................................1-24
9

Safety Belts
Center Rear Passenger Position....................1-24
Driver Position............................................1-14
How to Wear Safety Belts Properly................1-13
Questions and Answers About Safety Belts.....1-13
Rear Seat Passengers.................................1-21
Right Front Passenger Position......................1-21
Safety Belt Extender....................................1-24
Safety Belt Use During Pregnancy.................1-21
Safety Belts Are for Everyone......................... 1-8
Shoulder Belt Height Adjuster........................1-20
Safety Warnings and Symbols.............................. iii
Seats
Driver Seat Tilt Adjuster................................. 1-3
Head Restraints............................................ 1-6
Manual..................................................1-2, 1-3
Manual Lumbar............................................. 1-4
Rear Seat Operation...................................... 1-7
Reclining Seatbacks...................................... 1-4
Securing a Child Restraint
Designed for the LATCH System...................1-41
Rear Seat Position......................................1-41
Right Front Seat Position..............................1-43
Selecting the Right Schedule, Maintenance.......... 6-5
Service........................................................... 5-3
Adding Equipment to the Outside of
Your Vehicle.............................................. 5-5Service (cont.)
Doing Your Own Work................................... 5-4
Engine Soon Light.......................................3-36
Publications Ordering Information...................7-11
Servicing Your Airbag-Equipped Vehicle..............1-62
Sheet Metal Damage.......................................5-72
Shifting Into Park (P).......................................2-28
Shifting Out of Park (P)...................................2-29
Short Trip/City Scheduled Maintenance................ 6-6
Shoulder Belt Height Adjuster...........................1-20
Signals, Turn and Lane-Change........................3-10
Spare Tire
Installing....................................................5-61
Removing...................................................5-60
Storing.......................................................5-65
Specifications, Capacities.................................5-82
Speed Sensitive Power Steering (SSPS)
Warning Light.............................................3-34
Speedometer..................................................3-28
Starting Your Engine.......................................2-19
Steering.......................................................... 4-9
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..............................6-22
Steering Wheel Controls, Audio.........................3-52
Steering Wheel, Tilt Wheel................................. 3-9
11

Storage Areas................................................2-35
Convenience Net.........................................2-37
Cupholder(s)...............................................2-35
Front Armrest Storage Area...........................2-36
Front Storage Area......................................2-36
Glove Box..................................................2-35
Rear Seat Armrest.......................................2-37
Roof Rack Provisions...................................2-37
Sunglasses Storage Compartment..................2-36
Stuck in Sand, Mud, Ice or Snow......................4-27
Sun Visors.....................................................2-16
Sunroof.........................................................2-38
T
Tachometer....................................................3-28
Taillamps
Turn Signal, Stoplamps and Back-up Lamps....5-42
TCS Warning Light..........................................3-34
Theft-Deterrent System....................................2-16
Theft-Deterrent Systems...................................2-16
Throttle System Inspection...............................6-23
Tilt Adjuster, Driver Seat.................................... 1-3
Tilt Wheel........................................................ 3-9
Time .............................................................3-20Tires.............................................................5-45
Aluminum Wheels, Cleaning..........................5-71
Buying New Tires........................................5-54
Chains.......................................................5-57
Changing a Flat Tire....................................5-59
Cleaning....................................................5-72
Compact Spare Tire.....................................5-66
If a Tire Goes Flat.......................................5-58
Inflation -- Tire Pressure...............................5-51
Inspection and Rotation................................5-52
Installing the Spare Tire................................5-61
Removing the Flat Tire.................................5-61
Removing the Spare Tire and Tools...............5-60
Storing a Flat or Spare Tire and Tools............5-65
Tire Sidewall Labelling..................................5-46
Tire Terminology and Definitions....................5-48
Uniform Tire Quality Grading.........................5-55
Wheel Alignment and Tire Balance.................5-56
Wheel Replacement.....................................5-56
When It Is Time for New Tires......................5-53
Top Strap......................................................1-35
Top Strap Anchor Location...............................1-36
Towing
Recreational Vehicle.....................................4-33
Towing a Trailer..........................................4-35
Your Vehicle...............................................4-33
12