maintenance schedule CHEVROLET OPTRA 5 2007 1.G User Guide

Every 90,000 Miles (150 000 km):Fuel Filter
Replacement.
Every 150,000 Miles (240 000 km):Cooling
System Service.
These intervals only summarize maintenance
services. Be sure to follow the complete scheduled
maintenance on the following pages.
Long Trip/Highway Denition
Follow this scheduled maintenanceonlyif none of
the conditions from the Short Trip/City Scheduled
Maintenance are true. Do not use this schedule
if the vehicle is driven in a dusty area or used off
paved roads. Use the Short Trip/City schedule
for these conditions.
Driving a vehicle with a fully warmed engine
under highway conditions will cause engine oil to
break down slower.
Long Trip/Highway Intervals
Every 7,500 Miles (12 500 km):Engine Oil and
Filter Change and Engine Oil Pan Drain Plug
Washer Replacement (or every 12 months,
whichever occurs first). Tire Rotation.
Every 15,000 Miles (25 000 km):Engine Air
Cleaner Filter Inspection. Passenger Compartment
Air Filter Replacement. Drive Belt(s) Inspection.
Every 30,000 Miles (50 000 km):Engine Air
Cleaner Filter Replacement. Spark Plug
Replacement. EVAP System Service. PCV
System Service. Timing Belt Inspection.
Brake/Clutch Fluid Change (or 24 months,
whichever occurs first).
Every 60,000 Miles (100 000 km):Spark Plug
Wire Replacement. Timing Belt Replacement.
EVAP System Solenoid Valve Replacement.
Every 90,000 Miles (150 000 km):Fuel Filter
Replacement.
Every 150,000 Miles (240 000 km):Cooling
System Service.
These intervals only summarize maintenance
services. Be sure to follow the complete scheduled
maintenance on the following pages.
360

Short Trip/City Scheduled
Maintenance
The services shown in this schedule up to
100,000 miles (166 000 km) should be repeated
after 100,000 miles (166 000 km) at the same
intervals for the life of this vehicle. The services
shown at 150,000 miles (240 000 km) should be
repeated at the same interval after 150,000 miles
(240 000 km) for the life of this vehicle.
SeePart B: Owner Checks and Services on
page 374andPart C: Periodic Maintenance
Inspections on page 380.
Footnotes
†The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that
the failure to perform this maintenance item will not
nullify the emission warranty or limit recall liability
prior to the completion of the vehicle’s useful life.
We, however, urge that all recommended
maintenance services be performed at the indicated
intervals and the maintenance be recorded.
+A good time to check your brakes is during
tire rotation. See Brake System Inspection
on page 381.
3,000 Miles (5 000 km)
❑Change engine oil and filter and replace engine
oil pan drain plug washer (or every 3 months,
whichever occurs first).An Emission Control
Service.
6,000 Miles (10 000 km)
❑Change engine oil and filter and replace engine
oil pan drain plug washer (or every 3 months,
whichever occurs first).An Emission Control
Service.
❑Rotate tires. SeeTire Inspection and Rotation
on page 316for proper rotation pattern and
additional information.(See footnote +.)
9,000 Miles (15 000 km)
❑Change engine oil and filter and replace engine
oil pan drain plug washer (or every 3 months,
whichever occurs first).An Emission Control
Service.
361

Long Trip/Highway Scheduled
Maintenance
The services shown in this schedule up to
100,000 miles (166 000 km) should be repeated
after 100,000 miles (166 000 km) at the same
intervals for the life of this vehicle. The services
shown at 150,000 miles (240 000 km) should be
repeated at the same interval after 150,000 miles
(240 000 km) for the life of this vehicle.
SeePart B: Owner Checks and Services on
page 374andPart C: Periodic Maintenance
Inspections on page 380.
Footnotes
†The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that
the failure to perform this maintenance item will not
nullify the emission warranty or limit recall liability
prior to the completion of the vehicle’s useful life.
We, however, urge that all recommended
maintenance services be performed at the indicated
intervals and the maintenance be recorded.
+A good time to check your brakes is during tire
rotation. See Brake System Inspection on
page 381.
7,500 Miles (12 500 km)
❑Change engine oil and filter and replace engine
oil pan drain plug washer (or every 12 months,
whichever occurs first).An Emission Control
Service.
❑Rotate tires. SeeTire Inspection and Rotation
on page 316for proper rotation pattern and
additional information.(See footnote +.)
15,000 Miles (25 000 km)
❑Change engine oil and filter and replace engine
oil pan drain plug washer (or every 12 months,
whichever occurs first).An Emission Control
Service.
❑Replace passenger compartment air filter.
If you drive regularly under dusty conditions, the
filter may require replacement more often.
❑Inspect engine air cleaner filter. SeeEngine Air
Cleaner/Filter on page 264for more information.
❑Rotate tires. SeeTire Inspection and Rotation
on page 316for proper rotation pattern and
additional information.(See footnote +.)
❑Inspect drive belt(s).
369

Part E: Maintenance Record
After the scheduled services are performed, record the date, odometer reading, and who performed the
service and any additional information from “Owner Checks and Services” or “Periodic Maintenance” on the
following record pages. Also, you should retain all maintenance receipts.
Maintenance Record
DateOdometer
ReadingServiced By Maintenance Record
384

Online Owner Center
Online Owner Center
(United States only)
The Owner Center is a resource for your
GM ownership needs. Specific vehicle information
can be found in one place.
The Online Owner Center allows you to:
•Get e-mail service reminders.
•Access information about your specific
vehicle, including tips and videos and
an electronic version of this owner manual.
•Keep track of your vehicle’s service history
and maintenance schedule.
•Find GM dealers for service nationwide.
•Receive special promotions and privileges
only available to members.
Refer to www.MyGMLink.com on the web for
updated information and to register your vehicle.
My GM Canada (Canada only)
My GM Canada is a password-protected section
of gmcanada.com where you can save information
on GM vehicles, get personalized offers, and
use handy tools and forms with greater ease.
Here are a few of the valuable tools and services
you will have access to:
- My Showroom: Find and save information on
vehicles and current offers in your area.
- My Dealers/Retailers: Save details such as
address and phone number for each of
your preferred GM Dealers or Retailers.
- My Driveway: Receive service reminders and
helpful advice on owning and maintaining
your vehicle.
- My Preferences: Manage your profile,
subscribe to E-News and use tools and forms
with greater ease.
To sign up to My GM Canada, visit the My
GM Canada section within www.gmcanada.com.
391

In Canada, the service bulletin reference number
can be obtained by contacting your General Motors
dealer or by calling 1-800-GM-DRIVE
(1-800-463-7483). This reference number is
needed to order the service bulletin from Helm, Inc.
RETAIL SELL PRICE: $6.00 US + Processing Fee
Owner Information
Owner publications are written specifically for
owners and intended to provide basic operational
information about the vehicle. The owner
manual will include the Maintenance Schedule for
all models.
In-Portfolio: Includes a Portfolio, Owner Manual,
and Warranty Booklet.
RETAIL SELL PRICE: $35.00 US
+ Processing Fee
Without Portfolio: Owner’s Manual only.
RETAIL SELL PRICE: $25.00 US
+ Processing Fee
Current and Past Model Order Forms
Technical Service Bulletins and Manuals are
available for current and past model GM vehicles.
To request an order form, please specify year
and model name of the vehicle.
ORDER TOLL FREE: 1-800-551-4123
Monday-Friday 8:00 AM - 6:00 PM
Eastern Time
For Credit Card Orders Only
(VISA-MasterCard-Discover), visit Helm, Inc. on
the World Wide Web at: www.helminc.com
Or you can write to:
Helm, Incorporated
P.O. Box 07130
Detroit, MI 48207
Prices are subject to change without notice and
without incurring obligation. Allow ample time
for delivery.
Note to Canadian Customers: All listed prices are
quoted in U.S. funds. Canadian residents are
to make checks payable in U.S. funds.
407

Light (cont.)
Charging System..................................... 167
Cruise Control.......................................... 176
Daytime Running Lamps Indicator............ 176
Door Ajar................................................. 177
Fog Lamp................................................ 176
Highbeam On.......................................... 176
Hold Mode............................................... 170
Low Fuel Warning.................................... 178
Malfunction Indicator................................ 172
Oil Pressure............................................. 175
Passenger Airbag Status Indicator............ 165
Safety Belt Reminder............................... 164
Safety Belt Reminder Tone...................... 164
Speed Sensitive Power Steering (SSPS)
Warning Light....................................... 170
Tire Pressure........................................... 171
Trunk Ajar................................................ 177
Loading Your Vehicle................................... 236
Lockout Protection......................................... 98
Locks
Central Door Unlocking System................. 96
Door.......................................................... 95
Lockout Protection..................................... 98
Power Door............................................... 96
Rear Door Security Locks.......................... 97Long Trip/Highway Scheduled
Maintenance............................................ 369
Loss of Control........................................... 219
Low Fuel Warning Light............................... 178
Lumbar
Manual Controls......................................... 12
M
Maintenance, Normal Replacement Parts...... 353
Maintenance Schedule
At Each Fuel Fill...................................... 374
At Least Once a Month............................ 374
At Least Once a Year.............................. 376
At Least Twice a Year.............................. 375
Brake System Inspection.......................... 381
Engine Cooling System Inspection........... 381
Exhaust System Inspection...................... 380
Fuel System Inspection............................ 380
How This Section is Organized................ 356
Introduction.............................................. 356
Long Trip/Highway Scheduled
Maintenance......................................... 369
Maintenance Requirements...................... 356
Part A - Scheduled Maintenance
Services............................................... 358
416

Maintenance Schedule (cont.)
Part B - Owner Checks and Services...... 374
Part C - Periodic Maintenance
Inspections........................................... 380
Part D - Recommended Fluids and
Lubricants............................................. 382
Part E - Maintenance Record................... 384
Selecting the Right Schedule................... 359
Short Trip/City Scheduled Maintenance...... 361
Steering, Suspension and Front Drive
Axle Boot and Seal Inspection.............. 380
Throttle System Inspection....................... 381
Using....................................................... 358
Your Vehicle and the Environment............ 356
Malfunction Indicator Light........................... 172
Manual Lumbar Controls............................... 12
Manual Seats........................................... 9, 10
Manual Transaxle
Fluid........................................................ 266
Operation................................................. 114
Manual Windows......................................... 100
Map Lamps................................................. 151
Mirrors
Manual Rearview Mirror........................... 123
Outside Convex Mirror............................. 125Mirrors (cont.)
Outside Heated Mirrors............................ 125
Outside Manual Mirrors............................ 123
Outside Power Mirrors............................. 124
MP3 ...................................................194, 198
MyGMLink.com............................................ 391
N
New Vehicle Break-In.................................. 105
Normal Maintenance Replacement Parts....... 353
O
Odometer.................................................... 163
Odometer, Trip............................................ 163
Off-Road Recovery...................................... 216
Oil
Engine..................................................... 260
Pressure Light.......................................... 175
Older Children, Restraints............................. 38
Online Owner Center................................... 391
Other Warning Devices................................ 140
Outlet Adjustment........................................ 159
Outlet(s), Accessory Power.......................... 152
417

Outside
Convex Mirror.......................................... 125
Heated Mirrors......................................... 125
Manual Mirrors......................................... 123
Power Mirrors.......................................... 124
Owners, Canadian.......................................... 3
P
Paint, Damage............................................ 342
Park (P)
Shifting Into............................................. 117
Shifting Out of......................................... 118
Parking
Brake....................................................... 116
Over Things That Burn............................ 120
Parking Your Vehicle................................... 119
Part A - Scheduled Maintenance Services...... 358
Part B - Owner Checks and Services.......... 374
Part C - Periodic Maintenance
Inspections............................................... 380
Part D - Recommended Fluids and
Lubricants................................................ 382
Part E - Maintenance Record...................... 384
Passenger Airbag Status Indicator............... 165
Passenger Compartment Air Filter............... 159Passenger Sensing System........................... 76
Passing....................................................... 217
Power
Accessory Outlet(s).................................. 152
Door Locks................................................ 96
Electrical System..................................... 346
Inadvertent Battery Saver ......................... 152
Steering Fluid.......................................... 279
Windows.................................................. 101
Pretensioners, Safety Belt............................. 37
Questions and Answers About Safety Belts...... 22
R
Radios........................................................ 178
Care of Your CD Player........................... 204
Care of Your CDs.................................... 203
Radio with CD......................................... 180
Radio with Six-Disc CD............................ 186
Understanding Reception ......................... 203
Rear Door Security Locks............................. 97
Rear Seat Armrest...................................... 129
Rear Seat Operation..................................... 16
Rear Seat Passengers, Safety Belts.............. 33
Rear Windshield Washer/Wiper.................... 145
418

Securing a Child Restraint
Rear Seat Position..................................... 59
Right Front Seat Position........................... 62
Selecting the Right Schedule,
Maintenance............................................ 359
Service........................................................ 248
Accessories and Modifications.................. 249
Adding Equipment to the Outside of
Your Vehicle......................................... 251
California Proposition 65 Warning............. 249
Doing Your Own Work............................. 250
Engine Soon Light................................... 172
Publications Ordering Information............. 406
Servicing Your Airbag-Equipped Vehicle......... 82
Sheet Metal Damage................................... 342
Shifting Into Park (P)................................... 117
Shifting Out of Park (P)............................... 118
Short Trip/City Scheduled Maintenance........ 361
Shoulder Belt Height Adjuster........................ 31
Signals, Turn and Lane-Change.................. 142
Spare Tire
Compact.................................................. 334
Installing.................................................. 329
Removing................................................ 326
Storing..................................................... 333Specifications, Capacities............................ 352
Speed Sensitive Power Steering (SSPS)
Warning Light........................................... 170
Speedometer............................................... 163
Starting Your Engine................................... 107
Steering...................................................... 214
Steering, Suspension and Front Drive
Axle Boot and Seal Inspection................. 380
Steering Wheel Controls, Audio................... 202
Steering Wheel, Tilt Wheel.......................... 141
Storage Areas............................................. 126
Convenience Net..................................... 129
Cupholder(s)............................................ 126
Front Armrest Storage Area...................... 128
Front Storage Area.................................. 127
Glove Box................................................ 126
Hideaway Rear Storage Bins................... 130
Rear Seat Armrest................................... 129
Roof Rack Provisions............................... 128
Sunglasses Storage Compartment............ 127
Stuck in Sand, Mud, Ice, or Snow............... 235
Sun Visors.................................................. 102
Sunroof....................................................... 131
420