headlamp CHEVROLET S10 1996 2.G User Guide

Downloaded from www.Manualslib.com manuals search engine driving, don’t wear sunglasses at night. They may cut
down
on glare from headlamps, but they also make a lot
of things invisible.
You can be temporarily blinded by approaching lights.
It can take
a second or two, or even several seconds, for
your eyes to readjust to the dark. When you are faced
with severe glare (as from a driver who doesn’t lower
the high beams, or a vehicle
with misaimed headlamps),
slow down a little. Avoid staring directly into the
approaching lights.
Keep your windshield and all the glass on your vehicle
clean
-- inside and out. Glare at night is made much
worse by dirt on the glass. Even the inside of the glass
can build up a
film caused by dust. Dirty glass makes
lights dazzle and flash more than clean glass would,
making the pupils of your eyes contract repeatedly.
Remember that your headlamps light up
far less of a
roadway when you are in a turn or curve. Keep your
eyes moving; that way, it’s easier to pick out dimly
lighted objects. Just as your headlamps should be
checked regularly for proper aim,
so should your eyes
be examined regularly. Some drivers suffer from night
blindness
-- the inability to see in dim light -- and
aren’t even aware of
it.
Driving in Rain and on Wet Roads
Rain and wet roads can mean driving trouble. On a wet
road, you can’t stop, accelerate or
turn as well because
your tire-to-road traction isn’t as good as on dry roads.
And,
if your tires don’t have much tread left, you’ll get
even less traction. It’s always wise to go slower and be
4-29

Downloaded from www.Manualslib.com manuals search engine -
Snow can trap exhaust gases under your vehicle.
This can cause deadly
CO (carbon monoxide) gas
to get inside.
CO could overcome you and kill
you. You can’t see it
or smell it, so you might not
know it is in your vehicle. Clear away snow from
around the base of your vehicle, especially any
that
is blocking your exhaust pipe. And check
around again from time to time to be sure snow
doesn’t collect there.
Open a window just a little on the side
of the
vehicle that’s away from the wind. This will help
keep
CO out.
Run your engine only as long as you must. This saves
fuel. When you
run the engine, make it go a little faster
than just idle. That
is, push the accelerator slightly. This
uses less fuel for the heat that you get and
it keeps the
battery charged.
You will need a well-charged battery to
restart the vehicle, and possibly for signaling later
on
with your headlamps. Let the heater run for awhile.
Then, shut the engine off and close the window almost
all the way
to preserve the heat. Start the engine again
and repeat this only when you feel really uncomfortable
from the cold.
But do it as little as possible. Preserve the
fuel as long as you can.
To help keep warm, you can get
out of the vehicle and
do some fairly vigorous exercises
every
half hour or so until help comes.
4-40

Downloaded from www.Manualslib.com manuals search engine Headlamps
Sealed Beam Lamps
1. Remove the screws from
the headlamp retainer.
2. Pull the headlamp out
and remove the retainer.
3. Unplug and remove the headlamp.
4. Plug in the new headlamp and put it in place.
5. Put the retainer on the headlamp and install and
tighten the screws.
6-36

Downloaded from www.Manualslib.com manuals search engine Composite Headlamps
1. Open the hood.
2. Remove the black
protective caps from the
removal pins at the top
of the radiator support.
Use a hex socket to
unscrew the pins.
3. Pull the headlamp lens
I
assembly out. (Some
vehicles may have
4. Unplug the electrical connector.
6-37

Downloaded from www.Manualslib.com manuals search engine 5. Turn the bulb
counterclockwise
to remove it.
6. Put the new bulb into the headlamp lens assembly
and turn it clockwise until
it is tight.
7. Plug in the electrical connector.
8. Put the headlamp lens assembly back into the
vehicle. Install and tighten the screws.
Front Turn Signal Lamps
If you have fog lamps, the fog lamp bracket must be
removed before
you can replace the front parkinghum
signal lamps.
1. Reach under the bumper and behind the parkinghrn
signal lamp assembly.
2. Push the tab on the socket, turn the socket
counterclockwise and pull
it out.
3. Holding the base of the bulb, pull the bulb straight
out
of the socket.
4. Push the new bulb into the socket until it clicks.
5. Put the socket back into the parkinghrn signal lamp
assembly and
turn it clockwise until it locks in place.
6-38

Downloaded from www.Manualslib.com manuals search engine Your dealer will know the kind of wheel you need.
Each new wheel should have the same load carrying
capacity, diameter, width, offset and be mounted the same way as the one it replaces.
If you need
to replace any of your wheels, wheel bolts
or wheel nuts, replace them only with new
GM original
equipment parts. This way, you will be sure
to have the
right wheel, wheel bolts and wheel nuts for your model.
Using the wrong replacement wheels, wheel bolts
or wheel nuts on your vehicle can be dangerous.
It could affect the braking and handling
of your
vehicle, make your tires lose air and make
you lose control.
You could have a collision in
which you or others could be injured. Always
use the correct wheel, wheel bolts and wheel
nuts for replacement.
NOTICE:
The wrong wheel can also cause problems with
bearing life, brake cooling, speedometer/odometer
calibration, headlamp aim, bumper height, vehicle
ground clearance and tire or tire chain clearance
to the body and chassis,
See “Changing a Flat Tire” in the Index for more
information.
sed Replacement
7 keels
Putting
a used wheel on your vehicle is
dangerous. You can’t know how it’s been used or
how many miles it’s been driven, It could fail
suddenly and cause an accident.
If you have to
replace a wheel, use
a new GM original
equipment wheel.
6-51

Downloaded from www.Manualslib.com manuals search engine Electrical System
Add-on Electrical Equipment
NOTICE:
Don’t add anything electrical to your vehicle
unless you check with your dealer first. Some
electrical equipment can damage your vehicle
and the damage wouldn’t be covered by your
warranty. Some add-on electrical equipment can
keep other components from working as they
should.
Your vehicle has an air bag system. Before attempting to
add anything electrical
to your vehicle, see “Servicing
Your Air Bag-Equipped Vehicle” in the Index.
Headlamps
The headlamp wiring is protected by an internal circuit
breaker. An electrical overload will cause the lamps to
go on and
off, or in some cases to remain off. If this
happens, have your headlamp wiring checked right away.
Windshield Wipers
The windshield wiper motor is protected by a circuit
breaker and a fuse. If the motor overheats due
to heavy
snow, etc., the wiper will stop until the motor cools. If
the overload is caused by some electrical problem, be
sure to get it fixed.
Power Windows and Other Power Options
Circuit breakers protect the power windows and other
power accessories. When the current load is too heavy,
the circuit breaker opens and closes, protecting the
circuit until the problem is fixed
or goes away.
6-62

Downloaded from www.Manualslib.com manuals search engine Replacement Bulbs
Lamps
Sealed Beam Halogen Headlamps
Composite Low-Beam
Halogen Headlamps Composite High-Beam
Halogen Headlamps
Tail and Stoplamps
Quantity
2
2
2
2
Number
2El
9006 HB4
9005 HB3 3057
Capacities and Specifications
Type L4
Engine 2.2L
VIN Code 4
Firing Order 1-3-4-2
Horsepower
(T Series) 1 18 at 5,200 rpm
Horsepower
(S Series) 1 18 at 5,200 rpm
Thermostat Specification 195°F (91°C)
Spark
Plug Gap 0.045 inches
(0.1 14 cm)
Lamps
Front Sidemarker Lamps
Front Turn Signal Lamps
Center High-Mounted
Stoplamp
Underhood Lamp
Visor Vanity Mirror Lamps
“VORTEC” 4300
V6
X
1-6-5-4-3-2
180 at 4,400 rpm
170
at 4,400 rpm
195°F (91°C)
0.045 inches (0.114 cm)
Quantity
2
2
Number
194
3 157NA
577 93
74
“VORTEC” 4300
V6
W
1-6-5-4-3-2
190 at 4,400 rpm
180 at 4,400 rpm
195°F (91 “C)
0.045 inches (0.1 14 cm)
6-66

Downloaded from www.Manualslib.com manuals search engine Halogen Bulbs ................................ 6-35
Hazard Warning Flashers
.......................... 5- I
Headlamps .................................... 2-39
Bulb Replacement
............................ 6-36
HighLow Beam Changer
...................... 2-35
Wiring
..................................... 6-62
Headlamps
On Reminder ......................... 2-40
Hearing Impaired. Customer Assistance
.............. 8-3
Heater Controls ................................. 3- I
Heater/Air Conditioning Controls ................... 3-2
Highway Hypnosis
.............................. 4-35
Hill and Mountain Roads
......................... 4-35
Hitches. Trailer
................................. 4-5 1
Hood .......................................... 6-7
Horn
......................................... 2-33
Horsepower
................................... 6-66
Hydraulic Clutch
............................... 6-20
HighLow
Beam Changer
........................ 2-35
Hydroplaning
.................................. 4-31
Ignition Positions
............................... 2-8
Inflation. Tire
.................................. 6-45
Inside Day/Night Rearview Mirror
................. 2-43
Inspections Brakesystem
................................ 7-52
Drive
Axle .................................. 7-52
Exhaust Systems
............................. 7-5 1
Radiator and Heater Hose ...................... 7-5 1
Steering .................................... 7-51 Suspension
.................................. 7-51
Throttle
Linkage ..............................
Instrument Panel ............................... 2-48
Cleaning
.................................... 6-55
Cluster ..................................... 2-50
Fuse Block .................................. 6-63
Interior Lamps
................................. 2-42
.................................... J ack. Tire 5-22
JumpSeat
...................................... 1-6
Jump Starting
................................... 5-2
Key
in the Ignition .............................. 2-7
Keyless Entry System
............................ 2-5
Key Lock Cylinders Service
...................... 7-48
Key Release Button
............................. 2-10
Keys
.......................................... 2-1
Labels CertificationRire
............................. 4-42
Fuse
....................................... 6-64
Safety Belt
.................................. 1-39
Service Parts Identification
..................... 6-61
Vehicle Identification Number
................... 6-61
Dome ...................................... 2-42
Front Map
................................... 2-42
Interior
..................................... 2-42
Lamps
........................................ 2-39
9-5

Downloaded from www.Manualslib.com manuals search engine Trailer Brakes .................................. 4-52
Trailer Hitches
................................. 4-5 1
Trailer Recommendations ........................ 4-47
.Trailer Tongue Weight
............................ 4-50
Trailer Weight
.................................. 4-49
Trailer Wiring Harness
............................ 4-56
Transfer Case
............................. 2-20, 6-22
Electronic
................................... 2-23
TrailerTowing
................................. 4-47
Manual
..................................... 2-20
'Transmission Fluid
Automatic
............................... 6-16, 6-68
Manual
..................................... 6-19
Transmitters, Keyless Entry
......................... 2-5
Transportation. Courtesy
.......................... 8-6
Trip, Before Leaving
............................ 4-34
Trip Odometer
................................. 2-52
Turn Signal and Lane Change Signals
............... 2-34
Two-Tiered Loading
............................ 4-44
TTYUsers
..................................... 8-3
Turn Signals
When Towing a Trailer ................. 4-54
Underbody Maintenance
........................ 6-59
Vanity Mirror Lamp Bulb Replacement
............ 6-41
Underhood Lamp Bulb Replacement
................ 6-41
Used Replacement Wheels
......... : .............. 6-51
Vehicle Control
....................................... 4-5
Damage Warnings
.............................. iv
Dimensions ................................. 6-68
Loading
.................................... 4-42
Ventilation System
............................... 3-4
Voltmeter ..................................... 2-55
Identification
Number
......................... 6-61
. Storage ........ ............................ 6-35
Visors, Sun
..................................... 2-46
warning Devices
........................ ........ 5-1
Warning Lights. Gages and Indicators
............... 2-53
Washer Fluid. Windshield
......................... 6-29
Washing Your Vehicle
........................... 6-57
Weatherstrips
.................................. 6-56
Wheel Alignment
............................... 6-50
Wheel Nut Torque
......................... 5-29. 6-68
Wheel Replacement
............................. 6-50
Sliding Rear
................................. 2-33
Windshield Washer
............................. 2-36
Fluid Level Check
............................ 7-47
Windshield Wiper
.............................. 2-35
Blade Replacement
...................... 6-42, 6-67
Winter Driving
................................. 4-37
Wiring, Headlamp
............................... 6-62
Wrecke~Towing
.................................. 5-7
Windows
..................................... 2-31
Express-Down
................................ 2-32
Swing-Out
.................................. 2-32
Fluid
....................................... 6-29
Fuses
...................................... 6-62
9-10 .